NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
9 reportsClear category filter159,200 miles · Apr 8, 2015
EngineSteeringVehicle Speed Control
I WAS DRIVING WHEN MY CAR JUST TURN OFF,I TURN BACK ON WHIT NO PROBLEM AND TIME LATER PASSES AGAIN,SOMETIMES TURN OFF 2 OR 3 TIMES A DAY AND SOMETIMES WORK FINE, THE COMPUTER SHOWS NO CODE, AND I CHANGE MANY THING TRYING TO FIX IT, SPARK PLUGS, RELAY FUEL PUMP, SPARK PLUG WIRES, RELAY STARTER. I WENT WHIT THE MECHANIC FOR CHEC…
Read full complaint
I WAS DRIVING WHEN MY CAR JUST TURN OFF,I TURN BACK ON WHIT NO PROBLEM AND TIME LATER PASSES AGAIN,SOMETIMES TURN OFF 2 OR 3 TIMES A DAY AND SOMETIMES WORK FINE, THE COMPUTER SHOWS NO CODE, AND I CHANGE MANY THING TRYING TO FIX IT, SPARK PLUGS, RELAY FUEL PUMP, SPARK PLUG WIRES, RELAY STARTER. I WENT WHIT THE MECHANIC FOR CHECK THE FUEL PUMP AND IS GOOD. DON'T KNOW WHAT ELSE TO DO. I HOPE YOU CAN HELP ME. THANKS. *TR
NHTSA ODI #10704346
203,000 miles · Nov 17, 2014
Air BagsVehicle Speed Control
TL* THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY AND THE CRUISE CONTROL MALFUNCTIONED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 203,000.
NHTSA ODI #10658732
90,000 miles · Mar 2, 2008
Vehicle Speed Control
I OWN A 2002 DODGE GRAND CARAVAN, WHICH HAS CRUISE CONTROL INSTALLED. THERE ARE TWO BUTTONS ON THE LEFT SIDE OF THE STEERING WHEEL, ENGAGE/DISENGAGE WHICH ENGAGES THE SYSTEM, AND SET, WHICH SETS THE SYSTEM ON THE SPEED SELECTED. THERE ARE THREE BUTTONS ON THE RIGHT SIDE OF THE STEERING WHEEL, ACCEL/RESUME, CANCEL WHICH CANCELS…
Read full complaint
I OWN A 2002 DODGE GRAND CARAVAN, WHICH HAS CRUISE CONTROL INSTALLED. THERE ARE TWO BUTTONS ON THE LEFT SIDE OF THE STEERING WHEEL, ENGAGE/DISENGAGE WHICH ENGAGES THE SYSTEM, AND SET, WHICH SETS THE SYSTEM ON THE SPEED SELECTED. THERE ARE THREE BUTTONS ON THE RIGHT SIDE OF THE STEERING WHEEL, ACCEL/RESUME, CANCEL WHICH CANCELS THE LAST SETTING SET, AND DECEL. ABOUT 50% OF THE TIME WHEN I 'CANCEL' THE LAST SETTING ENGAGED, AFTER 1 TO 3 SECONDS THE SYSTEM WILL RE-ENGAGE AND ACCELERATE TOWARD THE SPEED PREVIOUSLY SELECTED. IT WILL NOT RE-ENGAGE IF THE SYSTEM IS DE-ACTIVATED BY EITHER THE BRAKE APPLICATION OR BY PRESSING THE DISENGAGE BUTTON. *TR
NHTSA ODI #10219847
9,000 miles · Oct 15, 2007
Service Brakes, HydraulicSteeringVehicle Speed Control
TL*THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. WHILE DRIVING BETWEEN 10-20 MPH, THE BRAKES SQUEALED AND MADE A GRINDING NOISE WHEN APPLIED. HOWEVER, THE VEHICLE STILL STOPPED NORMALLY. A POLICE REPORT WAS FILED. THE FRONT BRAKES WERE REPLACED, THE FRONT ROTORS WERE CUT, AND THE REAR DRUMS WERE CUT AND ADJUSTED AT 9,000, 22,…
Read full complaint
TL*THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. WHILE DRIVING BETWEEN 10-20 MPH, THE BRAKES SQUEALED AND MADE A GRINDING NOISE WHEN APPLIED. HOWEVER, THE VEHICLE STILL STOPPED NORMALLY. A POLICE REPORT WAS FILED. THE FRONT BRAKES WERE REPLACED, THE FRONT ROTORS WERE CUT, AND THE REAR DRUMS WERE CUT AND ADJUSTED AT 9,000, 22,000, 33,000, 45,000, AND 61,000 MILES. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY THE BRAKES HAVING A LOT OF WEIGHT ON THE FRONT END. THE FAILURE MILEAGE WAS 9,000 AND CURRENT MILEAGE WAS 67,000. THE DEALER STATED POWER STEERING NOISE, VEHICLE REVVING ON HILLS. UPDATED 11/14/07 *TR
NHTSA ODI #10205668
60,000 miles · Jan 26, 2005
Air BagsElectrical SystemVehicle Speed Control
AIR BAG SENSOR LIGHT CONTINUED TO STAY ON. AS A RESULT HORN AND CRUISE CONTROL BECOME INOPERABLE. A RECALL FOR THE CLOCK SPRING WAS ISSUED. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK *TC
NHTSA ODI #10097448
7,600 miles · Jun 13, 2004
Power TrainVehicle Speed Control
AT 7,600 MILES IN NOVEMBER OF 2002 THE AUTOMATIC TRANSMISSION FAILED. DEALER REPLACED THE TRANSMISSION WITH A REBUILT ONE. SINCE THEN THE SPEEDOMETER READS INCORRECTLY. AT LOWER SPEEDS IT READS UNDER BY 4 TO 7 MPH, AT HIGHER SPEEDS -- 60 MPH IT READS 15 - 20 MPH UNDER. I DISCOVERED THIS WHEN ON A ROAD TRIP I WAS STOPPED FO…
Read full complaint
AT 7,600 MILES IN NOVEMBER OF 2002 THE AUTOMATIC TRANSMISSION FAILED. DEALER REPLACED THE TRANSMISSION WITH A REBUILT ONE. SINCE THEN THE SPEEDOMETER READS INCORRECTLY. AT LOWER SPEEDS IT READS UNDER BY 4 TO 7 MPH, AT HIGHER SPEEDS -- 60 MPH IT READS 15 - 20 MPH UNDER. I DISCOVERED THIS WHEN ON A ROAD TRIP I WAS STOPPED FOR GOING 85 WHEN I THOUGHT I WAS GOING 68 IN A 70MPH ZONE. I THOUGHT THE POLICE OFFICER WAS CRAZY -- EVEN PROTESTED AND HAD HIM VERIFY THE CALLIBRATION OF HIS RADAR. HIS READING WAS CONFIRMED WHEN I PASSED A ROADSIDE SPEED INDICATOR, AND WAS STOPPED AGAIN. SPEEDOMETER WAS REPROGRAMMED AT A DEALER IN MICHIGAN AFTER WHICH IT READ 4 MPH UNDER FOR THE MOST PART. HAD IT LOOKED AT BY DEALER IN FLORIDA AGAIN IN APRIL 2004, THEY REPLACED A SENSOR. SINCE, IT AGAIN READS 4 TO 10 MILES UNDER AT LOWER SPEEDS -- E.G. WHEN I THINK I'M GOING 35, I'M REALLY GOING 42 OR 43, AT 65 MPH ACTUAL SPEED IS 76MPH. DEALER SAYS ITS "THE WAY YOU'RE DRIVING" -- A POOR EXCUSE FOR SHIFTING THE BLAME AND NOT MAKING THE REPAIR CORRECTLY THE FIRST TIME WHEN THE TRANSMISSION WAS REPLACED. THIS IS A REAL HAZARD AND SAFETY ISSUE NOT JUST FOR MYSELF BUT FOR OTHER FAMILY MEMBERS WHO DRIVE THE VAN AND PEOPLE ON THE ROAD. *AK
NHTSA ODI #10075291
Mileage unknown · Jun 22, 2003
Electrical SystemUnknown Or OtherVehicle Speed ControlFire
MY VAN WAS BOUGHT NEW AND IS JUST ABOUT 1 YEAR OLD. I HAVE BEEN HAVING MANY PROBLEMS WITH THIS VEHICLE. THE VEHICLE WOULD GO 30 MPH BY ITSELF ALTHOUGH I WAS PRESSING THE BRAKE. THIS EVEN HAPPENED WHILE I WAS DRIVING ON AN ICY ROAD. THE DEALER SAID THAT THIS IS NORMAL. ALL THE VEHICLE'S LOCKS WOULD LOCK AND UNLOCK BY THEMSEL…
Read full complaint
MY VAN WAS BOUGHT NEW AND IS JUST ABOUT 1 YEAR OLD. I HAVE BEEN HAVING MANY PROBLEMS WITH THIS VEHICLE. THE VEHICLE WOULD GO 30 MPH BY ITSELF ALTHOUGH I WAS PRESSING THE BRAKE. THIS EVEN HAPPENED WHILE I WAS DRIVING ON AN ICY ROAD. THE DEALER SAID THAT THIS IS NORMAL. ALL THE VEHICLE'S LOCKS WOULD LOCK AND UNLOCK BY THEMSELVES, SOMETIMES LOCKING MY KEYS IN IT BEFORE I CAN GET THEM OUT. THREE MONTHS AFTER THE VEHICLE WAS PURCHASED IT WAS RETURNED TO THE DEALER BECAUSE THE HEATER AND AIR DID NOT WORK PROPERLY. A FIRE BURNED THE DRIVER'S DOOR, SEAT, FLOOR RUGS AND WINDOW. THE FIREMAN SAID IT WAS AN ELECTRICAL FIRE, WHICH STARTED IN THE DRIVER'S DOOR BY THE WIRES. THE FIRE HAPPENED ON THE WEEKEND THEREFORE THE DEALER IS NOT AWARE OF THE FIRE YET. I PLAN TO GO TO THE DEALER ON MONDAY TO SEE WHAT CAN BE DONE. THE VEHICLE CANNOT BE DRIVEN AND THE SMELL INSIDE THE VEHICLE IS OVERWHELMING. EVERYTHING ON DRIVERS SIDE IS BURNED. I WILL ASK FOR A NEW REPLACEMENT VEHICLE. *NM
NHTSA ODI #10023547
3,000 miles · Mar 4, 2003
SteeringVehicle Speed Control
AFTER MAKING A LEFT OR RIGHT TURN THE VEHICLES STEERING WHEEL DID NOT RETURN TO CENTER AND AS A RESULT THE VEHICLE HIT A CURVE. WHILE THE DRIVER DEPRESSED THE GAS PEDAL THERE WAS A DELAY IN ACCELERATION. ONCE GAS PEDAL CAUGHT THE VEHICLE JUMPED FORWARD. *NLM
NHTSA ODI #10009820
Mileage unknown · Aug 11, 2002
Vehicle Speed Control
WHEN ACCELERATING FROM A FULL STOP THE CAR WILL EITHER SPUTTER AND ALMOST STALL OR IT WILL IN FACT STALL. THIS HAS HAPPENED AS CLOSE AS THE END OF OUR BLOCK TO 15 MINUTES INTO A TRIP. IT HAS USUALLY OCCURED IN THE FIRST DRIVE OF THE DAY, BUT LATELY IT HAS BEEN HAPPENENING AT ANY POINT OF THE DAY.*AK
NHTSA ODI #765491
Official recalls
5Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Oct 8, 2002
ON CERTAIN MINI VANS, THE FUEL TANK CONTROL VALVE WELD JOINT COULD SEPARATE RESULTING IN A POSSIBLE FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Oct 4, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration