IllustrationWHILE DRIVING 70 MPH ENGINE SHUT OFF. DEALER STATED THAT FUEL PUMP MALFUNCTIONED WHICH ENABLED FUEL TO REACH THE ENGINE.*AK
2002 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
440–25K
5625–50K
3950–75K
2175–100K
19100–150K
16150K+
195 reports with mileage · 95 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports14 fire reports11 injury reports
Fuel System, Gasoline complaints
15 reportsCONSUMER NOTICED A GAS LEAK. THE MECHANIC STATED THAT O-RINGS WERE LEAKING. CAUSE UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. PH...*AK
CONSUMER STATES THAT VEHICLE'S GAS GAUGE READS INCORRECTLY WHICH CAUSES VEHICLE TO RUN OUT OF GAS WHILE DRIVING. DEALER CONTACTED. PLEASE PROVIDE ADDITIONAL INFORMATION. TS
THE TOP OF THE GAS TANK CAME OFF AND WITIN 40 MILES I LOST 10 GALONS OF GAS. *AK
THIS IS MY SECOND 2002 GRAND CARAVAN...THE FIRST WAS PURCHASED ON 10/23/2001 AND ON THE WAY HOME WE SMELLED STRONG FUEL VAPORS, THE CHECK ENGINE LIGHT CAME ON, AND IT STARTED RUNNING ROUGH. DEALER COULD NOT DETERMINE PROBLEM AND WE WERE GIVEN A REPLACEMENT 2002 GRAND CARAVAN ON 10/24/2001....I LATER FOUND OUT THAT THIS REPLACEME…
Read full complaint
THIS IS MY SECOND 2002 GRAND CARAVAN...THE FIRST WAS PURCHASED ON 10/23/2001 AND ON THE WAY HOME WE SMELLED STRONG FUEL VAPORS, THE CHECK ENGINE LIGHT CAME ON, AND IT STARTED RUNNING ROUGH. DEALER COULD NOT DETERMINE PROBLEM AND WE WERE GIVEN A REPLACEMENT 2002 GRAND CARAVAN ON 10/24/2001....I LATER FOUND OUT THAT THIS REPLACEMENT VEHICLE WAS BUILT ON THE SAME DAY AND SAME PRODUCTION LINE AS THE PREVIOUS 2002 I HAD...AND ONLY ONE OTHER VEHICLE WAS PRODUCED BETWEEN THEM. THE VEHICLE I HAVE JUST STARTED TO HAVE THE SAME PROBLEM AS THE PREVIOUS ONE (STRONG VAPORS, CHECK ENGINE LITE), AND WAS DIAGNOSED AS HAVING GAS TANK/PRESSURE RELIEF VALVE PROBLEMS. SINCE THE VEHICLES WERE BUILT ON THE SAME LINE/DAY, AND SINCE IT IS A GAS TANK/VAPOR PROBLEM, AM CONCERNED ABOUT THE SAFETY OF ALL GRAND CARAVANS BUILT ON THAT LINE ON/AROUND THAT DAY.*AK
Official recalls
504V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
02V274000 · Fuel System, Gasoline:storage:tank Assembly
Oct 8, 2002
ON CERTAIN MINI VANS, THE FUEL TANK CONTROL VALVE WELD JOINT COULD SEPARATE RESULTING IN A POSSIBLE FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V310000 · Child Seat
Oct 4, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.