NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
38 reportsClear category filterMileage unknown · Apr 10, 2026
Electrical SystemSeat Belts
I just bought a 2002 Dodge Grand caravan. I have noticed the seat belts do not lock when I installed the car seat and pulled the seat belt to lock the car seat in place it will not work which makes the car seat tip and fall every direction. I tried every seat in van to see if the lock and they do not unless the car is started if…
Read full complaint
I just bought a 2002 Dodge Grand caravan. I have noticed the seat belts do not lock when I installed the car seat and pulled the seat belt to lock the car seat in place it will not work which makes the car seat tip and fall every direction. I tried every seat in van to see if the lock and they do not unless the car is started if you pull it down fast it locks but not when it's off and will not stay locked. Speedometer and gas gage quit working.
NHTSA ODI #11730502
Mileage unknown · May 6, 2022
Electrical System
Every time I go Though a small puddle rain or snow 10 to 30 mph I loose power steering and have a battery light pop on I have to pull over turn off van and restart sometime it goes back to normal
NHTSA ODI #11463671
185,000 miles · Feb 7, 2022
Electrical SystemFire
The contact owns a 2002 Dodge Grand Caravan. The contact stated that the heater blower had become inoperable and upon inspection, it was discovered that the heater blower wiring harness was burnt and the wires were melted together. The cause of the failure was not determined. The vehicle was not yet repaired. The local dealer an…
Read full complaint
The contact owns a 2002 Dodge Grand Caravan. The contact stated that the heater blower had become inoperable and upon inspection, it was discovered that the heater blower wiring harness was burnt and the wires were melted together. The cause of the failure was not determined. The vehicle was not yet repaired. The local dealer and manufacturer were not yet contacted. The failure mileage was 185,000.
NHTSA ODI #11450831
Mileage unknown · Apr 7, 2017
Electrical SystemEngineFuel/propulsion System
LEAKING FUEL RAIL CAP 2002 DODGE CARAVAN IS LEAKING GAS ALL OVER THE SPARK PLUGS ENGINE AND ELECTRICAL PARTS WHEN 1ST TURNING THE VEHICLE ON IN THE MORNING.
NHTSA ODI #10971147
Mileage unknown · Aug 10, 2015
Electrical System
TL* THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V234000 (ELECTRICAL SYSTEM) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10747570
165,000 miles · Jun 25, 2015
Electrical System
THE DATE AND MILEAGE ARE APPROXIMATE, BUT THIS HAS BEEN HAPPENING SINCE LAST FALL (2014). WHEN PLACING THE KEY IN THE ACC POSITION EVERYTHING WORKS. AFTER STARTING THE MOTOR, MANY TIMES THE WIPERS, RADIO, POWER WINDOWS AND INTERNAL FAN WILL NOT COME ON FOR AS LITTLE AS A FEW SECONDS OR AS LONG AS AN HOUR. IT DOES NOT TO ALWAYS …
Read full complaint
THE DATE AND MILEAGE ARE APPROXIMATE, BUT THIS HAS BEEN HAPPENING SINCE LAST FALL (2014). WHEN PLACING THE KEY IN THE ACC POSITION EVERYTHING WORKS. AFTER STARTING THE MOTOR, MANY TIMES THE WIPERS, RADIO, POWER WINDOWS AND INTERNAL FAN WILL NOT COME ON FOR AS LITTLE AS A FEW SECONDS OR AS LONG AS AN HOUR. IT DOES NOT TO ALWAYS HAPPEN, BUT VERY FREQUENTLY IT DOES. IT SOMETIMES SEEMS TO BE WEATHER RELATED... HEAT, COLD, RAINING OR SNOWING WHEN THIS HAPPENS. THE DANGER IS SHUTTING THE VEHICLE OFF ESPECIALLY ON A RAINY/SNOWY DAY, BEING AWAY FROM HOME AND THE WIPERS WILL NOT WORK WHEN RE-STARTING THE VEHICLE. I HAVE HAD THE FUSE AND COMPUTER UNITS CHANGED (TOTAL FUSE POWER BOX REPLACED NEW ABOUT 1-1/2 YEARS AGO WHICH I WAS TOLD WAS AN UPGRADED BETTER SEALED UNIT AND THE COMPUTER ATTACHED IN FRONT OF IT REPLACED WITH A USED ONE ABOUT 1 MONTH AGO) BUT THE PROBLEM STILL EXISTS. IT IS MY OPINION THIS IS A DANGEROUS SAFETY ISSUE SINCE IT CONCERNS THE WIPERS NOT ABLE TO WORK. I KNOW WHICH FUSE OPERATES THEM AND HAVE TRIED REPLACING IT, BUT THIS IS NOT THE PROBLEM. THE PROBLEM IS, IT WILL NOT CLICK ON UNTIL WHAT EVER IS CAUSING IT NOT TO DECIDES TO LET IT COME ON. I BELIEVE THIS IS A SERIOUS SAFETY ISSUE THAT SHOULD BE ADDRESSED BY DODGE AND NOT BE AN EXPENSE TO MYSELF OR ANY OTHER OWNER WHO HAS THIS PROBLEM. THANK YOU FOR HEARING MY GRIEVANCE. *TR
NHTSA ODI #10730482
137,700 miles · Aug 14, 2014
Electrical SystemVisibility
TL* THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. THE CONTACT STATED THAT SMOKE APPEARED FROM THE SIDE MIRROR POWER SWITCH. THE PANEL MELTED ALTHOUGH NO FLAMES WERE PRESENT. IN ADDITION, THE HORN FAILED TO ACTIVATE WHEN DEPRESSED. THE CONTACT REPLACED THE POWER SWITCH, BUT THE HORN WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFI…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. THE CONTACT STATED THAT SMOKE APPEARED FROM THE SIDE MIRROR POWER SWITCH. THE PANEL MELTED ALTHOUGH NO FLAMES WERE PRESENT. IN ADDITION, THE HORN FAILED TO ACTIVATE WHEN DEPRESSED. THE CONTACT REPLACED THE POWER SWITCH, BUT THE HORN WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 137,700.
NHTSA ODI #10622199
161,000 miles · Dec 10, 2012
Air BagsElectrical SystemExterior Lighting
AIR BAG LIGHT STAYS ON, WHEN I USE TURN SIGNAL TO TURN LEFT THE RIGHT ONE COMES ON AND VICE VERSA, ONE HEAD LIGHT WILL COME ON AND AFTER A WHILE THE OTHER ONE WILL TURN ITSELF ON, WENT OUT ONE NIGHT TO EAT AND WHEN ENTERING THE VAN WITH THE AUTOMATIC UNLOCK KEY THE SECURITY ALARM WENT OFF NOTHING WORKED WHAT WE DID SO WE HAD TO …
Read full complaint
AIR BAG LIGHT STAYS ON, WHEN I USE TURN SIGNAL TO TURN LEFT THE RIGHT ONE COMES ON AND VICE VERSA, ONE HEAD LIGHT WILL COME ON AND AFTER A WHILE THE OTHER ONE WILL TURN ITSELF ON, WENT OUT ONE NIGHT TO EAT AND WHEN ENTERING THE VAN WITH THE AUTOMATIC UNLOCK KEY THE SECURITY ALARM WENT OFF NOTHING WORKED WHAT WE DID SO WE HAD TO UNHOOK THE BATTERY FOR 20 MINS. I WAS TOLD THAT WEIRD THINGS HAPPEN WHEN THE CLOCK SPRING GOES BAD. I WAS TOLD THAT ALL 2002 DODGE GRAND CARAVAN'S HAD RECALLS ON THE CLOCK SPRING AND WHEN I CALLED THE DODGE DEALER CLOSE TO ME I WAS TOLD MY VIN WASN'T IN THE SYSTEM AND THEY REFUSED TO REPAIR THE PROBLEM. *TR
NHTSA ODI #10487804
Mileage unknown · Mar 14, 2012
Electrical SystemFuel System, GasolineSuspensionFire
DODGE GRAND CARAVAN JUST WENT UP IN FLAMES WHILE DRIVING WITHIN MAYBE 5 MINUTES FIRE FIGHTERS CONTROL THE SITUATION BUT THE MOTOR ,BATTERY, EVERYTHING IN FRONT INSIDE HOOD JUST MELTED I REALLY NEED HELP I HAD JUST FINISHED PAYING IT WHEN THIS HAPPENED. I ATTRIBUTE THIS TO THE FAULTY ELECTRICAL RECALLS IT HAS AS WELL AS THE FUEL.…
Read full complaint
DODGE GRAND CARAVAN JUST WENT UP IN FLAMES WHILE DRIVING WITHIN MAYBE 5 MINUTES FIRE FIGHTERS CONTROL THE SITUATION BUT THE MOTOR ,BATTERY, EVERYTHING IN FRONT INSIDE HOOD JUST MELTED I REALLY NEED HELP I HAD JUST FINISHED PAYING IT WHEN THIS HAPPENED. I ATTRIBUTE THIS TO THE FAULTY ELECTRICAL RECALLS IT HAS AS WELL AS THE FUEL. HELP. AT LEAST I WANT A REPLACEMENT. *TR
NHTSA ODI #10451654
120,000 miles · Feb 7, 2012
Electrical SystemEngine And Engine CoolingPower Train
OUR 2002 DODGE GRAND CARAVAN WITH A 3.8 AWD BEGAN CUTTING OUT ON ACCELERATION AND AT INTERSECTIONS RECENTLY. CURRENTLY IT WILL DIE 3 OR 4 TIMES IN A HALF A MILE WHEN IT IS COLD. THIS CONDITION HAS NEARLY CAUSED AN ACCIDENT ON MULTIPLE OCCASIONS AS THE CAR WILL STOP IN THE MIDDLE OF AN INTERSECTION WITH OUT WARNING. NO CEL IS PRE…
Read full complaint
OUR 2002 DODGE GRAND CARAVAN WITH A 3.8 AWD BEGAN CUTTING OUT ON ACCELERATION AND AT INTERSECTIONS RECENTLY. CURRENTLY IT WILL DIE 3 OR 4 TIMES IN A HALF A MILE WHEN IT IS COLD. THIS CONDITION HAS NEARLY CAUSED AN ACCIDENT ON MULTIPLE OCCASIONS AS THE CAR WILL STOP IN THE MIDDLE OF AN INTERSECTION WITH OUT WARNING. NO CEL IS PRESENT ALL MAINTENANCE IS UP TO SCHEDULE. FUEL FILTER,SPARK PLUGS, WIRES,AIR FILTER,CLEANED THROTTLE BODY. DEALER HAS NO IDEA WHAT IT CAN BE. THIS IS NOT A SAFE CAR AND SHOULD BE RECALLED DUE TO THIS DANGEROUS FLAW. *TR
NHTSA ODI #10446975
Official recalls
5Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Oct 8, 2002
ON CERTAIN MINI VANS, THE FUEL TANK CONTROL VALVE WELD JOINT COULD SEPARATE RESULTING IN A POSSIBLE FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Oct 4, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration