IllustrationUSING EITHER TURN SIGNAL CUTS OFF POWER TO THE DASH. DASH COMES BACK ON A FEW SECONDS AFTER USING. I CHECK THE LIGHTS (EXTERIOR), BUT NO BLINKING THE INTERIOR TURN SIGNALS BLINK SOMETIMES, BUT NO SOUND ANYBODY FAMILIAR WITH PROBLEM? I'VE SEEN MANY SIMILAR CONDITIONS. *TR
2001 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
5325–50K
5150–75K
4175–100K
31100–150K
11150K+
200 reports with mileage · 98 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports1 fire reports8 injury reports
What owners actually said
298 reportsFUEL JUMPER HOSE POPPED OFF FROM STEEL LINE THAT COMES FROM FUEL TANK SUPPLY THE SIDE THAT KEEPS COMING OFF, IS CONNECT TO THE FUEL JUMPER HOSE FITTING TO THE FUEL RAIL V-6 3.3L ENGINE. *TR
SITTING IDLE AT A STOP LIGHT AND MY VAN STALLED. WHILE I TRIED TO START IT AGAIN, IT BEGAN TO ACCELERATE ON ITS OWN. IT WILL STALL WHILE DRIVING AND LOSE ALL POWER AND THE STEERING/ BRAKES GET HARD. IT WILL BEGIN TO ACCELERATE ON ITS OWN WHILE THE BRAKE IS PUSHED. I HAD IT DIAGNOSED YESTERDAY AND IT IS A MELTED WIRING FUEL RAIL …
Read full complaint
SITTING IDLE AT A STOP LIGHT AND MY VAN STALLED. WHILE I TRIED TO START IT AGAIN, IT BEGAN TO ACCELERATE ON ITS OWN. IT WILL STALL WHILE DRIVING AND LOSE ALL POWER AND THE STEERING/ BRAKES GET HARD. IT WILL BEGIN TO ACCELERATE ON ITS OWN WHILE THE BRAKE IS PUSHED. I HAD IT DIAGNOSED YESTERDAY AND IT IS A MELTED WIRING FUEL RAIL HARNESS THAT WAS PLACED RIGHT ABOVE THE EXHAUST MANIFOLD. IT CAN MELT AND CATCH FIRE. THIS IS A KNOWN PROBLEM WITH THIS YEAR AND MODEL. PLEASE HELP! *TR
THE FIRST YEAR I PURCHASED THE VEHICLE, I HAD TO TAKE IT IN FOR FUEL ISSUES ,PAID OUT $50 THE FIRST TIME FOR DEDUCTIBLE, THEN THE SECOND YEAR $150 SAME PROBLEM, FUEL, HAD TO HAVE A NEW FUEL PUMP,NOW I HAVE HAVING MORE FUEL PROBLEMS WHICH MEANS I WILL HAVE TO PAY OUT $250 BEING THIS IS MY THIRD YEAR. NOW I WAS READING ONLINE TH…
Read full complaint
THE FIRST YEAR I PURCHASED THE VEHICLE, I HAD TO TAKE IT IN FOR FUEL ISSUES ,PAID OUT $50 THE FIRST TIME FOR DEDUCTIBLE, THEN THE SECOND YEAR $150 SAME PROBLEM, FUEL, HAD TO HAVE A NEW FUEL PUMP,NOW I HAVE HAVING MORE FUEL PROBLEMS WHICH MEANS I WILL HAVE TO PAY OUT $250 BEING THIS IS MY THIRD YEAR. NOW I WAS READING ONLINE THAT THERE HAVE BEEN SOME RECALLS FOR THIS SAME PROBLEM ON DODGE CARAVANS. I WOULD LIKE TO KNOW IF THERE IS ANYTHING I CAN DO, TO HAVE Y PROBLEM LOOKED AT AND FIXED WITHOUT COMING OUT OF MY POCKET A 3RD TIME FOR THE SAME ISSUE. WHEN I PURCHASED THE VEH FROM DRIVE TIME, THEY STATED THEY DID AN ALL AROUND INSPECTION. ALSO, MY PASSENGER SIDE SLIDING DOOR WILL OPEN ON ITS OWN EVEN WHILE I AM DRIVING SOMETIMES. AND IT WONT LATCH ON UNTIL THE 3RD OR 4TH TRY. *TR
WHILE DRIVING IT CUT OUT AND STALLED. I WAS ON THE HIGHWAY GOING ABOUT 65 MPH. THERE WAS MINIMAL FUEL PRESSURE. *TR
I HAVE A 2001 DODGE GRAND CARAVAN SPORT AND I HAD NOTHING BUT PROBLEMS WITH IT FROM THE BRAKE LINES ROTTED AWAY TO THE ANTI FREEZE LINE ROTTED AWAY ALSO THE STEERING GETTING HARD TO WERE IT WONT BUDGE ALSO LIGHTS FLICKERING AND OVERHEATING SO THERE'S NOTHING ON MY VAN THAT ISN'T A PROBLEM I SPENT THOUSANDS OF DOLLARS ON THESE PR…
Read full complaint
I HAVE A 2001 DODGE GRAND CARAVAN SPORT AND I HAD NOTHING BUT PROBLEMS WITH IT FROM THE BRAKE LINES ROTTED AWAY TO THE ANTI FREEZE LINE ROTTED AWAY ALSO THE STEERING GETTING HARD TO WERE IT WONT BUDGE ALSO LIGHTS FLICKERING AND OVERHEATING SO THERE'S NOTHING ON MY VAN THAT ISN'T A PROBLEM I SPENT THOUSANDS OF DOLLARS ON THESE PROBLEMS AND THEY JUST CONTINUE TO HAPPEN ANYTHING ON MY VAN THAT HOLDS FLUIDS JUST ROTS AWAY FROM THE INSIDE OUT AND NOW THE WATER PUMP HOUSING THAT'S BOLTED ONTO THE MOTOR WERE THE HOSE ATTACHES TO GOTO THE FIREWALL SO THAT YOU HAVE HEAT AND AC INSIDE THE VAN ROTTED OFF SO THERE'S A HOLE WERE THE NIPPLE WOULD BE TO CONNECT A HOSE TO AND THE DEALERSHIP WONT HELP ME IN ANYWAY SHAPE OR FORM SO IM BASICALLY ON MY OWN SO I GUESS THERE WAITING FOR SOMEONE TO DIE BEFORE THEY FIX ANYTHING ON THESE VANS THEY HAVE SO MUCH CONCERN FOR THE CIVILIANS THAT BUY THERE CAR VANS EXT. THEY KEEP UP LIKE THIS EVERYONE WHO BUYS A VEHICLE FROM THEM IS CERTAIN TO DIE AND THEY WONT HAVE ANY CUSTOMERS TO SELL TO PERIOD BECAUSE THEY WILL ALL BE DEAD.... ITS TIME TO TAKE OUR STORY TO THE PRESS AND YOU WILL SEE HOW FAST THE WILL FIX THESE ISSUES SO IF YOUR A OWNER OF A DODGE CHRYSLER AND HAVING PROBLEMS SUCH AS ME WE SHOULD GET THE PRESS INVOLVED AND HAVE THEM WRITE A STORY ABOUT THERE LACK OR CARE FOR THERE CUSTOMERS SAFETY SO LETS TEAM UP AND WRITE ME AT [XXX] AND LETS PUT A FLAME UNDER THERE BUTTS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY AND WHENEVER THE CONTACT WOULD ATTEMPT A TURN. THE LIGHT REMAINED ILLUMINATED AS THE FAILURE PROGRESSED. THE CONTROLS ON THE STEERING WHEEL FAILED AND LATER, THE HORN ALSO FA…
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY AND WHENEVER THE CONTACT WOULD ATTEMPT A TURN. THE LIGHT REMAINED ILLUMINATED AS THE FAILURE PROGRESSED. THE CONTROLS ON THE STEERING WHEEL FAILED AND LATER, THE HORN ALSO FAILED. AFTER PERFORMING EXTENSIVE RESEARCH, THE CONTACT CONCLUDED THAT THE CLOCK SPRING FAILED. THE DEALER AND MANUFACTURER WERE BOTH NOTIFIED AND NEITHER OFFERED ANY ASSISTANCE TO THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 166,000.
MY VAN IS OVERHEATING. IT BROKE DOWN ON THE MASSACHUSETTS PIKE, IT THEN STARTED SMOKING FROM UNDER THE HOOD AND FROM THE UNDERCARRIAGE. THE FANS AREN'T TURNING ON WHEN THE AIR CONDITIONER IS ON, AND THE AIR CONDITIONER IS NOT STAYING COOL. *TR
IN APRIL OF 2009 I NOTICED THAT THE STEERING WAS TIGHT AT TIMES. I CHECKED THE POWER STEERING FLUID AND WHEN ADDED, THE STEERING WAS BETTER. IN COLD MONTHS IT WAS WORST. IN DEC. 2009 I HAD THE POWER STEERING PUMP REPLACED. IT WORKED FOR ABOUT A YEAR. THEN IN DEC. 2010, I HAD THE POWER STEERING PUMP FLUSH. THE MECHANIC SAID T…
Read full complaint
IN APRIL OF 2009 I NOTICED THAT THE STEERING WAS TIGHT AT TIMES. I CHECKED THE POWER STEERING FLUID AND WHEN ADDED, THE STEERING WAS BETTER. IN COLD MONTHS IT WAS WORST. IN DEC. 2009 I HAD THE POWER STEERING PUMP REPLACED. IT WORKED FOR ABOUT A YEAR. THEN IN DEC. 2010, I HAD THE POWER STEERING PUMP FLUSH. THE MECHANIC SAID TO WARM UP THE CAR BEFORE DRIVING. IT WORKED IN THE SUMMER MONTHS BUT NOT IN THE WINTER. IN JANUARY 2012 THE STEERING WAS REALLY HARD. I HAD A HARD TIME BACKING UP, TURNING EITHER WAY OR JUST DRIVING AT ALL. I GOT TWO DIFFERENT MECHANICS OPINION AND THEY SAID THAT THE RACK AND PINION, STEERING RACK, NEEDED TO BE REPLACED. SO, AFTER CHANGING THE RESERVOIR THE RACK AND PINION STILL NEEDED TO BE CHANGED. THE MECHANIC SAID THEY HAVE CHANGED A LOT OF RACK AND PINION IN DODGE/CHRYSLER MINI VANS. THEY ARE NOT LASTING THE LIFE OF THE VEHICLE.
TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT HEARD A CLUNKING NOISE WHEN HE APPLIED PRESSURE TO THE BRAKES. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INFORMED THE CONTACT THAT THE LOWER CONTROL ARM PIVOT BOLT WAS FRACTURED. THE DEALER INFORMED THE CONTACT THAT HIS VIN WAS NOT INCLUDED IN THE RECALL ASSOCI…
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT HEARD A CLUNKING NOISE WHEN HE APPLIED PRESSURE TO THE BRAKES. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INFORMED THE CONTACT THAT THE LOWER CONTROL ARM PIVOT BOLT WAS FRACTURED. THE DEALER INFORMED THE CONTACT THAT HIS VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 01V152000 (SUSPENSION:FRONT:CONTROL ARM:LOWER ARM) AND OFFERED NO FURTHER ASSISTANCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT AND THE FAILURE MILEAGES WERE 171,000.
Official recalls
304V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
01V152000 · Suspension:front:control Arm:lower Arm
May 8, 2001
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.