NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
209 reportsClear category filterMileage unknown · May 18, 2000
Engine And Engine CoolingPower Train
PEDESTAL HOLDING THE ROCKER ARM BROKE CAUSING ROCKER ARM SHAFT TO BREAK, ALSO THE TRANSMISSION HAS BROKEN THIS IS STILL A NEW VEHICLE AND THESE TWO ITEMS SHOULD NOT HAVE BROKEN THE ROCKER ARM AND PEDESTAL SHOULD NOT HAVE BROKEN I FILL THIS IS A DESIGN DEFECT BECAUSE OF THE WAY IT BROKE AND COULD HAVE CAUSED SERIOUS PROBLEMS ARE …
Read full complaint
PEDESTAL HOLDING THE ROCKER ARM BROKE CAUSING ROCKER ARM SHAFT TO BREAK, ALSO THE TRANSMISSION HAS BROKEN THIS IS STILL A NEW VEHICLE AND THESE TWO ITEMS SHOULD NOT HAVE BROKEN THE ROCKER ARM AND PEDESTAL SHOULD NOT HAVE BROKEN I FILL THIS IS A DESIGN DEFECT BECAUSE OF THE WAY IT BROKE AND COULD HAVE CAUSED SERIOUS PROBLEMS ARE DAMAGES. I ALSO WOULD LIKE FOR THIS TO BE LOOKED INTO. THE LOCAL DEALER TOLD ME THAT. *AK
NHTSA ODI #722857
Mileage unknown · May 9, 2000
Power TrainService Brakes, HydraulicStructure
AUTOMATIC LOCK MOTOR DOESN'T SHUT OFF RIGHT AWAY WHEN OPENED FROM KEYLESS REMOTE OR DURING AUTOLOCK WHEN DRIVING, STRUTS ARE LEAKING OIL AT LESS THAN 50000 MILES, WINDSHIELD WIPERS LOCK UP DURING COLD WEATHER, TRANSMISSION SLIPS OUT OF GEAR DURING COLD WEATHER, FRONT BRAKES VIBRATE AND CHATTER: PADS AND ROTORS HAVE BEEN REPLACED…
Read full complaint
AUTOMATIC LOCK MOTOR DOESN'T SHUT OFF RIGHT AWAY WHEN OPENED FROM KEYLESS REMOTE OR DURING AUTOLOCK WHEN DRIVING, STRUTS ARE LEAKING OIL AT LESS THAN 50000 MILES, WINDSHIELD WIPERS LOCK UP DURING COLD WEATHER, TRANSMISSION SLIPS OUT OF GEAR DURING COLD WEATHER, FRONT BRAKES VIBRATE AND CHATTER: PADS AND ROTORS HAVE BEEN REPLACED TWICE IN THE LAST 6 MONTHS, GRINDING NOISE FROM STEERING COLUMN, WHINNING NOISE DURING ACCELLERATION. ARE THERE ANY RECALLS REGARDING THESE ISSUES. THE CAR IS FALLING APART AFTER 4 YEARS. *AK
NHTSA ODI #722473
Mileage unknown · May 3, 2000
Engine And Engine CoolingPower Train
RIGHT LEFT INNER/OUTER CV JOINT FAILURE CAUSED THE FRONT END TO SWERVE. YH
NHTSA ODI #552067
Mileage unknown · May 1, 2000
Power Train
MADE A THE PURCHASE IN NOV. WITH 37373 MILES ON THE VEHICLE, MAJOR TRANSMISSION FAILURE AT 46500 MILES. THE TRANSMISSION WILL NO LONGER SHIFT OUT OF LOW GEAR. NEITHER CHRYSLER OR THE DEALER FROM WHICH I PURCHASED THE VEHICLE WILL STAND BEHIND THERE PRODUCT. THESE VEHICLES ARE KNOWN FOR HAVING SEVERE TRANSMISSION PROBLEMS AND …
Read full complaint
MADE A THE PURCHASE IN NOV. WITH 37373 MILES ON THE VEHICLE, MAJOR TRANSMISSION FAILURE AT 46500 MILES. THE TRANSMISSION WILL NO LONGER SHIFT OUT OF LOW GEAR. NEITHER CHRYSLER OR THE DEALER FROM WHICH I PURCHASED THE VEHICLE WILL STAND BEHIND THERE PRODUCT. THESE VEHICLES ARE KNOWN FOR HAVING SEVERE TRANSMISSION PROBLEMS AND CHRYSLER CLAIMS THEY HAVE FIXED THE ISSUES SO WHY IS IT THAT THESE VEHICLES CONTINUE TO HAVE THESE PROBLEMS. A MAJOR RECALL FOR ALL THESE VEHICLES SHOULD BE MADE AS THE CONSUMERS ARE CONTINUALLY BEING LIED TO AND TAKEN ADVANTAGE OF. *AK
NHTSA ODI #722155
Mileage unknown · Apr 18, 2000
Power Train
TRANSMISSION FAILED. NLM
NHTSA ODI #551931
Mileage unknown · Apr 13, 2000
Engine And Engine CoolingPower Train
WHILE DRIVING TRANSMISSION BROKE. TRANSMISSION DIFFERENTIAL PIN HAD SEPARATED & CAUSED A HOLE IN THE HOUSING. THE PIN THEN FLEW OUT & CRACKED THE ENGINE BLOCK. THE VEHICLE SHUT DOWN WITHOUT WARNING. VEHICLE WAS TOWED TO DEALER. CONSUMER WAS INFORMED BY MECHANIC THAT TRANSMISSION & ENGINE BLOCK NEEDED TO BE REPLACED. *AK
NHTSA ODI #860299
Mileage unknown · Apr 10, 2000
Engine And Engine CoolingPower Train
ALL OF THESE BREAK DOWNS HAVE COME WITH IN THE 9 MONTH PERIOD THERE ARE OTHER BREAK DOWNS THAT HAVE NOT BEEN SAID LIKE THE MAIN COMP (EMC COMP),3 SENSORS AND ABOUT 5 RECALLS IN THIS TIME PERIOD WE CONTACTED DEALERSHIP TO SEE IF THERE WAS ANY MAJOR PROBLEMS WITH THIS VAN PRIOR TO PURCHASING THIS VAN AND TO SEE IF THERE WAS ANYTHI…
Read full complaint
ALL OF THESE BREAK DOWNS HAVE COME WITH IN THE 9 MONTH PERIOD THERE ARE OTHER BREAK DOWNS THAT HAVE NOT BEEN SAID LIKE THE MAIN COMP (EMC COMP),3 SENSORS AND ABOUT 5 RECALLS IN THIS TIME PERIOD WE CONTACTED DEALERSHIP TO SEE IF THERE WAS ANY MAJOR PROBLEMS WITH THIS VAN PRIOR TO PURCHASING THIS VAN AND TO SEE IF THERE WAS ANYTHING THEY COULD DO AND NOTHING WAS DONE.WE FEEL THIS VAN WAS A LEMON AND WILL CONT TO HAVE PROBLEMS WE ASK THAT DODGE STAND BY THERE NAME AND DO SOMETHING ABOUT THIS. *AK
NHTSA ODI #721248
Mileage unknown · Apr 4, 2000
Power Train
AT 50,00 MILES TRANSMISSION SEAL BUSTED, CAUSING A TRANSMISSION LEAK. TRANSMISSION WAS DROPPED TO RESEAL THE SEALS. ALSO FUEL HOSE LINE BUSTED AT 69.734 MILES. THE PROBLEM HAS OCCURRED AGAIN. DEALER WAS CONTACTED. *AK.ET.
NHTSA ODI #859643
Mileage unknown · Apr 4, 2000
Power Train
THE VEHICLES TRANSMISSION FAILED CAUSING IT TO SLIP OUT OF GEAR WHILE DRIVING AND THE SES LIGHT TO ILLUMINATE. NLM
NHTSA ODI #551708
Mileage unknown · Mar 30, 2000
Power Train
SECOND COMPLETE FAILURE OF TRASMISSION ASSEMBLY; 1ST @ 29K, 2ND @ 50K. *AK
NHTSA ODI #720800
Official recalls
9Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 9, 1999
VEHICLE DESCRIPTION: MINIVANS. FUEL CAN LEAK FROM THE FUEL TANK AT THE INTERFACE OF THE FUEL PUMP MODULE ATTACHMENT.
Consequence & remedy
Consequence: IF A FUEL LEAK OCCURS IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE ATTACHING NUT WITH A NUT THAT INCLUDES TIGHTER DESIGN TOLERANCES. THE SEALING O-RING WILL ALSO BE REPLACED.
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
Jul 18, 1996
THE BOLTS WHICH SECURE THE INTEGRATED CHILD SEAT MODULES TO THE SEAT FRAME CAN BREAK.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE ACCIDENT, THE CHILD SEAT MAY NOT PROVIDE ADEQUATE PROTECTION TO THE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE INTEGRATED CHILD SEAT MODULE BOLTS.
Jan 16, 1996
A STATIC ELECTRIC CHARGE CAN BUILD UP ON THE UNGROUNDED METAL SECTION OF THE FUEL FILLER TUBE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A SPARK TO OCCUR WHEN FUELING THE VEHICLE AND POSSIBLY IGNITE THE FUEL VAPORS.
Remedy: DEALERS WILL INSTALL A GROUND STRAP FOR THE FUEL FILLER TUBE.
Jan 11, 1996
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Dec 8, 1995
THE FUEL TANK ROLLOVER VALVE CAN ALLOW FUEL TO PASS INTO THE VAPOR CANISTER RESULTING IN THE POTENTIAL FOR FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE INCREASES THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER TUBE WITH A FILLER TUBE THAT HAS AN ADDITIONAL ROLLOVER VALVE. THE ASSOCIATED ROLLOVER VALVE VAPOR HOSES WILL BE REROUTED.
Nov 28, 1995
THE BOLTS WHICH SECURE THE REAR BENCH SEATS TO THE SEAT RISERS MAY BE EMBRITTLED AND FRACTURE.
Consequence & remedy
Consequence: IN CASE OF AN ACCIDENT, THE BOLT MAY FAIL AND CAN CAUSE THE SEAT TO BREAK AWAY FROM THE SEAT RISERS, WHICH INCREASES THE POTENTIALOF INJURY TO ITS OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE REAR BENCH SEAT TO RISER BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
Illustration