NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
209 reportsClear category filterMileage unknown · Dec 22, 2010
Engine And Engine CoolingPower TrainSteering
I HAVE A 1996 DODGE GRAND CARAVAN LE 3.8. IN THE LAST 2 MONTHS THE SERPENTINE BELT SLIPPED OFF 2 TIMES WHEN IT IS RAINING OUTSIDE OR THE VAN GOES THROUGH A PUDDLE OF WATER. I HAVE ALMOST BEEN KILLED TWICE. I HAVE READ THAT OTHER DODGE OWNERS HAVE ALSO HAD THIS PROBLEM. THE WHEEL CANNOT BE CONTROLLED WHEN THIS HAPPENS, AND MY WIF…
Read full complaint
I HAVE A 1996 DODGE GRAND CARAVAN LE 3.8. IN THE LAST 2 MONTHS THE SERPENTINE BELT SLIPPED OFF 2 TIMES WHEN IT IS RAINING OUTSIDE OR THE VAN GOES THROUGH A PUDDLE OF WATER. I HAVE ALMOST BEEN KILLED TWICE. I HAVE READ THAT OTHER DODGE OWNERS HAVE ALSO HAD THIS PROBLEM. THE WHEEL CANNOT BE CONTROLLED WHEN THIS HAPPENS, AND MY WIFE IS SCARED TO DRIVE THIS CAR NOW. I THINK THAT DODGE HAS SOME EXPLAINING TO DO AS THEY HAVE BEEN MADE AWARE OF THIS DEFECT, AND ARE NOT TAKING ANY RESPONSIBILITY FOR THIS REPEATED SERIOUS SAFETY FAULT. *TR
NHTSA ODI #10372161
126,000 miles · Jan 1, 2007
Power Train
AUTOMATIC TRANSMISSION BROKE FOR THE THIRD TIME IN JUST 30,000 MILES, THIS TIME MY WIFE AND 4 KIDS WERE NEARLY KILLED ON A BUSY INTERSTATE BECAUSE WE WERE ALMOST HIT . THIS VEHICLE IS A 1996 DODGE GRAND CARAVAN. *NM
NHTSA ODI #10177453
Mileage unknown · Aug 6, 2006
Power Train
WE HAVE HAD THE CAR APPROX 6 YEARS AND HAD TO PUT IN FIVE TRANSMISSIONS. THEY KEEP BURNING UP AND NOBODY CAN TELL US WHY. WE USE THE VEHICLE FOR VERY LITTLE TRANSPORTATION TO AND FROM SCHOOL MOSTLY APPROX 2 AND 1/2 MILES EACH WAY. THE VAN CONSTANTLY BUCKS WHEN SLOWING DOWN FROM HIGH SPEEDS TO LOW SPEEDS AND WILL OFTEN DIE DO…
Read full complaint
WE HAVE HAD THE CAR APPROX 6 YEARS AND HAD TO PUT IN FIVE TRANSMISSIONS. THEY KEEP BURNING UP AND NOBODY CAN TELL US WHY. WE USE THE VEHICLE FOR VERY LITTLE TRANSPORTATION TO AND FROM SCHOOL MOSTLY APPROX 2 AND 1/2 MILES EACH WAY. THE VAN CONSTANTLY BUCKS WHEN SLOWING DOWN FROM HIGH SPEEDS TO LOW SPEEDS AND WILL OFTEN DIE DOING THE SAME THING. THE TRANSMISSION ALWAYS SEEMS TO BE MAKING A SOUND THAT INDICATES IT IS BEING STRESSED WHILE IN 2 TO 3 GEARS. *NM
NHTSA ODI #10164647
93,500 miles · Aug 18, 2005
Power Train
BOUGHT A 1996 CARAVAN NEW, IN AUGUST 1999 THE TRANSMISSION WENT WITH ABOUT 36,000 MILES AND REBUILT PUT IN - LASTED TILL JAN 2005. TRANSMISSION WENT OUT JAN 2005 AND A REBUILT WAS PUT IN AND LASTED UNTIL JULY 2005 AND ANOTHER REBUILT WAS PUT IN. *NM
NHTSA ODI #10133409
165,000 miles · Feb 18, 2005
Air BagsEngine And Engine CoolingPower Train
- 96 DODGE GRAND CARAVAN W/3.8 V6 AND 41TE 4SPD TRANSMISION - 2 TRANSMISSION FAILURES - 1ST WENT TO ABOUT 125000, THEN KEPT HITTING THE "LIMP HOME MODE" - 2ND HAS "TORQUE CONVERTER LOCKUP" PROBLEM, SHOPS SAY REBUILD AGAIN, AFTER ONLY 38000 MILES. - FAN RELAY WENT OUT BEFORE RECALL WAS ISSUED, HAD TO REPLACE THE RADIATOR …
Read full complaint
- 96 DODGE GRAND CARAVAN W/3.8 V6 AND 41TE 4SPD TRANSMISION - 2 TRANSMISSION FAILURES - 1ST WENT TO ABOUT 125000, THEN KEPT HITTING THE "LIMP HOME MODE" - 2ND HAS "TORQUE CONVERTER LOCKUP" PROBLEM, SHOPS SAY REBUILD AGAIN, AFTER ONLY 38000 MILES. - FAN RELAY WENT OUT BEFORE RECALL WAS ISSUED, HAD TO REPLACE THE RADIATOR OUT OF POCKET. - HAD CLOCK SPRING REPLACED AFTER COMPONENT FAILURE RELATING TO IT (HORN, CRUISE ETC) - UNION CITY GA DEALER ATTEMPTED TO FIX THE FUEL RETURN LINE ISSUE, BOTCHED IT UP AND CAUSED MAJOR LEAK WHEN REFUELING. THEY RE-FIXED IT AFTER MUCH COMPLAINING. *AK
NHTSA ODI #10110774
90,000 miles · Feb 3, 2005
Power TrainSuspension
TOOK MY 1996 DODGE CARAVAN IN FOR TRANSMISSION REPAIR. SHOP WOULD NOT REPAIR AND SAID THE VEHICLE WAS INOPERABLE DUE TO RUSTING OUT OF STRUT MOUNT TOWER. HAVE NOT SEEN THIS ON ANY OTHER VEHICLE. *JB
NHTSA ODI #10108471
84,700 miles · Jan 5, 2005
Power Train
AS I BROUGHT DOWN SPEED OF MY VEHICLE FROM 65 MPH TO STOP TODAY, JUST STOPPED DEAD AT THE STOP SIGN AND THE TRANSMISSION OF MY VEHICLE FAILED. WHEN I SEARCHED THE INTERNET, I FOUND A TONS OF PEOPLE HAVING THE SAME PROBLEM.*AK WITH SO MANY PEOPLE OUT THERE WITH THE SAME PROBLEM THERE HAS TO BE A RECALL OR A CLASS ACTION LAW SUI…
Read full complaint
AS I BROUGHT DOWN SPEED OF MY VEHICLE FROM 65 MPH TO STOP TODAY, JUST STOPPED DEAD AT THE STOP SIGN AND THE TRANSMISSION OF MY VEHICLE FAILED. WHEN I SEARCHED THE INTERNET, I FOUND A TONS OF PEOPLE HAVING THE SAME PROBLEM.*AK WITH SO MANY PEOPLE OUT THERE WITH THE SAME PROBLEM THERE HAS TO BE A RECALL OR A CLASS ACTION LAW SUIT .
NHTSA ODI #10105822
109,000 miles · Sep 23, 2004
Power Train
THE CONSUMER STATED THE TRANSMISSION MALFUNCTIONED. AS A RESULT THE VEHICLE HESITATED BEFORE SHIFTING GEARS. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
NHTSA ODI #10094157
115,450 miles · Sep 23, 2004
Power Train
I BOUGHT A 1996 DODGE GRAND CARAVAN 3 YEARS AGO. THIS PAST JULY I HAD TO TAKE A LOAN OUT TO PAY $2000 FOR A TRANSMISSION. AFTER SPEAKING TO QUITE A FEW MECHANICS, I WAS TOLD THAT THE DODGES THAT HAVE THE 3.3 LITER ENGINES IN THEM HAVE TROUBLE WITH THE TRANSMISSIONS. THE MECHANICS STATED THAT HAVE HAD A LOT OF DODGES THAT THEY…
Read full complaint
I BOUGHT A 1996 DODGE GRAND CARAVAN 3 YEARS AGO. THIS PAST JULY I HAD TO TAKE A LOAN OUT TO PAY $2000 FOR A TRANSMISSION. AFTER SPEAKING TO QUITE A FEW MECHANICS, I WAS TOLD THAT THE DODGES THAT HAVE THE 3.3 LITER ENGINES IN THEM HAVE TROUBLE WITH THE TRANSMISSIONS. THE MECHANICS STATED THAT HAVE HAD A LOT OF DODGES THAT THEY HAVE TO REPLACE THE TRANSMISSION IN AND THE DODGE IS AWARE OF THIS PROBLEM AND HAS DONE NOTHING ABOUT IT. I HAVE OWED 2 OTHER VEHICLES THAT ARE NOT DODGES AND HAVE NEVER HAD TO REPLACE A TRANSMISSION AT ALL AND THEY ARE OLDER THAN MY VAN. I HAD TO PURCHASE MY VAN, SO I COULD PUT MY HUSBAND'S WHEELCHAIR IN IT. IT IS EASIER TO GET IT IN AND OUT OF THE VAN. I AM ON A FIXED INCOME DUE TO MY HUSBAND BEING DISABLED AND WE HAVE SON IN SCHOOL. SO MONEY IS VERY TIGHT. I WAS LUCKY I QUALIFIED FOR THE LOAN TO GET A NEW TRANSMISSION, OR I WOULD BE UNABLE TO TRANSPORT MY HUSBAND BACK AND FORTH TO DOCTOR APPTS AND SHOPPING. I HAVE SPOKE WITH OTHER DODGE OWNERS WHO HAVE ALL TOLD ME THEY HAVE HAD TO REPLACE THE TRANSMISSION IN THEIR DODGE 3.3 LITER VEHICLES. BUT WHAT GETS ME IS THAT ALL THE TRANSMISSION EXPERTS THAT I SPOKE WITH SAID, THEY CHANGE AT LEAST 2 -3 TRANSMISSION A WEEK IN THESE DODGES. AND THAT DODGE IS FULLY AWARE OF THIS PROBLEM. IT SEEMS TO ME THAT DODGE DOESN'T MIND FIXING THE SMALL PROBLEMS, BUT OVER LOOK THAT FACT THAT THEY HAVE A DEFECT THAT CAUSING A TRANSMISSION TO GO OUT AND IT COSTING THE BUYER AT A MINIMUM OF $2000 TO REPLACE. THIS HAS TO BE STOPPED AND DODGE MADE TO BE HELD ACCOUNTABLE FOR OUR COST. THERE NEEDS TO BE A CLASS ACTION SUIT BROUGHT AGAINST THEM FOR THIS. ONE GUY I WORK WITH HAD HIS BRAND NEW DODGE TRUCK LEAVE HIM ON THE SIDE OF THE ROAD, WHEN THE TRANSMISSION WENT OUT AND HE HAD ONLY 57,800 MILES ON IT. DODGE KNOWS THEY PUT OUT A DEFECT TRANSMISSION, BUT THEY ARE MAKING THE CONSUMER PAY FOR IT. THIS IS WRONG AND THEY NEED TO BE HELD ACCOUNTABLE. *JB
NHTSA ODI #10093085
92,000 miles · Aug 24, 2004
Engine And Engine CoolingPower TrainSuspension
THERE ARE TWO MAJOR PROBLEMS WITH MY 1996 DODGE GRAND CARAVAN. FIRST THERE IS A SERIOUS VIBRATION IN THE FRONT WHEEL/TIRES. I HAVE REPLACED 8 TIRES (IN 30000 MILES!), BOTH FRONT AXLES, ALL THREE MOTOR MOUNTS, AND HAD THE TRANSMISSION OVERHAULED, AS WELL AS HAVING THREE ALIGNMENT CHECKS. THE VIBRATION IS STILL THERE. THE SECO…
Read full complaint
THERE ARE TWO MAJOR PROBLEMS WITH MY 1996 DODGE GRAND CARAVAN. FIRST THERE IS A SERIOUS VIBRATION IN THE FRONT WHEEL/TIRES. I HAVE REPLACED 8 TIRES (IN 30000 MILES!), BOTH FRONT AXLES, ALL THREE MOTOR MOUNTS, AND HAD THE TRANSMISSION OVERHAULED, AS WELL AS HAVING THREE ALIGNMENT CHECKS. THE VIBRATION IS STILL THERE. THE SECOND PROBLEM INVOLVES THE WINDSHIELD WIPERS. THE FRONT WIPERS WERE, FOR A TIME, COMING ON ANY TIME THEY FELT LIKE IT; THIS WAS REMEDIED BY REPLACING THE MULTI FUNCTION SWITCH ON 09/21/01. SINCE THEN, THE REAR WIPER WILL OCCASIONALLY COME ON FOR ONE SWIPE WHEN I FIRST START THE VEHICLE - ANNOYING, BUT NOT AN IMMEDIATE HAZARD. BUT TODAY, MY WINDSHIELD WIPERS QUIT WORKING AT ALL. THEY WILL ONLY WORK IF I PUT THE WIPERS ON INTERVAL - IN WHICH CASE THEY DO NOTHING FOR A TIME, THEN MAKE TWO TO FOUR SWIPES, THEN WAIT A WHILE, MAKE ONE OR TWO SWIPES, WAIT A WHILE, ETC. THEY WILL MAKE ONE HIGH SPEED SWIPE ACROSS THE WINDSHIELD IF I PRESS THE WASHER BUTTON IN. I SPENT $80 TODAY SO THE DODGE DEALER COULD TELL ME THIS WAS CAUSED BY A BODY CONTROL MODULE FAILURE. THIS REPAIR COSTS OVER $400...AND RESEARCHING A USED PART ONLINE, I LEARNED THAT BOTH THE WHEEL SHIMMY PROBLEM AND THE WINDSHIELD WIPER PROBLEMS ARE NOT UNIQUE TO MY CAR BUT ARE VERY COMMON ISSUES WITH THE DODGE CARAVAN/CHRYSLER TOWN & COUNTRY/PLYMOUTH VOYAGER FAMILY. LOSING YOUR WIPERS, HAVING THEM COME ON AT RANDOM WHEN THEY TAKE A NOTION TO, AND A NON-STOP SHIMMY IN THE FRONT ARE EACH, BY THEMSELVES, SERIOUS SAFETY ISSUES WARRANTING A RECALL. COLLECTIVELY, THEY SPELL OUT A LACK OF CONCERN THAT DAIMLER CHRYSLER HAS FOR THE SAFETY OF THOSE WHO DRIVE THEIR PRODUCTS. IT IS MY UNDERSTANDING FROM MY ONLINE RESEARCH THAT CHRYSLER WAS AWARE OF THE PROBLEM AS LONG AGO AS 1998 BUT DELIBERATELY IGNORED ITS OWN INFORMATION. IT IS APPARENT THAT THE ONLY WAY THESE SAFETY ISSUES ARE GOING TO BE ADDRESSED IS IF THE FEDERAL GOVERNMENT TAKES THEM TO TASK.*AK
NHTSA ODI #10088514
Official recalls
9Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 9, 1999
VEHICLE DESCRIPTION: MINIVANS. FUEL CAN LEAK FROM THE FUEL TANK AT THE INTERFACE OF THE FUEL PUMP MODULE ATTACHMENT.
Consequence & remedy
Consequence: IF A FUEL LEAK OCCURS IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE ATTACHING NUT WITH A NUT THAT INCLUDES TIGHTER DESIGN TOLERANCES. THE SEALING O-RING WILL ALSO BE REPLACED.
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
Jul 18, 1996
THE BOLTS WHICH SECURE THE INTEGRATED CHILD SEAT MODULES TO THE SEAT FRAME CAN BREAK.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE ACCIDENT, THE CHILD SEAT MAY NOT PROVIDE ADEQUATE PROTECTION TO THE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE INTEGRATED CHILD SEAT MODULE BOLTS.
Jan 16, 1996
A STATIC ELECTRIC CHARGE CAN BUILD UP ON THE UNGROUNDED METAL SECTION OF THE FUEL FILLER TUBE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A SPARK TO OCCUR WHEN FUELING THE VEHICLE AND POSSIBLY IGNITE THE FUEL VAPORS.
Remedy: DEALERS WILL INSTALL A GROUND STRAP FOR THE FUEL FILLER TUBE.
Jan 11, 1996
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Dec 8, 1995
THE FUEL TANK ROLLOVER VALVE CAN ALLOW FUEL TO PASS INTO THE VAPOR CANISTER RESULTING IN THE POTENTIAL FOR FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE INCREASES THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER TUBE WITH A FILLER TUBE THAT HAS AN ADDITIONAL ROLLOVER VALVE. THE ASSOCIATED ROLLOVER VALVE VAPOR HOSES WILL BE REROUTED.
Nov 28, 1995
THE BOLTS WHICH SECURE THE REAR BENCH SEATS TO THE SEAT RISERS MAY BE EMBRITTLED AND FRACTURE.
Consequence & remedy
Consequence: IN CASE OF AN ACCIDENT, THE BOLT MAY FAIL AND CAN CAUSE THE SEAT TO BREAK AWAY FROM THE SEAT RISERS, WHICH INCREASES THE POTENTIALOF INJURY TO ITS OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE REAR BENCH SEAT TO RISER BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
Illustration