NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
177 reportsClear category filterMileage unknown · Nov 30, 1999
Electrical SystemEngine And Engine CoolingPower Train
THIS VEHICLE HAS BEEN THE WORST VEHICLE I HAVE EVER OWNED BECAUSE OF CONTINUOUS ONGOING PROBLEMS ,THE BIGGEST OF WHICH WAS THE ENGINE HEAD FAILURE WHICH COST ME ABOUT A $1,000.00 THATS WITH DODGE PAYING AN ADDITONAL $800.00 FOR THE PARTS. NOW A YEAR LATER, MY TRANSMISSION IS FAILING AND DOES NOT CHANGE GEARS. PLEASE HELP I PR…
Read full complaint
THIS VEHICLE HAS BEEN THE WORST VEHICLE I HAVE EVER OWNED BECAUSE OF CONTINUOUS ONGOING PROBLEMS ,THE BIGGEST OF WHICH WAS THE ENGINE HEAD FAILURE WHICH COST ME ABOUT A $1,000.00 THATS WITH DODGE PAYING AN ADDITONAL $800.00 FOR THE PARTS. NOW A YEAR LATER, MY TRANSMISSION IS FAILING AND DOES NOT CHANGE GEARS. PLEASE HELP I PROMISE NOT TO BUY A CHRYSLER PRODUCT AGAIN, I SWEAR. ALL THE OTHER PROBLEMS HAVE BEEN NAGGING, BUT TOLERABLE. BUT THIS IS TOO MUCH. *AK
NHTSA ODI #715415
Mileage unknown · Nov 29, 1999
Electrical SystemEngine And Engine CoolingSuspension
WENT TO START VEHICLE & THE STARTER FAILED TO CONNECT. MANAGED TO GET VEHICLE TO SHOP. INFORMED BY MECHANIC STARTED BURNED OUT. ALSO, SHOCKS/STRUTS WERE LEAKING FLUID & NEEDED TO BE CHANGED. IN ADDITION, WATER PUMP WAS LEAKING DUE TO CORROSION. *AK
NHTSA ODI #853453
Mileage unknown · Nov 23, 1999
Engine And Engine Cooling
ENGINE CYLINDER HEAD BROKE, CAUSING THE ENGINE TO KNOCK. A RECALL HAS BEEN ISSUED ON THESE VEHICLES, HOWEVER THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. MANUFACTURER HAS BEEN NOTIFIED. *AK
NHTSA ODI #847526
Mileage unknown · Nov 4, 1999
Engine And Engine Cooling
WHILE TRAVELING 55 MPH WITHOUT INDICATION VEHICLE STALL. *YC
NHTSA ODI #852564
Mileage unknown · Oct 29, 1999
Engine And Engine CoolingSuspension
BOLT THAT SECURES THE ROCKER ARM TO THE ENGINE HEAD WERE NOT DRILLED DEEP ENOUGH TO ALLOW EVEN TENSION TO SECURE THE ROCKER ARM SHAFT PROPERLY CAUSING IT TO BREAK AND RESULTING IN VIOLENT VIBRATION. NLM
NHTSA ODI #549386
Mileage unknown · Oct 21, 1999
Engine And Engine CoolingService Brakes, HydraulicSteering
THERE WAS A LOSS OF POWER STEERING AND POWER BRAKES DUE TO THE IDLER PULLEY BREAKING OFF. ALSO, VEHICLE OVERHEATED QUICKLY. DEALER HAS THE VEHICLE. NEEDS NEW IDLER PULLEY. *AK
NHTSA ODI #851381
Mileage unknown · Oct 1, 1999
Engine And Engine Cooling
THIS COMPONENT FAILURE IN HEAVY TRAFFIC COULD CAUSE LOSS OF ALL POWER ASSIST EQUIPMENT DUE TO CONSEQUENTIAL DAMAGE TO SURROUNDING COMPONENTS. THE MANUFACTURER CLASSIFIES IT AS A "WEAR PART". THE SHAFT CONNECTING THE PART TO THE ENGINE SHOWED QUITE CLEAR EVIDENCE OF A FRACTURE LINE. THE DEALER SEEMED UNFAZED BY OUR COMPLAINT OF P…
Read full complaint
THIS COMPONENT FAILURE IN HEAVY TRAFFIC COULD CAUSE LOSS OF ALL POWER ASSIST EQUIPMENT DUE TO CONSEQUENTIAL DAMAGE TO SURROUNDING COMPONENTS. THE MANUFACTURER CLASSIFIES IT AS A "WEAR PART". THE SHAFT CONNECTING THE PART TO THE ENGINE SHOWED QUITE CLEAR EVIDENCE OF A FRACTURE LINE. THE DEALER SEEMED UNFAZED BY OUR COMPLAINT OF PART DEFECT AND APPEARED TO CONSIDER THIS A COMMON FAILURE. THE COMPONENT FAILURE COULD EASILY HAVE CAUSED MY WIFE TO LOSE CONTROL OF THE VEHICLE IF SHE HAD BEEN DRIVING AT HIGH SPEED IN TRAFFIC.
NHTSA ODI #712611
Mileage unknown · Sep 22, 1999
Engine And Engine Cooling
WHEN THE TENSIONER PULLEY FAILED AND SNAPPED OFF OF THE ENGINE AT THE BLOCK MOUNT I WAS PROCEEDING IN A LEFT HAND TURN ONTO A BUSY STREET. LOSS OF THE PULLEY CAUSED LOSS OF POWER STEERING WHICH CAUSED A HAZARDOUS CONDITION THAT NEARLY CAUSED A BAD CRASH.
NHTSA ODI #711844
Mileage unknown · Sep 16, 1999
Engine And Engine CoolingEquipment
REPLACEMENT OF AC COMPRESSOR & EVAPORATOR COST $1450; ENGINE HEAD WAS REPLACED FREE EVEN THOUGH WARRANTY HAD EXPIRED(SPENT $870 ON MAINT AND REPAIRS OF WHICH $300 WAS TO REPLACE SPARK PLUG WIRES AND RESISTOR PACK THAT WAS SAID TO CAUSE CHECK ENGINE LIGHT. HEAD WAS ACTUALLY CASUING PROBLEM); FAN RELAY REPAIRED UNDER WARRANTY; F…
Read full complaint
REPLACEMENT OF AC COMPRESSOR & EVAPORATOR COST $1450; ENGINE HEAD WAS REPLACED FREE EVEN THOUGH WARRANTY HAD EXPIRED(SPENT $870 ON MAINT AND REPAIRS OF WHICH $300 WAS TO REPLACE SPARK PLUG WIRES AND RESISTOR PACK THAT WAS SAID TO CAUSE CHECK ENGINE LIGHT. HEAD WAS ACTUALLY CASUING PROBLEM); FAN RELAY REPAIRED UNDER WARRANTY; FIRESTONE SAID WATER PUMP FROZED AND CAUSED BELT TO BREAK ($300 REPAIR).
NHTSA ODI #711429
Mileage unknown · Sep 7, 1999
Engine And Engine Cooling
VEHICLE WOULD STALL OUT FOR NO REASON & NO WARNING. SPEED WOULD NOT BE A FACTOR. HAS TAKEN TO DEALER & NO ERROR WOULD APPEAR ON DIAGNOSTIC MACHINE. SO FAR, PROBLEM IS INTERMITTENT & ONLY HAPPENED TWICE SINCE. IT SEEMS TO OCCUR WHEN TRAVELING AT HIGHWAY SPEEDS THEN LETTING OF THE ACCELERATOR AND GRADUALLY DECELERAING. THE VEHIC…
Read full complaint
VEHICLE WOULD STALL OUT FOR NO REASON & NO WARNING. SPEED WOULD NOT BE A FACTOR. HAS TAKEN TO DEALER & NO ERROR WOULD APPEAR ON DIAGNOSTIC MACHINE. SO FAR, PROBLEM IS INTERMITTENT & ONLY HAPPENED TWICE SINCE. IT SEEMS TO OCCUR WHEN TRAVELING AT HIGHWAY SPEEDS THEN LETTING OF THE ACCELERATOR AND GRADUALLY DECELERAING. THE VEHICLE WILL STALL INSTEAD OF IDLING. *AK
NHTSA ODI #846998
Official recalls
9Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 9, 1999
VEHICLE DESCRIPTION: MINIVANS. FUEL CAN LEAK FROM THE FUEL TANK AT THE INTERFACE OF THE FUEL PUMP MODULE ATTACHMENT.
Consequence & remedy
Consequence: IF A FUEL LEAK OCCURS IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE ATTACHING NUT WITH A NUT THAT INCLUDES TIGHTER DESIGN TOLERANCES. THE SEALING O-RING WILL ALSO BE REPLACED.
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
Jul 18, 1996
THE BOLTS WHICH SECURE THE INTEGRATED CHILD SEAT MODULES TO THE SEAT FRAME CAN BREAK.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE ACCIDENT, THE CHILD SEAT MAY NOT PROVIDE ADEQUATE PROTECTION TO THE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE INTEGRATED CHILD SEAT MODULE BOLTS.
Jan 16, 1996
A STATIC ELECTRIC CHARGE CAN BUILD UP ON THE UNGROUNDED METAL SECTION OF THE FUEL FILLER TUBE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A SPARK TO OCCUR WHEN FUELING THE VEHICLE AND POSSIBLY IGNITE THE FUEL VAPORS.
Remedy: DEALERS WILL INSTALL A GROUND STRAP FOR THE FUEL FILLER TUBE.
Jan 11, 1996
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Dec 8, 1995
THE FUEL TANK ROLLOVER VALVE CAN ALLOW FUEL TO PASS INTO THE VAPOR CANISTER RESULTING IN THE POTENTIAL FOR FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE INCREASES THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER TUBE WITH A FILLER TUBE THAT HAS AN ADDITIONAL ROLLOVER VALVE. THE ASSOCIATED ROLLOVER VALVE VAPOR HOSES WILL BE REROUTED.
Nov 28, 1995
THE BOLTS WHICH SECURE THE REAR BENCH SEATS TO THE SEAT RISERS MAY BE EMBRITTLED AND FRACTURE.
Consequence & remedy
Consequence: IN CASE OF AN ACCIDENT, THE BOLT MAY FAIL AND CAN CAUSE THE SEAT TO BREAK AWAY FROM THE SEAT RISERS, WHICH INCREASES THE POTENTIALOF INJURY TO ITS OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE REAR BENCH SEAT TO RISER BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
Illustration