Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 10 of 108 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports1 injury reports
What owners actually said
108 reports
Mileage unknown · Jan 1, 2001
Power Train
DEFECTIVE TRANSMISSION - WHEN VEHICLE WAS IN "D" IT WOULD SLIP OPERATING IN A NETURAL POSITION WHEN DRIVING ESP WHEN STOPPED. SOMETIMES SHIFTING BACK IN TO "D" POSITION CAUSING VECHILCE TO SUDDEN MOVE FORWARD WITH LITTLE WARNING. OR IF VEHICLE WAS STOP ON AN INCLINE (HILL) THE VECHILCE WOULD ROLL BACK WHICH SOMETIMES CAME CLO…
Read full complaint
DEFECTIVE TRANSMISSION - WHEN VEHICLE WAS IN "D" IT WOULD SLIP OPERATING IN A NETURAL POSITION WHEN DRIVING ESP WHEN STOPPED. SOMETIMES SHIFTING BACK IN TO "D" POSITION CAUSING VECHILCE TO SUDDEN MOVE FORWARD WITH LITTLE WARNING. OR IF VEHICLE WAS STOP ON AN INCLINE (HILL) THE VECHILCE WOULD ROLL BACK WHICH SOMETIMES CAME CLOSE TO HITTING THE VECHICLE BEHIND. FEELING IS THAT THE TRANMISSION IS FAULTY. COST OF REPAIR WAS $1708.25 TO REPAIR.*AK
NHTSA ODI #738568
Mileage unknown · Dec 3, 2000
Power Train
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #737248
Mileage unknown · Nov 16, 2000
Power Train
AUOT TRANSMISSION WENT OUT AND REPLACED UNDER WARRANTY AT 49,700 MILES. TRANSMISSION HAS AGAIN GONE OUT AT 67,300 MILES. ALL SCHEDULED MAINTENANCE AND LUBRICATIONS WERE PERFORMED ON THE VEHICLE. *AK
NHTSA ODI #736418
Mileage unknown · Oct 21, 2000
Structure
FAILURE OF THE DOOR FRAME AT THE HINGE POINT FOR BOTH DRIVER AND PASSANGER SIDE FRONT DOORS CAUSING THEM TO SAG AND SCRAPE ON THE DOOR LOCK POST, PASSENGER SIDE DOOR ALSO RUBS ON THE FRONT FENDER. RIGHT SIDE DOOR REPAIRED AT LOCAL BODY SHOP 1 YEAR AGO BY WELDING EXTRA STRUCTURAL BACKING BEHIND THE DOOR HINGE MATING AREA AND THEN…
Read full complaint
FAILURE OF THE DOOR FRAME AT THE HINGE POINT FOR BOTH DRIVER AND PASSANGER SIDE FRONT DOORS CAUSING THEM TO SAG AND SCRAPE ON THE DOOR LOCK POST, PASSENGER SIDE DOOR ALSO RUBS ON THE FRONT FENDER. RIGHT SIDE DOOR REPAIRED AT LOCAL BODY SHOP 1 YEAR AGO BY WELDING EXTRA STRUCTURAL BACKING BEHIND THE DOOR HINGE MATING AREA AND THEN WELDING HING TO FRAME AND EXTRA BACKING (DOOR LOCKS HAD TO BE REPLACED DUE TO DOOR SAG INTERFERANCE). LEFT SIDE NOT REPAIRED TO DATE.
NHTSA ODI #734848
Mileage unknown · Sep 27, 2000
Engine And Engine Cooling
TENSIONER BROKE, AND CAR WAS DISABLED BECAUSE FAN BELT DOESN'T RUN. *AK BOLT/MOUNT HOLDING TENSIONER TO THE ENGINE BLOCK SHEARED OFF COMPLETELY DISABELING THE FAN BELT. *YH
NHTSA ODI #871625
Mileage unknown · Sep 12, 2000
Engine And Engine Cooling
BOLT THAT HELD TENSIONER PULLEY TO ENGINE BLOCK HAS SNAPPED OFF. HALF OF THE BOLT WAS STILL LEFT ON THE ENGINE BLOCK . THERE WAS NO EVIDENCE OF RUST. *AK
NHTSA ODI #870284
Mileage unknown · Aug 24, 2000
Structure
CONSUMERS DOOR IS CRACKING AT THE HINGE, IT'S BEGINNING TO DETERIORATE. DEALER SAID IT'S CHEAP METAL THAT'S BEING USED. *AK
NHTSA ODI #868604
Mileage unknown · Aug 24, 2000
Structure
NO SUMMARY
NHTSA ODI #728883
Mileage unknown · Jun 5, 2000
Power Train
TRAVEL @35MPH TRANSMISSION REFUSED TO SWITCH OUT OF 2ND GEAR. *AK
NHTSA ODI #723580
Mileage unknown · Apr 17, 2000
Power Train
INTERMITTENTLY TRANSMISSION WILL NOT SHIFT INTO GEAR OR HAVE A DELAY IN THE SHIFTING, AND WILL NOT GO INTO REVERSE. *AK LOCKS INTO LOW GEAR (LIMP MODE). *YH
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1995 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration