IllustrationA CROSS OVER IN THE FUEL RAIL WAS LEAKING. RECALL 00V268000 WAS ISSUED ON THIS PROBLEM. CONSUMER WAS CONCERNED BECAUSE VEHICLE WAS SHOOTING OUT FUEL.WHEN IT FIRST STARTED HAPPENING IT WAS ON THE LEFT SIDE, AND CURRENTLY IT IS ON THE RIGHT SIDE. THERE WERE NO LIGHTS ILLUMINATING ON THE DASHBOARD. *AK
1995 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1995 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 10 of 108 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports1 injury reports
Fuel System, Gasoline complaints
6 reportsFUEL INJECTION RACKS ON MY 1995 GRAND CARAVAN [XXX] SPLIT, SPILLING FUEL OVER ENGINE. I WAS TOLD THAT OTHER GRAND CARAVANS WERE COVERED BY A RECALL, BUT THAT MINE WAS NOT. FUEL RACKS WERE REPLACED AT A COST OF $560.71 BUT CHRYSLER REFUSES TO REIMBURSE ME EVEN THOUGH THIS FAILURE IS SIMILAR TO THE RECALL. I WOULD LIKE THE NHTS…
Read full complaint
FUEL INJECTION RACKS ON MY 1995 GRAND CARAVAN [XXX] SPLIT, SPILLING FUEL OVER ENGINE. I WAS TOLD THAT OTHER GRAND CARAVANS WERE COVERED BY A RECALL, BUT THAT MINE WAS NOT. FUEL RACKS WERE REPLACED AT A COST OF $560.71 BUT CHRYSLER REFUSES TO REIMBURSE ME EVEN THOUGH THIS FAILURE IS SIMILAR TO THE RECALL. I WOULD LIKE THE NHTSA TO RECONSIDER THE LIMITS OF ITS RECALL FOR THIS FAILURE ON GRAND CARAVANS.*AK UPDATED 07/25/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
THE CONSUMER SMELLED GAS COMING FROM THE TRUCK, HE OPENED THE HOOD AND DISCOVERED A FUEL LEAK. IT WAS CONFIRMED BY A MECHANIC, THERE WAS A FUEL INJECTION RAIL CROSSOVER TUBE LEAK AND THE FUEL RAIL NEEDED TO BE REPLACED. *JB PH *JB
STRONG GAS ODOR WHEN ENGINE SHUT OFF. CAN SMELL INSIDE DRIVER AREA AND GARAGE HAS STRONG SMELL OF GAS. SEEMS TO ORIGINATE FROM FRONT AREA OF VEHICLE.
FUEL PUMP FAILED DUE TO BLOCKED FILTER (SECONDARY FILTER) HAD TO BE TOWED. NOWHERE IN THE OWNER'S MANUAL DOES IT SAY TO CHECK AND REPLACE THIS FILTER, WHICH IS ONLY A 20.00 PART. MY REAPIR COST 450.00 PLUS TOWING. I FOLLOW THE MAINTENANCE DILIGENTLY. THE CHILTON REPAI MANUAL RECOMMENDS CHANGING THIS AT 52000. WE WOULD HAVE…
Read full complaint
FUEL PUMP FAILED DUE TO BLOCKED FILTER (SECONDARY FILTER) HAD TO BE TOWED. NOWHERE IN THE OWNER'S MANUAL DOES IT SAY TO CHECK AND REPLACE THIS FILTER, WHICH IS ONLY A 20.00 PART. MY REAPIR COST 450.00 PLUS TOWING. I FOLLOW THE MAINTENANCE DILIGENTLY. THE CHILTON REPAI MANUAL RECOMMENDS CHANGING THIS AT 52000. WE WOULD HAVE DONE SO IF INFO PROVIDED. WE BOUGHT THE OTHER MANUAL WHEN I RETURNED HOME. THERE WAS NO WARNING AND FORTUNATELY I WAS IN A PARKING LOT AT THE TIME. CHRYSLER SAYS I CANNOT BE REIMBURSED EVEN THOUGH THEY ADMIT I AM RIGHT. LETTERS SHOULD BE SENT TO OWNERS ADVISING THEM OF THIS MORE THAN LIKELY FAILURE. THE MECHANIC WHO FIXED IT RECOMMENDS CHANGING THIS FILTER AT 30,000. HE HAS REPAIRED MANY. I WOULD HATE TO SEE SOMEONE HURT IF THIS FAILS WHILE THEY ARE ON THE HIGHWAY. IT WAS BAD ENOUGH I WAS 200 MILES FROM HOME AND IT WAS DARK.
THE VEHICLE IS STALLING WITHOUT WARNING, CAUSING LOSS OF VEHICLE CONTROL. DEALER CANNOT DETERMINE WHAT IS CAUSING THE PROBLEM,AND REPLACED FUEL INJECTION AND MAP SENSOR, ETC. *AK
Official recalls
199V113000 · Air Bags
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available