IllustrationNO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
1994 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 15 of 199 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports5 fire reports9 injury reports
Power Train complaints
56 reportsHAD CLASSIC SYMPTOMS FOR OVER A YEAR: STUCK 2ND GEAR, ACCELERATION SHUDDER, DELAYED ENGAGEMENT, FINALLY FAILED COMPLETELY WITH NO REVERSE GEAR. *AK
1. AUTOMATIC TRANSMISSIONS LOCKS UP IN SECOND GEAR, RPM'S WILL DOUBLE, SPEED BECOMES LIMITED. 2. WINDOW ON REAR HATCH IS OOZING GLUE AND THE WINDOW IS BUCKELING.
TRANSMISSION IS HESITATING & WON'T CATCH IN 2ND GEAR. DEALER PUT VEHICLE ON THE DIAGNOSTIC MACHINE & FOUND FAILURE OF 2ND GEAR. WARRANTY HAD EXPIRED. *AK
THE INTERNET IS CHOCK FULL OF CONSUMERS REPORTING PROBLEMS WITH CHRYSLER CORPORATIONS AUTOMATIC TRANSMISSIONS. WHY IS IT TAKING YOU SO LONG TO DO SOMETHING ABOUT THIS? *AK
I BELIEVE THAT THIS VAN WAS A "LEMON" FROM THE START. IT WAS PURCHASED WITH 60,000 MILES ON IT LESS THAN 2 YEARS AGO. THE DEALERSHIP, "AURORA CHRYSLER-PLYMOUTH" DID WHAT THEY CALLED A SAFETY CHECK ON IT. SOMEHOW THEY FAILED TO FIND THAT BOTH TIE ROD ENDS NEEDED REPLACED. THAT WAS WITHIN 1 MONTH OF PURCHASE. WE TOOK IT TO …
Read full complaint
I BELIEVE THAT THIS VAN WAS A "LEMON" FROM THE START. IT WAS PURCHASED WITH 60,000 MILES ON IT LESS THAN 2 YEARS AGO. THE DEALERSHIP, "AURORA CHRYSLER-PLYMOUTH" DID WHAT THEY CALLED A SAFETY CHECK ON IT. SOMEHOW THEY FAILED TO FIND THAT BOTH TIE ROD ENDS NEEDED REPLACED. THAT WAS WITHIN 1 MONTH OF PURCHASE. WE TOOK IT TO A MORE LOCAL DEALER FOR THE SERVICE. THEN BEFORE WE HAD 84,000 MILES ON IT, THE TRANSMISSION HAD TO BE COMPLETELY REBUILT. NOW THE ENGINE HAS FAILED E-CHECK WITH MAJOR PROBLEMS. AFTER READING ALL THE CONSUMER COMPLAINTS ON FAILED TRANSMISSIONS, I AM VERY SURPRISED THAT THERE HAS NEVER BEEN A "FORCED" RECALL ON THESE. I ALSO WONDER HOW MANY OTHER ENGINE FAILURES ARE OUT THERE, NOT BEING REPORTED.
THE HYDRAULIC LIFT ARM ON PASSENGER SIDE OF THE VEHICLE P0PPED OUT DUE TO THE LIFT SUPPORT ARM FAILURE. YH
WHEN DRIVING 20-30 MPH AND COMING TO A STOP, TRANSMISSION SHIFTS INTO SECOND GEAR, DECREASING DRIVER'S SPEED. ALSO, THE VEHICLE PAUSES MOMENTARILY BETWEEN SHIFTS FROM REVERSE TO DRIVE BEFORE ENGAGING, AND IT DOES NOT ALWAYS SHIFT INTO HIGH GEAR WHEN IT SHOULD. *AK *ML
COMPUTER FAILED POSSIBLY DUE TO TRANSMISSION FAILING WHICH HAPPENED PRIOR. ALSO, SLIDING DOOR LATCH IS STUCK , WHICH WILL NOT ALLOW DOOR TO OPEN OR CLOSE. CAUSE IS UNKNOWN. *AK
TRANSMISSION STARTED ACTING-UP APPROX. TEN MONTHS AGO. VEHICLE DEVELOPED A SHUDDER AROUND 40 MPH WHEN TRANSMISSION WAS SHIFTING FROM DRIVE INTO OVER-DRIVE. RECENTLY, WHEN COLD, THE VEHICLE WOULD NOT MOVE WHEN PUT INTO REVERSE. UPON CONTACTING A RECOMMENDED TRANSMISSION REPAIR SHOP, I WAS TOLD THAT THESE WERE COMMON PROBLEMS WITH…
Read full complaint
TRANSMISSION STARTED ACTING-UP APPROX. TEN MONTHS AGO. VEHICLE DEVELOPED A SHUDDER AROUND 40 MPH WHEN TRANSMISSION WAS SHIFTING FROM DRIVE INTO OVER-DRIVE. RECENTLY, WHEN COLD, THE VEHICLE WOULD NOT MOVE WHEN PUT INTO REVERSE. UPON CONTACTING A RECOMMENDED TRANSMISSION REPAIR SHOP, I WAS TOLD THAT THESE WERE COMMON PROBLEMS WITH CHRYSLER PRODUCED MINI VANS. THEY EXPLAINED TO ME THAT THE SHUDDER WAS MOST LIKELY CAUSED BY A BROKEN SNAP-RING THAT THE MANUFACTURER MADE TOO THIN AND THE REASON THE VEHICLE WOULD NOT MOVE WHEN PUT INTO REVERSE WAS THAT THE INTERNAL SEALS WERE FAILING BECAUSE THE MANUFACTURER MADE THEM OUT OF THE WRONG MATERIAL. I UNDERSTAND THAT CHRYSLER HAS REPAIR KITS TO TAKE CARE OF THESE DEFECTS. MY QUESTION IS: IF THIS IS SUCH A COMMON PROBLEM, WHY HASN'T THERE BEEN A RECALL? WE ARE FACING A REPAIR BILL OF WELL OVER $1000 BECAUSE OF THE AMOUNT OF LABOR INVOLVED TO CORRECT PROBLEM. IS CHRYSLER DOING ANYTHING FOR CUSTOMERS REGARDING THIS SITUATION? *AK
Official recalls
400V305000 · Steering: Steering Wheel/handle Bar
Oct 12, 2000
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
99V213000 · Structure:body:hatchback/liftgate:hinge And Attachments
Sep 2, 1999
VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
99V113000 · Air Bags
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
93V215000 · Wheels:lugs/nuts/bolts/studs
Dec 14, 1993
WHEELS WITH MISFORMED LUG NUT SEATS WERE INSTALLED ON THESE VEHICLES. THIS CAUSES REDUCED NUT TO WHEEL CONTACT AREA AND LIMITS THE WHEEL SELF-CENTERING CAPABILITY DURING INSTALLATION. THIS RESULTS IN LOSS OF WHEEL LUG NUT TORQUE RETENTION.
Consequence & remedy
Consequence: LOSS OF LUG NUT TORQUE RETENTION MAY LEAD TO WHEEL LUGFAILURE WHICH MAY CAUSE WHEEL SEPARATION AND AN ACCIDENT.
Remedy: INSPECT THE WHEEL ASSEMBLY PLANT CODE; REPLACE WHEELS KNOWN TO HAVE THE PROBLEM AND INSTALL NEW LUG NUTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00011 · Steering Wheel Separation
Opened May 1, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Additional source detail variants (2)
Steering
There is no summary currently available
Steering
There is no summary currently available
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.