← New search

2016 Dodge Durango

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2016 Dodge Durango do not stand out strongly from the model-year median of 231.

About this comparison →

When problems were reported

Mileage at the reported incident

103 reports with mileage · 58 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports1 fire reports11 injury reports

Vehicle Speed Control complaints

9 reports
Clear category filter
102,000 miles · Jan 13, 2020
Vehicle Speed Control

5TH TIME EVENT HAS OCCURRED. AFTER EXTENDED DRIVING WHEN PULLING INTO A PARKING SPOT THE VEHICLE WILL COMMENCE TO ACCELERATE. ONLY BY AGGRESSIVELY APPLYING THE BRAKE TO PREVENT THE VEHICLE FROM PLOWING AHEAD CAN I PLACE THE TRANSMISSION INTO PARK AND TURN OFF THE VEHICLE. CHRYSLER PREVIOUSLY ACKNOWLEDGED CRUISE CONTROL PROB…

Read full complaint

5TH TIME EVENT HAS OCCURRED. AFTER EXTENDED DRIVING WHEN PULLING INTO A PARKING SPOT THE VEHICLE WILL COMMENCE TO ACCELERATE. ONLY BY AGGRESSIVELY APPLYING THE BRAKE TO PREVENT THE VEHICLE FROM PLOWING AHEAD CAN I PLACE THE TRANSMISSION INTO PARK AND TURN OFF THE VEHICLE. CHRYSLER PREVIOUSLY ACKNOWLEDGED CRUISE CONTROL PROBLEMS. I THINK THE PROBLEM STILL EXISTS. THIS IS A DANGEROUS VEHICLE. PREVIOUS FILE NUMBER #10916715.

NHTSA ODI #11298978

105,000 miles · Dec 13, 2019
Electrical SystemVehicle Speed Control

TL* THE CONTACT OWNS A 2016 DODGE DURANGO. WHILE DRIVING 70 MPH, THE VEHICLE BEGAN TO LOSE POWER AND THE SERVICE POWER STEERING, SERVICE ELECTRIC STABILITY, AND CONTROL SERVICE AIR BAG WARNING INDICATORS ILLUMINATED. THE CONTACT VEERED TO THE SHOULDER OF THE ROAD AND THE VEHICLE SHUT OFF. THE CONTACT WAS ABLE TO PLACE THE GEAR I…

Read full complaint

TL* THE CONTACT OWNS A 2016 DODGE DURANGO. WHILE DRIVING 70 MPH, THE VEHICLE BEGAN TO LOSE POWER AND THE SERVICE POWER STEERING, SERVICE ELECTRIC STABILITY, AND CONTROL SERVICE AIR BAG WARNING INDICATORS ILLUMINATED. THE CONTACT VEERED TO THE SHOULDER OF THE ROAD AND THE VEHICLE SHUT OFF. THE CONTACT WAS ABLE TO PLACE THE GEAR IN PARK, BUT IT DID NOT RESUME NORMAL OPERATION. THE VEHICLE WAS TOWED TO MOSS MOTOR COMPANY (1000 S CEDAR AVE, SOUTH PITTSBURG, TN 37380, (423) 837-7114), BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE AND WERE STILL WORKING ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED CASE NUMBER: [XXX]. THE CONTACT MENTIONED THAT THE STABILITY CONTROL SYSTEM WAS UPDATED APPROXIMATELY A YEAR AGO AT THE SAME DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.*DT CONSUMER STATED VEHICLE WAS CONSIDERED A LEMON. ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).')*JB

NHTSA ODI #11288829

53,348 miles · Jun 28, 2019
Electrical SystemUnknown Or OtherVehicle Speed Control

'TAKATA RECALL' PROBLEM WHEN SHIFTING, THE CHECK ENGINE LIGHT AND IT SAID THAT THERE IS A PROBLEM WITH THE SENSOR. IT ALWAYS HAPPEN WHENEVER IM RUNNING IN FREEWAY. IT'S LIKE SHIFTING AND WHENEVER I PUT IT ON REVERSE I GET STUCK ON NEUTRAL WHENEVER I SWITCH IT TO DRIVE OR PARK I HAD TO TURN OFF THE CAR TO MAKE IT WORK AGAIN

NHTSA ODI #11223166

36,000 miles · Jul 21, 2018
Vehicle Speed ControlCrash

WHILE DRIVING ON THE INTERSTATE ,WITH THE CRUISE CONTROL ENGAGED,TRAFFIC WAS SLOWING DOWN DUE TO ROAD REPAIR, I APPLIED MY BRAKES LIGHTLY TO DISENGAGE THE CRUISE CONTROL, BUT THE VEHICLE REMAINED IN A FORWARD THRUST. I WAS FAST APPROACHING A VEHICLE AHEAD OF ME, AND BEFORE I REALISED I WASNT GOING TO STOP WITH FURTHER APPLICATIO…

Read full complaint

WHILE DRIVING ON THE INTERSTATE ,WITH THE CRUISE CONTROL ENGAGED,TRAFFIC WAS SLOWING DOWN DUE TO ROAD REPAIR, I APPLIED MY BRAKES LIGHTLY TO DISENGAGE THE CRUISE CONTROL, BUT THE VEHICLE REMAINED IN A FORWARD THRUST. I WAS FAST APPROACHING A VEHICLE AHEAD OF ME, AND BEFORE I REALISED I WASNT GOING TO STOP WITH FURTHER APPLICATION OF MY BREAKS, I HIT THE VEHICLE IN FRONT OF ME RESULTING IN A NEAR FATAL COLISION. I WAS SAVED BY MY SEAT BELT AND THE AIR BAGS. I CAN ONLY ESTIMATE MY SPEED AT THE TIME OF COLLISION TO BE BETWEEN 40 OR 50 MPH, AS MY CRUISE CONTROL WAS SET AT 62 MPH *TT

NHTSA ODI #11112859

26,171 miles · Jul 25, 2017
Electrical SystemPower TrainVehicle Speed ControlCrash

WHILE REVERSING TO HOOK BOAT TRAILER UP TO VEHICLE, VEHICLE TOOK OFF AT A HIGH RATE OF SPEED IN REVERS. HITTING THE BRAKES DID NOT HELP. THE VEHICLE SLAMMED INTO THE TRAILER WITH BOAT SITTING ON IT AND PUSHED INTO A TREE BEFORE THE VEHICLE WOULD STOP. FURTHERMORE, THIS VEHICLE HAS BEEN INTO THE DEALER'S 5 TIMES FOR HEADLINER ISS…

Read full complaint

WHILE REVERSING TO HOOK BOAT TRAILER UP TO VEHICLE, VEHICLE TOOK OFF AT A HIGH RATE OF SPEED IN REVERS. HITTING THE BRAKES DID NOT HELP. THE VEHICLE SLAMMED INTO THE TRAILER WITH BOAT SITTING ON IT AND PUSHED INTO A TREE BEFORE THE VEHICLE WOULD STOP. FURTHERMORE, THIS VEHICLE HAS BEEN INTO THE DEALER'S 5 TIMES FOR HEADLINER ISSUES WHICH INCLUDED INTERIOR LIGHTS NOT WORKING, REAR AC VENTS NOT WORKING, PINCHED WIRES IN THE WIRING HARNESS AND AIRBAG LIGHTS ON.

NHTSA ODI #11010515

Mileage unknown · Dec 21, 2016
Electrical SystemPower TrainVehicle Speed ControlCrash

THE 2016 DURANGO RENTED FROM ENTERPRISE REPEATEDLY, INCREASINGLY BUT INTERMITTENTLY AND WITHOUT DRIVER INPUT, CHANGED GEAR, REVVED AND INDICATED ON THE SCREEN THAT THERE WERE ISSUES WITH "KEY FOB NOT IN VEHICLE AND "TIRES PRESSURE". AT FIRST THEIR WERE THREE VERY BRIEF INCIDENTS LASTING LESS THAN THREE SECONDS OVER A WEEK, OCC…

Read full complaint

THE 2016 DURANGO RENTED FROM ENTERPRISE REPEATEDLY, INCREASINGLY BUT INTERMITTENTLY AND WITHOUT DRIVER INPUT, CHANGED GEAR, REVVED AND INDICATED ON THE SCREEN THAT THERE WERE ISSUES WITH "KEY FOB NOT IN VEHICLE AND "TIRES PRESSURE". AT FIRST THEIR WERE THREE VERY BRIEF INCIDENTS LASTING LESS THAN THREE SECONDS OVER A WEEK, OCCURRING AT IDLE AND WHEN ACCELERATING. LATER THE OCCURRENCES LASTED SOMETIMES OVER 20 SECONDS EACH AND HAPPENED SOMETIMES SEVERAL TIMES PER HOUR, INCREASINGLY WORSE. WHILE THERE WAS CLEARLY AN ISSUE WITH THE SHIFTER, THERE APPEARED TO BE ADDITIONAL OR RELATED ISSUES WITH THE ELECTRONIC BRAIN. RESETTING THE OPTIONS, LIKE SHUTTING OFF THE HILL CLIMB OPTION WHICH IT WAS SET ON BEFORE WE RENTED IT SEEMED TO HELP AT FIRST BUT DID NOT. THIS WAS DANGEROUS AND DISTURBING. FINALLY, THE CAR LURCHED OUT OF PARK AND HIT A WALL ON ITS OWN FROM A FEW FEET AWAY. I HAVE PHOTOS AND WILL GIVE MORE INFORMATION. THESE INCIDENTS OCCURRED AT VARIOUS TIMES, AND SEEMINGLY MORE IN THE RAIN AND FOG, THOUGH NOT EXCLUSIVELY. THEY OCCURRED ONCE WHEN LEAVING A STOPLIGHT AT A LOW SPEED TURNING LEFT, ON THE FREEWAY, ON STREETS AROUND 30/35 MPH AND AT IDLE AT FULL STOP. MOST OCCURRENCES WERE WHILE DRIVING ON REGULAR CITY STREETS WHERE WE DID MOST OF THE DRIVING ON THAT TRIP IN SAN JOSE, MONTEREY AND CARMEL. THE WORST WAS RIGHT BEFORE THE PEBBLE BEACH CONCOURS D'ELEGANCE, AFTER I HAD DRIVEN NORTH FROM SAN DIEGO ON A CONTINUOUS FREEWAY DRIVE IN THE RAIN. IT MAY JUST BE A COINCIDENCE, BUT ALL THREE OF THE FIRST INSTANCES IN THE FIRST WEEK OF RENTAL OCCURRED AFTER AT LEAST AN HOUR DRIVE ON THE FREEWAY. IN SAN JOSE, I IMMEDIATELY REQUESTED A REPLACEMENT CAR BUT THEY HAD NONE.THE SECOND DRIVER IMMEDIATELY NOTICED ISSUES WITH THE CAR, BUT WE WERE TOLD THERE WERE NO OTHER CARS AVAILABLE. I THINK EITHER THE COMPUTER CIRCUITS WERE CORRODED AND/OR DAMAGED OR DAMP. *TR

NHTSA ODI #10936829

3,000 miles · Oct 18, 2016
Electrical SystemFuel/propulsion SystemService Brakes

AUTONOMOUS ACCELERATION. THE VEHICLE WITHOUT DRIVER ASSIST ACCELERATED TWICE WHEN PULLING INTO PARKING SPOTS. IN BOTH CASES I WAS MAKING A LEFT TURN INTO A PARKING SPOT WHEN THE ACCELERATION COMMENCED. ONLY BY STANDING ON THE BRAKE WHILE AT SAME TIME PLACING THE VEHICLE IN PARK AND PRESSING ENGINE OFF BUTTON WAS I ABLE TO STOP V…

Read full complaint

AUTONOMOUS ACCELERATION. THE VEHICLE WITHOUT DRIVER ASSIST ACCELERATED TWICE WHEN PULLING INTO PARKING SPOTS. IN BOTH CASES I WAS MAKING A LEFT TURN INTO A PARKING SPOT WHEN THE ACCELERATION COMMENCED. ONLY BY STANDING ON THE BRAKE WHILE AT SAME TIME PLACING THE VEHICLE IN PARK AND PRESSING ENGINE OFF BUTTON WAS I ABLE TO STOP VEHICLES FORWARD MOTION. THE DURANGO CAME CLOSE TO RAMMING PARKED CAR IN THE SPACE IN FRONT OF THE ONE I WAS PULLING INTO. DURANGO HAD APPROX. 3000 MILES ON ODOMETER WHEN THE 2 INCIDENTS OF ACCELERATION OCCURRED. THE INCIDENTS OCCURRED ON CONSECUTIVE DAYS, OCT 9 & 10, AFTER DRIVING THE VEHICLE APPROX. 6-8 HOURS STRAIGHT EACH DAY. PURCHASING DEALER WAS CONTACTED IMMEDIATELY TO INFORM IT'S SERVICE DEPARTMENT OF THE 2 INCIDENTS. VEHICLE WAS TAKEN TO AN OUT OF AREA DEALER ON THE MORNING FOLLOWING 1ST INCIDENT. THEY READ THE FAULT CODES AND INFORMED ME THAT NOTHING REGISTERED OTHER THAN THE ECM HAD BROKEN CONTACT. UPON THE OCCURRENCE OF 2ND INCIDENT WE CUT SHORT OUR TRIP AND RETURNED TO OUR HOME SO THAT WE COULD TAKE VEHICLE TO PURCHASING DEALER, SUBURBAN CHRYSLER IN FARMINGTON HILLS MICHIGAN. AFTER TWO DAYS IN SERVICE THE REPORT THAT CAME BACK WAS NO PROBLEM FOUND. MY CONCERN IS THAT THIS ACCELERATION COULD OCCUR DURING A MORE PROBLEMATIC SITUATION WHERE ABILITY TO CONTROL DURANGO WILL BE LIMITED WHICH COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE. LETTERS OF RECORD HAVE BEEN SENT TO [XXX], CEO DODGE, AND [XXX], SERVICE MGR AT SUBURBAN CHRYSLER IN FARMINGTON HILLS MI. I HAVE TAKEN PHOTOS OF BRAKE & GAS PEDDLES TO SHOW THERE RELATION TO A WEATHER TECH WHICH THE DEALER HAS SUGGESTED AS A POSSIBLE CAUSE FOR ACCELERATION. CONSUMER STATES THERE WERE 2 MORE OCCURRENCES. DASH BOARD WENT COMPLETELY BLANK DURING LAST OCCURRENCE. CONSUMER BELIEVES FAILURE IS RELATED TO A CRUISE CONTROL RECALL.*DL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR *TR *JS

NHTSA ODI #10916715

981 miles · Sep 13, 2016
Vehicle Speed Control

TL* THE CONTACT OWNS A 2016 DODGE DURANGO. WHILE DRIVING 10 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED TO 35 MPH WITHOUT WARNING. IN ADDITION, THE RPMS REVVED AND THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MIL…

Read full complaint

TL* THE CONTACT OWNS A 2016 DODGE DURANGO. WHILE DRIVING 10 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED TO 35 MPH WITHOUT WARNING. IN ADDITION, THE RPMS REVVED AND THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 981. THE VIN WAS UNAVAILABLE.

NHTSA ODI #10905984

62 miles · Jul 13, 2016
Electrical SystemExterior LightingVehicle Speed Control

AFTER PURCHASE, IMMEDIATELY WE STARTED HAVING PROBLEMS WITH HEADLIGHT NOT WORKING, THEN A REAR LIGHT AND BRAKE LIGHT NOT WORKING. TOOK IN FOR RECALL ON ANOTHER PART AND THEY DISCOVERED IT WAS THE ELECTRICAL, WHILE DRIVING AND SITTING AT LIGHTS. LIGHTS ON DASH, RADIO, HEADLIGHTS, ETC, NOT WORK PROPERLY OR ALL SUDDEN DECIDE NOT TO…

Read full complaint

AFTER PURCHASE, IMMEDIATELY WE STARTED HAVING PROBLEMS WITH HEADLIGHT NOT WORKING, THEN A REAR LIGHT AND BRAKE LIGHT NOT WORKING. TOOK IN FOR RECALL ON ANOTHER PART AND THEY DISCOVERED IT WAS THE ELECTRICAL, WHILE DRIVING AND SITTING AT LIGHTS. LIGHTS ON DASH, RADIO, HEADLIGHTS, ETC, NOT WORK PROPERLY OR ALL SUDDEN DECIDE NOT TO WORK AT ALL. WE'VE TAKEN IT BACK NOW 5 TIMES. MECHANIC SAYS THE WHOLE WIRING HARNESS IS BAD AND CANNOT BE REPAIRED, BUT CONTINUES TO SAY THEY CALLED CHRYSLER FOR PARTS TO TRY TO REPAIR. WHILE MY 83 YRS OLD DAD WHO BOUGHT THE CAR, LEFT SITTING AT THE DEALER FOR 4-5 HOURS EVERY TRIP AND NO RENTAL VEHICLE AVAILABLE FROM ENTERPRISE OR HERTZ. AFTER SITTING THERE 5 HOURS TODAY, WE HAD TO LEAVE VEHICLE. THIS TIME, WE ARE READY TO CALL ATTORNEY FOR LEMON LAW IN MISSOURI.

NHTSA ODI #10884582

Official recalls

3

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Electrical System:wiring

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

16V814000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Nov 10, 2016

Chrysler (FCA US LLC) is recalling certain model year 2016 Dodge Durango and Jeep Grand Cherokee vehicles manufactured February 10, 2016, to April 28, 2016 and equipped with a 3.6L engine built at the Saltillo engine plant. During the assembly of the engine, the fuel rail crossover tube may have been damaged, which, over time, may result in a fuel leak.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source, can increase the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the engine assembly for damage to the fuel rail crossover tube, replacing it as necessary, free of charge. The recall began on December 23, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S85.

16V168000 · Service Brakes, Hydraulic:foundation Components:disc:caliper

Mar 23, 2016

Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Grand Cherokee and Dodge Durango vehicles manufactured December 9, 2015, to January 14, 2016. In the affected vehicles, the left front brake caliper may crack due to being made from an incorrect material.

Consequence & remedy

Consequence: A cracked brake caliper may lengthen the distance needed to stop the vehicle and increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the front left brake caliper and depending on its casting date, replace it, free of charge. The recall is expected to begin on May 12, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S16.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

PE16014 · Vehicle Rollaway

Opened Dec 16, 2016 · Closed Jan 25, 2024

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:gear Position Indication (prndl)

Basis – On December 16, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-014 to investigate 43 vehicle rollaway incidents with operators alleging they had shifted to Park and then exited the vehicle prior to the rollway incidents.  These complaints involved multiple Fiat Chrysler Automobiles (FCA) model and model year vehicles that share a common electronic rotary shifter design.  Of the 43 consumer complaints, 25 complaints alleged crashes, and eight complaints alleged at least one injury. Subject Vehicles – When NHTSA opened the investigation, the subject vehicles were model year (MY) 2013-2016 Ram 1500 vehicles and MY 2014-2016 Dodge Durango vehicles equipped with a rotary electronic shifter. However, NHTSA expanded the scope of the investigation to include subsequent model years of the same model vehicles when the Agency learned that those new model year vehicles use the same rotary shifter.  Additionally, all subject vehicles manufactured by FCA are equipped with electronic rotary shifters supplied by Kostal Automotive. Reason for closing - During the course of this investigation, ODI did not find evidence that a vehicle-based design or manufacturing defect was the cause of vehicle rollaway incidents on the subject vehicles. Nevertheless, given the risk of a vehicle rollaway, FCA’s CSN actions provide automated vehicle securement when an operator attempts to exit the vehicle without successfully achieving a Park position with the rotary shifter mechanism. ODI closely monitored the subject vehicles on which the CSN actions implement a vehicle securement strategy and found that the CSN actions were effective in reducing the frequency of vehicle rollaway incidents in the subject vehicles. ODI analyzed the incidents when a CSN had been implemented and a rollaway still occurred, and ODI was unable to find an actionable defect that caused vehicle rollaway incidents. ODI found that the failure rates on subject vehicles that received a CSN remedy were similar to the failure rates on other vehicle populations and additionally had similar mechanisms as other vehicle populations such as slippery surfaces and various mechanical failures. Furthermore, as discussed above, after FCA’s release of the CSN actions, consumer complaints have decreased significantly. Given the absence of an identified safety defect based on available information and FCA’s customer satisfaction campaign which addresses the failure mode, further action is not warranted at this time. Accordingly, this Preliminary Evaluation is closed. However, the Agency reserves the right to take further action, if warranted.Please see the attached detailed closing summary for more information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (3)

Power Train:automatic Transmission

Basis – On December 16, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-014 to investigate 43 vehicle rollaway incidents with operators alleging they had shifted to Park and then exited the vehicle prior to the rollway incidents.  These complaints involved multiple Fiat Chrysler Automobiles (FCA) model and model year vehicles that share a common electronic rotary shifter design.  Of the 43 consumer complaints, 25 complaints alleged crashes, and eight complaints alleged at least one injury. Subject Vehicles – When NHTSA opened the investigation, the subject vehicles were model year (MY) 2013-2016 Ram 1500 vehicles and MY 2014-2016 Dodge Durango vehicles equipped with a rotary electronic shifter. However, NHTSA expanded the scope of the investigation to include subsequent model years of the same model vehicles when the Agency learned that those new model year vehicles use the same rotary shifter.  Additionally, all subject vehicles manufactured by FCA are equipped with electronic rotary shifters supplied by Kostal Automotive. Reason for closing - During the course of this investigation, ODI did not find evidence that a vehicle-based design or manufacturing defect was the cause of vehicle rollaway incidents on the subject vehicles. Nevertheless, given the risk of a vehicle rollaway, FCA’s CSN actions provide automated vehicle securement when an operator attempts to exit the vehicle without successfully achieving a Park position with the rotary shifter mechanism. ODI closely monitored the subject vehicles on which the CSN actions implement a vehicle securement strategy and found that the CSN actions were effective in reducing the frequency of vehicle rollaway incidents in the subject vehicles. ODI analyzed the incidents when a CSN had been implemented and a rollaway still occurred, and ODI was unable to find an actionable defect that caused vehicle rollaway incidents. ODI found that the failure rates on subject vehicles that received a CSN remedy were similar to the failure rates on other vehicle populations and additionally had similar mechanisms as other vehicle populations such as slippery surfaces and various mechanical failures. Furthermore, as discussed above, after FCA’s release of the CSN actions, consumer complaints have decreased significantly. Given the absence of an identified safety defect based on available information and FCA’s customer satisfaction campaign which addresses the failure mode, further action is not warranted at this time. Accordingly, this Preliminary Evaluation is closed. However, the Agency reserves the right to take further action, if warranted.Please see the attached detailed closing summary for more information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Basis – On December 16, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-014 to investigate 43 vehicle rollaway incidents with operators alleging they had shifted to Park and then exited the vehicle prior to the rollway incidents.  These complaints involved multiple Fiat Chrysler Automobiles (FCA) model and model year vehicles that share a common electronic rotary shifter design.  Of the 43 consumer complaints, 25 complaints alleged crashes, and eight complaints alleged at least one injury. Subject Vehicles – When NHTSA opened the investigation, the subject vehicles were model year (MY) 2013-2016 Ram 1500 vehicles and MY 2014-2016 Dodge Durango vehicles equipped with a rotary electronic shifter. However, NHTSA expanded the scope of the investigation to include subsequent model years of the same model vehicles when the Agency learned that those new model year vehicles use the same rotary shifter.  Additionally, all subject vehicles manufactured by FCA are equipped with electronic rotary shifters supplied by Kostal Automotive. Reason for closing - During the course of this investigation, ODI did not find evidence that a vehicle-based design or manufacturing defect was the cause of vehicle rollaway incidents on the subject vehicles. Nevertheless, given the risk of a vehicle rollaway, FCA’s CSN actions provide automated vehicle securement when an operator attempts to exit the vehicle without successfully achieving a Park position with the rotary shifter mechanism. ODI closely monitored the subject vehicles on which the CSN actions implement a vehicle securement strategy and found that the CSN actions were effective in reducing the frequency of vehicle rollaway incidents in the subject vehicles. ODI analyzed the incidents when a CSN had been implemented and a rollaway still occurred, and ODI was unable to find an actionable defect that caused vehicle rollaway incidents. ODI found that the failure rates on subject vehicles that received a CSN remedy were similar to the failure rates on other vehicle populations and additionally had similar mechanisms as other vehicle populations such as slippery surfaces and various mechanical failures. Furthermore, as discussed above, after FCA’s release of the CSN actions, consumer complaints have decreased significantly. Given the absence of an identified safety defect based on available information and FCA’s customer satisfaction campaign which addresses the failure mode, further action is not warranted at this time. Accordingly, this Preliminary Evaluation is closed. However, the Agency reserves the right to take further action, if warranted.Please see the attached detailed closing summary for more information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Power Train:automatic Transmission:gear Position Indication (prndl)

Basis – On December 16, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-014 to investigate 43 vehicle rollaway incidents with operators alleging they had shifted to Park and then exited the vehicle prior to the rollway incidents.  These complaints involved multiple Fiat Chrysler Automobiles (FCA) model and model year vehicles that share a common electronic rotary shifter design.  Of the 43 consumer complaints, 25 complaints alleged crashes, and eight complaints alleged at least one injury. Subject Vehicles – When NHTSA opened the investigation, the subject vehicles were model year (MY) 2013-2016 Ram 1500 vehicles and MY 2014-2016 Dodge Durango vehicles equipped with a rotary electronic shifter. However, NHTSA expanded the scope of the investigation to include subsequent model years of the same model vehicles when the Agency learned that those new model year vehicles use the same rotary shifter.  Additionally, all subject vehicles manufactured by FCA are equipped with electronic rotary shifters supplied by Kostal Automotive. Reason for closing - During the course of this investigation, ODI did not find evidence that a vehicle-based design or manufacturing defect was the cause of vehicle rollaway incidents on the subject vehicles. Nevertheless, given the risk of a vehicle rollaway, FCA’s CSN actions provide automated vehicle securement when an operator attempts to exit the vehicle without successfully achieving a Park position with the rotary shifter mechanism. ODI closely monitored the subject vehicles on which the CSN actions implement a vehicle securement strategy and found that the CSN actions were effective in reducing the frequency of vehicle rollaway incidents in the subject vehicles. ODI analyzed the incidents when a CSN had been implemented and a rollaway still occurred, and ODI was unable to find an actionable defect that caused vehicle rollaway incidents. ODI found that the failure rates on subject vehicles that received a CSN remedy were similar to the failure rates on other vehicle populations and additionally had similar mechanisms as other vehicle populations such as slippery surfaces and various mechanical failures. Furthermore, as discussed above, after FCA’s release of the CSN actions, consumer complaints have decreased significantly. Given the absence of an identified safety defect based on available information and FCA’s customer satisfaction campaign which addresses the failure mode, further action is not warranted at this time. Accordingly, this Preliminary Evaluation is closed. However, the Agency reserves the right to take further action, if warranted.Please see the attached detailed closing summary for more information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.