NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
119 reportsClear category filter58,000 miles · Oct 23, 2013
Electrical SystemEngineFuel/propulsion System
I TOOK MY VEHICLE TO THE DODGE DEALER AND WAS TOLD THAT MY CAR COULD NOT CRANK BECAUSE OF A BAD TIPM MODULE. WELL THAT WAS A MONTH AGO, AS I WAS TOLD THE PART WAS ON BACK ORDER AND WOULD BE HERE OCTOBER 20TH. WELL THAT DATE CAME AND PASSED AND NOW I AM TOLD THE PART WILL NOT BE AVAILABLE UNTIL NOVEMBER 19TH. AS I AM A CUSTOME…
Read full complaint
I TOOK MY VEHICLE TO THE DODGE DEALER AND WAS TOLD THAT MY CAR COULD NOT CRANK BECAUSE OF A BAD TIPM MODULE. WELL THAT WAS A MONTH AGO, AS I WAS TOLD THE PART WAS ON BACK ORDER AND WOULD BE HERE OCTOBER 20TH. WELL THAT DATE CAME AND PASSED AND NOW I AM TOLD THE PART WILL NOT BE AVAILABLE UNTIL NOVEMBER 19TH. AS I AM A CUSTOMER WHO IS SUPPORTED DODGE I AM BEGINNING TO HAVE SECOND THOUGHTS AND WILL KEEP THIS IN MIND WHEN I PURCHASE ANOTHER VEHICLE. I CANNOT BELIEVE THAT THERE IS NOT A NATIONAL RECALL BECAUSE OF THE NUMEROUS CUSTOMERS THAT ARE AWAITING THIS PARTICULAR PART. WE NEED HELP FROM SOMEONE AS MY CAR WILL SIT FOR AT LEAST 2 MONTHS. *TR
NHTSA ODI #10549031
47,460 miles · Oct 21, 2013
Fuel/propulsion System
TL* THE CONTACT OWNS A 2011 DODGE DURANGO. THE CONTACT STATED THE VEHICLE WOULD STALL SPORADICALLY DUE TO LACK OF FUEL REACHING THE ENGINE WHEN FIRST STARTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST. THE DEALER STATED THAT THE TIPM THAT POWERED THE FUEL PUMP TO THE ENGINE WAS DEFECTIVE. THE VEHICLE WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2011 DODGE DURANGO. THE CONTACT STATED THE VEHICLE WOULD STALL SPORADICALLY DUE TO LACK OF FUEL REACHING THE ENGINE WHEN FIRST STARTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST. THE DEALER STATED THAT THE TIPM THAT POWERED THE FUEL PUMP TO THE ENGINE WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED BECAUSE THE PART NEEDED TO COMPLETE THE REPAIRS WAS ON BACKORDER. THE CONTACT DID NOT CALL THE MANUFACTURER. THE FAILURE MILEAGE WAS 47,460.
NHTSA ODI #10548810
36,963 miles · Oct 2, 2013
EngineFuel/propulsion System
I HAVE A 2011 DODGE DURANGO THAT HAS BEEN IN THE DEALERSHIP'S SHOP SINCE SEPT 20TH. THE FUEL PUMPS FAILED BECAUSE OF A KNOWN ISSUE WITH THE TOTALLY INTEGRATED POWER MODULE. THIS ITEM HAS BEEN ON BACKORDER AND IF THAT'S NOT ENOUGH...DEALERSHIPS NATIONWIDE ARE RESTRICTED TO ORDERING ONE MODULE PER WEEK. I BELIEVE THIS ITEM SHOULD …
Read full complaint
I HAVE A 2011 DODGE DURANGO THAT HAS BEEN IN THE DEALERSHIP'S SHOP SINCE SEPT 20TH. THE FUEL PUMPS FAILED BECAUSE OF A KNOWN ISSUE WITH THE TOTALLY INTEGRATED POWER MODULE. THIS ITEM HAS BEEN ON BACKORDER AND IF THAT'S NOT ENOUGH...DEALERSHIPS NATIONWIDE ARE RESTRICTED TO ORDERING ONE MODULE PER WEEK. I BELIEVE THIS ITEM SHOULD BE ON RECALL BECAUSE APPARENTLY OTHERS ARE WAITING FOR THIS PART...SOME OVER A PERIOD OF MONTHS. I NEED MY VEHICLE. I'VE BEEN IN TOUCH WITH CUSTOMER SERVICE/CORPORATE WHO HAS BEEN GIVING ME THE RUN AROUND AND EVEN PROMISING ME A RENTAL CAR...BUT NOT MAKING GOOD ON THEIR PROMISE. I'M TO THE POINT WHERE I'M CALLING THEM DAILY AND GETTING THE SAME RESPONSE. I'VE BEEN ASSIGNED A CASE MANAGER...BUT THE CASE MANAGER NEVER CALLED ME. DODGE DOESN'T HAVE THE COURTESY OF CALLING ME BACK TO LET ME KNOW WHAT'S GOING ON. WHAT KIND OF BUSINESS IS THAT? TOMORROW I WILL HAVE BEEN WITHOUT MY VEHICLE FOR TWO WEEKS WITHOUT ANY OTHER MEANS OF TRANSPORTATION. I WASN'T GIVEN AN ESTIMATE ON WHEN THE PART WOULD BE IN OR A RENTAL CAR. THIS REALLY SUCKS! I HAVE YOUNG KIDS AND PRAY THAT THERE ISN'T AN EMERGENCY WHERE I NEED TO JUMP IN MY VEHICLE AND GO BECAUSE I WON'T BE ABLE TO. *TR
NHTSA ODI #10546531
49,996 miles · Oct 1, 2013
Electrical SystemFuel/propulsion System
I ATTEMPTED TO START MY VEHICLE AND IT WOULD NOT START IF I STEPPED ON THE GAS VERY HARD AND SEVERAL TIME IT WOULD THEN START. I WAS THEN SITTING AT A RED LIGHT AND THE CAR STALLED IN THE MIDDLE OF AN INTERSECTION. I MADE AN APPOINTMENT WITH A LOCAL DODGE DEALERSHIP AT MOTORWOLD. MY APPOINTMENT WASN'T FOR SEVERAL DAYS AND I CONT…
Read full complaint
I ATTEMPTED TO START MY VEHICLE AND IT WOULD NOT START IF I STEPPED ON THE GAS VERY HARD AND SEVERAL TIME IT WOULD THEN START. I WAS THEN SITTING AT A RED LIGHT AND THE CAR STALLED IN THE MIDDLE OF AN INTERSECTION. I MADE AN APPOINTMENT WITH A LOCAL DODGE DEALERSHIP AT MOTORWOLD. MY APPOINTMENT WASN'T FOR SEVERAL DAYS AND I CONTINUED TO HAVE PROBLEMS STARTING MY VEHICLE IN WHICH I WOULD ATTEMPT TO START THE IGNITION AND IT WOULDN'T TURN ON AND I WOULD HAVE TO STEP ON THE GAS VERY HARD UNTIL IT STARTED. I THEN HAD MY APPOINTMENT WITH THE DODGE DEALER AT MOTORWORLD. I WAS TOLD 2 DAYS LATER THAT MY VEHICLE HAD BEEN DIAGNOSED WITH A TOTAL TIPM(TOTAL INTEGRATED POWER MODULE) FAILURE AND THAT MY CAR WAS UNSAFE TO DRIVE. I WOULD TOLD THAT THE TIPM WAS ON AN INTERGALACTIC BACK ORDER AND THAT THERE WERE NO PARTS IN USA AND THAT OVER 1000 PEOPLE THROUGHOUT THE US WERE AWAITING THIS PART. I WAS TOLD THAT MOTORWOLD WOULD NOT BE ABLE TO GET THE TIPM UNTIL APPROXIMATELY SOME TIME IN NOVEMBER 2013. I WAS TOLD THAT MY WARRANTY COMPANY FIDELITY WHOM I HAD AN EXTENDED WARRANTY THROUGH WOULD ONLY COVER 1 DAY OF RENTAL. I WAS TOLD THAT I NEEDED TO CONTACT CHRYSLER REGARDING A RENTAL VEHICLE. I SPEND HOURS CALLING AND ON HOLD WITH CHRYSLER WITH PHONE CALLS. I ALSO HAVE LODGED A COMPLAINT WITH THE DEPARTMENT OF CONSUMER PROTECTION. AT THIS TIME I AM PAYING FOR VEHICLE THAT I CAN NOT DRIVE. I AM CURRENTLY IN A RENTAL VEHICLE AND IT IS UNKNOWN WHEN MY VEHICLE WILL BE FIXED. I FEAR THAT THE TIPM WILL BE REPLACED WITH ANOTHER FAULTY PART. I FEAR SOMEONE WILL BE SERIOUSLY INJURED OR KILLED DUE TO THIS FAULTY VEHICLE. I AM CURRENTLY PAYING FOR A CARE THAT I CAN NOT DRIVE BC IT IS UNSAFE. DODGE/CHRYSLER NEEDS TO DO SOMETHING FOR THEIR CUSTOMERS WHO WERE SOLD A FAULTY UNSAFE VEHICLE. *TR
NHTSA ODI #10546386
85,251 miles · Sep 19, 2013
Electrical SystemFuel/propulsion System
VEHICLE DIFFICULT TO START UP AND WILL SHUT OFF AT ANY TIME WHILE DRIVING...LUCKILY I COASTED TO SIDE OF ROAD WITHOUT LOSING CONTROL. *TR
NHTSA ODI #10544414
57,000 miles · Sep 16, 2013
Fuel/propulsion System
MY EXPRESS DODGE DURANGO (PURCHASED IN FEBRUARY 2011 WITH 4 MILES ON IT) BEGAN EXPERIENCING PROBLEM STARTING ABOUT 4 WEEKS AGO AUGUST 2013. IT STARTED TAKING MULTIPLE ATTEMPTS TO ACTUALLY GET THE ENGINE TO CATCH. THEN LAST SATURDAY, I WENT TO TURN THE CAR ON AND IT WOULD NOT START AT ALL. I HAD TO HAVE THE VEHICLE TOWED TO A…
Read full complaint
MY EXPRESS DODGE DURANGO (PURCHASED IN FEBRUARY 2011 WITH 4 MILES ON IT) BEGAN EXPERIENCING PROBLEM STARTING ABOUT 4 WEEKS AGO AUGUST 2013. IT STARTED TAKING MULTIPLE ATTEMPTS TO ACTUALLY GET THE ENGINE TO CATCH. THEN LAST SATURDAY, I WENT TO TURN THE CAR ON AND IT WOULD NOT START AT ALL. I HAD TO HAVE THE VEHICLE TOWED TO A DODGE DEALERSHIP IN AUBURN, WA. I JUST RECEIVED A REPORT THAT PROBLEM IS DUE TO A BROKEN FUEL PUMP. HOWEVER,AFTER READING ALL THE COMPLAINTS ON THE VEHICLE THIS PROBABLY SOUNDS VERY SIMILAR TO THE OTHER OWNERS OF THIS VEHICLE. THE FUEL PUMP IS ON BACK ORDER FOR 2 WEEKS! *TR
NHTSA ODI #10543934
50,145 miles · Sep 10, 2013
Electrical SystemFuel/propulsion System
WE STARTED HAVING ISSUES WITH THE CAR WANTING TO START OR START FOR A FEW SECONDS AND SLOWLY DIE UNTIL WE HEAR A KNOCKING SOUND. AFTER QUITE A FEW ATTEMPTS THE CAR WOULD FINALLY START. 2011 DODGE DURANGO, WAS THEN TAKEN TO THE DEALERSHIP WHERE IT WAS IDENTIFIED AS A FAULTY TIPM (TOTALLY INTEGRATED POWER MODULE) THAT WAS NOT SE…
Read full complaint
WE STARTED HAVING ISSUES WITH THE CAR WANTING TO START OR START FOR A FEW SECONDS AND SLOWLY DIE UNTIL WE HEAR A KNOCKING SOUND. AFTER QUITE A FEW ATTEMPTS THE CAR WOULD FINALLY START. 2011 DODGE DURANGO, WAS THEN TAKEN TO THE DEALERSHIP WHERE IT WAS IDENTIFIED AS A FAULTY TIPM (TOTALLY INTEGRATED POWER MODULE) THAT WAS NOT SENDING SIGNAL CORRECTLY TO FUEL PUMP. DEALERSHIP MADE US PAY $900 PLUS FOR THE PART AND LET US DRIVE IT OFF THE LOT. ISSUE STILL OCCURRED FOR A LITTLE OVER A WEEK BEFORE THE VEHICLE COMPLETELY SHUT OFF WHILE GOING 60 MPH DOWN THE ROAD. LUCKILY WE WERE ABLE TO GET THE VEHICLE TO THE SHOULDER BEFORE BEING IN AN ACCIDENT. THE VEHICLE STARTED BACK UP AND CONTINUED TO BEHAVE THE SAME UNTIL ONE DAY THE VEHICLE WOULD NOT START ANY MORE AT ALL. NOW WHAT HAPPEN WAS THE TIPM WAS CAUSING THE FUEL PUMP TO STAY ON ALL THE TIME AND THUS DRAINED THE BATTERY, AND NOW THE VEHICLE WILL NOT START AT ALL. THE VEHICLE IS JUST OVER TWO YEARS OLD. TODAY WE CONTACTED THE CORPORATE OFFICE AND WERE TOLD, THEY WERE NOT EVEN SUPPOSE TO LET US DRIVE THE VEHICLE OFF THE LOT WITH THE TIPM BEING BAD. WE HAVE WAITED OVER 10 WEEKS FOR A REPLACEMENT PART AFTER THEY HAVE ALREADY TAKEN THE MONEY AND WERE TOLD TODAY BY CORPORATE THAT OVER +1000 OF THE TIPMS ARE ON BACK ORDER WITH NO EXPECTED DATE OF DELIVERY. THIS IS ABSOLUTELY RIDICULOUS THAT A PART LIKE THIS WOULD GO OUT ON A TWO YEAR OLD VEHICLE. THIS DEFINITELY NEEDS TO BE MADE A MANDATORY RECALL AND REIMBURSEMENT BY THE CHRYSLER CORPORATION. *TR
NHTSA ODI #10542989
55,000 miles · Aug 29, 2013
Fuel/propulsion System
MY VEHICLE WOULD NOT START AFTER MULTIPLE ATTEMPTS. DODGE DEALERSHIP DIAGNOSED THE PROBLEM AT THE TIPM. THERE ARE OVER 800 TIPMS ON BACK ORDER TO DATE WITH AN ESTIMATED 4-6 WEEKS ON EXPECTED DELIVERY. THE DODGE TALK FORUM HAS OVER 900 BLOGS WITH OTHER DODGE VEHICLE OWNERS HAVING SIMILAR ISSUES WITH THE TIPM. THE TIPM ON MY C…
Read full complaint
MY VEHICLE WOULD NOT START AFTER MULTIPLE ATTEMPTS. DODGE DEALERSHIP DIAGNOSED THE PROBLEM AT THE TIPM. THERE ARE OVER 800 TIPMS ON BACK ORDER TO DATE WITH AN ESTIMATED 4-6 WEEKS ON EXPECTED DELIVERY. THE DODGE TALK FORUM HAS OVER 900 BLOGS WITH OTHER DODGE VEHICLE OWNERS HAVING SIMILAR ISSUES WITH THE TIPM. THE TIPM ON MY CAR IS CAUSING THE FUEL SYSTEM TO MALFUNCTION BUT SINCE THE TIPM IS THE FUSE BOX IT CONTROLS MULTIPLE COMPONENTS ON THE VEHICLE. OTHER DODGE OWNERS HAVE HAD PROBLEMS WITH HEADLIGHTS, ELECTRIC WINDOWS, BATTERIES, AND THE LIST GOES ON. DODGE CUSTOMER SERVICE IS ONLY WILLING TO OFFER ASSISTANCE IF THE PART IS ORDERED THROUGH THE DEALERSHIP AND THEN THE ASSISTANCE IS LIMITED TO EXPEDITING THE PART ORDER. AT THE VERY LEAST DODGE SHOULD OFFER EXTENDED WARRANTY ON THE PART ITSELF WHICH COSTS $800 ALONE AND WITH INSTALLATION AT THE DEALERSHIP RUNS OVER $1300.
NHTSA ODI #10537920
42,108 miles · Jul 22, 2013
Electrical SystemEquipment Adaptive/mobilityFuel/propulsion System
MY VEHICLE HAS PUSH BUTTON START. THE BATTERY IN THE REMOTE THAT CONTROLS THE VEHICLE STARTED TO DIE AND THE VEHICLE BECAME HARD TO START. TOOK THE REMOTES TO THE DEALERSHIP TO GET THE BATTERIES CHANGED. THEY MANAGED TO DAMAGE THE PROGRAMMING TO THE VEHICLE. TWO DAYS AFTER CHANGING THE BATTERY, THE VEHICLE WOULD NOT START AT ALL…
Read full complaint
MY VEHICLE HAS PUSH BUTTON START. THE BATTERY IN THE REMOTE THAT CONTROLS THE VEHICLE STARTED TO DIE AND THE VEHICLE BECAME HARD TO START. TOOK THE REMOTES TO THE DEALERSHIP TO GET THE BATTERIES CHANGED. THEY MANAGED TO DAMAGE THE PROGRAMMING TO THE VEHICLE. TWO DAYS AFTER CHANGING THE BATTERY, THE VEHICLE WOULD NOT START AT ALL. IT WAS NO LONGER STALLING. HAD THE VEHICLE TOWED TO THE DEALERSHIP AND THEY STATED THE PROGRAMMING WAS OFF AND THE TIP MODULE WAS GONE AND NEEDED REPLACEMENT. THEY COULD NOT OFFER FURTHER DETAILS. *TR
NHTSA ODI #10526271
Official recalls
8Nov 14, 2019
Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice when the final remedy becomes available. Owner notification letters were mailed on December 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V62.
Sep 18, 2017
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence & remedy
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Additional source detail variants (2)
Service Brakes
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Service Brakes, Hydraulic:power Assist
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Jul 10, 2017
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.
Dec 28, 2015
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence & remedy
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Additional source detail variants (2)
Interior Lighting
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Oct 8, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.
Sep 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, to July 20, 2011, and equipped with either a 3.6L or 5.7L engine. In the affected vehicles, the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM, free of charge. The recall began December 19, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P54. Note: This recall has been superseded by recall 19V813.
Jul 2, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is performed.
Consequence & remedy
Consequence: If the vanity lamp wiring shorts, there is an increased risk of fire.
Remedy: Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.
Apr 1, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence & remedy
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Additional source detail variants (2)
Service Brakes
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Service Brakes, Hydraulic:power Assist:vacuum
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ15003 · Post 14V-391 Headliner Fires
Opened May 1, 2015 · Closed Jul 6, 2016
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Additional source detail variants (5)
Electrical System
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring:fuses And Circuit Breakers
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring:interior/under Dash
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Interior Lighting
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
EA14001 · Headliner Fires
Opened Jan 10, 2014 · Closed Aug 12, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Additional source detail variants (5)
Electrical System
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring:fuses And Circuit Breakers
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring:interior/under Dash
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Interior Lighting
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
PE13027 · Headliner Fires
Opened Aug 19, 2013 · Closed Jan 14, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Additional source detail variants (5)
Electrical System
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring:fuses And Circuit Breakers
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Interior Lighting
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Illustration