NHTSA owner reports · September 18, 2026 snapshot.
Electronic Stability Control (esc) complaints
21 reportsClear category filter160,000 miles · May 11, 2017
Electrical SystemElectronic Stability Control (esc)Steering
FAULTY VEHICLE 180 AMP ALTERNATOR CAUSED A VERY DANGEROUS SITUATION FOR ME AND MY PASSENGER AND OTHER VEHICLES DRIVING BEHIND ME THAT REQUIRED A SHERIFF TO KEEP OTHER VEHICLES FROM WRECKING WHILE TRYING CONTROL THE VEHICLE WHILE DRIVING. THE DASHBOARD AND ALL ELETRICAL FUNCTIONS STARTED GOING HAYWIRE ALL AT THE SAME TIME WHEN …
Read full complaint
FAULTY VEHICLE 180 AMP ALTERNATOR CAUSED A VERY DANGEROUS SITUATION FOR ME AND MY PASSENGER AND OTHER VEHICLES DRIVING BEHIND ME THAT REQUIRED A SHERIFF TO KEEP OTHER VEHICLES FROM WRECKING WHILE TRYING CONTROL THE VEHICLE WHILE DRIVING. THE DASHBOARD AND ALL ELETRICAL FUNCTIONS STARTED GOING HAYWIRE ALL AT THE SAME TIME WHEN DRIVING ON A VERY WINDING CURVY BUSY BACK ROAD, LOST STEERING CONTROLL, ALL MESSAGE CENTER LIGHTS FLASHING AND WIPERS GOING ALL AT THE SAME TIME HOT AIR BLOWING THROUGH AC VENTS, THEN VEHICLE ABRUPTLY STOPS WHILE SMOKING ACTING AS IT SEEMED TO BE OVER HEATED OR SOMETHING BURNING. HAD TO MANUALLY GET DOORS UNLOCKED TO GET OUT OF VEHICLE QUICKLY BEFORE ANOTHER VEHICLE WOULD HIT US. VEHICLE KEY STAYED STUCK IN THE IGNITION AND VEHICLE COULD NOT BE STARTED OR PLACED IN REVERSE OR NEUTRAL TO PUSH THE VEHICLE TO SAFETY TO MAKE SURE OTHER DRIVERS WOULD NOT CRASH WHERE THE VEHICLE ABRUPTLY STOPPED, THIS HAPPEND WHILE VEHICLE WAS RUNNING WITH NO WARNING SIGNS PRIOR TO HAPPENING. HOW CAN DODGE ONLY RECALL 2011 160 AMP ALTERNATORS AND NOT THE 2011 180 AMP ALTERNATORS THAT ARE CLEARLY PUTTING THE CUSTOMERS AND OTHERS LIVES IN DANGER FOR THE SAME ISSUES. THIS NEEDS TO BE RECALLED AND REPAIRED. THIS FAULTY ALTERNATOR ISSUE IS CAUSING DAMAGE TO ALL 2011 DODGE DURANGO AND COSTING DRIVERS TO ALMOST BE IN SERIOUS ACCIDENTS AND LOTS OF MONEY FOR REPAIRS. WHEN PURCHASING VEHICLES WE ARE TRUSTING THAT THEY ARE SAFE
NHTSA ODI #10984896
80,000 miles · Oct 31, 2016
Electrical SystemElectronic Stability Control (esc)Engine
SAFETY ISSUE ON MY 2011 DODGE DURANGO. WHILE DRIVING HOME AFTER WORK LATE ONE NIGHT, THE DURANGO STARTED ACTING UP LIKE IT WAS POSSESSED. THE LIGHTS WOULD GO ON AND OFF, THE WIPERS WENT ON AND WOULDN'T SHUT OFF, SEATS WENT BACK AND FORTH WHILE DRIVING!, RADIO, HEAT, AC. I WAS IN TRAFFIC AND FINALLY MANAGED TO MOVE OVER TO A S…
Read full complaint
SAFETY ISSUE ON MY 2011 DODGE DURANGO. WHILE DRIVING HOME AFTER WORK LATE ONE NIGHT, THE DURANGO STARTED ACTING UP LIKE IT WAS POSSESSED. THE LIGHTS WOULD GO ON AND OFF, THE WIPERS WENT ON AND WOULDN'T SHUT OFF, SEATS WENT BACK AND FORTH WHILE DRIVING!, RADIO, HEAT, AC. I WAS IN TRAFFIC AND FINALLY MANAGED TO MOVE OVER TO A SECURE LOCATION OUT OF HARMS WAY NO SOONER DID I PULL OFF THE SIDE OF THE ROAD THEN THE DODGE COMPLETELY DIED. I HAD TO COAST DOWN A HILL. TRIED TO TURN IT OVER AND NOTHING. NO LIGHTS NO RADIO NO NOTHING. IT WAS DEAD. HAD TO HAVE IT TOWED TO THE DEALERSHIP. THE DEALER CLAIMED IT WAS THE BATTERY, INSTALLED A NEW ONE AND SENT ME ON MY WAY. FAST FORWARD TO LESS THAN 2 WEEKS LATER- SAME PROBLEM. DRIVING TO DROP OFF MY 5 YEAR OLD AND IT STARTS ACTING UP AGAIN COMPLETELY POSSESSED. HOW IS THIS SAFE? I MADE IT TO WORK WITH IT GOING CRAZY. AT LUNCH, I WENT TO START IT AND CHECK IT OUT. DEAD. BRAND NEW BATTERY DEAD. 400 BUCKS DOWN THE DRAIN- WHEN THAT WASN'T THE PROBLEM. NOT TO MENTION THE 200 BUCKS TO TOW. I BROUGHT IT TO A LITTLE SHOP AROUND THE CORNER AND THEY COULDN'T FIND THE PROBLEM AND TOWED IT BACK TO THE DEALER. AND THERE IT SITS. NO ONE CAN FIGURE OUT WHAT IS WRONG WITH IT OVER THERE. IT IS REALLY PATHETIC. SO NOW ADD'L TOW CHARGES-$200, NO VEHICLE TO GET BACK AND FORTH TO WORK AND CHILD'S STROKE THERAPISTS, AND HAD TO BREAK DOWN AND PAY FOR A RENTAL. WHAT A JOKE THANKS DODGE. THEY ARE WELL AWARE OF THE TIPM ISSUES AND REFUSE TO RECALL ANY OF THEIR VEHICLES. THIS IS A HUGE HUGE SAFETY ISSUE. EVERYTHING JUST DIES.. THE ENGINE THE BRAKES DON'T WORK NOTHING. *TR
NHTSA ODI #10920306
Mileage unknown · Sep 29, 2016
Electronic Stability Control (esc)Engine
2011 DODGE DURANGO RECALL# 14V634000, ELECTRICAL SYSTEM, ALTERNATOR. THE TRUCK WAS IN MOTION ON A BUSY CITY STREET AND STOPPED ABRUPTLY. THE ENTIRE COMPUTER SYSTEM WENT OUT, CAUSING THE ALTERNATOR, AND THE BATTERY TO BE DISABLED. DODGE REFUSED TO REIMBURSE FOR THE 2K WE PAID IN REPAIRS.
NHTSA ODI #10910530
Mileage unknown · Sep 28, 2016
Electronic Stability Control (esc)Fuel/propulsion System
RADIO STARTED GOING OFF AND ON ONCE THE CAR WAS PARKED STARTED SMOKING UNDER HOOD AND THEN WOULD NOT START AT ALL HAD TO HAVE IT TOWED TO A GARAGE. GARAGE ALTERNATOR CAUGHT ON FIRE ORDER NEW ALTERNATOR ALSO IT RUINED THE BATTERY NEW BATTERY PUT IN STILL WOULD NOT START HAD TO TAKE IT TO A DODGE DEALER NOW I HAVE A BILL FOR $1500…
Read full complaint
RADIO STARTED GOING OFF AND ON ONCE THE CAR WAS PARKED STARTED SMOKING UNDER HOOD AND THEN WOULD NOT START AT ALL HAD TO HAVE IT TOWED TO A GARAGE. GARAGE ALTERNATOR CAUGHT ON FIRE ORDER NEW ALTERNATOR ALSO IT RUINED THE BATTERY NEW BATTERY PUT IN STILL WOULD NOT START HAD TO TAKE IT TO A DODGE DEALER NOW I HAVE A BILL FOR $1500.00 I HAVE TRYING TO PAY AS MUCH AS I COULD AFFORD EACH WEEK BUT NOT GETTING FAR I NEED SOMETHING,I REALLY NEED MY CAR BACK
NHTSA ODI #10910118
90,000 miles · Jul 18, 2016
Electrical SystemElectronic Stability Control (esc)Engine
I WAS DRIVING WITH MY KIDS GETTING OUR DAY STARTED. I TURN ON WITH REMOTE START WAS MAKING LOUD SCREECHING SOUND. LOADED UP KIDS AND STARTED TO TAKE OFF. WE COULD ALL SMELL A BAD BURNING SMELL. I CHECK ALL TEMPS ON CAR AND NOTHING READ HIGH TEMPERATURE. I DROVE ON MY WAY TO DAYCARE WHEN MY CAR STALLED AND SHUT DOWN. AND IT H…
Read full complaint
I WAS DRIVING WITH MY KIDS GETTING OUR DAY STARTED. I TURN ON WITH REMOTE START WAS MAKING LOUD SCREECHING SOUND. LOADED UP KIDS AND STARTED TO TAKE OFF. WE COULD ALL SMELL A BAD BURNING SMELL. I CHECK ALL TEMPS ON CAR AND NOTHING READ HIGH TEMPERATURE. I DROVE ON MY WAY TO DAYCARE WHEN MY CAR STALLED AND SHUT DOWN. AND IT HAD PREVIOUSLY DID THIS B4 LIKE 4 MONTHS OR SO AND A RECALL OF FUEL PUMP WAS DONE AND HAD BEEN RUNNING FINE TILL THIS DAY. I TRIED STARTING IT A FEW TIMES NOTHING. FINALLY TURN ON AND BATTERY LIGHT CAME ON. I DROVE IT TO DROP OF MY 3 KIDS AT CAMP WHEN IT KEPT FEELING LIKE IT WANTED TO TURN OF. STILL SMELLING BURNING. FINALLY I'M HEADED TO WORK AND IT STALLED IN MIDDLE OF INTERSECTION. THANK GOD I DIDN'T HAVE MY KIDS WITH ME AND NO ACCIDENTS HAPPENED. I HAD CAR TOWED TO LOCAL MECHANIC BECAUSE DEALERSHIP IS AND HOUR AWAY. HE SAID ALTERNATOR GAVE OUT. PUT NEW ALTERNATOR IN STILL NOTHING. 600 DOLLARS DOWN DRAIN. NOW I HAVE TO PAY TOWING TO GET TO DEALERSHIP WHICH WILL MEAN JUST MORE MONEY DOWN THE DRAIN WHICH I DON'T HAVE THE EXTRA MONEY AND USE THIS CAR FOR WK SO HOPEFULLY I DON'T LOSE MY JOB. I DON'T UNDERSTAND HOW I HAVE SAME EXACT PROBLEMS AS ANOTHER 2011 DURANGO UNDER RECALL BUT MINE AIN'T ONE OF THEM. DO YOU HAVE TO WAIT TILL SOMEONE IS SERIOUSLY HURT OR KILLED TO HAVE A RECALL. IF NONE OF THIS IS RESOLVED PROPERLY I WILL BE HIRING A LAWYER. I HAVE ONLY HAD VEHICLE FOR 2YRS.
NHTSA ODI #10885696
90,000 miles · Jun 20, 2016
Electrical SystemElectronic Stability Control (esc)
WHILE IN MOTION ON CITY STREET, FIRST MY RADIO WOULD TURN OFF ON ITS OWN, THEN THE BATTERY LIGHT CAME ON, THEN ALL THE SERVICE LIGHTS CAME ON FILLED BY MY ACCOUNT BLOWING OUT HOT AIR AND THEN MY CAR COMPLETELY SHUT OFF ON ME NOT ALLOWING ME TO REMOVE MY KEY OR PUT MY CAR ON NEUTRAL OR ALLOWING ME TO PUT ON THE HAZARD LIGHTS ON. …
Read full complaint
WHILE IN MOTION ON CITY STREET, FIRST MY RADIO WOULD TURN OFF ON ITS OWN, THEN THE BATTERY LIGHT CAME ON, THEN ALL THE SERVICE LIGHTS CAME ON FILLED BY MY ACCOUNT BLOWING OUT HOT AIR AND THEN MY CAR COMPLETELY SHUT OFF ON ME NOT ALLOWING ME TO REMOVE MY KEY OR PUT MY CAR ON NEUTRAL OR ALLOWING ME TO PUT ON THE HAZARD LIGHTS ON. IT FOLLOWED BY A BURNING SMELL UNDER THE HOOD.
NHTSA ODI #10875464
79,000 miles · Jan 15, 2016
Electronic Stability Control (esc)SteeringVehicle Speed Control
I PURCHASED MY 2011 DODGE DUANGO CITADEL IN AUGUST 2015. ON SEVERAL OCCASIONS, BOTH WEEKS AND MONTHS APART, MY HAZARD LIGHTS WILL RANDOMLY CUT OFF AND ON JUST LONG ENOUGH FOR YOU TO THINK YOU'RE CRAZY AND SECOND GUESS IF YOU SAW THEM. I EVENTUALLY HAD TO TAKE MY CAR TO THE DODGE DEALERSHIP BECAUSE THE CAR WAS NOT TURNING OVER …
Read full complaint
I PURCHASED MY 2011 DODGE DUANGO CITADEL IN AUGUST 2015. ON SEVERAL OCCASIONS, BOTH WEEKS AND MONTHS APART, MY HAZARD LIGHTS WILL RANDOMLY CUT OFF AND ON JUST LONG ENOUGH FOR YOU TO THINK YOU'RE CRAZY AND SECOND GUESS IF YOU SAW THEM. I EVENTUALLY HAD TO TAKE MY CAR TO THE DODGE DEALERSHIP BECAUSE THE CAR WAS NOT TURNING OVER AT THE START AND BECAME INOPERABLE. ONCE AT THE DEALERSHIP, THE MANAGER DETERMINED THAT ALTHOUGH MY CAR REPORTED TO HAVE ALREADY HAD THE TIPM REPLACED, IT WAS ACTUALLY NOT. THE ORIGINAL TIPM WAS STILL IN THE CAR, MEANING THAT THE CARFAX REPORTING THAT THE TIPM RECALL HAD BEEN EXECUTED WAS FALSE. AFTER MY TIPM WAS REPLACED, MY CAR OPERATED FINE UNTIL ONE DAY WHILEI WAS DRIVING WITH MY 2 YEAR OLD IN THE CAR. I WAS COMING UP ON A STOP SIGN, AND WHEN I WENT TO MAKE A RIGHT HAND TURN MY CAR STALLED. ALL OF THE LIGHTS WERE ON AND THE RADIO STILL FUNCTIONED, BUT I LOST COMPLETE POWER STEERING AND MY HAZARD LIGHTS WOULD NOT WORK WHEN I TRIED TO CUT THEM ON TO ALERT OTHER DRIVERS. I WAS ABLE TO PUT MY CAR IN PARK AND RESTART IT SUCCESSFULLY. I TOOK AROUND 3 WEEKS BEFORE I WAS ABLE TO MAKE AN APPT. FOR MY CAR TO BE LOOKED AT. DURING THIS TIME MY HAZARD LIGHTS SPORADICALLY CAME ON FROM TIME TO TIME, LASTING NO LONGER THAN A COUPLE OF SECONDS. MIGHT I MENTION THAT WHEN THE CAR STALLED MY FCW OFF LIGHT AND THE ADAPTIVE CRUISE CONTROL SYMBOL CAME ON. AFTER A THOROUGH REVIEW AT THE DODGE DEALERSHIP, I WAS INFORMED THAT THAT THERE WAS NO PROBLEM DETECTED. I WAS TOLD THAT ALL THE CONNECTIONS WERE CHECKED AND THAT NO TROUBLE CODES WERE COMING UP WHEN RUNNING DIAGNOSTICS. I LEFT THE DEALERSIHP HOPING MY PROBLEM HAD BEEN A FLUKE. BOY WAS I WRONG! SINCE THEN, MY HAZARD LIGHTS HAVE STILL BEEN SPIRATICALLY GOING OFF AND HAS STALLED AGAIN, THIS TIME WHILE I WAS MAKING A LEFT HAND TURN ONTO MY ROAD WITH MY 5 YEAR OLD IN THE CAR. THIS IS RIDICULOUS!
NHTSA ODI #10820596
150,000 miles · Dec 4, 2015
Electrical SystemElectronic Stability Control (esc)
I WAS DRIVING ON A MAJOR INTERSTATE (I-70) WHEN DASHBOARD LIGHTS STARTED FLASHING AND SIGNALS STARTED GOING OFF. SEAT BELT SIGNAL. AIRBAG SIGNAL. ABS LIGHT SIGNAL. I THEN LOST POWER STEERING. MY 12-YEAR OLD WAS WITH ME AND SCARED TO DEATH AS CARS WHIZZED BY AT 70 MPH. I LUCKILY WAS AT AN OFF RAMP AND TOOK IT AND MANAGED TO PULL…
Read full complaint
I WAS DRIVING ON A MAJOR INTERSTATE (I-70) WHEN DASHBOARD LIGHTS STARTED FLASHING AND SIGNALS STARTED GOING OFF. SEAT BELT SIGNAL. AIRBAG SIGNAL. ABS LIGHT SIGNAL. I THEN LOST POWER STEERING. MY 12-YEAR OLD WAS WITH ME AND SCARED TO DEATH AS CARS WHIZZED BY AT 70 MPH. I LUCKILY WAS AT AN OFF RAMP AND TOOK IT AND MANAGED TO PULL OFF THE MAIN ROAD. CAR WOULD NOT TURNOVER WHEN I TRIED IT AGAIN. GOT TOWED TO A DEALERSHIP. BATTERY WAS REPLACED FIRST. THEN THEY HOOKED UP THE ALTERNATOR TO THE NEW BATTERY, AND THE ALTERNATOR DRAINED THE NEW BATTERY BY HALF IN A MATTER OF SECONDS. AND STARTED SMOKING PROFUSELY. DEALERSHIP REPLACED THE ALTERNATOR, WHICH WAS A 220 AMP. AFTER THE ALTERNATOR WAS REPLACED IT WAS DETERMINED THAT THE ALTERNATOR BLEW THE PCM, SO I HAD TO HAVE THE COMPUTER PCM REPLACED TOO. DEALER SAYS THERE MAY BE MORE ISSUES THAT ARISE FROM THE BAD ALTERNATOR. HE WAS SURPRISED MORE WIRES AND FUSES WEREN'T MELTED OR DAMAGED BECAUSE OF HOW BAD THE ALTERNATOR WAS. MY CAR WAS NOT PART OF THE RECALL BECAUSE I HAVE A 220 AMP. BUT ALL OF THE SYMPTOMS THEY DESCRIBE FOR THE 160 AMP ALTERNATOR IS WHAT I EXPERIENCED WITH MY CAR. I AM JUST THANKFUL MY SON AND I, NOR ANYONE ELSE, WAS HURT OR KILLED IN THIS INCIDENT. ALL ALTERNATORS NO MATTER WHAT AMP NEED TO BE RECALLED. THIS IS A TRUE SAFETY HAZARD!
NHTSA ODI #10808353
31,000 miles · Oct 17, 2014
Electrical SystemElectronic Stability Control (esc)Engine
I BELIEVE THERE IS ACTUALLY 3 INCIDENTS THAT ARE ALL CONNECTED. FIRST WAS AUGUST 2014 CHECK ENGINE LIGHT WAS ON AND CAR WAS LOSING POWER. THE DEALER REPLACED THE BATTERY. I ASKED THEM TO CHECK ALTERNATOR BUT WAS TOLD IT WAS FINE. OCT 4, 2014 WE WHERE DRIVING AND THE CHECK ENGINE LIGHT CAME ON CAR WAS HAVING POWER LOSS AND ENGINE…
Read full complaint
I BELIEVE THERE IS ACTUALLY 3 INCIDENTS THAT ARE ALL CONNECTED. FIRST WAS AUGUST 2014 CHECK ENGINE LIGHT WAS ON AND CAR WAS LOSING POWER. THE DEALER REPLACED THE BATTERY. I ASKED THEM TO CHECK ALTERNATOR BUT WAS TOLD IT WAS FINE. OCT 4, 2014 WE WHERE DRIVING AND THE CHECK ENGINE LIGHT CAME ON CAR WAS HAVING POWER LOSS AND ENGINE BEGAN TO SMOKE. TOOK TO THE DEALER AND THEY CLAIMED IT WAS A BAD WATERPUMP. THEY ALSO DID RECALL WORK ON THE BRAKING SYSTEM. TWO DAYS LATER THE CHECK ENGINE LIGHT WAS ON AGAIN AND THE BATTERY LIGHT WOULD COME ON AND OFF. MY WIFE AND DAUGHTER WERE DRIVING CAR DOWN THE ROAD AND CAR POWER SYSTEM JUST SHUT DOWN. THEY HAD NO CONTROL OVER ANYTHING AT ALL IN THE VEHICLE. TOWED TO DEALER AND THEY CLAIM IT WAS THE ALTERNATOR AND THE BATTER. I AM SORRY BUT A VEHICLE WITH 31,000 MILES WITH PROPER MAINTENANCE AND AROUND 10,000 MILES A YEAR SHOULD NOT BE HAVING ALL OF THESE PROBLEM. *TR
NHTSA ODI #10648432
28,100 miles · Jul 29, 2014
Electrical SystemElectronic Stability Control (esc)Engine
WHEN THE KEY IS PUT INSIDE THE IGNITION, IT TAKES A COUPLE OF TRIES FOR THE ENGINE TO START (IF AT ALL) AFTER FAILING MULTIPLE TIMES. AFTER IT STARTS, SOMETIMES THE ENGINE SHUTS DOWN COMPLETELY WHEN I AM DRIVING AT 30+MPH AND WHEN I HIT A STOP SIGN/RED LIGHT! THIS IS VERY DANGEROUS AND NEEDS TO BE FIXED! *JS
NHTSA ODI #10617448
Official recalls
8Nov 14, 2019
Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice when the final remedy becomes available. Owner notification letters were mailed on December 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V62.
Sep 18, 2017
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence & remedy
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Additional source detail variants (2)
Service Brakes
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Service Brakes, Hydraulic:power Assist
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Jul 10, 2017
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.
Dec 28, 2015
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence & remedy
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Additional source detail variants (2)
Interior Lighting
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Oct 8, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.
Sep 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, to July 20, 2011, and equipped with either a 3.6L or 5.7L engine. In the affected vehicles, the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM, free of charge. The recall began December 19, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P54. Note: This recall has been superseded by recall 19V813.
Jul 2, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is performed.
Consequence & remedy
Consequence: If the vanity lamp wiring shorts, there is an increased risk of fire.
Remedy: Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.
Apr 1, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence & remedy
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Additional source detail variants (2)
Service Brakes
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Service Brakes, Hydraulic:power Assist:vacuum
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ15003 · Post 14V-391 Headliner Fires
Opened May 1, 2015 · Closed Jul 6, 2016
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Additional source detail variants (5)
Electrical System
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring:fuses And Circuit Breakers
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring:interior/under Dash
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Interior Lighting
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
EA14001 · Headliner Fires
Opened Jan 10, 2014 · Closed Aug 12, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Additional source detail variants (5)
Electrical System
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring:fuses And Circuit Breakers
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring:interior/under Dash
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Interior Lighting
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
PE13027 · Headliner Fires
Opened Aug 19, 2013 · Closed Jan 14, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Additional source detail variants (5)
Electrical System
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring:fuses And Circuit Breakers
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Interior Lighting
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Illustration