NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
514 reportsClear category filter44,000 miles · Oct 1, 2013
Electrical System
I AM JUST NOW BEING TOLD IT IS THE TIPM. APPARENTLY THAT CAN AFFECT SO MANY THINGS LIKE ABOUT A COUPLE OF MONTHS AFTER I BOUGHT MY CAR IN NOVEMBER 2012 I WOULD BE DRIVING DOWN THE ROAD & IT WOULD TELL ME KEY NOT DETECTED. I WOULD HAVE TO STOP & TURN MY CAR OFF THEN RESTART. AT THAT TIME MY CAR WAS STILL UNDER WARRANTY NOW I'M WI…
Read full complaint
I AM JUST NOW BEING TOLD IT IS THE TIPM. APPARENTLY THAT CAN AFFECT SO MANY THINGS LIKE ABOUT A COUPLE OF MONTHS AFTER I BOUGHT MY CAR IN NOVEMBER 2012 I WOULD BE DRIVING DOWN THE ROAD & IT WOULD TELL ME KEY NOT DETECTED. I WOULD HAVE TO STOP & TURN MY CAR OFF THEN RESTART. AT THAT TIME MY CAR WAS STILL UNDER WARRANTY NOW I'M WISHING I WOULD HAVE GOTTEN IT CHECKED OUT THEN. FOR THE LAST COUPLE OF MONTHS I'VE BEEN HAVING PROBLEMS STARTING MY CAR. THEN TODAY I HAD MY KEY FOB IN MY CAR & IT JUST LOCKED ON IT'S OWN. *TR
NHTSA ODI #10546464
49,996 miles · Oct 1, 2013
Electrical SystemFuel/propulsion System
I ATTEMPTED TO START MY VEHICLE AND IT WOULD NOT START IF I STEPPED ON THE GAS VERY HARD AND SEVERAL TIME IT WOULD THEN START. I WAS THEN SITTING AT A RED LIGHT AND THE CAR STALLED IN THE MIDDLE OF AN INTERSECTION. I MADE AN APPOINTMENT WITH A LOCAL DODGE DEALERSHIP AT MOTORWOLD. MY APPOINTMENT WASN'T FOR SEVERAL DAYS AND I CONT…
Read full complaint
I ATTEMPTED TO START MY VEHICLE AND IT WOULD NOT START IF I STEPPED ON THE GAS VERY HARD AND SEVERAL TIME IT WOULD THEN START. I WAS THEN SITTING AT A RED LIGHT AND THE CAR STALLED IN THE MIDDLE OF AN INTERSECTION. I MADE AN APPOINTMENT WITH A LOCAL DODGE DEALERSHIP AT MOTORWOLD. MY APPOINTMENT WASN'T FOR SEVERAL DAYS AND I CONTINUED TO HAVE PROBLEMS STARTING MY VEHICLE IN WHICH I WOULD ATTEMPT TO START THE IGNITION AND IT WOULDN'T TURN ON AND I WOULD HAVE TO STEP ON THE GAS VERY HARD UNTIL IT STARTED. I THEN HAD MY APPOINTMENT WITH THE DODGE DEALER AT MOTORWORLD. I WAS TOLD 2 DAYS LATER THAT MY VEHICLE HAD BEEN DIAGNOSED WITH A TOTAL TIPM(TOTAL INTEGRATED POWER MODULE) FAILURE AND THAT MY CAR WAS UNSAFE TO DRIVE. I WOULD TOLD THAT THE TIPM WAS ON AN INTERGALACTIC BACK ORDER AND THAT THERE WERE NO PARTS IN USA AND THAT OVER 1000 PEOPLE THROUGHOUT THE US WERE AWAITING THIS PART. I WAS TOLD THAT MOTORWOLD WOULD NOT BE ABLE TO GET THE TIPM UNTIL APPROXIMATELY SOME TIME IN NOVEMBER 2013. I WAS TOLD THAT MY WARRANTY COMPANY FIDELITY WHOM I HAD AN EXTENDED WARRANTY THROUGH WOULD ONLY COVER 1 DAY OF RENTAL. I WAS TOLD THAT I NEEDED TO CONTACT CHRYSLER REGARDING A RENTAL VEHICLE. I SPEND HOURS CALLING AND ON HOLD WITH CHRYSLER WITH PHONE CALLS. I ALSO HAVE LODGED A COMPLAINT WITH THE DEPARTMENT OF CONSUMER PROTECTION. AT THIS TIME I AM PAYING FOR VEHICLE THAT I CAN NOT DRIVE. I AM CURRENTLY IN A RENTAL VEHICLE AND IT IS UNKNOWN WHEN MY VEHICLE WILL BE FIXED. I FEAR THAT THE TIPM WILL BE REPLACED WITH ANOTHER FAULTY PART. I FEAR SOMEONE WILL BE SERIOUSLY INJURED OR KILLED DUE TO THIS FAULTY VEHICLE. I AM CURRENTLY PAYING FOR A CARE THAT I CAN NOT DRIVE BC IT IS UNSAFE. DODGE/CHRYSLER NEEDS TO DO SOMETHING FOR THEIR CUSTOMERS WHO WERE SOLD A FAULTY UNSAFE VEHICLE. *TR
NHTSA ODI #10546386
47,623 miles · Sep 30, 2013
Electrical SystemPower Train
TIPM=TOTALLY INTERGRATED POWER MODULE. THIS STOPS THE VEHICLE FROM CRANKING PROPERLY. IT KEEPS TURNING AND TURNING AFTER TRYING TO USE THE PUSH TO START, IT WILL CRANK, REV UP AND TURN RIGHT BACK OFF IF YOU USE THE KEY TO START IT, AND IT HAS ALREADY BEEN FLASHED WHICH DID NOT FIX THE ISSUE. I HAVE LEARNED FROM TWO DEALERSHIPS T…
Read full complaint
TIPM=TOTALLY INTERGRATED POWER MODULE. THIS STOPS THE VEHICLE FROM CRANKING PROPERLY. IT KEEPS TURNING AND TURNING AFTER TRYING TO USE THE PUSH TO START, IT WILL CRANK, REV UP AND TURN RIGHT BACK OFF IF YOU USE THE KEY TO START IT, AND IT HAS ALREADY BEEN FLASHED WHICH DID NOT FIX THE ISSUE. I HAVE LEARNED FROM TWO DEALERSHIPS THAT THERE IS OVER 14,000 ON BACKORDER. THEY DO NOT HAVE A ETA AND THEY ARE TRYING TO GET CONSUMERS TO PAY FOR THE VEHICLES IF THEY DO NOT HAVE THE BASIC WARRANTY. I EVEN PURCHASED A EXTENDED WARRANTY AT THE POINT OF PURCHASE AND THEY STATED THAT IT IS NOT COVERED. THE COST FOR THE PART AND REPAIR THEY ARE TRYING TO CHARGE ME IS $1100. THE DEALERSHIP I WENT TO ADVISED ME TO CONTACT DODGE AT 1-800-423-6343 AND I SPOKE WITH SOMEONE WHOM STATED IT WAS COVERED, IT IS NOTED IN MY FILE 3 TIMES BY 3 DIFFERENT PEOPLE THAT IT IS COVERED AND THEN I CALLED THE DEALERSHIP TO SEE IF THEY KNEW WHEN THEY WOULD GET SOME TO GET ME ON A LIST AND THEY SAID IT IS NOT COVERED, HAD TO START ALL OVER AGAIN WITH SPEAKING WITH DODGE AT THE 1800 NUMBER AND GOING BACK AND FORTH. I HAVE ONLY HAD MY VEHICLE FOR 10 MONTHS AND OF COURSE IT WAS MORE THAN 20,000 WHICH MAKES ME LIVID THAT I WOULD EVEN HAVE CAR TROUBLE THIS EARLY IN THE LOAN. I AM NOT GOING TO STOP UNTIL IT IS FIXED PROPERLY AND PEOPLE SHOULD NOT BE RESPONSIBLE FOR THIS IT SHOULD BE ON RECALL. *TR
NHTSA ODI #10546228
56,000 miles · Sep 25, 2013
Electrical SystemFuel System, GasolineService Brakes
I WAS HAVING TROUBLES WITH THE AUTO START. READ ABOUT A SERVICE BULLETIN (NUMBER: 08-024-11 REV. A) THAT FIXES THE ISSUE WITH A FLASH REPROGRAM HOWEVER THE DEALERSHIP AND CHRYSLER SAID THAT MY VIN NUMBER WERE NOT AFFECTED BY THE ISSUE. THEN FIVE DAYS AGO THERE WAS A FAN TYPE NOISE FROM THE REAR BOTTOM OF THE VEHICLE. THE FAN NO…
Read full complaint
I WAS HAVING TROUBLES WITH THE AUTO START. READ ABOUT A SERVICE BULLETIN (NUMBER: 08-024-11 REV. A) THAT FIXES THE ISSUE WITH A FLASH REPROGRAM HOWEVER THE DEALERSHIP AND CHRYSLER SAID THAT MY VIN NUMBER WERE NOT AFFECTED BY THE ISSUE. THEN FIVE DAYS AGO THERE WAS A FAN TYPE NOISE FROM THE REAR BOTTOM OF THE VEHICLE. THE FAN NOISE STAYED ON ALL NIGHT AND DRAINED MY BATTERY. I JUMP STARTED THE CAR AND IT HELD A CHARGE AND RAN FINE BUT THE FAN NOISE NEVER STOPPED. I'M BEING TOLD THAT THE FAN NOISE IS THE ABS STAYING ON BECAUSE THE TIPM IS BAD. I'M SURE THAT PARTS OF THE CAR STAYING ON BY THEMSELVES ESPECIALLY THOSE RELATED TO THE ABS MODULE MUST BE OF SOME SAFETY CONCERN. THE CAR NOT STARTING COULD BE DUE TO THE FUEL PUMP NOT BEING STARTED BY THE TIPM THIS ALSO IS CONCERNING. THE PART IS ON A 800+ BACK ORDER. SO THIS IS AFFECTING OVER 800 CUSTOMERS. I'VE MET ONE PERSON HERE IN MY CITY WHO SAYS HE IS HAVING THE SAME ISSUES WITH THE CAR NOT STARTING AND 9 OTHER PEOPLE AT HIS DEALERSHIP ARE WAITING ON THIS PART. MULTIPLE POSTERS ARE STATING THAT THEY'VE BEEN WAITING OVER A MONTH FOR A PART AND CHRYSLER IS NOT TAKING RESPONSIBILITY. FAULTY COMPUTERS THAT KEEP CERTAIN COMPONENTS ON AND OTHERS OFF IS VERY SCARY AND THE FACT THAT THEY HAVE 800+ BACK ORDER IS CONCERNING. NOT TO MENTION THAT A LOT OF THE OWNERS ARE BEING TOLD TO DRIVE THEIR CARS IN THIS CONDITION WHILE THEY WAIT FOR THE REPLACEMENT PARTS. "JUST KEEP TRYING TO START IT MANUALLY UNTIL IT STARTS". PLEASE LOOK INTO THIS ISSUE AND MAKE CHRYSLER TAKE RESPONSIBILITY FOR THIS FAULTY PRODUCT. *JS
NHTSA ODI #10545382
72,500 miles · Sep 23, 2013
Electrical System
MY 2011 DURANGO DOES NOT START. IT PRESENTS SIMILAR TO HOW A CAR WOULD IN THE PAST WHEN THE FUEL PUMP WOULD FAIL. THE DEALER DID A "DIAGNOSTIC" AND INITIALLY SAID IT WAS OK AND IT STARTED RIGHT AWAY. FIRST STOP ON THE WAY HOME AT THE STORE, IT WOULDN'T START AGAIN. WHEN WE DID GET IT STARTED, IT HAS NOW BEEN SITTING IN OUR DRIVE…
Read full complaint
MY 2011 DURANGO DOES NOT START. IT PRESENTS SIMILAR TO HOW A CAR WOULD IN THE PAST WHEN THE FUEL PUMP WOULD FAIL. THE DEALER DID A "DIAGNOSTIC" AND INITIALLY SAID IT WAS OK AND IT STARTED RIGHT AWAY. FIRST STOP ON THE WAY HOME AT THE STORE, IT WOULDN'T START AGAIN. WHEN WE DID GET IT STARTED, IT HAS NOW BEEN SITTING IN OUR DRIVE FOR A MONTH WAITING FOR A PART THE DEALER IDENTIFIED AS THE TIPM, TOTAL INTEGRATED POWER MODULE. THEY SAID IT WAS 1100 PARTS BACKORDERED, AND GAVE A STORY ABOUT HOW THE PART IS SPECIFIC FOR THE VEHICLE AND HOW THE PART PRODUCTION WERE AFFECTED BY THE RECESSION ETC. THE VEHICLE IS ALMOST DONE WITH IT'S THIRD YEAR PRODUCTION, MOVING TO 4TH YEAR NOW, AND THEY CLAIM THEY HAVE NO PART. WE HAVE NOW BEEN TOLD OCTOBER 22 THEY MAY HAVE THE PART, AFTER BEING TOLD IT WOULD BE "NO LATER THAT 9/23/13". THE DEALERSHIP (AND ANOTHER LOCAL ONE) HAVE BEEN LOOKING FOR RESOLUTION, AND DESPITE HAVING A CASE MANAGER AT DODGE, STILL GETTING RUN AROUND. WE HAVE HEARD THIS IS FAIRLY COMMON FOR THIS TO OCCUR BETWEEN 35000 AND 75000 MILES ON THIS VEHICLE, AND IT MANIFEST AS VARIOUS ELECTRONIC ISSUES FROM STARTING, TO VARIOUS SIGNAL AND WIPER MALFUNCTIONS ETC, ANYTHING ELECTRICAL.
NHTSA ODI #10545075
62,000 miles · Sep 20, 2013
Electrical System
THE TOTAL INTEGRATED POWER MODULE (TIPM) ON MY 2011 DODGE DURANGO CITADEL HAS ALSO GONE OUT AS OTHER HAVE POSTED. I TOOK MY CAR TO THE DEALERSHIP FOR AN OIL CHANGE AND EXPLAINED TO THEM THAT THE LAST 2 DAYS I HAVE HAD PROBLEMS STARTING THE VEHICLE. AFTER 65 MINUTES THEY SAID THEY HAD TO REPROGRAM THE COMPUTER AND MY VEHICLE WAS …
Read full complaint
THE TOTAL INTEGRATED POWER MODULE (TIPM) ON MY 2011 DODGE DURANGO CITADEL HAS ALSO GONE OUT AS OTHER HAVE POSTED. I TOOK MY CAR TO THE DEALERSHIP FOR AN OIL CHANGE AND EXPLAINED TO THEM THAT THE LAST 2 DAYS I HAVE HAD PROBLEMS STARTING THE VEHICLE. AFTER 65 MINUTES THEY SAID THEY HAD TO REPROGRAM THE COMPUTER AND MY VEHICLE WAS GOOD TO GO. THE NEXT MORNING THE VEHICLE HAD NO POWER AT ALL. THE BATTERY WAS GOOD BUT NO ELECTRICAL ITEMS WORKED. I CALLED THE DEALERSHIP WHICH TOWED THE VEHICLE IN AFTER 8 HOURS THEY CLAIMED IT WAS NOW THE TOTAL INTERGRATED POWER MODULE THAT WENT OUT. THEY SAID THE COST FOR THE PART AND LABOR WILL BE ABOUT $1,185. BUT THE PART IS BACK-ORDERED. THEY CLAIM THERE ARE CURRENTLY 2085 VEHICLES WAITING FOR THIS PART AND THAT IT COULD BE 1-5 MONTHS TO GET THE PART. *TR
NHTSA ODI #10544694
85,251 miles · Sep 19, 2013
Electrical SystemFuel/propulsion System
VEHICLE DIFFICULT TO START UP AND WILL SHUT OFF AT ANY TIME WHILE DRIVING...LUCKILY I COASTED TO SIDE OF ROAD WITHOUT LOSING CONTROL. *TR
NHTSA ODI #10544414
37,800 miles · Sep 19, 2013
Electrical System
THE TIPM (TOTAL INTEGRATED POWER MODULE) ON MY 2011 DODGE DURANGO HAS GONE OUT. MY CAR HAS BEEN SITTING AT A DEALERSHIP FOR OVER 2 WEEKS BECAUSE THIS PART IS ON NATIONAL BACKORDER. THE DEALERSHIP HAS NO IDEA WHEN THEY CAN GET ONE (THEY SAID IT COULD BE WEEKS). WHEN I DROPPED MY DURANGO OFF, THERE WERE 3 OTHER VEHICLES THERE WIT…
Read full complaint
THE TIPM (TOTAL INTEGRATED POWER MODULE) ON MY 2011 DODGE DURANGO HAS GONE OUT. MY CAR HAS BEEN SITTING AT A DEALERSHIP FOR OVER 2 WEEKS BECAUSE THIS PART IS ON NATIONAL BACKORDER. THE DEALERSHIP HAS NO IDEA WHEN THEY CAN GET ONE (THEY SAID IT COULD BE WEEKS). WHEN I DROPPED MY DURANGO OFF, THERE WERE 3 OTHER VEHICLES THERE WITH THE SAME PROBLEM AS MINE. AS OF YESTERDAY, I AM 2ND IN LINE FOR THE PART AT THE DEALERSHIP, BUT WHO KNOWS WHAT "NUMBER" I AM NATIONALLY!! FROM WHAT I'M READING, CHRYSLER HAS A MAJOR NATIONWIDE ISSUE WITH THIS PART, BUT THEY ARE NOT WILLING TO DO A RECALL. I SPOKE WITH THE DEALERSHIP THAT HAS MY CAR ABOUT GETTING A LOANER, BUT THEY INSTRUCTED ME TO CALL CUSTOMER CARE AT CHRYSLER CORP. I HAVE BEEN TRYING TO TALK TO A CASE MANAGER FOR A WEEK NOW. I HAVE CALLED EVERYDAY, AND EVERY TIME THEY TELL ME THAT THEY WILL HAVE SOMEONE CALL ME WITHIN THE DAY. I CALLED THIS MORNING, AND WAS TOLD THAT MY CASE WAS ASSIGNED A CASE NUMBER JUST TODAY (AFTER A WHOLE WEEK), AND THAT HE WOULD CALL ME IN A DAY OR 2. I ASKED TO SPEAK TO A SUPERVISOR, AND WAS TOLD THAT THERE WASN'T ONE AVAILABLE. I HAVE SPENT OVER $300 DOLLARS ON A RENT CAR, AND IT LOOKS LIKE I'LL BE SPENDING MUCH MORE. I JUST WANT THEM TO TAKE RESPONSIBILITY FOR THEIR PROBLEM AND REIMBURSE ME/PAY FOR NEXT WEEK'S RENTAL (AND BEYOND THAT). IT SEEMS THAT CHRYSLER IS NOT CONCERNED AT ALL, AND CONTINUE TO DISMISS MY CONCERNS. IT'S VERY FRUSTRATING THAT I'M HAVING THIS KIND OF PROBLEM WITH A VEHICLE THAT ONLY HAS A 37,800 MILES ON IT AND IS ONLY TWO YEARS OLD. MY HUSBAND AND I HAVE ALWAYS OWNED CHRYSLER PRODUCTS, BUT THIS WILL DEFINITELY BE THE LAST. WE ARE PLANNING ON GOING TO THE DEALERSHIP THIS WEEKEND, AND TRADING IT IN "AS IS" FOR SOMETHING ON THEIR PREOWNED LOT...SOMETHING THAT IS NOT CHRYSLER!! (CHRYSLER DID AGREE TO PAY FOR THE PART, SO THE DEALERSHIP WILL NOT BE OUT ANY MONEY IF WE TRADE IT IN.) *TR
NHTSA ODI #10544413
24,500 miles · Sep 18, 2013
Electrical System
MY PROBLEMS STARTED ONLY A FEW WEEKS AFTER PURCHASING THE VEHICLE. I WOULD BE INSIDE THE CAR, BUT THE CAR WOULD SAY KEY NOT FOUND. AFTER MOVING AROUND IN THE CAR A BIT, FINALLY, IT WOULD FIND THE KEY AND START. ALSO, I CAN ONLY BE 10 TO 15 FEET AWAY FROM THE CAR TO ARM IT. ANY FURTHER, AND I CAN'T ARM, DISARM OR REMOTE START THE…
Read full complaint
MY PROBLEMS STARTED ONLY A FEW WEEKS AFTER PURCHASING THE VEHICLE. I WOULD BE INSIDE THE CAR, BUT THE CAR WOULD SAY KEY NOT FOUND. AFTER MOVING AROUND IN THE CAR A BIT, FINALLY, IT WOULD FIND THE KEY AND START. ALSO, I CAN ONLY BE 10 TO 15 FEET AWAY FROM THE CAR TO ARM IT. ANY FURTHER, AND I CAN'T ARM, DISARM OR REMOTE START THE CAR. DOESN'T MAKE SENSE TO HAVE A REMOTE START OPTION ON THE REMOTE BUT HAVE IT ONLY WORK FROM 10 TO 15 FEET AWAY. TRANSMISSION ISSUES HAVE ALSO OCCURRED WITH THE VEHICLE. SOMETIMES, 1ST GEAR WILL GO ALL THE WAY TO 6000 RPM'S BEFORE GOING INTO 2ND GEAR. ALSO WHILE DRIVING, THE GEARS WILL SURGE/SKIP AND THEN I'LL HEAR A LARGE KNOCKING NOISE BEFORE IT KICKS INTO GEAR. MORE RECENTLY, THE CAR JUST WONT START. I'VE BEEN TOLD THAT IT IS THE TIPM AND THE PART IS ON BACK ORDER. VERY UPSET. EXPENSIVE CAR, ONLY 2 YEARS OLD, AND HAVING ALL THESE PROBLEMS. IT IS NOT RIGHT, AND CHRYSLER SHOULD RECALL THESE VEHICLES. I'M IN A RENTAL NOW, BUT I WANT MY CAR BACK, FIXED COMPLETELY. TOO MUCH TO ASK?? I DON'T THINK SO. CORPORATIONS TAKING ADVANTAGE. ABSOLUTELY. HOPE EVERYTHING WORKS OUT FOR ME AND EVERYONE ELSE. *JB
NHTSA ODI #10544295
23,000 miles · Sep 15, 2013
Electrical System
I HAVE A 2011 DODGE DURANGO ONLY HAD IT FOR TWO YEARS BOUGHT IT BRAND NEW. STARTED HAVING TROUBLE WITH IT NOT STARTING. I WOULD PUSH THE BUTTON AND SOME TIMES IT WOULD START THEN IT WOULD DIE, SO I TOOK IT TO CHRYSLER TOLD THEM WHAT IT WAS DOING, SO THEY CHECKED IT OUT THE FIRST TIME SAYING THAT THE SOFTWARE NEEDS TO BE UPDATED…
Read full complaint
I HAVE A 2011 DODGE DURANGO ONLY HAD IT FOR TWO YEARS BOUGHT IT BRAND NEW. STARTED HAVING TROUBLE WITH IT NOT STARTING. I WOULD PUSH THE BUTTON AND SOME TIMES IT WOULD START THEN IT WOULD DIE, SO I TOOK IT TO CHRYSLER TOLD THEM WHAT IT WAS DOING, SO THEY CHECKED IT OUT THE FIRST TIME SAYING THAT THE SOFTWARE NEEDS TO BE UPDATED, SO UPDATED AND SAID IT WAS FIXED TOOK IT HOME AND IN A COUPLE OF DAYS IT STARTED DOING THE SAME THING AGAIN TOOK IT BACK, SAID THAT THEY HAD TO TOO PUT NEW HEADS ON IT. SO THEY KEPT IT FOR A MONTH CALLED AND KEPT TELLING ME DEFERENT STORIES THAT THEY PUT STUFF ON IT AND STILL NOT WORKING, THEN GOING ON THREE MONTHS SAYING THEY WERE WAITING ON A PART CALLED TIPM AND IT IS BACK ORDERED. AND THAT IT WOULD BE OCTOBER 2013 BEFORE THEY GET IT.GOT MAD TOLD THEM TO PUT ME IN ANOTHER VEHICLE WENT UP THERE . ALL THE SUDDEN SAID ARE CAR WAS FIXED . BROUGHT IT HOME AND THE NEXT DAY IT DIED ON THE RAILROAD TRACK AND GAS POURING OUT OF IT. ONE SPARK WE WOULD HAD BURNED UP AND GET HIT BY THE TRAIN. AS I SPEAK THEY STILL HAVE ARE CAR TELLING US THAT THE MECHANIC DIDN'T TIGHTEN UP THE SCREWS. THIS IS CRAZY AND SOMETHING NEEDS TO BE DONE .DON'T SEE HOW THEY GOT THE PART SO QUICK AFTER TELLING ME THAT IT WOULDN'T BE THERE UNTIL OCTOBER 2013. AND THEY HAVE ARE CAR GOING ON THREE MONTHS WHY DO THEY STILL HAVE IT, IF THE PART WAS PUT ON AND FIXED. *TR
NHTSA ODI #10543696
Official recalls
8Nov 14, 2019
Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice when the final remedy becomes available. Owner notification letters were mailed on December 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V62.
Sep 18, 2017
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence & remedy
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Additional source detail variants (2)
Service Brakes
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Service Brakes, Hydraulic:power Assist
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Jul 10, 2017
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.
Dec 28, 2015
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence & remedy
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Additional source detail variants (2)
Interior Lighting
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Oct 8, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.
Sep 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, to July 20, 2011, and equipped with either a 3.6L or 5.7L engine. In the affected vehicles, the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM, free of charge. The recall began December 19, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P54. Note: This recall has been superseded by recall 19V813.
Jul 2, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is performed.
Consequence & remedy
Consequence: If the vanity lamp wiring shorts, there is an increased risk of fire.
Remedy: Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.
Apr 1, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence & remedy
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Additional source detail variants (2)
Service Brakes
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Service Brakes, Hydraulic:power Assist:vacuum
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ15003 · Post 14V-391 Headliner Fires
Opened May 1, 2015 · Closed Jul 6, 2016
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Additional source detail variants (5)
Electrical System
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring:fuses And Circuit Breakers
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring:interior/under Dash
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Interior Lighting
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
EA14001 · Headliner Fires
Opened Jan 10, 2014 · Closed Aug 12, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Additional source detail variants (5)
Electrical System
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring:fuses And Circuit Breakers
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring:interior/under Dash
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Interior Lighting
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
PE13027 · Headliner Fires
Opened Aug 19, 2013 · Closed Jan 14, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Additional source detail variants (5)
Electrical System
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring:fuses And Circuit Breakers
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Interior Lighting
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Illustration