Illustration2011 DODGE DURANGO. CONSUMER WRITES IN REGARDS TO TIPM RECALL ISSUES. *SMD THE CONSUMER LEARNED THERE WAS A SHORTAGE OF PARTS FOR SEVERAL MONTHS. *JB
2011 Dodge Durango
Owner reports · Recalls · Investigations
More warning signs than most Durango years
Owner complaints for the 2011 Dodge Durango are substantially higher than the model-year median of 231.
About this comparison →How this year compares
Owner complaints by model year
Compare all Durango years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
13125–50K
18850–75K
12175–100K
90100–150K
40150K+
604 reports with mileage · 194 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 514 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 179 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports57 fire reports8 injury reports
Electrical System complaints
514 reportsTL* THE CONTACT OWNS A 2011 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS IN ORDER TO RESTART THE VEHICLE. THE CONTACT HEARD A GRINDING NOISE EACH TIME THE VEHICLE STARTED. THE DEALER DID NOT PROVIDE A REMEDY. THE VEHICLE WAS SOLD TO THE CONTACT WITHOUT …
Read full complaint
TL* THE CONTACT OWNS A 2011 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS IN ORDER TO RESTART THE VEHICLE. THE CONTACT HEARD A GRINDING NOISE EACH TIME THE VEHICLE STARTED. THE DEALER DID NOT PROVIDE A REMEDY. THE VEHICLE WAS SOLD TO THE CONTACT WITHOUT INFORMING THE CONTACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V154000 (SERVICE BRAKES, SERVICE BRAKES HYDRAULIC). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.
I WAS DRIVING DOWN THE ROAD AND MY CAR STALLED. SOUNDED LIKE ENGINE JUST SHUT OFF AND THEN IT STRUGGLED TO START AGAIN AND THEN JUST SPONTANEOUSLY STARTED. ADDITIONALLY SOMETIMES AND EVER INCREASING MY CAR WILL NOT START OR TAKES SEVERAL ATTEMPTS. YOU TURN THE KEY AND IT TRIES TO START YOU CAN HEAR IT, BUT WONT WITHOUT SEVERAL A…
Read full complaint
I WAS DRIVING DOWN THE ROAD AND MY CAR STALLED. SOUNDED LIKE ENGINE JUST SHUT OFF AND THEN IT STRUGGLED TO START AGAIN AND THEN JUST SPONTANEOUSLY STARTED. ADDITIONALLY SOMETIMES AND EVER INCREASING MY CAR WILL NOT START OR TAKES SEVERAL ATTEMPTS. YOU TURN THE KEY AND IT TRIES TO START YOU CAN HEAR IT, BUT WONT WITHOUT SEVERAL ATTEMPTS.SOMETIMES I WILL GO TO BACK OUT AND IT WILL GO AND THEN JUST STOP AND TURN OFF. I THOUGHT DUE TO MY CAR HAVING DIFFICULTIES STARTING IT COULD BE MY BATTERY SO I WENT AND GOT THAT CHECKED AND HE SAID MY BATTERY WAS WEAK SO I PURCHASED A 200 DOLLAR BATTERY TO FIND OUT MY CAR IS STILL NOT STARTING. MY CAR HAS STALLED ONCE ON MAIN ROAD WHICH IS FRIGHTENING WITH 4 KIDS IN THE CAR IN A VERY BUSY CITY! NOT TO MENTION WHEN UR BACKING OUT AND UR CAR JUST STOPS THAT'S A SAFETY RISK TOO! I HAVE HEARD OTHERS ARE HAVING SAME ISSUE AND THEY ARE UNDER A RECALL STARTING OCTOBER 24TH, BUT CHRYSLER TOLD ME MY CAR ISN'T UNDER A RECALL FOR IT, THOUGH IT IS A 2011. I WANTED TO BE SURE MY ISSUE WAS DOCUMENTED SINCE THIS IS A SAFETY ISSUE AND FRIGHTENING WHEN YOU HAVE 4 YOUNG KIDS IN THE CAR WITH YOU. I HOPE THAT THEY WAKE UP AND WIDEN THEIR RECALL BECAUSE WITH JUST OVER 50000 MILES MY CAR SHOULDN'T BE FACING THESE TYPE OF ISSUES AND IT IS A RISK TO MY FAMILY! *TR
MY WIFE HAD PROBLEMS STARTING THE DURANGO ON TUESDAY MORNING 9/16. MY WIFE REPEATLY TRIED TO RESTART THE VEHICLE. WHEN IT WOULD FINALLY CRANK, IT WOULD SPUTTER AND DIE. IF YOU TRIED TO GIVE IT GAS THE ACCELERATOR WOULD GO ALL THE WAY TO THE FLOOR WITHOUT THE ENGINE REVVING. AFTER SEVERAL MORE ATTEMPTS IT FINALLY STARTED AND SHE …
Read full complaint
MY WIFE HAD PROBLEMS STARTING THE DURANGO ON TUESDAY MORNING 9/16. MY WIFE REPEATLY TRIED TO RESTART THE VEHICLE. WHEN IT WOULD FINALLY CRANK, IT WOULD SPUTTER AND DIE. IF YOU TRIED TO GIVE IT GAS THE ACCELERATOR WOULD GO ALL THE WAY TO THE FLOOR WITHOUT THE ENGINE REVVING. AFTER SEVERAL MORE ATTEMPTS IT FINALLY STARTED AND SHE WAS ABLE TO MAKE IT TO WORK WITHOUT ANY PROBLEMS. AS SHE LEFT WORK THE SAME PROBLEM OCCURED TURN THE KEY NOTHING, TURN THE KEY NOTHING, TAKE THE KEY OUT, TURN THE KEY, IT CRANKS AND THEN SHUTS OFF. AFTER GOING THROUGH THE SAME ROUTINE OVER AND OVER WE FINALLY GOT IT TO CRANK. WE DECIDED TO HAVE THE CAR BATTERY TESTED AND IT PASSED. WE GOT A NEW BATTERY FOR THE REMOTE BUT THAT DIDN'T SOLVE THE PROBLEM. WE FINALLY TOOK OUR DURANGO TO THE LOCAL DEALERSHIP THE NEXT DAY 9/17 KNOWING THEY WERE GOING TO CHARGE $100 DIAGNOSTIC FEE. WE EXPLAINED THE PROBLEM AND EVEN TOOK THE SERVICE MAN TO THE VEHICLE AND IT WOULD NOT START. SO HE ACTUALLY OBSERVED THE ISSUE. 2HRS LATER THEY CALL SAYING A PROBLEM COULD'NT BE FOUND. THE TEST DIDN'T PRODUCE A CODE. OK, SO WE SPENT $100 DOLLARS ON A DIAGNOSTIC TEST WITH NO DIAGNOSIS. AS WE PICKED UP THE VEHICLE I ASKED THE SERVICE MAN IF THEY HAD SEEN THIS PROBLEM BEFORE AND OF COURSE HIS ANSWER WAS NO. HE SUGGESTED IT WAS PROBABLY A COMMUNICATION PROBLEM. WELL DUH, SOMETHING WASN'T COMMUNICATING. HE TELLS US TO MAKE SURE ALL DOORS, INCLUDING THE REAR HATCH ARE CLOSED BEFORE STARTING. NOT WHAT I WAS EXPECTING FOR $100. WELL, HE MAY HAVE BEEN TELLING THE TRUTH BUT I AM NOT A MECHANIC AND SINCE THEN I HAVE RESEARCHED THE PROBLEM AND FOUND MANY COMPLAINTS REGARDING THE FAULTY TIPM. I AGEEE WITH OTHERS WHO HAVE FILED A COMPLAINT. CHRYSLER IS AWARE OF THIS PROBLEM AND ARE REFUSING TO TAKE OWNERSHIP. WHAT WILL IT TAKE, DEATH OR A SERIOUS INJURY? I WANT MY FAMILY SAFE. NO AMOUNT OF MONEY CAN REPLACE LOVED ONES! *TR
THIS VEHICLE HAS BEEN TO THE DEALERSHIP 4 TIMES FOR THE SAME ISSUE, FAILURE TO START. THE STARTER WOULD CRANK, THE FUEL PUMP WOULD WORK, IT JUST WOULD NOT TURN OVER. THE FIRST TIME THEY REPLACED THE BATTERY. THE SECOND TIME THEY SAID THEY COULD NOT FIND A PROBLEM. THE THIRD TIME THE VEHICLE HAD TO BE TOWED TO THE DEALERSHIP.…
Read full complaint
THIS VEHICLE HAS BEEN TO THE DEALERSHIP 4 TIMES FOR THE SAME ISSUE, FAILURE TO START. THE STARTER WOULD CRANK, THE FUEL PUMP WOULD WORK, IT JUST WOULD NOT TURN OVER. THE FIRST TIME THEY REPLACED THE BATTERY. THE SECOND TIME THEY SAID THEY COULD NOT FIND A PROBLEM. THE THIRD TIME THE VEHICLE HAD TO BE TOWED TO THE DEALERSHIP. THEY SAID THE BATTERY WAS DRAINED. THEY CHARGED IT AND IT TESTED FINE. IT STILL HAD ISSUES STARTING. THEY KEPT IT FOR 2 DAYS AND FINALLY REPLACED THE TPIM. 2 WEEKS LATER, THEY VEHICLE FAILED TO START AGAIN. THEY TOLD ME I HAD A DEAD BATTERY AND REPLACED IT AGAIN. IT LOOKS LIKE THIS EXACT ISSUE IS NOTED BY MANY OTHER PEOPLE. WHY HAS A RECALL NOT BEEN ISSUED ON THIS ISSUE? MY WIFE, 2 YEAR OLD AND 1 MONTH OLD WERE STUCK IN 110 DEGREE HEAT TRYING TO START THE VEHICLE. THIS IS A SAFETY ISSUE! *TR
THE TIPM IS RESPONSIBLE FOR CONTROLLING AND DISTRIBUTING POWER TO ALL OF THE ELECTRICAL FUNCTIONS OF THE VEHICLE, INCLUDING SAFETY AND IGNITION SYSTEMS. THE LAWSUIT CLAIMS CHRYSLER HAS LONG BEEN AWARE OF THE TIPM PROBLEM, BUT REFUSES TO PUBLICLY ACKNOWLEDGE IT. A DEFECTIVE TIPM CAN SOMETIMES MAKE IT IMPOSSIBLE TO START YOUR C…
Read full complaint
THE TIPM IS RESPONSIBLE FOR CONTROLLING AND DISTRIBUTING POWER TO ALL OF THE ELECTRICAL FUNCTIONS OF THE VEHICLE, INCLUDING SAFETY AND IGNITION SYSTEMS. THE LAWSUIT CLAIMS CHRYSLER HAS LONG BEEN AWARE OF THE TIPM PROBLEM, BUT REFUSES TO PUBLICLY ACKNOWLEDGE IT. A DEFECTIVE TIPM CAN SOMETIMES MAKE IT IMPOSSIBLE TO START YOUR CAR. IN ADDITION, IT CAN CAUSE ANY OF THE FOLLOWING: THE FUEL PUMP NOT TURNING OFF THE AIRBAGS NOT DEPLOYING OR DEPLOYING RANDOMLY THE ENGINE STALLING WHILE DRIVING THE HORN GOING OFF AT RANDOM TIMES IN OTHER WORDS, HAVING A VEHICLE WITH A FAULTY TIPM IS LIKE DRIVING SOMETHING POSSESSED. *TR
MY 2011 DODGE DURANGO WILL NOT START AS OF TODAY. THERE HAVE BEEN HINTS OF A PROBLEM OVER THE PAST FEW WEEKS WITH HESITANT STARTS AND/OR REQUIRING 3-4 ATTEMPTS BEFORE THE VEHICLE STARTS. LOOKS LIKE THIS IS THE INFAMOUS TIPM ISSUE, BUT I'M TAKING IT TO THE DEALER TOMORROW FOR CONFIRMATION. *TR
MY WIFE HAD PROBLEMS STARTING THE VEHICLE THAT MORNING AFTER 10 MINUTES IT FINALLY STARTED SHE WAS GOING TO WORK AND WHEN SHE ARRIVED AND TURNED IT OFF THE VEHICLE WAS SMOKING. IT WOULD NOT START AGAIN. SHE CALLED THE DEALERSHIP WHO CAME OUT AND PICKED IT UP. AFTER THEY CHECKED IT OUT THEY FOUND OUT THAT THE TIPM HAD SHORTED …
Read full complaint
MY WIFE HAD PROBLEMS STARTING THE VEHICLE THAT MORNING AFTER 10 MINUTES IT FINALLY STARTED SHE WAS GOING TO WORK AND WHEN SHE ARRIVED AND TURNED IT OFF THE VEHICLE WAS SMOKING. IT WOULD NOT START AGAIN. SHE CALLED THE DEALERSHIP WHO CAME OUT AND PICKED IT UP. AFTER THEY CHECKED IT OUT THEY FOUND OUT THAT THE TIPM HAD SHORTED . WE WERE INFORMED THAT IT WAS NOT COVERED UNDER ANY WARRANTY WE HAD. I THEN CONTACTED DODGE AND EXPLAINED WHAT HAD HAPPENED AND WAS INFORMED THERE WAS NOTHING THEY WOULD DO FOR ME. I THEN EXPLAINED THAT THIS WAS SOMETHING I HAD NO CONTROL OVER WITH THIS PART GOING OUT AND THAT REPEATED THERE WAS NOTHING THEY WERE GOING TO DO. THE NEXT DAY I CONTACTED THE DEALER REQUESTING THE PART THEY WERE GOING TO REPLACE AND I WAS INFORMED IT I WANTED IT I WOULD HAVE TO PAY A CORE FEE OF $150.00, I WAS ALREADY PAYING $1200.00 TO REPLACE THE PART. SO ONCE AGAIN I CALLED DODGE AND WAS INFORMED IF I WANTED THE PART I WOULD HAVE TO PAY THE CORE FEE AND THERE WAS NOTHING THEY COULD DO FOR ME. AFTER SOME INVESTIGATING THE NIGHT BEFORE I FOUND OUT THAT IS HAS BEEN AN ONGOING SINCE 2007 AND THAT IT WAS UNDER INVESTIGATION, AND A POSSIBLE RECALL WAS PENDING I ASKED BARBRA WITH DODGE ABOUT THIS AND SHE INFORMED ME IF THAT WAS THE CASE SAVE MY RECEIPTS. MY QUESTION IS HOW LONG IS THIS GOING TO BE ALLOWED TO GO ON. *TR
MY CAR WOULDN'T START AND AFTER CHECKING THE FUSES AND RELAYS I FOUND A RELAY THAT RESET THE DASHBOARD ALARM I BOUGHT A NEW RELAY AND REPLACED IT.SOMETIME LATER MY CAR LOST ALL POWER . TOOK MY BATTERY OUT AND INSPECTED AND FOUND THAT THE BATTERY WAS DRAINED /BAD. AFTER BUYING A NEW BATTERY MY WIFE REPORTED TO ME A NOISE COMING F…
Read full complaint
MY CAR WOULDN'T START AND AFTER CHECKING THE FUSES AND RELAYS I FOUND A RELAY THAT RESET THE DASHBOARD ALARM I BOUGHT A NEW RELAY AND REPLACED IT.SOMETIME LATER MY CAR LOST ALL POWER . TOOK MY BATTERY OUT AND INSPECTED AND FOUND THAT THE BATTERY WAS DRAINED /BAD. AFTER BUYING A NEW BATTERY MY WIFE REPORTED TO ME A NOISE COMING FROM THE GAS TANK AREA . AFTER INSPECTING THE AREA IN QUESTION I TOOK IT TO GET LOOKED AT AND FOUND OUT THAT MY FUEL PUMP WILL NOT SHUT OFF AND WAS THE REASON WHY MY ORIGINAL BATTERY DIED.AFTER DOING SOME RESEARCH I HAVE FOUND THE SAME PROBLEMS WITH OTHER DODGE DURANGO'S AND THE ROOT CAUSE BEING THE TIPM.I DON'T WANT TO SPEND THE MONEY ON A TEST FROM THE DEALER TELLING ME I HAVE A BAD TIPM WHEN I ALREADY KNOW WHAT'S WRONG. SO WHERE DO I GO FROM HERE? I SPENT GOOD MONEY ON THIS CAR AND I AM IN FEAR OF MY FAMILY'S SAFETY WHEN DRIVING THIS CAR. *TR
OVER THE LIFE OF THE VEHICLE EXACT SAME YEAR MAKE AND MODEL I HAVE SEEN MORE THAN 1500 COMPLAINTS OF THE IGNITION ISSUES INVOLVING THE KEY MECHANISM ON THIS VEHICLE. SOME COMPLAINTS HAVE WARNED OF POTENTIAL FOR THE VEHICLE TO SHUTDOWN WHILE BEING DRIVEN. MY VEHICLE STALLED OUT IN TRAFFIC IT WOULD APPEAR THE KEY HAD SLIPPED BAC…
Read full complaint
OVER THE LIFE OF THE VEHICLE EXACT SAME YEAR MAKE AND MODEL I HAVE SEEN MORE THAN 1500 COMPLAINTS OF THE IGNITION ISSUES INVOLVING THE KEY MECHANISM ON THIS VEHICLE. SOME COMPLAINTS HAVE WARNED OF POTENTIAL FOR THE VEHICLE TO SHUTDOWN WHILE BEING DRIVEN. MY VEHICLE STALLED OUT IN TRAFFIC IT WOULD APPEAR THE KEY HAD SLIPPED BACK TO THE OFF POSITION. SOON AFTER WHEN ATTEMPTING TO RESTART THE VEHICLE IT WOULD NOT START BUT SOUND AS IF IT WERE TRYING TO START. I BELIEVE DODGE IS AVOIDING TRYING TO AVOID ADDRESS THESE ISSUES AND JUST HOW WIDE SPREAD THIS ISSUE HAS BECOME. *TR
Official recalls
819V813000 · Electrical System
Nov 14, 2019
Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice when the final remedy becomes available. Owner notification letters were mailed on December 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V62.
17V572000 · Service Brakes; Service Brakes, Hydraulic:power Assist
Sep 18, 2017
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence & remedy
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Additional source detail variants (2)
Service Brakes
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Service Brakes, Hydraulic:power Assist
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Consequence: If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
17V435000 · Electrical System:alternator/generator/regulator
Jul 10, 2017
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.
15V879000 · Electrical System:wiring; Interior Lighting
Dec 28, 2015
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence & remedy
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Additional source detail variants (2)
Interior Lighting
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
Consequence: The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
14V634000 · Electrical System:alternator/generator/regulator
Oct 8, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.
14V530000 · Electrical System
Sep 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, to July 20, 2011, and equipped with either a 3.6L or 5.7L engine. In the affected vehicles, the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM, free of charge. The recall began December 19, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P54. Note: This recall has been superseded by recall 19V813.
14V391000 · Electrical System:wiring
Jul 2, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is performed.
Consequence & remedy
Consequence: If the vanity lamp wiring shorts, there is an increased risk of fire.
Remedy: Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.
14V154000 · Service Brakes; Service Brakes, Hydraulic:power Assist:vacuum
Apr 1, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence & remedy
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Additional source detail variants (2)
Service Brakes
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Service Brakes, Hydraulic:power Assist:vacuum
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Consequence: The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ15003 · Post 14V-391 Headliner Fires
Opened May 1, 2015 · Closed Jul 6, 2016
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Additional source detail variants (5)
Electrical System
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring:fuses And Circuit Breakers
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Electrical System:wiring:interior/under Dash
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
Interior Lighting
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
EA14001 · Headliner Fires
Opened Jan 10, 2014 · Closed Aug 12, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Additional source detail variants (5)
Electrical System
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring:fuses And Circuit Breakers
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Electrical System:wiring:interior/under Dash
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
Interior Lighting
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
PE13027 · Headliner Fires
Opened Aug 19, 2013 · Closed Jan 14, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Interior Lighting
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Additional source detail variants (5)
Electrical System
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring:fuses And Circuit Breakers
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Interior Lighting
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592