NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,075 reports185,000 miles · Oct 11, 2011
Suspension
TL* THE CONTACT OWNS A 2000 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE HUB UNIT FRACTURED IN HALF. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 08E064000 (SUSPENSION:FRONT:HUB). THE DEALER DENIED ANY ASSISTANC…
Read full complaint
TL* THE CONTACT OWNS A 2000 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE HUB UNIT FRACTURED IN HALF. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 08E064000 (SUSPENSION:FRONT:HUB). THE DEALER DENIED ANY ASSISTANCE WITH REPAIRED TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 185,000.
NHTSA ODI #10429411
87,000 miles · Oct 6, 2011
Service Brakes, Hydraulic
WHILE DRIVING NB ON SOUTHWEST HIGHWAY IN PALOS THE LIGHT CHANGED TO YELLOW, THEN RED, I APPLIED THE BRAKES AND THE VEHICLE WAS SLOWING DOWN AS NORMAL. SUDDENLY THE BRAKE PEDAL HIT THE FLOOR AS IF THE HYDRAULICS FLUID HAD BEEN LET OUT OF THE BRAKE SYSTEM. THE ABS AND BRAKE LIGHT WENT ON AND I COULD HEAR THE ANTI LOCK SYSTEM MAKIN…
Read full complaint
WHILE DRIVING NB ON SOUTHWEST HIGHWAY IN PALOS THE LIGHT CHANGED TO YELLOW, THEN RED, I APPLIED THE BRAKES AND THE VEHICLE WAS SLOWING DOWN AS NORMAL. SUDDENLY THE BRAKE PEDAL HIT THE FLOOR AS IF THE HYDRAULICS FLUID HAD BEEN LET OUT OF THE BRAKE SYSTEM. THE ABS AND BRAKE LIGHT WENT ON AND I COULD HEAR THE ANTI LOCK SYSTEM MAKING NOISE. I PUMPED THE BRAKES QUICKLY AND CAR STOPPED IN JUST ENOUGH TIME TO PREVENT AN ACCIDENT. I PULLED TO THE SIDE OF THE ROAD AND OPENED THE HOOD TO INSPECT THE FLUID LEVELS, THEY WERE PERFECT, NO LEAKS EITHER. I RESTARTED THE CAR AND THE ABS AND BRAKE LIGHT WENT OUT, THE BRAKES DO NOT APPEAR TO BE WORKING CORRECTLY HOWEVER, I WILL HAVE A MECHANIC CHECK THEM OUT ON FRIDAY. *TR
NHTSA ODI #10429010
Mileage unknown · Sep 20, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2000 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO HIS HOME SEVERAL TIMES. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMA…
Read full complaint
TL* THE CONTACT OWNS A 2000 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO HIS HOME SEVERAL TIMES. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10426415
95,000 miles · Jul 2, 2011
Electrical System
I HAVE A 2000 DURANGO 5.9 THAT WILL SHUT OFF WHILE DRIVING. NO CODES ARE STORED, AND THE DASH READS "NO BUS". IT HAS DONE THIS SEVERAL TIMES OVER THE PAST FEW MONTHS AND WILL ALWAYS RESTART AFTER A FEW MINUTES. THIS LAST TIME IT WOULDN'T RESTART AND WE HAD IT TOWED HOME AND IT STARTED UP AFTER THAT JUST FINE. I HAVE REPLACED MOS…
Read full complaint
I HAVE A 2000 DURANGO 5.9 THAT WILL SHUT OFF WHILE DRIVING. NO CODES ARE STORED, AND THE DASH READS "NO BUS". IT HAS DONE THIS SEVERAL TIMES OVER THE PAST FEW MONTHS AND WILL ALWAYS RESTART AFTER A FEW MINUTES. THIS LAST TIME IT WOULDN'T RESTART AND WE HAD IT TOWED HOME AND IT STARTED UP AFTER THAT JUST FINE. I HAVE REPLACED MOST OF THE IGNITION SYSTEM AND PULLED THE FUEL PUMP TO NO AVAIL. IT IS MY WIFE'S CAR AND SHE AND I BOTH CAN'T TRUST IT ANY MORE WITH THE SAFETY OF MY WIFE AND CHILDREN. THERE ARE MULTIPLE POSTS AND COMPLAINTS ONLINE ABOUT THIS PROBLEM BUT NO SINGLE "FIX", AND NOTHING OFFICIAL FROM DODGE ADDRESSING THIS VERY SERIOUS SAFETY ISSUE. *TR
NHTSA ODI #10410320
Mileage unknown · Jun 26, 2011
Seats
2000 DODGE DURANGO SLT / 2WD / 8 CYL 5.9L - VEHICLE MILEAGE 65,000; THE FOLLOWING OEM COMPONENTS / PARTS ARE DEFECTIVE / BROKEN / WORN PREMATURELY CAUSING OTHER PARTS / COMPONENTS / SYSTEMS TO FAIL, BRAKE & SHOULD BE RECALLED, SERVICED, REPLACED BY DAIMLER CHRYSLER, LLC AT THEIR EXPENSE (NO WONDER THEY NEEDED BAILOUT $): 3) DRIV…
Read full complaint
2000 DODGE DURANGO SLT / 2WD / 8 CYL 5.9L - VEHICLE MILEAGE 65,000; THE FOLLOWING OEM COMPONENTS / PARTS ARE DEFECTIVE / BROKEN / WORN PREMATURELY CAUSING OTHER PARTS / COMPONENTS / SYSTEMS TO FAIL, BRAKE & SHOULD BE RECALLED, SERVICED, REPLACED BY DAIMLER CHRYSLER, LLC AT THEIR EXPENSE (NO WONDER THEY NEEDED BAILOUT $): 3) DRIVERS POWER SEAT TRACK HAS EXCESSIVE MOTION WHEN ACCELERATING & STOPPING CAUSING SEAT TO SLIDE FORWARD / BACKWARD - POSSIBLY CAUSING ACCIDENT; *TR
NHTSA ODI #10408972
141,000 miles · Jun 12, 2011
Engine And Engine Cooling
I HAVE OWNED MY 2000 DURANGO SINCE IT WAS NEW, I HAVE CHANGED THE OIL REGULARLY FOR THE WHOLE TIME, I HAVE ALWAYS DONE IT MYSELF. I RECENTLY BROUGHT THE VEHICLE IN FOR THE "TICKING" NOISE THAT I'VE BEEN TOLD SINCE THE VEHICLE WAS NEW, "THERE IS NO CONCERN" WHEN I CHANGED THE OIL, IT WAS ALWAYS CLEAN, NO PROBLEMS. WELL, IT SEEMS …
Read full complaint
I HAVE OWNED MY 2000 DURANGO SINCE IT WAS NEW, I HAVE CHANGED THE OIL REGULARLY FOR THE WHOLE TIME, I HAVE ALWAYS DONE IT MYSELF. I RECENTLY BROUGHT THE VEHICLE IN FOR THE "TICKING" NOISE THAT I'VE BEEN TOLD SINCE THE VEHICLE WAS NEW, "THERE IS NO CONCERN" WHEN I CHANGED THE OIL, IT WAS ALWAYS CLEAN, NO PROBLEMS. WELL, IT SEEMS THE ENGINE OIL HAD NOT BEEN TRAVELING THROUGH THE MOTOR AND APPARENTLY DAMAGED INTERNAL PARTS TO THE TUNE OF $2700.00, WHEN I LOOKED IT UP ONLINE, I LEARNED THIS HAS HAPPENED TO NEARLY EVERY 4.7 V8 THAT CHRYSLER MAKES, MY COMPUTER LIT UP WITH THE EXACT SAME PROBLEMS, EVERYWHERE. WHY IS IT THAT CHRYSLER IS NOT RESPONSIBLE FOR A MOTOR DEFECT THAT THE CONSUMER HAS NO CONTROL OVER? ALL MAINTENANCE HAD BEEN DONE ON THIS ONE, AND HAS BEEN TAKEN CARE OF METICULOUSLY. I CALLED CHRYSLER FOR ASSISTANCE, BUT THE RESPONSE WAS THAT OF DENY, DENY, DENY AND REFER THE CUSTOMER TO THE ORIGINAL WARRANTY, THE END! I BELIEVE CHRYSLER SHOULD STEP UP AND BE RESPONSIBLE FOR THEIR INCOMPETENCE! I FOR ONE WOULD LIKE MY HARD EARNED MONEY BACK FOR THIS JOB, WHICH TOOK ME 6 MONTHS TO PAY OFF TO GET MY CAR BACK. *TR
NHTSA ODI #10406007
81,900 miles · Jun 2, 2011
Engine And Engine CoolingUnknown Or Other
I BOUGHT THE S.U.V MARCH 14,2011 AND 2 WEEKS LATER IT STALLED ON THE FREEWAY AFTER GETTING OUT OF COLLEGE ABOUT 4:25PM. HEAVY TRAFFIC, I TAUGHT I WAS GOING TO GET REAR ENDED. ITS HAPPEN 5 X SINCE TWICE ON FREE WAY ON 3 X IN TOWN.. I WAS NEVER GOING OVER 35 MPH WHEN IT ACCOURS..IT JUST SHUTS OFF WITH NO WARNING OF ANYTHING. TAY…
Read full complaint
I BOUGHT THE S.U.V MARCH 14,2011 AND 2 WEEKS LATER IT STALLED ON THE FREEWAY AFTER GETTING OUT OF COLLEGE ABOUT 4:25PM. HEAVY TRAFFIC, I TAUGHT I WAS GOING TO GET REAR ENDED. ITS HAPPEN 5 X SINCE TWICE ON FREE WAY ON 3 X IN TOWN.. I WAS NEVER GOING OVER 35 MPH WHEN IT ACCOURS..IT JUST SHUTS OFF WITH NO WARNING OF ANYTHING. TAYLOR DEALERS, WHICH I BOUGHT THE CAR FROM TOOK IT TO THERE SHOP AND THEY COULD NOT FIND ANYTHING NO CODES OR ANY SIGNS OF PROBLEMS WITH TRUCK THEY HAD THE TRUCK ABOUT A MONTH.. AFTER THE 3X IT STALLED I TOOK IT STRAIGHT TO SAN DIEGO TO THE MECHANIC OF TAYLOR MOTORS AND THEY RAN THE CODES AGAIN AND NOTHING SHOWS AND THEY SAID NOTHING THEY CAN DO BECAUSE THEY NEED TO SEE THE PROBLEM OR THE STALLING NEED TO HAPPEN WHILE THEY DRIVE AND IT NEVER HAPPENS. SO ON OR ABOUT MAY 11, 2011 I CALLED DODGE CORPARATE OFFICE AND EXPLAINED THE SITUATION AND I EXPLAINED ITS A SERIOUS SAFETY ISSUES THEY HAVE A CASE MANAGEMENT JUDY ON IT BUT NO WORD SINCE I EXPLAINED AND THEY CAN'T GET THE TRUCK TO STALL..THEY INTRUCTED ME TO TAKE THE TRUCK TO THERE DEALERSHIP.. THEY CAN'T FIND OUT THE ISSUE EITHER, MY TRUCKS IS STILL AT THE DEALERS WHILE THEY TRY TO FIGURE OUT THE PROBLEM BUT AS OF TODAY THEY STILL CAN'T FIGURE OUT WHAT COULD BE THE PROBLEM.. IT SEEMS THAT IT HAPPENS ON HOT DAYS OR DRIVING AROUND A LOT.. I EXPLAINED THAT IT HAPPENS PERIODICKLY... ITS REALLY SCARY BECAUSE IT JUST SHUTS OF WITH NO WARNING OR ANYTHING UNTIL U RELIZE THAT UR PRESSING GAS PEDAL AND ITS NOT GOING. I SEEN ONLINE ABOUT THIS TRUCK HAVING PROBLEMS IN OTHER STATES AS WELL AND NO ONE HAS DONE NOTHING.. I HOPE THERE NOT WAITING FOR A SERIOUS DRASTIC ACCIDENT TO ACCOUR IN ORDER TO RECALL THE TRUCK OR FIX THE ISSUE.. NO CAR SHOULD JUST TURN OFF WITHOUT WARNING..I READ SOME PERSON HAD SAME ISSUE AND IT WAS THE COIL TO CLOSE TO EXHAUST MANIFOLD. IT CAUSES COIL TO GET TO HOT AND SHUT TRUCK OFF
NHTSA ODI #10404982
161,000 miles · May 31, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2000 DODGE DURANGO. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE ALSO OCCURRED ON A SEPARATE OCCASION WHILE DRIVING 60 MPH. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 161,000. THE VIN WAS NOT AVAILABL…
Read full complaint
TL* THE CONTACT OWNS A 2000 DODGE DURANGO. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE ALSO OCCURRED ON A SEPARATE OCCASION WHILE DRIVING 60 MPH. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 161,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10403760
115,890 miles · May 24, 2011
SteeringSuspension
I WAS PULLING OUT OF MY CIRCULAR DRIVEWAY STEERING LEFT AND THE WHEEL BASE WOULDN'T TURN. SO I BACKED UP AND CONTINUE TO GO AROUND THE CURVE, ONCE I REACHED ABOUT 200 FT OFF MY DRIVEWAY, MY CAR COME TO A COMPLETE STOP ON IT'S OWN. I BACKED INTO MY DRIVEWAY DRAGGING MY PASSENGER SIDE FRONT WHEEL SIDEWAYS. ONCE I GOT OUT TO CHECK …
Read full complaint
I WAS PULLING OUT OF MY CIRCULAR DRIVEWAY STEERING LEFT AND THE WHEEL BASE WOULDN'T TURN. SO I BACKED UP AND CONTINUE TO GO AROUND THE CURVE, ONCE I REACHED ABOUT 200 FT OFF MY DRIVEWAY, MY CAR COME TO A COMPLETE STOP ON IT'S OWN. I BACKED INTO MY DRIVEWAY DRAGGING MY PASSENGER SIDE FRONT WHEEL SIDEWAYS. ONCE I GOT OUT TO CHECK WHAT WAS GOING ON, MY TIE ROD END HAD BECOME COMPLETELY STRIPPED OFF THE RACK AND PINION. AFTER FURTHER INSPECTIONS, SOMEHOW THE GROVES ON THE RACK AND PINION HAD WORE DOWN SO MUCH IT ALLOWED THE TIE ROD TO STRIP AND RELEASE. I WAS SO GLAD I HADN'T BEEN DRIVING WITH MY CHILDREN ON THE HIGHWAY, THIS WOULD HAVE CAUSED MY VEHICLE TO FLIP AND PROBABLY KILL US. I KNOW HAVE TO REPLACE MY RACK AND PINION AND TIE ROD AND JUST REPLACING THE BALL JOINTS ON THIS VEHICLE NOT A COUPLE MONTHS AGO. I AM VERY FRIGHTENED TO DRIVE IT NOW IN FEAR THIS WILL HAPPEN AGAIN.
NHTSA ODI #10403335
133,000 miles · May 16, 2011
Engine And Engine CoolingFire
I HAD A 2000 DODGE DURANGO AND AFTER DRIVING FOR ABOUT 15 MINUTES I TURNED ON THE AIR AND A SULFUR LIKE SMELL CAME THROUGH THE AIR SYSTEM. AFTER PULLING OVER AND CUTTING THE CAR OFF, FLAMES CAME FROM UNDER THE HOOD. THE CAR BURST INTO FLAMES AND BURNED COMPLETELY UP. NOTHING WAS LEFT BUT THE METAL FRAME. MY INSURANCE COMPANY COU…
Read full complaint
I HAD A 2000 DODGE DURANGO AND AFTER DRIVING FOR ABOUT 15 MINUTES I TURNED ON THE AIR AND A SULFUR LIKE SMELL CAME THROUGH THE AIR SYSTEM. AFTER PULLING OVER AND CUTTING THE CAR OFF, FLAMES CAME FROM UNDER THE HOOD. THE CAR BURST INTO FLAMES AND BURNED COMPLETELY UP. NOTHING WAS LEFT BUT THE METAL FRAME. MY INSURANCE COMPANY COULDN'T GIVE ME ANY INSIGHT AS TO WHY THIS HAPPENED. I HAD ABOUT 133,000 MILES ON IT. I WISH I KNEW ABOUT THIS SITE BEFORE I LOST MY VEHICLE. I WOULD'VE INSISTED THAT THE DEALERSHIP THOROUGHLY CHECK THE CAR OUT BEFORE I ENDED UP WITHOUT A VEHICLE FOR 2 MONTHS. *TR
NHTSA ODI #10400963
Official recalls
2Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE99074 · Steering Wheel/shaft Spline Attachment
Opened Dec 13, 1999 · Closed Feb 24, 2000
Status: closed (inferred from source dates) · Steering
THIS PE WAS OPENED BASED ON ODI'S RECEIPT OF ONE COMPLAINT OF STEERING WHEEL SEPARATION ON THE SUBJECT VEHICLES.ALLEGEDLY (THAT IS, ACCORDING TO THE REPAIRING FACILITY'S SERVICE MANAGER) THE HUB NUT WAS NEVER INSTALLED ON THE SHAFT SPLINE.ALTHOUGH THE DRIVER LOST CONTROL OF THE VEHICLE, HE/SHE WAS ABLE TO STOP WITHOUT IMPACTING ANYTHING.BASED ON OUR INVESTIGATION AND THE MANUFACTURER'S RESPONSE, ODI IS CLOSING THIS INVESTIGATION BECAUSE THE SINGLE KNOWN COMPLAINT APPEARS TO BE AN ISOLATED INCIDENT.FURTHER, CHRYSLER HAS NO OTHER WARRANTY CLAIMS AND HAS NOT ISSUED ANY SERVICE BULLETINS.IN SUMMARY, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTTINUE TO MONITOR THIS MATTER CLOSELY, AND THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THESE MODELS IF WARRANTED BY THE CIRCUMSTANCES.
Illustration