NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
26 reportsClear category filter138,000 miles · Nov 3, 2016
Electrical SystemEngineVehicle Speed Control
TL* THE CONTACT OWNS A 2000 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD. THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT STATED THAT THE SENSORS WERE REPLACED (THROTTLE POSITION SENSOR, CRANKSHAFT, SPEED CAM, AIC, SPARK PLUG WIRES…
Read full complaint
TL* THE CONTACT OWNS A 2000 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD. THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT STATED THAT THE SENSORS WERE REPLACED (THROTTLE POSITION SENSOR, CRANKSHAFT, SPEED CAM, AIC, SPARK PLUG WIRES, ROTORS AND DISTRIBUTOR CUP, DISTRIBUTOR ROTOR, IGNITION COIL, MAP SENSOR). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 138,000.
NHTSA ODI #10924029
130,000 miles · Aug 4, 2013
Electrical SystemSteeringVehicle Speed Control
PURCHASED THE VEHICLE LOCALLY. AFTER 2 DAYS OF OWNING IT THE VEHICLE WOULD SHUT OFF AT RANDOM MOMENTS. SOMETIMES WHEN I AM DRIVING AT 40MPH AND SOMETIMES AT 20MPH AND UNDER. IN TRAFFIC AND SOMETIMES AFTER BEING PARKED FOR A BIT WILL NOT STARTUP. WHEN WE ARE DRIVING AND THE ENGINE SHUTS OFF THE STEERING WHEEL LOCKS UP ALSO. THE V…
Read full complaint
PURCHASED THE VEHICLE LOCALLY. AFTER 2 DAYS OF OWNING IT THE VEHICLE WOULD SHUT OFF AT RANDOM MOMENTS. SOMETIMES WHEN I AM DRIVING AT 40MPH AND SOMETIMES AT 20MPH AND UNDER. IN TRAFFIC AND SOMETIMES AFTER BEING PARKED FOR A BIT WILL NOT STARTUP. WHEN WE ARE DRIVING AND THE ENGINE SHUTS OFF THE STEERING WHEEL LOCKS UP ALSO. THE VEHICLE MAY TAKE HOURS BEFORE IT STARTS AGAIN. THERE HAS BEEN MANY MANY COMPLAINTS AND STILL NO REAL SOLUTION. THE 1999 TO 2001 DURANGOS MUST BE RECALLED BEFORE A FATALITY OCCURS. *TR
NHTSA ODI #10533522
138,880 miles · Jul 15, 2009
Electrical SystemSteeringVehicle Speed Control
I OWN A 2000 DODGE DURANGO, AND IT OFTEN WILL JUST SHUT DOWN WHILE I'M DRIVING. I HAVE OWNED IT SINCE OCTOBER 2008, AND THIS HAS HAPPENED 12 OR 13 TIMES. I RECEIVE A "NO BUS" SIGNAL ON MY ODOMETER DISPLAY. I HAVE REPLACED BATTERY TERMINALS, AND A BATTERY. IT SEEMS TO HAPPEN FAR MORE OFTEN IN HOT WEATHER. IT SOMETIMES HAPPENS WHE…
Read full complaint
I OWN A 2000 DODGE DURANGO, AND IT OFTEN WILL JUST SHUT DOWN WHILE I'M DRIVING. I HAVE OWNED IT SINCE OCTOBER 2008, AND THIS HAS HAPPENED 12 OR 13 TIMES. I RECEIVE A "NO BUS" SIGNAL ON MY ODOMETER DISPLAY. I HAVE REPLACED BATTERY TERMINALS, AND A BATTERY. IT SEEMS TO HAPPEN FAR MORE OFTEN IN HOT WEATHER. IT SOMETIMES HAPPENS WHEN I'M DRIVING 65 MPH ON THE FREEWAY, AND THEN THE CAR SHUTS DOWN AND I LOSE POWER STEERING (VERY DANGEROUS), BRAKES (EVEN MORE DANGEROUS) AND THE ACCELERATOR DOESN'T FUNCTION. *TR
NHTSA ODI #10276908
68,000 miles · Jan 23, 2009
Air BagsElectrical SystemVehicle Speed Control
THE CRUISE CONTROL AND HORN QUIT WORKING. I WAS CHECKING THE INTERNET TO SEE WHAT COULD BE WRONG WITH IT. I FOUND THE RECALL FOR REPLACING THE CLOCKSPRING IN THE STEERING WHEEL AND THIS COULD CAUSE MY PROBLEMS PLUS CAUSE MY AIR BAG TO NOT DEPLOY IN AN ACCIDENT. I CONTACTED THE DEALER AND WAS TOLD MY # (*)WAS NOT INCLUDED AND TO…
Read full complaint
THE CRUISE CONTROL AND HORN QUIT WORKING. I WAS CHECKING THE INTERNET TO SEE WHAT COULD BE WRONG WITH IT. I FOUND THE RECALL FOR REPLACING THE CLOCKSPRING IN THE STEERING WHEEL AND THIS COULD CAUSE MY PROBLEMS PLUS CAUSE MY AIR BAG TO NOT DEPLOY IN AN ACCIDENT. I CONTACTED THE DEALER AND WAS TOLD MY # (*)WAS NOT INCLUDED AND TO CALL CHRYSLER, WHICH I DID. I WAS TOLD THE SAME THING AND THAT I SHOULD TAKE IT TO BE FIXED AND THEN IF IT WERE ADDED TO THE RECALL I WOULD BE REIMBURSED. I DON'T FEEL I SHOULD BE RESPONSIBLE FOR THIS REPAIR AND I DON'T HAVE THE MONEY FOR IT. WHAT HAPPENS IF I'M IN AN ACCIDENT LIKE THE ONES I'VE READ IN SOME OF THESE OTHER COMPLAINTS AND MY AIR BAG DOES NOT DEPLOY. IS IT JUST SOL OR CAN I SUE CHRYSLER? I FEEL THEY SHOULD INCLUDE MINE AND THE OTHERS IN THE RECALL. *TR
NHTSA ODI #10256114
110,000 miles · Nov 1, 2007
Vehicle Speed Control
TL*THE CONTACT OWNS A 2000 DODGE DURANGO. THE VEHICLE SURGED UNCONTROLLABLY BETWEEN 60-80 MPH BEFORE THE BRAKES ENGAGED. THE FAILURE OCCURRED ON TWO OCCASIONS. THE SERVICE SHOP ATTEMPTED TO REPAIR THE VEHICLE, BUT THEY COULD NOT. THE SECOND TIME THE FAILURE OCCURRED, THE VEHICLE WAS TAKEN TO A DIFFERENT DEALER. THEY WERE AB…
Read full complaint
TL*THE CONTACT OWNS A 2000 DODGE DURANGO. THE VEHICLE SURGED UNCONTROLLABLY BETWEEN 60-80 MPH BEFORE THE BRAKES ENGAGED. THE FAILURE OCCURRED ON TWO OCCASIONS. THE SERVICE SHOP ATTEMPTED TO REPAIR THE VEHICLE, BUT THEY COULD NOT. THE SECOND TIME THE FAILURE OCCURRED, THE VEHICLE WAS TAKEN TO A DIFFERENT DEALER. THEY WERE ABLE TO PROPERLY MAKE THE REPAIR ACCORDING TO THE SERVICE BULLETIN THAT THE MANUFACTURER ISSUED FOR THE VEHICLE. THE FAILURE MILEAGE WAS 110,000 AND CURRENT MILEAGE WAS 110,200. UPDATED 11/20/07
NHTSA ODI #10207643
Mileage unknown · May 17, 2007
Engine And Engine CoolingVehicle Speed Control
I OWN A 2000 DODGE DURANGO THAT SHUTS DOWN WHILE DRIVING. IT WAS A DANGEROUS SITUATION BECAUSE I DID NOT KNOW WHEN THE SITUATION WILL OCCUR. SOMETIMES IT HAPPENED WHEN I WAS IN HEAVY TRAFFIC. SO FAR, THE AIR INTAKE SENSOR AND THE THROTTLE CONTROL SENSORS HAVE BEEN REPLACED. THIS DID NOT FIX THE PROBLEM.*AK
NHTSA ODI #10191086
74,000 miles · Dec 12, 2005
Vehicle Speed ControlCrash
DT: THE CONTACT STATED VEHICLE SUDDENLY ACCELERATED. HAS BEEN INVOLVED IN THREE ACCIDENTS AS A RESULT OF NOT BEING ABLE TO STOP THE VEHICLE. THE CONTACT'S FOOT WAS ON THE BRAKE PEDAL WITH THE PEDAL COMPLETELY DEPRESSED ALL THREE TIMES. THE POLICE WERE PRESENT AFTER ALL THREE ACCIDENTS, BUT NO REPORTS WERE TAKEN. THE INSURANC…
Read full complaint
DT: THE CONTACT STATED VEHICLE SUDDENLY ACCELERATED. HAS BEEN INVOLVED IN THREE ACCIDENTS AS A RESULT OF NOT BEING ABLE TO STOP THE VEHICLE. THE CONTACT'S FOOT WAS ON THE BRAKE PEDAL WITH THE PEDAL COMPLETELY DEPRESSED ALL THREE TIMES. THE POLICE WERE PRESENT AFTER ALL THREE ACCIDENTS, BUT NO REPORTS WERE TAKEN. THE INSURANCE COMPANY PAID FOR COSMETIC BODY DAMAGE REPAIRS TO THE VEHICLE AFTER THE ACCIDENTS. THE VEHICLE HAS NOT BEEN TO A DEALERSHIP FOR INSPECTION OR DIAGNOSTIC TESTING. *AK
NHTSA ODI #10145003
Mileage unknown · Sep 28, 2005
Electrical SystemVehicle Speed Control
DT: 2000 DODGE DURANGO. THE CONSUMER HAD A PROBLEM FIXED TWICE. THE CONSUMER WENT TO HAVE THE PROBLEM FIXED FOR THE THIRD TIME, AND THE MECHANIC SHOP TOLD HER THAT THEY CONTACTED CHRYSLER, AND CHRYSLER TOLD THE MECHANIC SHOP THIS WAS A VERY COMMON PROBLEM. THE PROBLEM WAS A CLUSTER FOR THE DASHBOARD. THE CONSUMER STATE…
Read full complaint
DT: 2000 DODGE DURANGO. THE CONSUMER HAD A PROBLEM FIXED TWICE. THE CONSUMER WENT TO HAVE THE PROBLEM FIXED FOR THE THIRD TIME, AND THE MECHANIC SHOP TOLD HER THAT THEY CONTACTED CHRYSLER, AND CHRYSLER TOLD THE MECHANIC SHOP THIS WAS A VERY COMMON PROBLEM. THE PROBLEM WAS A CLUSTER FOR THE DASHBOARD. THE CONSUMER STATED THE ENGINE REVVED VERY LOUDLY JUST SITTING STILL. ALSO WHILE DRIVING, AND EVEN IN CRUISE CONTROL. CHRYSLER SAID ALL THEY COULD DO WAS PUT A NOTE IN CONSUMER'S FILE. *AK
NHTSA ODI #10138048
Mileage unknown · Apr 4, 2005
Vehicle Speed Control
RECALL 04V200000 CONCERNING THROTTLE CONTROL CABLE. DEALER REFUSED TO HONOR MANUFACTURER'S RECALL NOTICE. DEALER INSISTED THAT CONSUMER TAKE VEHICLE TO THE DEALER FROM WHICH THEY PURCHASED THEIR VEHICLE. *AK
NHTSA ODI #10117360
66,000 miles · Oct 15, 2004
Vehicle Speed ControlCrashInjury
CONSUMER HAD PLACED KEY IN THE IGNITION TO START VEHICLE WHEN IT SUDDENLY ACCELERATED FORWARD, WITHOUT WARNING, AND HIT A TREE. VEHICLE WAS STILL IN PARK POSITION WHEN ACCELERATION OCCUR. VEHICLE WAS TOTALED BY INSURANCE CO. BOTH AIR BAGS DEPLOYED. DRIVER SUFFERED SEVERE INJURIES AND WAS HOSPITALIZED. *NM
NHTSA ODI #10096955
Official recalls
2Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE99074 · Steering Wheel/shaft Spline Attachment
Opened Dec 13, 1999 · Closed Feb 24, 2000
Status: closed (inferred from source dates) · Steering
THIS PE WAS OPENED BASED ON ODI'S RECEIPT OF ONE COMPLAINT OF STEERING WHEEL SEPARATION ON THE SUBJECT VEHICLES.ALLEGEDLY (THAT IS, ACCORDING TO THE REPAIRING FACILITY'S SERVICE MANAGER) THE HUB NUT WAS NEVER INSTALLED ON THE SHAFT SPLINE.ALTHOUGH THE DRIVER LOST CONTROL OF THE VEHICLE, HE/SHE WAS ABLE TO STOP WITHOUT IMPACTING ANYTHING.BASED ON OUR INVESTIGATION AND THE MANUFACTURER'S RESPONSE, ODI IS CLOSING THIS INVESTIGATION BECAUSE THE SINGLE KNOWN COMPLAINT APPEARS TO BE AN ISOLATED INCIDENT.FURTHER, CHRYSLER HAS NO OTHER WARRANTY CLAIMS AND HAS NOT ISSUED ANY SERVICE BULLETINS.IN SUMMARY, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTTINUE TO MONITOR THIS MATTER CLOSELY, AND THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THESE MODELS IF WARRANTED BY THE CIRCUMSTANCES.
Illustration