IllustrationONGOING PROBLEMS WITH DIMMER SWITCH..BACK UP CAMERA..RECALL ON CABLE WHICH IS DANGEROUS...CRIUSE CONTROL CLUNKERS BADLY..IN SHOP NUMEROUS OCCASIONS
2016 Dodge Dart
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dart years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
5025–50K
4350–75K
1775–100K
8100–150K
4150K+
154 reports with mileage · 103 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports4 fire reports7 injury reports
Electronic Stability Control (esc) complaints
5 reportsCAR STALLED WHILE DRIVING ON A ON RAMP TO THE FREEWAY. I PULLED OVER AND TRIED TO START IT. IT SOUNDED LIKE IT WAS TRYING TO TURN OVER BY ITSELF FOR A GOOD 10 SECONDS. WHEN IT RESTARTED, AFTER RELEASING THE BREAK MY CAR THRUST FORWARD. THEN STARTED TO SPUBER LIKE IT WANTED TO STALL AGAIN. AT THAT TIME 3 LIGHTS CAME ON ON TH…
Read full complaint
CAR STALLED WHILE DRIVING ON A ON RAMP TO THE FREEWAY. I PULLED OVER AND TRIED TO START IT. IT SOUNDED LIKE IT WAS TRYING TO TURN OVER BY ITSELF FOR A GOOD 10 SECONDS. WHEN IT RESTARTED, AFTER RELEASING THE BREAK MY CAR THRUST FORWARD. THEN STARTED TO SPUBER LIKE IT WANTED TO STALL AGAIN. AT THAT TIME 3 LIGHTS CAME ON ON THE DASH... THE CHECK ENGINE, STABILIZATION AND ANOTHER I'VE NEVER SEEN. WAS REAL CLOSE TO A DODGE DEARER WHERE I BEARLY MADE IT TO. WHEN I ASKED THE PERSON ABOUT THE TIGRIS LIGHT COMING ON HE TOLD ME 'THAT MEANS GET IT IN ASAP! SOMETHING SERIOUSLY WRONG IS WITH THE VEHICLE.' THE CAR HAS JUST OVER 30K MILES AND I KNOW IT'S STILL UNDER WARRANTY.
'TAKATA RECALL' ABOUT 2 MONTHS AGO MY CAR WOULDN'T START. I THOUGHT IT WAS DUE TO THE COLD WEATHER. THE 2ND DAY SAME THING WOULDN'T START AND HAD TO END UP GETTING JUMPER CABLES. THE 3RD IN THE MORNING AGAIN SOME TROUBLE BUT NO CABLES WERE NEEDED. BUT LATER THAT AFTERNOON I HAD TO GO TO MY CHILD'S SCHOOL. GOT DOWN FOR WHAT WAS N…
Read full complaint
'TAKATA RECALL' ABOUT 2 MONTHS AGO MY CAR WOULDN'T START. I THOUGHT IT WAS DUE TO THE COLD WEATHER. THE 2ND DAY SAME THING WOULDN'T START AND HAD TO END UP GETTING JUMPER CABLES. THE 3RD IN THE MORNING AGAIN SOME TROUBLE BUT NO CABLES WERE NEEDED. BUT LATER THAT AFTERNOON I HAD TO GO TO MY CHILD'S SCHOOL. GOT DOWN FOR WHAT WAS NO MORE THAN ABOUT 7MINS CAME BACK AND MY CAR WOULDN'T START. HAD TO GET CABLES. SOON AS WE GOT THE CAR GOING WENT TO AUTOZONE AND THEY CHECKED IT SAYING IT WAS THE BATTERY. SO I BOUGHT ANOTHER BATTERY THEN AND THERE. HOOKED IT UP. THE CAR TURNED IN FINE BUT MY POWER STEERING LIGHT CAME ON. THE STEERING WHEEL WAS SO STIFF TO TURN BUT I HAD TO GO. AND LUCKY ME IT WASN'T A FAR DRIVE AND PRETTY STRAIGHT. ABOUT 3 DAYS FROM THEN WE TOOK IT TO THE DEALERSHIP. LET THEM KNOW WHAT HAPPENED AND THEY SAID THAT ALL THEY NEEDED TO DO WAS REPROGRAM THE MODULE. BUT THEY CALL BACK 15MINS LATER SAYING THEY COULDN'T DO IT BECAUSE THE MODULE WASN'T COMMUNICATING BACK AND THAT THEY NEED $230 TO RUN A DIAGNOSTIC SO THEY CAN KNOW WHAT WAS THE ROOT OF THE PROBLEM. I DIDN'T HAVE THE MONEY TO SPARE AT THE TIME. SO I SAID NOT NOW. ONCE THEY BROUGHT MY CAR AROUND, THEY LET ME KNOW THAT NOW THE OVERHEARING LIGHT CAME ON AFTER THEY LOOKED AT IT. ON THE WAY HOME THE CAR TURNED OFF AT A MAIN STREET, LUCKY US I GOT TO TURN INTO A PARKING LOT AS IT TURNED OFF ALL WHILE I,HUSBAND,AND MY DAUGHTERS. TURNED IT BACK ON AND CAME BACK ON FINE. THEN ALL I WANTED TO DO WAS COME HOME AND HOPE THE CAR WOULDN'T TURN OFF AGAIN. THE AIR,HEADLIGHT,AND BLUETOOTH CAN NOT RUN AT THE SAME TIME CAUSE THE DASHBOARD LIGHTS AND HEADLIGHT WILL FLICKER AND THEN THE CAR WILL TURN OFF.
TWICE WHILE DRIVING MY CAR HAS JUST COMPLETELY STALLED AND LOST POWER. BOTH TIMES I WAS SLOWING TO A STOP. OTHER TIMES IT FEELS AS IT IT WILL STALL BUT DOESN'T. IT HAS CAUSED TWO MINOR ACCIDENTS AT A STOP SIGN DUE TO THE STALLING.THE OTHER EVENT HAPPENED AT 50,0000 MILES IN JUNE. I TOOK CAR TO DEALERSHIP, NO CODES CAME UP.
UNKNOWN
Official recalls
525V674000 · Power Train:automatic Transmission:lever And Linkage:floor Shift
Oct 9, 2025
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles. The shifter cable may detach from the transmission, preventing the vehicle from shifting into the park (P) position and causing a loss of park function.
Consequence & remedy
Consequence: A loss of park function may allow the vehicle to rollaway, increasing the risk of a crash.
Remedy: Vehicles that were previously repaired under recall 19V293 will need to have the new remedy completed. The remedy is currently under development. Interim notification letters, explaining the safety risk, were mailed November 6, 2025. A second notice will be sent once the final remedy is available. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is A0C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 16, 2025.
19V293000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 11, 2019
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the shift cable to detach from the transmission.
Consequence & remedy
Consequence: If the shifter cable detaches from the transmission, the vehicle may not perform the shifts performed by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: This recall will be replaced by NHTSA recall number 25V674. Vehicles already repaired under this recall will need to have the new remedy completed. Chrysler will notify owners, and dealers will replace the transmission side shifter cable bushing, free of charge. The recall began September 5, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V34.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the shift cable to detach from the transmission.
Consequence: If the shifter cable detaches from the transmission, the vehicle may not perform the shifts performed by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: This recall will be replaced by NHTSA recall number 25V674. Vehicles already repaired under this recall will need to have the new remedy completed. Chrysler will notify owners, and dealers will replace the transmission side shifter cable bushing, free of charge. The recall began September 5, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V34.
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the shift cable to detach from the transmission.
Consequence: If the shifter cable detaches from the transmission, the vehicle may not perform the shifts performed by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: This recall will be replaced by NHTSA recall number 25V674. Vehicles already repaired under this recall will need to have the new remedy completed. Chrysler will notify owners, and dealers will replace the transmission side shifter cable bushing, free of charge. The recall began September 5, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V34.
17V824000 · Equipment
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
16V813000 · Visibility:windshield Wiper/washer
Nov 8, 2016
Chrysler (FCA US LLC) is recalling certain model year 2016 Dodge Dart vehicles manufactured April 13, 2015, to June 7, 2016. Due to voltage spikes caused by a problem within the windshield washer pump, the windshield wiper circuit may fail.
Consequence & remedy
Consequence: Without functioning windshield wipers, the driver's visibility may be reduced, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the windshield washer pumps, free of charge. The recall began on December 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S83.
16V113000 · Electrical System:software
Feb 26, 2016
Chrysler (FCA US LLC) is recalling certain model year 2016 Dodge Dart vehicles manufactured July 25, 2015, to December 16, 2015 and equipped with a 2.0L engine and a manual transmission. Additionally included are certain 2015 Dodge Dart vehicles similarly equipped and brought in for dealer service between September 15, 2015 and January 12, 2016. In the affected vehicles, the powertrain control module that monitors the engine torque output may be missing a backup layer of software.
Consequence & remedy
Consequence: Without a backup layer of software, the control module may fail to prevent an un-commanded torque event, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the Engine Control Module software, free of charge. The recall began on March 25, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S10.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ25002 · Recall 19V-293 Post Remedy Failures
Opened Jun 30, 2025 · Closed Dec 12, 2025
Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:shift Linkage/cable/rod; Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (6)
Power Train:automatic Transmission:lever And Linkage:floor Shift
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:automatic Transmission:lever And Linkage:floor Shift
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.