IllustrationMy car was stuck in drive. It would not shift into park. My father had to use the emergency switch under the hood to put it in park. A local dealership was contacted and parts have been ordered to fix the problem. The car has not been inspected. There were no warnings. I did not receive a recall notice in the mail.
2013 Dodge Dart
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dart years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1325–50K
2850–75K
4675–100K
25100–150K
11150K+
132 reports with mileage · 147 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports0 fire reports3 injury reports
Unknown Or Other complaints
33 reportsWhen I got in my car to leave work, the shifter cable had broken. It would not shift to reverse, neutral, or drive. I was left stranded in the middle of the night with no one to pick me up. Also, if it had broken while I was driving I wouldn’t have been able to put it in park and it would have potentially rolled into another car…
Read full complaint
When I got in my car to leave work, the shifter cable had broken. It would not shift to reverse, neutral, or drive. I was left stranded in the middle of the night with no one to pick me up. Also, if it had broken while I was driving I wouldn’t have been able to put it in park and it would have potentially rolled into another car or person. At this time it has been 6 months since the recall and Dodge has no remedy for it. The dealership looked at it and did confirm that the shifter cable had broken.
The transmission and powertrain were inspected due to concerns about the car possibly jolting in a different direction and causing an accident. The issue has been confirmed by the dealer, and the vehicle has been inspected by both the dealer and a mechanic. The car does indeed jolt unexpectedly.
The transmission shift cable detached from the transmission, causing the gear shifter to move freely without actually changing gears. When this happened, the vehicle could not be shifted into Park or Drive and became unsafe to operate. This created a serious safety risk because the car could roll or move unexpectedly even when t…
Read full complaint
The transmission shift cable detached from the transmission, causing the gear shifter to move freely without actually changing gears. When this happened, the vehicle could not be shifted into Park or Drive and became unsafe to operate. This created a serious safety risk because the car could roll or move unexpectedly even when the shifter was in Park. The vehicle is affected by Recall A0C / NHTSA 25V-674 for this exact issue. The failure has not yet been repaired because local dealers have been unresponsive. The problem can be reproduced by simply moving the shifter, as the cable will disconnect again. No warning lights appeared before the failure. The issue was visually confirmed by observing the detached cable under the hood.
This complaint is in regard to the most recent recall on Dodge Darts, the transmission shifter cable detachment. I was in the process of parking my car on an incline. All was normal. I had been out running errands, driving, and shifting for a few hours. The gear shift felt disconnected from anything; there was no effort required…
Read full complaint
This complaint is in regard to the most recent recall on Dodge Darts, the transmission shifter cable detachment. I was in the process of parking my car on an incline. All was normal. I had been out running errands, driving, and shifting for a few hours. The gear shift felt disconnected from anything; there was no effort required to move it back and forth in the shift. The car was not recognizing any movement I was making with the gear shift, and would not lock into place for any gear. I had to hold my foot on the brake even while "shifted" into park; otherwise, I would drift backwards into the car behind me, and potentially into a ditch/creek. I had to call for help to stabilize my car, with bricks behind the tires and a 25-pound weight left on the brake so I could exit the vehicle. We had to lift and open the gear shift to the compartment underneath and manually shift the car into park. During this, we unfortunately broke something under the gear shift. This happened on a Sunday evening (July 20), so no repair person was available to help me. Chrysler refused to offer any assistance or information about the last recall of this issue, and advised me to call the dealership that did the repair (they would not tell me which one I went to, just that it was marked complete in 2019). I know I went to a Shorkey location, but not which. I called three Jim Shorkey Dodge locations in Pittsburgh, and they all refused responsibility. I was told to call Chrysler again. I did not, because why would I? A local mechanic was able to acquire the part from Dodge to "fix" the issue. However, he had to override the safety mechanism that causes the car to recognize what gear the car is in before it can turn off. So now I have to drive around, hoping I don't accidentally press the power button and shut off my car on the road. The car was inspected by a representative from Progressive. They determined a mechanical failure and denied my claim for coverage. This is BS.
I was at a intersection when the incident occurred. I was unable to shift it into gear. I was able to roll it into the gas station at the intersection. Bushing on tension rod disintegrated. Causing the transmission to be stuck in neutral.
Shifter cable was replaced for recall in February of 2025 and it’s messed up again..
Shift gear assembly failure
I purchased it and within two months the cars breaks were slow to respond, or would lock up and the parking break did not work. The car suddenly shifts into neutral while driving on the high way and surface roads, loses power and has nearly caused multiple accidents. Other times when i try to shift, it does not respond. Car stal…
Read full complaint
I purchased it and within two months the cars breaks were slow to respond, or would lock up and the parking break did not work. The car suddenly shifts into neutral while driving on the high way and surface roads, loses power and has nearly caused multiple accidents. Other times when i try to shift, it does not respond. Car stalls going up hill and at stoplights. I took it for diagnostics twice and both places stated that the symptoms are mirroring the earlier recall problems. One said the spark plugs are ruined from some other issue. When I called the manufacturer they stated that it had previously been repaired on recall. I contacted the dealership where I purchased it and they told me the car was sold "as Is". The problems only got worse. The battery would go dead all of the time. I replaced it and still had the same problem. Windows wouldn't go up and down properly, sun roof would not open and close. Every time I used the blinker to turn right, the windshield wipers would turn on. Now they will not turn off at all. It also turned out that the tires had dry rot. When i went in for an oil change i was told that oil was back flowing into a part of the car that it shouldn't. Now I have to pay $300+ plus towing to have the dealership do a diagnostic so that I can ask the manufacturer to cover the cost of repairing it (again) because the first repairs done when the previous owner had it, did not work. The car is a death trap. At this point the car has been sitting until I can afford repairs because Ive been scared to death to drive it. Too many near misses, once with a semi, when the car shut down while doing almost 70mph. It should be illegal to sell this car to anyone new or used. I have an appointment at the Dodge/Chrysler dealership for repairs, but since it was supposedly "fixed" previously, i have very little faith that it can or will be properly repaired.
The shifter cable for this car once again came undone. I did the first original recall a couple a years ago and once again the same issue is happening.
Official recalls
125V674000 · Power Train:automatic Transmission:lever And Linkage:floor Shift
Oct 9, 2025
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles. The shifter cable may detach from the transmission, preventing the vehicle from shifting into the park (P) position and causing a loss of park function.
Consequence & remedy
Consequence: A loss of park function may allow the vehicle to rollaway, increasing the risk of a crash.
Remedy: Vehicles that were previously repaired under recall 19V293 will need to have the new remedy completed. The remedy is currently under development. Interim notification letters, explaining the safety risk, were mailed November 6, 2025. A second notice will be sent once the final remedy is available. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is A0C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 16, 2025.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ25002 · Recall 19V-293 Post Remedy Failures
Opened Jun 30, 2025 · Closed Dec 12, 2025
Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:shift Linkage/cable/rod; Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (6)
Power Train:automatic Transmission:lever And Linkage:floor Shift
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:automatic Transmission:lever And Linkage:floor Shift
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE15024 · Brake Power Assist Failure
Opened Jun 18, 2015 · Closed Dec 9, 2015
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist
On November 24, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding a brake booster defect in approximately 105,458 model year (MY) 2013 through 2014Dodge Dart vehicles equipped with a 2.0L or 2.4L engine and produced between February 27, 2012 and January 23, 2014 (NHTSA Recall# 15V-800, FCA Recall# R63).According to FCA's DIR, the affected vehicles, may experience engine oil migration from the vacuum pump to the brake booster.Brake booster diaphragms exposed to oil may become damaged, resulting in a loss of brake power assist.FCA's recall will inspect the affected vehicles for the presence of engine oil in the brake booster.If no oil is found, the vacuum tube assembly will be replaced with a new design part.If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced.On June 18, 2015, the Office of Defects Investigations opened Preliminary Evaluation PE15-024 to investigate complaints alleging sudden increases in brake pedal effort with corresponding reductions in brake performance in MY 2013 Dodge Dart vehicles.The vehicle population and Failure Report figures in this resume are limited to the MY 2013 Dodge Dart vehicles that are the subject vehicles of PE15-024 all of which are included in the FCA recall.Some of the complaints reported hearing a popping noise during a brake application, which corresponded with sudden reaction force from the brake pedal, increased difficulty in applying the pedal and decreased brake effectiveness.FCA's analysis of field return booster assemblies indicated that some brake booster diaphragms exposed to the engine oil leak condition experienced sudden catastrophic ruptures, resulting in complete loss of booster function.This investigation is hereby closed based on the FCA recall.The VOQs associated with the closing of this investigation are: 10795258, 10795140, 10790670, 10790397, 10786152, 10786142, 10783492, 10783153, 10781418, 10779446, 10778244, 10776581, 10765244, 10765141, 10763566, 10763143, 10762254, 10761075, 10760965, 10759817, 10758707, 10758639, 10750235, 10748935, 10747634, 10745494, 10745395, 10745185, 10744577, 10744361, 10744052, 10736149, 10734443, 10734108, 10732067, 10726648, 10715993, 10713690, 10695212, 10668965, 10660526, 10659435, 10638228, 10620713, 10619184, 10610512, 10597398, 10583883, 10569142, 10565689, 10556239, and 10533008.
Additional source detail variants (3)
Service Brakes
On November 24, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding a brake booster defect in approximately 105,458 model year (MY) 2013 through 2014Dodge Dart vehicles equipped with a 2.0L or 2.4L engine and produced between February 27, 2012 and January 23, 2014 (NHTSA Recall# 15V-800, FCA Recall# R63).According to FCA's DIR, the affected vehicles, may experience engine oil migration from the vacuum pump to the brake booster.Brake booster diaphragms exposed to oil may become damaged, resulting in a loss of brake power assist.FCA's recall will inspect the affected vehicles for the presence of engine oil in the brake booster.If no oil is found, the vacuum tube assembly will be replaced with a new design part.If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced.On June 18, 2015, the Office of Defects Investigations opened Preliminary Evaluation PE15-024 to investigate complaints alleging sudden increases in brake pedal effort with corresponding reductions in brake performance in MY 2013 Dodge Dart vehicles.The vehicle population and Failure Report figures in this resume are limited to the MY 2013 Dodge Dart vehicles that are the subject vehicles of PE15-024 all of which are included in the FCA recall.Some of the complaints reported hearing a popping noise during a brake application, which corresponded with sudden reaction force from the brake pedal, increased difficulty in applying the pedal and decreased brake effectiveness.FCA's analysis of field return booster assemblies indicated that some brake booster diaphragms exposed to the engine oil leak condition experienced sudden catastrophic ruptures, resulting in complete loss of booster function.This investigation is hereby closed based on the FCA recall.The VOQs associated with the closing of this investigation are: 10795258, 10795140, 10790670, 10790397, 10786152, 10786142, 10783492, 10783153, 10781418, 10779446, 10778244, 10776581, 10765244, 10765141, 10763566, 10763143, 10762254, 10761075, 10760965, 10759817, 10758707, 10758639, 10750235, 10748935, 10747634, 10745494, 10745395, 10745185, 10744577, 10744361, 10744052, 10736149, 10734443, 10734108, 10732067, 10726648, 10715993, 10713690, 10695212, 10668965, 10660526, 10659435, 10638228, 10620713, 10619184, 10610512, 10597398, 10583883, 10569142, 10565689, 10556239, and 10533008.
Service Brakes, Hydraulic
On November 24, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding a brake booster defect in approximately 105,458 model year (MY) 2013 through 2014Dodge Dart vehicles equipped with a 2.0L or 2.4L engine and produced between February 27, 2012 and January 23, 2014 (NHTSA Recall# 15V-800, FCA Recall# R63).According to FCA's DIR, the affected vehicles, may experience engine oil migration from the vacuum pump to the brake booster.Brake booster diaphragms exposed to oil may become damaged, resulting in a loss of brake power assist.FCA's recall will inspect the affected vehicles for the presence of engine oil in the brake booster.If no oil is found, the vacuum tube assembly will be replaced with a new design part.If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced.On June 18, 2015, the Office of Defects Investigations opened Preliminary Evaluation PE15-024 to investigate complaints alleging sudden increases in brake pedal effort with corresponding reductions in brake performance in MY 2013 Dodge Dart vehicles.The vehicle population and Failure Report figures in this resume are limited to the MY 2013 Dodge Dart vehicles that are the subject vehicles of PE15-024 all of which are included in the FCA recall.Some of the complaints reported hearing a popping noise during a brake application, which corresponded with sudden reaction force from the brake pedal, increased difficulty in applying the pedal and decreased brake effectiveness.FCA's analysis of field return booster assemblies indicated that some brake booster diaphragms exposed to the engine oil leak condition experienced sudden catastrophic ruptures, resulting in complete loss of booster function.This investigation is hereby closed based on the FCA recall.The VOQs associated with the closing of this investigation are: 10795258, 10795140, 10790670, 10790397, 10786152, 10786142, 10783492, 10783153, 10781418, 10779446, 10778244, 10776581, 10765244, 10765141, 10763566, 10763143, 10762254, 10761075, 10760965, 10759817, 10758707, 10758639, 10750235, 10748935, 10747634, 10745494, 10745395, 10745185, 10744577, 10744361, 10744052, 10736149, 10734443, 10734108, 10732067, 10726648, 10715993, 10713690, 10695212, 10668965, 10660526, 10659435, 10638228, 10620713, 10619184, 10610512, 10597398, 10583883, 10569142, 10565689, 10556239, and 10533008.
Service Brakes, Hydraulic:power Assist
On November 24, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding a brake booster defect in approximately 105,458 model year (MY) 2013 through 2014Dodge Dart vehicles equipped with a 2.0L or 2.4L engine and produced between February 27, 2012 and January 23, 2014 (NHTSA Recall# 15V-800, FCA Recall# R63).According to FCA's DIR, the affected vehicles, may experience engine oil migration from the vacuum pump to the brake booster.Brake booster diaphragms exposed to oil may become damaged, resulting in a loss of brake power assist.FCA's recall will inspect the affected vehicles for the presence of engine oil in the brake booster.If no oil is found, the vacuum tube assembly will be replaced with a new design part.If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced.On June 18, 2015, the Office of Defects Investigations opened Preliminary Evaluation PE15-024 to investigate complaints alleging sudden increases in brake pedal effort with corresponding reductions in brake performance in MY 2013 Dodge Dart vehicles.The vehicle population and Failure Report figures in this resume are limited to the MY 2013 Dodge Dart vehicles that are the subject vehicles of PE15-024 all of which are included in the FCA recall.Some of the complaints reported hearing a popping noise during a brake application, which corresponded with sudden reaction force from the brake pedal, increased difficulty in applying the pedal and decreased brake effectiveness.FCA's analysis of field return booster assemblies indicated that some brake booster diaphragms exposed to the engine oil leak condition experienced sudden catastrophic ruptures, resulting in complete loss of booster function.This investigation is hereby closed based on the FCA recall.The VOQs associated with the closing of this investigation are: 10795258, 10795140, 10790670, 10790397, 10786152, 10786142, 10783492, 10783153, 10781418, 10779446, 10778244, 10776581, 10765244, 10765141, 10763566, 10763143, 10762254, 10761075, 10760965, 10759817, 10758707, 10758639, 10750235, 10748935, 10747634, 10745494, 10745395, 10745185, 10744577, 10744361, 10744052, 10736149, 10734443, 10734108, 10732067, 10726648, 10715993, 10713690, 10695212, 10668965, 10660526, 10659435, 10638228, 10620713, 10619184, 10610512, 10597398, 10583883, 10569142, 10565689, 10556239, and 10533008.