Illustration2003 DODGE DAKOTA WITH 19,000 MILES. I HAVE BEEN TOLD THAT THE BALL JOINTS WILL NEED REPLACING VERY SOON. *CB
2003 Dodge Dakota
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Dodge Dakota do not stand out strongly from the model-year median of 166.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dakota years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
910–25K
4525–50K
3250–75K
1875–100K
24100–150K
12150K+
222 reports with mileage · 74 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports5 fire reports10 injury reports
What owners actually said
296 reportsWHEN THE TRUCK IS STARTED AND PUT INTO DRIVE IT HESITATES THEN SHIFTS REALLY HARD. ALSO WHEN THE TRUCK IS STARTED AND ALLOWED TO WARM UP FOR AROUND THREE MINUTES IT DIES WHEN IT IS PUT IN REVERSE. WHEN IT DOES THIS NONE OF THE LIGHTS ON THE INSTRUMENT PANEL COME ON. THE TRUCK JUST DIES. I HAVE HAD THE TRUCK INTO THE DEALERSHIP F…
Read full complaint
WHEN THE TRUCK IS STARTED AND PUT INTO DRIVE IT HESITATES THEN SHIFTS REALLY HARD. ALSO WHEN THE TRUCK IS STARTED AND ALLOWED TO WARM UP FOR AROUND THREE MINUTES IT DIES WHEN IT IS PUT IN REVERSE. WHEN IT DOES THIS NONE OF THE LIGHTS ON THE INSTRUMENT PANEL COME ON. THE TRUCK JUST DIES. I HAVE HAD THE TRUCK INTO THE DEALERSHIP FOUR TIMES NOW. THE FIRST TIME I TOOK IT IN, THE DEALERSHIP TOLD ME THAT THEY COULDN'T GET THE PROBLEM TO REPLICATE AND TOLD ME TO BRING IT BACK WHEN IT GOT WORSE. I AM NOW ON MY FORTH ATTEMPT TO GET THE PROBLEM FIXED AND THEY ARE CONTINUING TO TELL ME THAT THEY CAN'T GET THE PROBLEM TO REPLICATE. SO I WENT TO THE DEALERSHIP AND REPLICATED THE PROBLEM FOR THEM. THAT WAS ON 10-27-03. IT IS NOW 11-06-03 AND THEY CALLED ME TODAY TO TELL ME THAT THEY STILL CAN'T GET THE TRUCK TO REPLICATE. BUT THEY HAVE HOOKED UP A "CO-PILOT" WHICH WILL READ THE TRUCKS COMPUTER AND HOPEFULLY CATCH THE PROBLEM. I AM HAVING A REALLY HARD TIME BELIEVING THAT THEY CAN'T REPLICATE THE PROBLEM. I HAVE HAD THE TRUCK FOR THREE MONTHS NOW AND THE [XXX] THING HAS DIED EVERY SINGLE TIME I HAVE PUT IT IN REVERSE. I AM POSITIVE THAT I AM BEING BENT OVER. I KNOW THAT I WILL NEVER BUY ANOTHER CHRYSLER AGAIN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TRANSMISSION WILL NOT SHIFT FROM 2ND TO 3RD GEAR WHEN CLIMBING GRADES. ALSO TRUCK WILL STALL OUT WITH NO WARNING OR CHECK ENGINE LIGHTS.
AS TRUCK PULLS OUT (1-5MIN.)IT SLOWS DOWN AND BACKFIRES REAL LOUD. DOESNT STALL OUT, BUT NO POWER. WHEN YOU STEP ON THE GAS NOTHING HAPPENS IT STILL IS CRAWLING AROUND 5MI.THIS WILL HAPPEN ABOUT 1-3MMINUTES THEN IT AUTOMATICALLY PICKS UP BY ITSELF AND RESUMES SPEED. HAPPENING EVERY 2WKS THEN EVERY WK. SOMETIMES A DAY APART.HAD C…
Read full complaint
AS TRUCK PULLS OUT (1-5MIN.)IT SLOWS DOWN AND BACKFIRES REAL LOUD. DOESNT STALL OUT, BUT NO POWER. WHEN YOU STEP ON THE GAS NOTHING HAPPENS IT STILL IS CRAWLING AROUND 5MI.THIS WILL HAPPEN ABOUT 1-3MMINUTES THEN IT AUTOMATICALLY PICKS UP BY ITSELF AND RESUMES SPEED. HAPPENING EVERY 2WKS THEN EVERY WK. SOMETIMES A DAY APART.HAD CO-PILOT ON TWICE BUT RESULTS WERE O. NOTHING SHOWS ON THE DASHBOARD WHEN IT HAPPEND, BUT THE BACKFIRING IS GETTING LOUDER. CALLED CONSUMER AROUND 5 TIMES BUT I AM RIGHT WHERE I STARTED.
PEELING PAINT FROM FRONT GRILLE ASSEMBLY. ALSO AT 10600 MILES THE TRANSMISSION SHIFTS HARD. BOTH UPSHIFTS AND DOWNSHIFTS CAUSE A NOISE AND A SLIGHT HESITATION, FOLLOWED BY A VERY HARSH SHIFT. AND THE ENGINE SEEMS TO ENGAGE THE ELECTRIC HEAT/EXCHANGER FAN ASSEMBLY CAUSING A TREMENDOUS AMOUNT OF CAB NOISE. NO TEMPERATURE CHANG…
Read full complaint
PEELING PAINT FROM FRONT GRILLE ASSEMBLY. ALSO AT 10600 MILES THE TRANSMISSION SHIFTS HARD. BOTH UPSHIFTS AND DOWNSHIFTS CAUSE A NOISE AND A SLIGHT HESITATION, FOLLOWED BY A VERY HARSH SHIFT. AND THE ENGINE SEEMS TO ENGAGE THE ELECTRIC HEAT/EXCHANGER FAN ASSEMBLY CAUSING A TREMENDOUS AMOUNT OF CAB NOISE. NO TEMPERATURE CHANGE HAS BEEN DETECTED WITH THE DASH GAUGES WHEN THE ELECTRIC RADIATOR HAS ENGAGED. VERY NOISY. THERE WILL BE A FOLLOW UP LETTER AFTER THE TRUCK IS TAKEN TO THE DEALER. OCT. 5TH, 2003. 2:30 PM MST
TRANSFER CASE LEAKS FLUID ON OUTPUT SHAFT SEAL. FIRST REPAIR ATTEMPT REPLACED SEAL. SECOND ATTEMPT AT 2531 MILES REPLACED SEAL AGAIN. THIRD ATTEMPT AT 2909 MILES REPLACED EXTENSION HOUSING ON TRANSFER CASE. EXTENSION CAME WITH NEW SEAL ALREADY INSTALLED. FOURTH ATTEMPT AT 6,745 MILES REPLACED EXTENSION HOUSING AGAIN ALSO NE…
Read full complaint
TRANSFER CASE LEAKS FLUID ON OUTPUT SHAFT SEAL. FIRST REPAIR ATTEMPT REPLACED SEAL. SECOND ATTEMPT AT 2531 MILES REPLACED SEAL AGAIN. THIRD ATTEMPT AT 2909 MILES REPLACED EXTENSION HOUSING ON TRANSFER CASE. EXTENSION CAME WITH NEW SEAL ALREADY INSTALLED. FOURTH ATTEMPT AT 6,745 MILES REPLACED EXTENSION HOUSING AGAIN ALSO NEW YOKE AND CHECKED BALANCE IN DRIVELINE.
TRANSMISSION INTERMITTENTLY JERKS/SHUDDERS WHEN ACCELERATING AROUND 30-40 MPH.
WE HAVE RECENTLY SUBMITTED A CLAIM TO THE BUREAU OF AUTOMOTIVE REPAIRS. OUR TRUCK HAS BEEN IN THE SHOP 6 TIMES FOR THE SAME AND NEW PROBLEMS. WE BOUGHT THIS VEHICLE IN JUNE WITH 12 MILES ON IT. THEY RECENTLY HAD OUR VEHICLE FOR 3 DAYS IN A ROW AND WANTED TO KEEP IT FOR A 4TH DAY, HOWEVER WE DECLINED. BELOW PLEASE FIND A LIST…
Read full complaint
WE HAVE RECENTLY SUBMITTED A CLAIM TO THE BUREAU OF AUTOMOTIVE REPAIRS. OUR TRUCK HAS BEEN IN THE SHOP 6 TIMES FOR THE SAME AND NEW PROBLEMS. WE BOUGHT THIS VEHICLE IN JUNE WITH 12 MILES ON IT. THEY RECENTLY HAD OUR VEHICLE FOR 3 DAYS IN A ROW AND WANTED TO KEEP IT FOR A 4TH DAY, HOWEVER WE DECLINED. BELOW PLEASE FIND A LIST OF THE PROBLEMS: 1) LOUD HOWLING NOISE WHEN BACKING UP IN REVERSE 2) SLIPS OUT OF GEAR WHEN IN REVERSE OR DRIVE 3) IDLES ROUGHLY 4) OCCASIONALLY DIES WHEN BACKING IN REVERSE OR GOING FORWARD 5) WHEEL WELL GUARDS ARE STARTING TO PEEL AWAY 6) RUNS IN THE PAINT JOB 7) THERE WAS ELECTRICAL WIRING ISSUES 8) TRANSMISSION ISSUES
AFTER 6,000 MILES ON MY 2003 DAKOTA, I HAD TO HAVE THE ROTORS (ALL 4) TURNED BECAUSE THEY WERE WARPED. NOW DEALER DID IT FOR FREE. AGAIN 13,000 MILES THEY ARE WARPED NEED TURNED AGAIN. DEALER NOT PAYING I HAVE TO PAY THEM. IT IS CLOSE TO ANOTHER 6000 MILES AND THEY ARE STARTING TO BEHAVE IN THE WAY THEY DID WITH PEDAL PULSATING…
Read full complaint
AFTER 6,000 MILES ON MY 2003 DAKOTA, I HAD TO HAVE THE ROTORS (ALL 4) TURNED BECAUSE THEY WERE WARPED. NOW DEALER DID IT FOR FREE. AGAIN 13,000 MILES THEY ARE WARPED NEED TURNED AGAIN. DEALER NOT PAYING I HAVE TO PAY THEM. IT IS CLOSE TO ANOTHER 6000 MILES AND THEY ARE STARTING TO BEHAVE IN THE WAY THEY DID WITH PEDAL PULSATING AND VIBRATING AND THE TRUCK REAR END FEELING LIKE IT IS BOUNCING UP AND DOWN AND I KNOW THE SAME PROBLEM IS THERE, AND THIS TIME IT IS GOING TO BE REPLACE ALL 4. I AM NOT THE ONLY ONE WITH ROTOR PROBLEMS, IT APPEARS THE BRAKES AREN'T MADE FOR A TRUCK THIS SIZE BUT FOR A SMALLER VERSION OF IT. THIS NEEDS TO BE FIXED MY DODGE. *CB
2003 DAKOTA QUAD CAB. IN COLD TEMPERATURES BELOW 15F THE FLUID SPRAYERS WILL FREEZE. CAUSING LOW TO ZERO VISIBILITY IN WINTER WEATHER DRIVING. WHEN TRUCK IS PARKED AND WARMED UP FOR 10-15 MINS FLUID WILL SPRAY FOR AS LONG AS YOU WANT, AFTER YOU STOP IT POOLS UP IN THE TIPS OF THE SPRAYERS, AND WILL FREEZE ONCE YOU MOVE AGAIN. T…
Read full complaint
2003 DAKOTA QUAD CAB. IN COLD TEMPERATURES BELOW 15F THE FLUID SPRAYERS WILL FREEZE. CAUSING LOW TO ZERO VISIBILITY IN WINTER WEATHER DRIVING. WHEN TRUCK IS PARKED AND WARMED UP FOR 10-15 MINS FLUID WILL SPRAY FOR AS LONG AS YOU WANT, AFTER YOU STOP IT POOLS UP IN THE TIPS OF THE SPRAYERS, AND WILL FREEZE ONCE YOU MOVE AGAIN. THE HOSE'S ARE ALSO NOT INSULATED TO PROTECT FROM THE COLD SO THEY DON'T FREEZE AS WELL. THIS CAN AND WILL CAUSE ZERO VISIBILITY, CAUSING THE DRIVE TO NOT BE ABLE TO SEE AND POSSIBLY GETTING INTO AN ACCIDENT. *CB
Official recalls
404V596000 · Suspension:front:control Arm:upper Ball Joint
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V216000 · Visibility:windshield Wiper/washer
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V389000 · Electrical System:wiring
Oct 10, 2003
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
02V322000 · Exterior Lighting:headlights:switch
Dec 2, 2002
ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.