DT: THE CONTACT STATES THERE IS A RECALL ON 2003 DODGE DAKOTA CONCERNING THE UPPER BALL JOINT. THE CONTACT FEELS THE PROBLEM IS GOING TO CONTINUE BECAUSE WATER RUNS DOWN BETWEEN WHERE THE DOOR OPENS LEADING TO THE FRONT SUSPENSION. THE CONSUMER HAS CONTACTED TWO SERVICE DEALERS . THE CONSUMER HAS NOT CONTACTED THE MANUFACTU…
Read full complaint
DT: THE CONTACT STATES THERE IS A RECALL ON 2003 DODGE DAKOTA CONCERNING THE UPPER BALL JOINT. THE CONTACT FEELS THE PROBLEM IS GOING TO CONTINUE BECAUSE WATER RUNS DOWN BETWEEN WHERE THE DOOR OPENS LEADING TO THE FRONT SUSPENSION. THE CONSUMER HAS CONTACTED TWO SERVICE DEALERS . THE CONSUMER HAS NOT CONTACTED THE MANUFACTURER. *AK
NHTSA ODI #10133074
Mileage unknown · Jun 20, 2005
Suspension
2003 DODGE DAKOTA UPPER LEFT BALL JOINT HAD TO BE REPLACED.*MR THE CONSUMER REQUESTED THAT THE DEALER ALSO REPLACE THE UPPER RIGHT BALL JOINT BUT THEY REFUSED STATING THAT THE MANUFACTURER WOULDN'T COVER THE REPLACEMENT UNTIL IT FAILED. *NM
NHTSA ODI #10126874
41,000 miles · May 25, 2005
Suspension
1) AT ABOUT 40,000 MILES MY FRONT DRIVERS SIDE LOWER BALL JOINT STARTED MAKING AN EXTREMELY LOUD CRUNCHING NOISE AS IF METAL WERE GRINDING WITH METAL. 2) I SUBSEQUENTLY TOOK MY TRUCK TO A LOCAL DEALER WHO NOTIFIED ME THAT THE LOWER BALL JOINT WAS LOOSE AND THAT IT WAS NOT COVERED BY THE PREVIOUS RECALL WHICH COVERED THE UPPE…
Read full complaint
1) AT ABOUT 40,000 MILES MY FRONT DRIVERS SIDE LOWER BALL JOINT STARTED MAKING AN EXTREMELY LOUD CRUNCHING NOISE AS IF METAL WERE GRINDING WITH METAL. 2) I SUBSEQUENTLY TOOK MY TRUCK TO A LOCAL DEALER WHO NOTIFIED ME THAT THE LOWER BALL JOINT WAS LOOSE AND THAT IT WAS NOT COVERED BY THE PREVIOUS RECALL WHICH COVERED THE UPPER BALL JOINT ONLY. 3) THE PARTS AND LABOR TO REPLACE THIS PART COST IN EXCESS OF $270.00 NOT INCLUDING THE $40 INSPECTION FEE
NHTSA ODI #10122084
Mileage unknown · May 6, 2005
StructureSuspension
2003 DODGE DAKOTA EXPERIENCING PROBLEMS WITH THE BALL JOINTS AS WELL AS THE WELDS OF THE TRUCK BED AT THE UPPER PART NEAR THE REAR WINDOW.*MR A RECALL WAS ISSUED FOR THE UPPER BALL JOINTS (04V596000) BUT THE DEALER WANTED THE CONSUMER TO PAY TO DIAGNOSE THE PROBLEM. THERE ARE PLASTIC RIVETS ON BOTH SIDE PANELS THAT ATTACH TO T…
Read full complaint
2003 DODGE DAKOTA EXPERIENCING PROBLEMS WITH THE BALL JOINTS AS WELL AS THE WELDS OF THE TRUCK BED AT THE UPPER PART NEAR THE REAR WINDOW.*MR A RECALL WAS ISSUED FOR THE UPPER BALL JOINTS (04V596000) BUT THE DEALER WANTED THE CONSUMER TO PAY TO DIAGNOSE THE PROBLEM. THERE ARE PLASTIC RIVETS ON BOTH SIDE PANELS THAT ATTACH TO THE REAR PANEL TRUCK BED. THE REAR PANEL TRUCK BED IS SO WEAK THAT ABOUT FIVE POUNDS OF PRESSURE BENT THE PANEL. THE CONSUMER BELIEVES THE PLASTIC BED LINER IS STRONGER THAN THE REAR TRUCK BED PANEL *NM
NHTSA ODI #10121460
31,600 miles · May 3, 2005
Suspension
CONSUMER STATES: LOWER CONTROL ARM BALL JOINT RIGHT FRONT SEPARTED AND WHEEL AND CAME OFF VEHICLE WHILE IN MOTION
NHTSA ODI #10119482
Mileage unknown · May 3, 2005
Suspension
WITH REGARDS TO THE RECAL # 04V596000 ON THE 4X4 DODGE DAKOTA TRUCK. I AM HAVING THE SAME NOISES AND PROBLEMS ON THE 2X4 TRUCK WILL THIS RECALL BE EXSPENDED TO 2X4?
NHTSA ODI #10119412
31,600 miles · May 1, 2005
SuspensionCrash
THE RIGHT FRONT LOWER CONTROL ARM BALL JOINT SEPARATED CAUSING MY 2003 DODGE DAKOTA TO RUN OFF THE ROAD AND SWERVE TO THE RIGHT. THE TRUCK HIT A PARKED CAR AND BOTH VEHICLES WERE TOTALED. THERE WAS NO NOISE OR INDICATION OF ANY PROBLEM PRIOR TO THE INCIDENT. MILEAGE WAS 31,600.*AK
NHTSA ODI #10118784
Mileage unknown · Mar 29, 2005
Suspension
REAR BRAKES HOWL IN REVERSE. DEALER STATED NEEDS BREAK IN. AT 41.000 MILES, STILL HOWLS. RECALL ON UPPER BALL JOINTS RECEIVED IN FEBRUARY. AS OF 03-29-05, DEALER STATES THERE IS A 2 MONTH BACKORDER ON PARTS FOR REPAIR.
NHTSA ODI #10115993
Mileage unknown · Mar 1, 2005
Suspension
NHTSA RECALL CAMPAIGN 04V596000; DAIMLER CHRYSLER ISSUED A FRONT UPPER BALL JOINT RECALL. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL, BUT THE LEFT FRONT BALL JOINT FELL OFF.*AK
NHTSA ODI #10113209
Mileage unknown · Feb 25, 2005
Suspension
NHTSA CAMPAIGN 04V596000; DAIMLER CHRYSLER ISSUED AN UPPER BALL JOINT RECALL. THIS VEHICLE IS INCLUDED IN THE RECALL, BUT THERE ARE NO PARTS AVAILABLE IN ORDER TO REPAIR, WHICH IS DANGEROUS BECAUSE THE WHEELS CAN FALL OFF. *NM
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2003 Dodge Dakota Problems, Complaints & Recalls | Skip That Year
Illustration