NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
100 reportsClear category filter48,318 miles · Jan 18, 2007
Suspension
2003 DODGE DAKOTA 4X4 PICKUP 1D7H32N03S124289 LOUD CLUNKING NOISES, FRONT END, STEERING LOOSESNESS,SKITTISHNESS, SEVERE VIBRATION AND POOR HANDLING FELT IN FRONT END SECTION OF VEHICLE. (PURCHASED FROM MITCHELL SIMSBURY,CT )BROUGHT TO LOCAL DEALER WHO DIAGNOSED & REPLACED (2)BAD /DEFECTIVE UPPER BALL JOINTS 17011019 BUT CHARGED…
Read full complaint
2003 DODGE DAKOTA 4X4 PICKUP 1D7H32N03S124289 LOUD CLUNKING NOISES, FRONT END, STEERING LOOSESNESS,SKITTISHNESS, SEVERE VIBRATION AND POOR HANDLING FELT IN FRONT END SECTION OF VEHICLE. (PURCHASED FROM MITCHELL SIMSBURY,CT )BROUGHT TO LOCAL DEALER WHO DIAGNOSED & REPLACED (2)BAD /DEFECTIVE UPPER BALL JOINTS 17011019 BUT CHARGED FOR PARTS/SERVICE. APPROX MILEAGE:48,318 VERY PREMATURE FOR GOOD PRODUCT DESIGN & RELIABILITY. DANGEROUS SAFETY RELATED DEFECTS. *NM
NHTSA ODI #10179058
19,398 miles · Dec 5, 2006
Suspension
POPPING NOISE IN FRONT END ENTERING DRIVEWAY OR OVER SPEED BUMPS HAD DEALER INSPECT AND PERFORM TSB. ON UPPER BALL JOINTS PER LETTER FROM CHRYSLER CORP. THEY DID REPAIR AND TOLD ME THE HUB BEARINGS WERE ALSO BAD NOT COVERED, 552.00 I REPLACED THEM MYSELF I CAN'T FIND A PROBLEM THE HUBS . THE NOISE IS STILL THERE ! *JB …
Read full complaint
POPPING NOISE IN FRONT END ENTERING DRIVEWAY OR OVER SPEED BUMPS HAD DEALER INSPECT AND PERFORM TSB. ON UPPER BALL JOINTS PER LETTER FROM CHRYSLER CORP. THEY DID REPAIR AND TOLD ME THE HUB BEARINGS WERE ALSO BAD NOT COVERED, 552.00 I REPLACED THEM MYSELF I CAN'T FIND A PROBLEM THE HUBS . THE NOISE IS STILL THERE ! *JB
NHTSA ODI #10175264
300,000 miles · Sep 29, 2006
Suspension
BALL JOINT FAILURE ON DODGE DAKOTA 4X4. RECALL ON OTHER VINS NOT MINE. FAILURE AT 30000 MILES. THE DEALER SAID 1200 DOLLARS AND THEY WOULD PUT ON THE NEW MODIFIED ONES. WHY AM I PAYING FOR A DODGE DEFECT. *NM
NHTSA ODI #10169625
32,000 miles · Mar 15, 2006
Power TrainSuspensionInjury
I WAS CAUGHT IN AN ICE STORM IN MY 2003, DODGE DAKOTA, 4X4 QUAD CAB. THE TRUCK WENT INTO A SLIGHT SPIN AND BUMPED A SMALL CURB THEN SLID UP OVER THE CURB. I WAS ONLY TRAVELING AT APPROX. 5 MPH WHEN I BUMPED THE CURB. THE AXLE SHEARED OFF AND BROKE THE HUB, ROTOR, WHEEL, TIRE, AND BENT THE AXLE HOUSING. THE TRUCK WAS RENDERED…
Read full complaint
I WAS CAUGHT IN AN ICE STORM IN MY 2003, DODGE DAKOTA, 4X4 QUAD CAB. THE TRUCK WENT INTO A SLIGHT SPIN AND BUMPED A SMALL CURB THEN SLID UP OVER THE CURB. I WAS ONLY TRAVELING AT APPROX. 5 MPH WHEN I BUMPED THE CURB. THE AXLE SHEARED OFF AND BROKE THE HUB, ROTOR, WHEEL, TIRE, AND BENT THE AXLE HOUSING. THE TRUCK WAS RENDERED UNDRIVABLE AND WAS TOWED TO A DODGE DEALERSHIP FOR REPAIRS. I CALLED DAIMLERCHRYSLER AND ASKED FOR THE PARTS TO BE TESTED FOR DEFECTIVENESS. I HAD SEEN SEVERAL WEB SITES DEVOTED TO AXLES PUT INTO DODGE TRUCKS THAT WERE KNOWN TO DAIMLERCHRYSLER TO BE DEFECTIVE DUE TO POOR HEAT TREATING. I WAS TREATED VERY RUDELY AND THE PROBLEM WAS NOT ADDRESSED. SINCE THE ACCIDENT, I HAVE HAD SEVERAL MECHANICS AND MACHINISTS LOOK AT THIS AXLE AND ALL SAY THAT IT SHOULD HAVE NEVER BROKEN UNDER THE CIRCUMSTANCES IT WAS SUBJECTED TO. I AM NOW AFRAID TO DRIVE THIS VEHICLE, FEARING THAT THE REST OF THE AXLES ARE ALSO DEFECTIVE. I AM GETTING NO SATISFACTION IN SOLVING THIS PROBLEM AND MY OWN INSURANCE HAD TO PAY THE $3,000. DAMAGE CAUSED BY A 5 MPH BUMP. *NM
NHTSA ODI #10152783
48,000 miles · Mar 9, 2006
Suspension
EXPERIENCED CLUNKING NOISE IN FRONT SUSPENSION. BALL JOINT SUBSEQUENTLY FAILED CAUSING FRONT WHEEL TO SEPARATE FROM THE VEHICLE WHILE OPERATING. *NM
NHTSA ODI #10152277
40,000 miles · Jan 19, 2006
Suspension
DT: THE CONSUMER STATED WHILE DRIVING THERE WAS NOISE COMING FROM THE SUSPENSION WHEN GOING OVER BUMPS. THE PROBLEM OCCURRED AT LOW SPEEDS. THE DEALERSHIP DETERMINED THE BUSHINGS AND THE UPPER BALL JOINTS WERE WORN. THERE IS A RECALL WITH THE NHTSA # 04V596000. THE CONSUMER EXPERIENCED THE SAME PROBLEM AS INDICATED IN THE RE…
Read full complaint
DT: THE CONSUMER STATED WHILE DRIVING THERE WAS NOISE COMING FROM THE SUSPENSION WHEN GOING OVER BUMPS. THE PROBLEM OCCURRED AT LOW SPEEDS. THE DEALERSHIP DETERMINED THE BUSHINGS AND THE UPPER BALL JOINTS WERE WORN. THERE IS A RECALL WITH THE NHTSA # 04V596000. THE CONSUMER EXPERIENCED THE SAME PROBLEM AS INDICATED IN THE RECALL; HOWEVER, THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED. *JB
NHTSA ODI #10148148
64,000 miles · Dec 13, 2005
Suspension
DT: THE CONTACT STATES THERE I NHTSA RECALL CAMPAIGN ID 04V596000 CONCERNING THE UPPER BALL JOINT. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE VEHICLE IS CURRENTLY BEING REPAIRED AT THE CONTACT'S EXPENSE.*AK
NHTSA ODI #10145119
Mileage unknown · Sep 15, 2005
SuspensionCrashInjury
MY 18 MONTH OLD SON AND I WERE IN A SINGLE CAR ROLLOVER, ON SEPTEMBER 9, 2005. I WAS DRIVING A 2003 DODGE DAKOTA WHEN MY TRUCK STARTED TO MAKE A NOISE, THEN WE WERE SENT INTO A ROLLOVER. THE RIGHT FRONT TIRE WAS GONE WHEN WE STOPPED. I WAS SENT INFORMATION FROM MY UNCLE AFTER I SENT HIM PICTURES OF THE ACCIDENT AND HE SENT ME I…
Read full complaint
MY 18 MONTH OLD SON AND I WERE IN A SINGLE CAR ROLLOVER, ON SEPTEMBER 9, 2005. I WAS DRIVING A 2003 DODGE DAKOTA WHEN MY TRUCK STARTED TO MAKE A NOISE, THEN WE WERE SENT INTO A ROLLOVER. THE RIGHT FRONT TIRE WAS GONE WHEN WE STOPPED. I WAS SENT INFORMATION FROM MY UNCLE AFTER I SENT HIM PICTURES OF THE ACCIDENT AND HE SENT ME INFORMATION ON THE POSSIBLE RECALL. I NEED TO KNOW WHAT MY OPTIONS ARE AND WHAT DO I DO NOW. *NM
NHTSA ODI #10136605
Mileage unknown · Sep 7, 2005
Suspension
MY HUSBAND TOOK HIS 2003 DODGE DAKOTA TO A DODGE DEALERSHIP FOR RECALL WORK TO BE DONE. A FRONT BALL JOINT HAD TO BE REPLACED (TO KEEP THE FRONT END OF THE TRUCK FROM FALLING APART WHILE DRIVING AND KILLING EVERYONE.) WHEN HE TOOK IT IN IT DROVE FINE. AFTER THE WORK WAS DONE, IT PULLS TO THE RIGHT. I CALLED ANOTHER DODGE SERVIC…
Read full complaint
MY HUSBAND TOOK HIS 2003 DODGE DAKOTA TO A DODGE DEALERSHIP FOR RECALL WORK TO BE DONE. A FRONT BALL JOINT HAD TO BE REPLACED (TO KEEP THE FRONT END OF THE TRUCK FROM FALLING APART WHILE DRIVING AND KILLING EVERYONE.) WHEN HE TOOK IT IN IT DROVE FINE. AFTER THE WORK WAS DONE, IT PULLS TO THE RIGHT. I CALLED ANOTHER DODGE SERVICE DEPARTMENT TO ASK THEM ABOUT PROCEDURE, THEY SAID THAT AN ALIGNMENT IS STANDARD PROCEDURE WHEN COMPLETING THAT TYPE OF WORK, BUT THAT THE CAR OWNER IS SCREWED WHEN IT COMES TO RECALL WORK. I THEN CALLED THE MANUFACTURER WHO TOLD ME BASICALLY THE SAME THING. THAT'S NOT RIGHT!! I SHOULD NOT HAVE TO FORK OVER MONEY TO HAVE FIXED WHAT THEY SCREWED UP! PLEASE FIX THIS. *JB
NHTSA ODI #10135694
6,000 miles · Aug 22, 2005
Suspension
DT: 2003 DODGE DAKOTA. THE CONSUMER RECEIVED MANUFACTURER'S 35190558 CONCERNING UPPER BALL JOINTS FAILURE. CONSUMER CALLED THE DEALER, AND THE DEALER URGED THE CONSUMER TO CALL THE MANUFACTURER. THE CONSUMER CALLED THE MANUFACTURER, AND THEY SAID TO CALL THE DEALER BACK. THE CONSUMER COMPLAINED, WAS GETTING THE RUN ARO…
Read full complaint
DT: 2003 DODGE DAKOTA. THE CONSUMER RECEIVED MANUFACTURER'S 35190558 CONCERNING UPPER BALL JOINTS FAILURE. CONSUMER CALLED THE DEALER, AND THE DEALER URGED THE CONSUMER TO CALL THE MANUFACTURER. THE CONSUMER CALLED THE MANUFACTURER, AND THEY SAID TO CALL THE DEALER BACK. THE CONSUMER COMPLAINED, WAS GETTING THE RUN AROUND FROM BOTH PLACES. THE DEALERSHIP SAID THERE MUST BE A CERTIFIED MECHANIC TO HAVE THE REPAIRS DONE. THE ONLY CERTIFIED MECHANIC WAS IN ANCHORAGE, ALASKA . THERE WERE NO ROADS TO THE VILLAGE WHERE CONSUMER LIVED, COULD ONLY GET THERE BY AIRPLANE. *AK
NHTSA ODI #10133796
Official recalls
4Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Oct 10, 2003
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Dec 2, 2002
ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration