RECALL CAMPAIGN 04V596000 CONCERNING BALL JOINT WEAR. OWNER RECEIVED NOTIFICATION FROM THE MANUFACTURER IN JANUARY 4, 2005. OWNER CONTACTED THE DEALER, AND WAS TOLD THAT PARTS WERE NOT AVAILABLE, AND THERE WAS NO INDICATION AS TO WHEN THE PARTS WILL BE MADE AVAILABLE. ALSO, CONTACTED THE MANUFACTURER, AND THEY TOO WERE UNABLE TO…
Read full complaint
RECALL CAMPAIGN 04V596000 CONCERNING BALL JOINT WEAR. OWNER RECEIVED NOTIFICATION FROM THE MANUFACTURER IN JANUARY 4, 2005. OWNER CONTACTED THE DEALER, AND WAS TOLD THAT PARTS WERE NOT AVAILABLE, AND THERE WAS NO INDICATION AS TO WHEN THE PARTS WILL BE MADE AVAILABLE. ALSO, CONTACTED THE MANUFACTURER, AND THEY TOO WERE UNABLE TO GIVE A DARE AS TO WHEN PARTS WILL BE MADE AVAILABLE. *AK THE CONSUMER STATED THAT THE VEHICLE SWAYS FROM SIDE TO SIDE. *TC
NHTSA ODI #10109026
Mileage unknown · Feb 14, 2005
Suspension
NHTSA CAMPAIGN 04V596000; DAIMLER CHRYSLER ISSUED AN FRONT UPPER BALL JOINT RECALL. THIS VEHICLE WAS INCLUDED IN THE RECALL, BUT WHEN TAKEN IN FOR SERVICE, OWNER WAS INFORMED THAT THE LOWER BALL JOINTS NEED TO BE REPLACED AS WELL. OWNER WAS INFORMED THAT THE WHEELS CAN FALL OFF IF NOT REPLACED.
NHTSA ODI #10111456
42,000 miles · Feb 7, 2005
Suspension
CONSUMER COULD HEAR A CLICKING NOISE WHILE DRIVING AT ANY SPEED. VEHICLE WAS TAKEN TO A REPAIR SHOP, AND MECHANIC DETERMINED THAT BOTH FRONT UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. *AK *JB
NHTSA ODI #10106985
Mileage unknown · Feb 2, 2005
Suspension
THE CONSUMER BELIEVES THE VEHICLE'S FRONT BALL JOINTS ARE LOOSE. *NM *JB
NHTSA ODI #10111542
Mileage unknown · Feb 1, 2005
SuspensionFire
NHTSA RECALL CAMPAIGN 04V596000 CONCERNING FRONT BALL JOINTS. THIS VEHICLE WAS INCLUDED IN THE RECALL, BUT THERE WERE NO APPOINTMENTS AVAILABLE UNTIL MAY, WHICH COULD BE DANGEROUS BECAUSE THE WHEELS COULD FALL OFF.*AK
NHTSA ODI #10109479
43,500 miles · Jan 26, 2005
Electrical SystemSuspensionVisibility
VEHICLE WAS TAKEN TO DEALER FOR THE UPPER BALL JOINT RECALL. DEALER TOLD CONSUMER THAT THE LOWER BALL JOINTS WORE OUT AS WELL, AND NEEDED TO BE REPLACED. MANUFACTURER STATED NO RECALL.*AK RECALL CAMPAIGN; NHTSA CAMPAIGN ID NUMBER : 04V596000 DEALING WITH UPPER BALL JOINTS. THE RECALL DID NOT INCLUDE THE LOWER BALL JOINTS …
Read full complaint
VEHICLE WAS TAKEN TO DEALER FOR THE UPPER BALL JOINT RECALL. DEALER TOLD CONSUMER THAT THE LOWER BALL JOINTS WORE OUT AS WELL, AND NEEDED TO BE REPLACED. MANUFACTURER STATED NO RECALL.*AK RECALL CAMPAIGN; NHTSA CAMPAIGN ID NUMBER : 04V596000 DEALING WITH UPPER BALL JOINTS. THE RECALL DID NOT INCLUDE THE LOWER BALL JOINTS WITH THE SAME DEFECT. NHTSA CAMPAIGN ID NUMBER : 04V216000; DEALING WITH THE WINDSHIELD WIPER MOTOR. THE CONSUMER STATED THAT THE WINDSHIELD WIPER MOTOR WAS SERVICED AND HAD AT LEAST ONE FAILURE SINCE THE REPAIR. NHTSA CAMPAIGN ID NUMBER : 03V389000 DEALING WITH THE DASH WIRING HARNESS REPAIRED BY THE DEALER. *TC
NHTSA ODI #10106751
Mileage unknown · Jan 25, 2005
Suspension
NHTSA CAMPAIGN 04V596000; DAIMLER CHRYLSER ISSUED AN UPPER BALL JOINT RECALL. THIS VEHICLE WAS INCLUDED IN THE RECALL, BUT THERE WERE NO AVAILABLE APPOINTMENTS UNTIL MAY, WHICH COULD BE DANGEROUS BECAUSE THE WHEELS CAN FALL OFF. *JB. CONSUMER STATED NO AVAILABLE APPOINTMENTS UNTIL MAY WAS RIDICULOUS SINCE THIS WAS A SAFETY ISS…
Read full complaint
NHTSA CAMPAIGN 04V596000; DAIMLER CHRYLSER ISSUED AN UPPER BALL JOINT RECALL. THIS VEHICLE WAS INCLUDED IN THE RECALL, BUT THERE WERE NO AVAILABLE APPOINTMENTS UNTIL MAY, WHICH COULD BE DANGEROUS BECAUSE THE WHEELS CAN FALL OFF. *JB. CONSUMER STATED NO AVAILABLE APPOINTMENTS UNTIL MAY WAS RIDICULOUS SINCE THIS WAS A SAFETY ISSUE. *AK
NHTSA ODI #10108811
Mileage unknown · Jan 25, 2005
Suspension
RECALL CAMPAIGN: 2002 DODGE DAKOTA HAVE UPPER BALL JOINTS PROBLEMS. REPLACED UPPER BALL JOINTS. *BF RECALL CAMPAIGN; THE CONSUMER RECEIVED A SAFETY RECALL NOTICE TO HAVE THE UPPER BALL JOINTS REPLACED. THE CONSUMER WAS TOLD THAT THE TIE ROD REPLACEMENT AND FRONT END ALIGNMENT WOULD NOT BE COVERED. *TC THE CONSUMER HAD T…
Read full complaint
RECALL CAMPAIGN: 2002 DODGE DAKOTA HAVE UPPER BALL JOINTS PROBLEMS. REPLACED UPPER BALL JOINTS. *BF RECALL CAMPAIGN; THE CONSUMER RECEIVED A SAFETY RECALL NOTICE TO HAVE THE UPPER BALL JOINTS REPLACED. THE CONSUMER WAS TOLD THAT THE TIE ROD REPLACEMENT AND FRONT END ALIGNMENT WOULD NOT BE COVERED. *TC THE CONSUMER HAD THE BALL JOINTS REPLACED PRIOR TO RECEIVING THE RECALL NOTICE. *JB
NHTSA ODI #10108802
Mileage unknown · Jan 24, 2005
Suspension
2002 DODGE DAKOTA RECALL.***NO ANSWER REQUIRED***. *MR CONSUMER RECEIVE WARRANTY EXTENSION FOR UPPER BALL JOINTS. HOWEVER, CONSUMER WANTS TO KNOW WHY THE 2WDS WERE NOT INCLUDED IN THE RECALL FOR THE UPPER BALL JOINTS. *TT *NM
NHTSA ODI #10128087
Mileage unknown · Jan 18, 2005
Suspension
NHTSA RECALL 04V596000 ON THE BALL JOINT WEAR. CONSUMER CONTACTED THE DEALER AND WAS INFORMED THAT THE NEXT AVAILABLE APPOINTMENT IS ON MAY 26, 2005. PLEASE PROVIDE FURTHER DETAILS. *JB
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Dodge Dakota Problems, Complaints & Recalls | Skip That Year
Illustration