BRAKE ROTORS ARE WARPED. STARTED AT APPROXIMATELY 20,000 MILES. WAY TO EARLY TO BE WARPED. HAVE READ OF MANY OTHERS WITH SAME PROBLEM. ALSO HEARD NOISE FROM FRONT SUSPENSION, THOUGHT IT MIGHT BE BALL JOINT OR SUSPENSION PROBLEM, BUT DEALER STATED THAT IT IS OK. READ QUITE A BIT ABOUT BALL JOINT PROBLEMS ON SAME VEHICLE. *…
Read full complaint
BRAKE ROTORS ARE WARPED. STARTED AT APPROXIMATELY 20,000 MILES. WAY TO EARLY TO BE WARPED. HAVE READ OF MANY OTHERS WITH SAME PROBLEM. ALSO HEARD NOISE FROM FRONT SUSPENSION, THOUGHT IT MIGHT BE BALL JOINT OR SUSPENSION PROBLEM, BUT DEALER STATED THAT IT IS OK. READ QUITE A BIT ABOUT BALL JOINT PROBLEMS ON SAME VEHICLE. *JB
NHTSA ODI #10060598
64,000 miles · Mar 5, 2004
Suspension
WHILE DRIVING CONSUMER LOST CONTROL. DEALERSHIP INFORMED CONSUMER THAT THE PROBLEM PERTAINED TO THE FRONT UPPER BALL JOINTS. *AK
NHTSA ODI #10061420
Mileage unknown · Mar 5, 2004
Suspension
I OWN A 2002 DODGE DAKOTA PICKUP. AFTER HEARING AND READING CBS NEWS PIECE ON THE DURANGO AND DAKOTA HAVING FAULTY BALL JOINTS, I HAD MY LOCAL DODGE DEALER CHECK THE UPPER BALL JOINTS ON MY TRUCK. ONE UPPER JOINT WAS LOOSE AND THEY RECOMMENDED IT BE REPLACED. THE COST WAS $188. I FEEL SINCE THERE HAVE BEEN OVER 700 COMPLAINT…
Read full complaint
I OWN A 2002 DODGE DAKOTA PICKUP. AFTER HEARING AND READING CBS NEWS PIECE ON THE DURANGO AND DAKOTA HAVING FAULTY BALL JOINTS, I HAD MY LOCAL DODGE DEALER CHECK THE UPPER BALL JOINTS ON MY TRUCK. ONE UPPER JOINT WAS LOOSE AND THEY RECOMMENDED IT BE REPLACED. THE COST WAS $188. I FEEL SINCE THERE HAVE BEEN OVER 700 COMPLAINTS ABOUT THIS, THAT DAIMLER CHRYSLER SHOULD RECALL AFFECTED VEHICLES AND FIX THE PROBLEM. THE FACT THAT DODGE HAS HAD SO MANY COMPLAINTS AND IT TOOK A CBS NEWS REPORT TO EDUCATE THE PUBLIC IS TRAGIC. WHAT'S MORE TRAGIC IS THAT IT PUT THE LIFE OF MYSELF AND MY SON IN DANGER. I FEEL THAT DODGE SHOULD REIMBURSE MY $188. *JB
NHTSA ODI #10060502
Mileage unknown · Mar 5, 2004
Suspension
POPPING NOISE IN THE FRONT BALL JOINTS OF MY 2002 DODGE DAKOTA. I NOTICED THIS THE DAY I BOUGHT THIS UNIT. AND JUST TODAY (3-4-04) I FOUND OUT ON CBS THAT IT IS A MANUFACTURER DEFECT. AND WOULD LIKE VERY MUCH TO HAVE THE PROBLEM RESOLVED BEFORE SOMETHING BAD DOES HAPPEN ON THE HIGHWAY. *JB
NHTSA ODI #10060465
500 miles · Mar 4, 2004
Suspension
VEHICLE WAS TAKEN TO DEALER 4 TIMES FOR POPPING AND CRACKING SOUND HEARD IN THE FRONT OF VEHICLE WHEN MAKING TURNS. ALSO, CONSUMER HEARD A POPPING AND CRACKING NOISE WHEN DRIVING ON BUMPY ROADS. BALL JOINTS WERE CHANGED. HOWEVER, AFTER 500 MILES THE PROBLEM RECURRED. *AK
NHTSA ODI #10061405
35,000 miles · Mar 4, 2004
SteeringSuspension
WHEN MAKING A LEFT TURN THERE WAS A POPPING NOISE IN THE STEERING. DEALERSHIP REPLACED THE STEERING SHAFT SECTOR, RACK AND PINION, AND UPPER AND LOWER BALL JOINTS. *AK
NHTSA ODI #10061380
2,500 miles · Mar 4, 2004
Suspension
I BOUGHT MY 2002 DODGE DAKOTA NEW IN MARCH OF 2002. EVER SINCE APPROXIMATELY JULY OF THAT SUMMER, I HEARD THE NOW INFAMOUS CLUNKING NOISE IN MY FRONT END. IT WASN'T UNTIL LAST FALL OF 2003 AND SEVERAL VISITS TO 3 DIFFERENT DEALERSHIPS, THAT THEY FINALLY SOMEWHAT FIXED MY VEHICLE. I HAVE SINCE SEEN THE REPORTS BY CBS NEWS IN R…
Read full complaint
I BOUGHT MY 2002 DODGE DAKOTA NEW IN MARCH OF 2002. EVER SINCE APPROXIMATELY JULY OF THAT SUMMER, I HEARD THE NOW INFAMOUS CLUNKING NOISE IN MY FRONT END. IT WASN'T UNTIL LAST FALL OF 2003 AND SEVERAL VISITS TO 3 DIFFERENT DEALERSHIPS, THAT THEY FINALLY SOMEWHAT FIXED MY VEHICLE. I HAVE SINCE SEEN THE REPORTS BY CBS NEWS IN REGARDS TO THE BALL JOINTS AND THAT HAS PUT FURTHER CONCERN IN THE RELIABILITY OF MY VEHICLE. EVEN THOUGH SEVERAL PARTS, INCLUDING THE BALL JOINTS HAVE BEEN REPLACED BY THE DEALERSHIPS (NONE OF WHOM SAID THEY COULD FIGURE OUT WHAT THE PROBLEM WAS, OR EVEN CLAIMED THAT I DIDN'T KNOW WHAT I WAS TALKING ABOUT WHEN I SAID I HEARD THE NOISE), I STILL HEAR THE CLUNKING AND FEEL THAT IT WILL NEVER BE FIXED. I HAVE PUT IN SEVERAL COMPLAINTS AT CHRYSLER, SO MY PROBLEMS SHOULD BE VERY WELL DOCUMENTED, BUT FEEL IT IS CHRYSLERS RESPONSIBILTY IF ANYTHING FUTHER WOULD HAPPEN TO MY VEHICLE, OR ANY OTHER FOR THAT MATTER. PLEASE CONTINUE TO DO YOUR INVESTIGATION INTO THIS MATTER BEFORE SOMEONE DOES GET SERIOUSLY HURT.
NHTSA ODI #10060375
48,000 miles · Mar 4, 2004
Suspension
VEHICLE HAS DEFINITIVE CLUNK WHEN CROSSING OVER SMALL BUMPS OR TURNING TIGHTLY. WORN BALL JOINTS ARE TO BLAME. VEHICLE HAS 50,000 MILES.
NHTSA ODI #10060369
21,000 miles · Mar 3, 2004
Suspension
ALL FOUR BALL JOINTS BAD AT 21000. HEATER SWITCH BAD AT 21000K AND ALSO CANISTER HOSE CRACKED AT 21000. MY MAIN CONCERN IS FAULTY, FAILING BALL JOINTS. *AK
NHTSA ODI #10060228
5 miles · Mar 2, 2004
Suspension
2002 DODGE DAKOTA QUAD CAB, VIBRATION IN THE FRONT END, TAKEN TO DEALERSHIP MULT TIMES WITH NO LUCK, VIBRATION HAS LASTED SINCE TRUCK WAS NEW, NOW 24000 MILES LATER SAME PROBLEM. TRUCK JERKS IN GEAR 1ST TO 2ND AND POPPING WHEN TURNS, TAKEN IT 2 DIFFERENT DEALERS, 1 SAID BALANCE TIRES (3-4 TIMES) NO HELP, OTHER SAID POWER STEERIN…
Read full complaint
2002 DODGE DAKOTA QUAD CAB, VIBRATION IN THE FRONT END, TAKEN TO DEALERSHIP MULT TIMES WITH NO LUCK, VIBRATION HAS LASTED SINCE TRUCK WAS NEW, NOW 24000 MILES LATER SAME PROBLEM. TRUCK JERKS IN GEAR 1ST TO 2ND AND POPPING WHEN TURNS, TAKEN IT 2 DIFFERENT DEALERS, 1 SAID BALANCE TIRES (3-4 TIMES) NO HELP, OTHER SAID POWER STEERING PUMP BAD, FIX DID NOT HELP. WHAT CAN I DO 30K+ TRUCK HAS NOT BEEN FIXED SINCE DAY ONE! WHAT DO I DO FROM HERE . *AK
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Dodge Dakota Problems, Complaints & Recalls | Skip That Year
Illustration