Illustration2002 DODGE DAKOTA QUAD CAB W/ 5.9 LITER ENGINE. MY TRUCK SUFFERS FROM A SHAKY IDLE, VERY PREVALENT WHEN RELEASING THE BRAKE AND ROLLING. IS WORSE AT COLD START UP. I SUSPECT IGNITION SYSTEM= LOCATION OF COIL MAY BE THE CAUSE DUE TO BEING SO CLOSE TO THE TENSIONER PULLEY OR A OUT-OF BALANCE HARMONIC BALANCER. *JB
2002 Dodge Dakota
Owner reports · Recalls · Investigations
More warning signs than most Dakota years
Owner complaints for the 2002 Dodge Dakota are substantially higher than the model-year median of 166.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dakota years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1550–25K
15925–50K
8450–75K
4975–100K
36100–150K
22150K+
505 reports with mileage · 173 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 226 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 177 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 89 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
55 crash reports18 fire reports22 injury reports
Engine And Engine Cooling complaints
34 reportsTHE VEHICLE STALLED AT 30 MPH. *JB
WARM ENGINE IDLE ON 4.7L ENGINE IN 2002 DAKOTA QUAD CAB STUMBLES WHEN IDLING AT TRAFFIC LIGHTS. RPM AT NORMAL IDLE ONLY 500 TO 550. WHEN FLUCTUATION OCCURS IDLE SPEED RANGES BETWEEN 450 RPMS TO 650 RPMS. ENGINE VIBRATES DUE TO LOW IDLE RPM AND HAS STALLED ON ONE OCCASION. TO PREVENT STALL OUT I NEED TO SHIFT AUTOMATIC TRANSM…
Read full complaint
WARM ENGINE IDLE ON 4.7L ENGINE IN 2002 DAKOTA QUAD CAB STUMBLES WHEN IDLING AT TRAFFIC LIGHTS. RPM AT NORMAL IDLE ONLY 500 TO 550. WHEN FLUCTUATION OCCURS IDLE SPEED RANGES BETWEEN 450 RPMS TO 650 RPMS. ENGINE VIBRATES DUE TO LOW IDLE RPM AND HAS STALLED ON ONE OCCASION. TO PREVENT STALL OUT I NEED TO SHIFT AUTOMATIC TRANSMISSION INTO NEUTRAL. HAVE BEEN TO DEALER TWICE AND WAS TOLD THEY CAN'T FIX AS NO TSB HAS BEEN RECEIVED ALLOWING FOR CHANGE TO COMPUTER. THIS HAS BEEN AN ONGOING PROBLEM SINCE I BOUGHT THE TRUCK NEW LAST JUNE. NOT JUST DATE SPECIFIC AS REQUESTED BY AN INCIDENT DATE. *JB
PICKUP TRUCK DRIVE TRAIN BINDS UP DURING 2 WHEEL DRIVING. THE FRONT AXLE (4X4) DOES NOT ALLOW THE FRONT WHEELS TO DISENGAGE. TRUCK HAS BEEN TO THE DEALER 3 TIMES AND DODGE SAYS THIS IS THE WAY THEY ALL ARE. AT 4272 MILES THE FRONT TIRES SHOW SIGNIFICANT FEATHERING, AND IS STALLING OUT WHEN DRIVING AROUND CORNERS IN LOW GEAR M…
Read full complaint
PICKUP TRUCK DRIVE TRAIN BINDS UP DURING 2 WHEEL DRIVING. THE FRONT AXLE (4X4) DOES NOT ALLOW THE FRONT WHEELS TO DISENGAGE. TRUCK HAS BEEN TO THE DEALER 3 TIMES AND DODGE SAYS THIS IS THE WAY THEY ALL ARE. AT 4272 MILES THE FRONT TIRES SHOW SIGNIFICANT FEATHERING, AND IS STALLING OUT WHEN DRIVING AROUND CORNERS IN LOW GEAR MODE (@ INTERSECTIONS AND PARKING SPACES). DODGE SAYS THAT THE FRONT AND REAR AXLES ARE NOT LIMITED SLIP BUT POSITIVE TRACTION AND RECOMMENDS THAT I PUSH IN THE CLUTCH TO KEEP FROM STALLING. THEY WANT ME TO DOUBLE-CLUTCH TO GET THROUGH AN INTERSECTION WHEN I MAKE LEFT HAND TURNS? I FEEL THAT THIS IS A DESIGN ERROR WITH SAFETY IMPLICATIONS. *NLM
MY TRUCK HAS LOUD KNOCKING NOISE IN ENGINE AND DOES NOT SHIFT PROPERELY, HAVE TAKEN TRUCK IN AND THEY SAY THE ENGINE RACING IS NORMAL. THE KNOCKING NOISE IS A PURGE SOLINOID WHICH DODGE ADDMITS THERES A PROBLEM BUT REFUSES TO FIX. THEY HAVE MADE ADJUSTMENTS WHICH NOW HAS AFFECTED PERFORMANCE TO ENGINE. I HAVE HAD IT IN SHOP 4 TI…
Read full complaint
MY TRUCK HAS LOUD KNOCKING NOISE IN ENGINE AND DOES NOT SHIFT PROPERELY, HAVE TAKEN TRUCK IN AND THEY SAY THE ENGINE RACING IS NORMAL. THE KNOCKING NOISE IS A PURGE SOLINOID WHICH DODGE ADDMITS THERES A PROBLEM BUT REFUSES TO FIX. THEY HAVE MADE ADJUSTMENTS WHICH NOW HAS AFFECTED PERFORMANCE TO ENGINE. I HAVE HAD IT IN SHOP 4 TIMES SO FAR WITH NO RESULTS. THEY TRY TO TELL YOU THERES NOTHING WRONG LIKE ITS YOUR OWN IMAGINATION.
VEHICLE HAS A VERY ROUGH IDLE AND CONSTANTLY STALLS WITHOUT WARNING WHILE DRIVING. THE DEALER HAS NOT BEEN ABLE TO DETERMINE CAUSE OF PROBLEM. TS
CONSUMER STATES VEHICLE SPECIAL ORDERED WITH POWER WINDOWS AND LOCKS STALLED OUT 3 TIMES. DEALER REPLACED BLOWN IGNITION FUSE, REPLACED FUSE THAT SHORTEN RELATING TO THE INSTALLATION OF THE POWER WINDOWS AND LOCKS AND REPLACED A MIS-ROUTED WIRING IN THE IGNITION SWITCH. IN ADDITION, THE ELECTRIC LOCKS DO NOT WORK, AND THE LIGH…
Read full complaint
CONSUMER STATES VEHICLE SPECIAL ORDERED WITH POWER WINDOWS AND LOCKS STALLED OUT 3 TIMES. DEALER REPLACED BLOWN IGNITION FUSE, REPLACED FUSE THAT SHORTEN RELATING TO THE INSTALLATION OF THE POWER WINDOWS AND LOCKS AND REPLACED A MIS-ROUTED WIRING IN THE IGNITION SWITCH. IN ADDITION, THE ELECTRIC LOCKS DO NOT WORK, AND THE LIGHT SWITCH MUST BE JIGGLED IN ORDER TO TURN THE LIGHTS OFF. CONSUMER IS REQUESTING REPLACEMENT OF ANOTHER DAKOTA (SLT) MODEL. *TT
VEHICLE WILL STALL WHILE CONSUMER IS DRIVING. VEHICLE STALLS AT ANY SPEED. CONTACTED DEALER, AND THE DEALER CANNOT FIND CAUSE OF PROBLEM.*AK
GASOLINE IS GETTING INTO THE ENGINE OIL SYSTEM WHICH COULD RESULT IN AN EXPLOSION OR FIRE. *AK
VEHICLE WAS BURNING SMOKE AND ENGINE OIL. DEALER HAS BEEN NOTIFIED OF PROBLEM, AND TECHNICIAN COULDN'T DUPLICATE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION.*AK
Official recalls
507V555000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Dec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
04V596000 · Suspension:front:control Arm:upper Ball Joint
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V216000 · Visibility:windshield Wiper/washer
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V505000 · Equipment:other:labels
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
03V389000 · Electrical System:wiring
Oct 10, 2003
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.