NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
236 reportsClear category filterMileage unknown · Oct 28, 2003
Suspension
FRONT SUSPENSION PROBLEMS IDENTICAL TO THAT OF THE DODGE DURANGO. HAVE HAD BOTH LOWER AND UPPER CONTROL ARMS/BALL JOINTS RELACED WITH LESS THAN 50,000 MILES ON THE VEHICLE. PARTS WERE REPLACED BY DEALERSHIP WITH SAME DEFECTIVE PARTS AS ORIGINALLY INSTALLED ON VEHICLE. PERSONALLY, NO ACCIDENTS RELATED TO THIS PROBLEM YET. CON…
Read full complaint
FRONT SUSPENSION PROBLEMS IDENTICAL TO THAT OF THE DODGE DURANGO. HAVE HAD BOTH LOWER AND UPPER CONTROL ARMS/BALL JOINTS RELACED WITH LESS THAN 50,000 MILES ON THE VEHICLE. PARTS WERE REPLACED BY DEALERSHIP WITH SAME DEFECTIVE PARTS AS ORIGINALLY INSTALLED ON VEHICLE. PERSONALLY, NO ACCIDENTS RELATED TO THIS PROBLEM YET. CONCERNED ABOUT OVERALL SAFETY OF DAKOTA OWNERS. WE HAVE A 2001 DODGE DAKOTA.*AK
NHTSA ODI #10043772
29,000 miles · Oct 28, 2003
SteeringSuspension
RECENTLY HAD TO REPLACE THE FOLLOWING: DRIVERS SIDE UPPER BALL JOINT AND CONTROL ARM, DRIVERS SIDE SPINDLE RETAINING PLATE AND LOCKING NUT. THE SIMPTOMS WERE, A SLIGHT THUMPING NOISE WHEN GOING OVER SMAL BUT SHARP BUMPS (LIKE ENTERING A DRIVEWAY), AND A SOUND SIMILAR TO A SPRING BEING STRETCHED AND COMPRESSES. THE WORK WAS DON…
Read full complaint
RECENTLY HAD TO REPLACE THE FOLLOWING: DRIVERS SIDE UPPER BALL JOINT AND CONTROL ARM, DRIVERS SIDE SPINDLE RETAINING PLATE AND LOCKING NUT. THE SIMPTOMS WERE, A SLIGHT THUMPING NOISE WHEN GOING OVER SMAL BUT SHARP BUMPS (LIKE ENTERING A DRIVEWAY), AND A SOUND SIMILAR TO A SPRING BEING STRETCHED AND COMPRESSES. THE WORK WAS DONE UNDER WARANTY (29,000 MILES). THE THING THAT BOTHERS ME IS THAT IT TOOK 2 ATTEMPTS AT THE DEALER TO GET IT FIXED, AND THAT ALL THE THINGS I'VE BEEN READING INDICATE PROBLEMS ON THE PASSENGER SIDE! AM I JUST A DISASTER WAITING TO HAPPEN? IS DAIMLER CHRYSTLER GOING TO OWN UP TO DEFECTIVE DESIGN AND MANUFACTURE OR DO A BUNCH OF PEOPLE HAVE TO DIE FIRST?*AK
NHTSA ODI #10043754
38,400 miles · Oct 27, 2003
Suspension
FRONT UPPER BALL JOINTS ON BOTH SIDES ARE WORN OUT BEFORE 38,612 MILES (MILEAGE AT TIME I AM SENDING THIS EMAIL). TOOK DAKOTA DEALER (RAINIER DODGE, OLYMPIA, WASHINGTON) LAST MONDAY, OCTOBER 20, 2003, AND WAS TOLD THAT IT WAS SAFE TO DRIVE AND WOULD ONLY TAKE A FEW DAYS TO GET NEW PARTS. THEY STILL DON'T HAVE THE PARTS TO FIX …
Read full complaint
FRONT UPPER BALL JOINTS ON BOTH SIDES ARE WORN OUT BEFORE 38,612 MILES (MILEAGE AT TIME I AM SENDING THIS EMAIL). TOOK DAKOTA DEALER (RAINIER DODGE, OLYMPIA, WASHINGTON) LAST MONDAY, OCTOBER 20, 2003, AND WAS TOLD THAT IT WAS SAFE TO DRIVE AND WOULD ONLY TAKE A FEW DAYS TO GET NEW PARTS. THEY STILL DON'T HAVE THE PARTS TO FIX IT AND WE JUST SAW A NEWS REPORT (ON DURANGOS THAT ALSO MENTIONED DAKOTAS BEING WORSE) SHOWING HOW DANGEROUS IT IS TO DRIVE A VEHICLE WITH BAD UPPER BALL JOINTS (BROKE OFF AND WHEEL AND ALL WENT ACROSS 4 LANES OF TRAFFIC). ON THEIR WORD THAT IT WAS SAFE TO DRIVE, WE TOOK AN OUT OF TOWN TRIP THIS WEEKEND. I THANK GOD THAT WE MADE THE TRIP SAFELY! WHEN IS A RECALL GOING TO BE MADE ON BOTH THE DAKOTA AND DURANGO? OUR DODGE DEALER SEEMS TO BE DRAGGING THEIR FEET GETTING THE PARTS TO FIX OURS, AND I AM AFRAID TO DRIVE MY DAKOTA UNTIL IT IS REPAIRED. PEOPLE NEED TO KNOW HOW DANGEROUS THIS CONDITION IS AND DODGE NEEDS TO ACCEPT THE RESPONSIBILITY TO CORRECT THE PROBLEM ASAP! *LA
NHTSA ODI #10043700
23,558 miles · Oct 27, 2003
Suspension
I HAVE A 2001 DODGE DAKOTA PICKUP. LAST YEAR IT STARTED MAKING A SQUEAKY NOISE (LIKE AN OLD CAR CREAKING) IN THE FRONT END. I HAVE TAKEN IT INTO DEALMAKER DODGE HERE IN WATERTOWN, NY. THE FIRST TIME TAKING IT IN THEY STATED THAT THE NOISE WAS FROM LOOSE BOLTS IN THE FRONT END AND THAT THEY JUST TIGHTENED THEM UP. THE NOISE PROGR…
Read full complaint
I HAVE A 2001 DODGE DAKOTA PICKUP. LAST YEAR IT STARTED MAKING A SQUEAKY NOISE (LIKE AN OLD CAR CREAKING) IN THE FRONT END. I HAVE TAKEN IT INTO DEALMAKER DODGE HERE IN WATERTOWN, NY. THE FIRST TIME TAKING IT IN THEY STATED THAT THE NOISE WAS FROM LOOSE BOLTS IN THE FRONT END AND THAT THEY JUST TIGHTENED THEM UP. THE NOISE PROGRESSIVELY GOT WORSE. I TOOK IT IN AGAIN AND THEY TOLD ME THAT IT WAS POSSIBLY THE SWAY BARS. THEN THE OCT. 10, 2003 I WAS DRIVING AND WHEN I HIT A BUMP IN THE ROAD, SOMETHING POPPED IN THE FRONT END, THE FRONT END DROPPED DOWN AND I LOST STEERING OF THE TRUCK. THIS WAS EXTREMELY FRIGHTENING. I IMMEDIATELY DROVE THE TRUCK VERY SLOWLY OVER TO DEALMAKER DODGE AND THEY LOOKED AT IT (NEVER TEST DROVE IT, JUST LOOKED AT IT). THEY STATED THAT THEY ARE NOT SURE WHAT HAPPENED BUT THAT MAYBE THE SWAY BARS GAVE WAY. TIM (SERVICE MGR) STATED THAT THEY WOULD NEED TO ORDER BUSHINGS AND A PART FOR THE STEERING BOX AND THAT UNTIL THEY CAME IN THE TRUCK WOULD BE SAFE TO DRIVE. UNFORTUNATELY, I DID NOT FEEL IT WAS SAFE TO DRIVE - WE PARKED THE TRUCK IN OUR DRIVEWAY UNTIL THE PARTS CAME IN. WE ASKED WHY THIS HAPPENED TO A FAIRLY NEW TRUCK AND TIM (SERVICE MGR) COULD NOT ANSWER US, HE DID NOT KNOW. WE TOOK THE TRUCK IN ONCE THE PARTS ARRIVED AND HAD IT WORKED ON. WHEN I WENT TO PICK IT UP, I ASKED TIM (SERVICE MGR) WHAT DID THEY DO TO THE TRUCK (REPAIRS)? HE STATED HE DID NOT KNOW BUT THAT HIS WARRANTY GIRL WAS OUT OF THE OFFICE AND THAT THEY WOULD MAIL ME A COPY OF THE PAPERWORK. UPON RECEIPT OF THIS PAPERWORK, IT NOTED THAT BOTH SWAY BAR BUSHINGS WERE REPLACED AS WELL AS THE COUPLING. THE NOISE SEEMS TO BE GONE IN THE FRONT END, HOWEVER, WHEN I GO OVER BUMPS OR ROUGH ROAD, IT STILL MAKES A POPPING NOISE IN THE FRONT END. AFTER WATCHING THE CBS EVENING NEWS TONIGHT WITH REGARD THE FRONT END SAFETY ISSUES ABOUT DAKOTAS, I AM NOW VERY CONCERNED ABOUT THE SAFETY OF MYSELF AND THE LIFE OF PASSENGERS WHILE DRIVING THIS VEHICLE. *LA
NHTSA ODI #10043687
34,000 miles · Oct 27, 2003
Suspension
I HAVE A 2001 DAKOTA THAT STARTED KNOCKING ON BUMPS AT APPROX. 25000 MILES. I DETERMINED THAT THIS WAS NOT NORMAL AND TOOK IT TO A 5 STAR DEALER AT APPROX. 34000 AND 37000 MILES AT WHICH BOTH TIMES THEY COULD NOT FIND A PROBLEM. IT IS VERY OBVIOUS THERE IS AN ISSUE WITH THE SUSPENSION. MY FATHER OWNS A 1995 DAKOTA THAT HAD TH…
Read full complaint
I HAVE A 2001 DAKOTA THAT STARTED KNOCKING ON BUMPS AT APPROX. 25000 MILES. I DETERMINED THAT THIS WAS NOT NORMAL AND TOOK IT TO A 5 STAR DEALER AT APPROX. 34000 AND 37000 MILES AT WHICH BOTH TIMES THEY COULD NOT FIND A PROBLEM. IT IS VERY OBVIOUS THERE IS AN ISSUE WITH THE SUSPENSION. MY FATHER OWNS A 1995 DAKOTA THAT HAD THE SAME PROBLEM. ONCE THE BALL JOINTS WERE REPLACED, NOT BY A DODGE DEALERSHIP, THE NOISE ISSUE WAS RESOLVED. THERE ARE MANY REVIEWS STATING THIS ISSUE BUT CHRYLER DOES NOTHING TO ADDRESS IT. THE ONLY THING I AM LEFT TO DO IS PAY $800-$1000 TO REPAIR IT. I UNFORTUNATELY CANNOT AFFORD THIS AND RISK HAVING IT BREAK AT ANYTIME. *AK
NHTSA ODI #10043686
28,000 miles · Oct 24, 2003
Suspension
THE UPPER BALL JOINTS WORE OUT PREMATURELY. THE CONSUMER HAD TO REPLACE THE PART WITHIN FOUR MONTHS. DEALER STATED THERE WAS NO GREASE FITTING IN THE BALL JOINTS AND THE JOINTS BECAME DRY. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
NHTSA ODI #10044671
40,690 miles · Oct 20, 2003
Suspension
UPPER BALL JOINT ON BOTH RIGHT AND LEFT SIDE ARE FAILING. VEHICLE ONLY HAS APPROXIMATELY 40000 MILES ON IT. JUST OUT OF WARRANTY. *LA
NHTSA ODI #10043221
36,000 miles · Sep 12, 2003
Engine And Engine CoolingSeat BeltsSuspension
PROBLEMS WITH VEHICLE'S ENGINE.*MR WHEN USING THE DEFROST OR A/C, THE ENGINE PUMP DID NOT FUNCTION PROPERLY. THE SEAT BELT WAS INSTALLED IMPROPERLY AND ALSO THE WHEEL BEARING WAS NOT FUNCTIONING PROPERLY, THE CONSUMER WAS TOLD A HOSE WOULD BE PLACED ON THE RETAINING BOLT.*TS *JB
NHTSA ODI #10040606
46,258 miles · Sep 12, 2003
Suspension
TOOK MY 2001 DODGE DAKOTA TO GET ALIGNMENT AT LOCAL DODGE DEALER AND WAS TOLD UPPER BALL JOINTS WERE WORN EXCESSIVELY AND NEEDED TO BE REPLACED. THE TRUCK ONLY HAS 45000 MILES ON IT, THIS IF YOU ASK ME IS UNACCEPTABLE. ALSO THE TRUCK WAS IN THE DEALER 2 TIMES BEFORE THIS BECAUSE OF A NOISE IN THE FRONT END, AND THEY COULD NEVER…
Read full complaint
TOOK MY 2001 DODGE DAKOTA TO GET ALIGNMENT AT LOCAL DODGE DEALER AND WAS TOLD UPPER BALL JOINTS WERE WORN EXCESSIVELY AND NEEDED TO BE REPLACED. THE TRUCK ONLY HAS 45000 MILES ON IT, THIS IF YOU ASK ME IS UNACCEPTABLE. ALSO THE TRUCK WAS IN THE DEALER 2 TIMES BEFORE THIS BECAUSE OF A NOISE IN THE FRONT END, AND THEY COULD NEVER FIND ANYTHING WRONG, AND I BELIEVE THIS COULD BE RELATED. *PH
NHTSA ODI #10038777
40,000 miles · Sep 10, 2003
Suspension
BOTH UPPER BALL JOINTS WENT BAD AT ABOUT 40,000 MILES. EVERYONE I TALKED TO SAID THAT WAS MUCH TOO EARLY. HAD TO REPLACE BOTH UPPER CONTROL ARMS. ALSO MADE FOR EARLY TIRE REPLACEMENT BECAUSE OF WEAR. DODGE SHOULD REALLY HAVE A RECALL ON THESE ITEMS. ALOT OF DAKOTA OWNERS HAVE GONE THROUGH THE SAME PROBLEM.*AK
NHTSA ODI #10038655
Official recalls
7Dec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Oct 10, 2003
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Jul 5, 2001
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS. THE FRONT OUTBOARD LOWER SEAT BELT ANCHOR BOLTS MAY NOT BE TIGHTENED CORRECTLY.
Consequence & remedy
Consequence: AN IMPROPERLY TIGHTENED SEAT BELT ANCHOR MAY NOT PROVIDE THE ANTICIPATED LEVEL OF OCCUPANT RESTRAINT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE DRIVER AND PASSENGER SIDE LOWER SEAT BELT ANCHOR BOLTS AND TIGHTEN TO SPECIFICATION. OWNER NOTIFICATION BEGAN JULY 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 7, 2001
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE ELECTRIC SHIFT TRANSFER CASE MAY NOT FULLY ENGAGE INTO GEAR WHEN THE OPERATOR MOVES THE TRANSFER CASE SELECTOR SWITCH.
Consequence & remedy
Consequence: THIS COULD CAUSE THE TRANSFER CASE TO END UP IN THE NEUTRAL POSITION UNEXPECTEDLY AND ALLOW THE VEHICLE TO ROLL AWAY IF THE PARKING BRAKE IS NOT APPLIED.
Remedy: DEALERS WILL REPROGRAM THE TRANSFER CASE CONTROL MODULE. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
Illustration