I HAVE A 2001 DODGE DAKOTA QUAD CAB 4X4 AND HAD THE PASSENGER SIDE UPPER BALL JOINT FAIL (LUCKLY I WAS HAVING MY MECHANIC CHANGE THE OIL) WHEN HE SAID THAT THE UPPER BALL JOINT SIMPLY FELL OUT. I THINK THAT DODGE SHOULD HAVE MADE OWNERS AWARE OF THIS PROBLEM RATHER THAN CAUSE INJURIES TO CONSUMERS. ALSO WHY IS IT THAT YOU CANNOT…
Read full complaint
I HAVE A 2001 DODGE DAKOTA QUAD CAB 4X4 AND HAD THE PASSENGER SIDE UPPER BALL JOINT FAIL (LUCKLY I WAS HAVING MY MECHANIC CHANGE THE OIL) WHEN HE SAID THAT THE UPPER BALL JOINT SIMPLY FELL OUT. I THINK THAT DODGE SHOULD HAVE MADE OWNERS AWARE OF THIS PROBLEM RATHER THAN CAUSE INJURIES TO CONSUMERS. ALSO WHY IS IT THAT YOU CANNOT PURCHASE A REPLACEMENT BALL JOINT FROM DODGE (YOU MUST PURCHASE THE WHOLE UPPER CONTROL ARM ASSEMBLY?)*AK
NHTSA ODI #10064177
Mileage unknown · Mar 25, 2004
Suspension
A CONTINUOUS "CLUNK" IN THE FRONT LEFT SUSPENSION WHICH THE CONSUMER WAS TOLD WAS THE BALL JOINTS. *PH THE LEFT SIDE WAS AT "380 DEGREE" AND THE OE SPECIFIC WAS "0," AND NEEDED TO BE REPLACED. A NON DEALER TOLD THE CONSUMER THAT THE ORIGINAL DESIGN WAS POOR. *SC
NHTSA ODI #10065124
Mileage unknown · Mar 24, 2004
Suspension
WHILE DRIVING, THE FRONT OF THE TRUCK BEGAN TO SHAKE ALONG WITH A NOISE. THE CONSUMER INSPECTED THE FRONT AND NOTICED THE PASSENGER SIDE TIRE HAD COME OFF. THE CONSUMER WAS ABLE TO PULL THE ENTIRE TIRE OFF WITH HIS HANDS BECAUSE THE BALL JOINT HAD FAILED. *JB.
NHTSA ODI #10064809
41,000 miles · Mar 18, 2004
Suspension
FOUND OUT THAT MY FRONT WHEEL BEARINGS ARE BOTH GOING OUT. THIS VEHICLE ONLY HAS 42,000 MILES.*AK
NHTSA ODI #10062551
Mileage unknown · Mar 17, 2004
Suspension
FRONT END FELT LOOSE AND THE STEERING WHEEL SHOOK. VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED THAT UPPER AND LOWER BALL JOINTS WERE WORN OUT AND MUST BE REPLACED. *AK
NHTSA ODI #10063356
Mileage unknown · Mar 15, 2004
Suspension
2001 DODGE DAKOTA HAS NEVER HELD IT'S ALIGHNMENT SINCE IT WAS BOUGHT BRAND NEW. WHEN WE HEARD THE REPORT ON CBS NEWS ABOUT BALL JOINT PROBLEMS ON THIS TYPE OF VEHICLE, AND CHECKED IN INTERNET ABOUT SAME PROBLEM WE BECAME VERY ALARMED. I TOOK THE TRUCK IN AGAIN TO SEE WHAT WAS WRONG WITH IT AND HAD THEM CHECK THE BALL JOINTS JU…
Read full complaint
2001 DODGE DAKOTA HAS NEVER HELD IT'S ALIGHNMENT SINCE IT WAS BOUGHT BRAND NEW. WHEN WE HEARD THE REPORT ON CBS NEWS ABOUT BALL JOINT PROBLEMS ON THIS TYPE OF VEHICLE, AND CHECKED IN INTERNET ABOUT SAME PROBLEM WE BECAME VERY ALARMED. I TOOK THE TRUCK IN AGAIN TO SEE WHAT WAS WRONG WITH IT AND HAD THEM CHECK THE BALL JOINTS JUST IN CASE. THEY SAID IT HAS PROBLEM, AND WE ARE NOT THE ONLY CUSTOMERS WITH THIS PROBLEM ON THIS YEAR OR TYPE OF TRUCK. THE DEALER CAN NOT GET THE BALL JOINTS IN BECAUSE THEY ARE ON BACK ORDER, TOO MUCH DEMAND. THERE IS NOT A RECALL AS OF YET. THIS TRUCK HAS HAD A PROBLEM SINCE WE BOUGHT IT THAT KEEPS IT FROM HOLDING AN ALIGHNMENT. THERE ARE OTHER CASES OF PROBLEMS WITH THIS TYPE OF TRUCK, AND DURANGOS (USE THE SAME BALL JOINT). THE COMPANY DOES NOT WANT TO FACE THE PROBLEM. I BELIEVE THAT AN INVESTAGATION SHOULD BE DONE ON THESE TRUCKS BEFORE SOMEONE IS HURT OR KILLED. I ALSO BELIEVE THAT MANY CASES OF THE PROBLEM WERE NOT REPORTED, THEY WERE PROBLEY JUST FIXED OR TRADED OFF. I AM USEING THE MOST RECENT DATE ONLY TO BE ABLE TO PRECEED.*AK
NHTSA ODI #10062256
32,000 miles · Mar 14, 2004
Suspension
PREMATURE BALL JOINT DAMAGE @ 32,000 MILES HAD THE BALL JOINT REPLACED BEFORE ANY DAMAGE COULD BE DONE.... THATS TO THE NEWS REPORT ON OTHER DODGE DAKOTA BALL JOINT FAILUERS. *AK
NHTSA ODI #10062159
18,000 miles · Mar 13, 2004
Suspension
UPPER BALL JOINT FAILURE ON MY DODGE DAKOTA, AT 18500 MILES. *AK
NHTSA ODI #10062119
60,000 miles · Mar 12, 2004
Suspension
I HAVE A 2001 DODGE DAKOTA 2WD. I HAVE A POPPING NOISE COMING FROM THE FRONT END OF MY VEHICLE WHEN MAKING TURNS. I HAD THE LOCAL DODGE DEALERSHIP LOOK INTO THIS FOR ME AND THEY SAY THE SOURCE OF MY PROBLEMS IS THE UPPER CONTROL A-ARMS. SINCE MY WARRANTY HAS EXPIRED, THEY CAN NOT SERVICE MY TRUCK. *AK
NHTSA ODI #10062021
63,000 miles · Mar 10, 2004
Suspension
UPPER BALL JOINTS FAILED. AS A RESULT, THE FRONT WHEELS WOBBLED BACK AND FORTH. *AK
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS. THE FRONT OUTBOARD LOWER SEAT BELT ANCHOR BOLTS MAY NOT BE TIGHTENED CORRECTLY.
Consequence & remedy
Consequence: AN IMPROPERLY TIGHTENED SEAT BELT ANCHOR MAY NOT PROVIDE THE ANTICIPATED LEVEL OF OCCUPANT RESTRAINT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE DRIVER AND PASSENGER SIDE LOWER SEAT BELT ANCHOR BOLTS AND TIGHTEN TO SPECIFICATION. OWNER NOTIFICATION BEGAN JULY 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE ELECTRIC SHIFT TRANSFER CASE MAY NOT FULLY ENGAGE INTO GEAR WHEN THE OPERATOR MOVES THE TRANSFER CASE SELECTOR SWITCH.
Consequence & remedy
Consequence: THIS COULD CAUSE THE TRANSFER CASE TO END UP IN THE NEUTRAL POSITION UNEXPECTEDLY AND ALLOW THE VEHICLE TO ROLL AWAY IF THE PARKING BRAKE IS NOT APPLIED.
Remedy: DEALERS WILL REPROGRAM THE TRANSFER CASE CONTROL MODULE. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
2001 Dodge Dakota Problems, Complaints & Recalls | Skip That Year
Illustration