NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
20 reportsClear category filter110,800 miles · Jan 11, 2008
Exterior LightingFire
THE FUSE FOR MY DIMMER SWITCH KEPT BLOWING. AND I KEPT REPLACING. BECAUSE WITH OUT IT IN I CAN NOT SEE GAUGES. AND MY OUTSIDE MARKER LIGHT FUSE KEPT DOING SAME. I REPLACED FUSES AGAIN TODAY THEY IMMEDIATELY BLEW. I ROTATED THE DIMMER SWITCH TO THE LOWEST POSITION. AGAIN I REPLACED FUSES. THEN I TURNED ON LIGHTS AND SLOWLY ROTAT…
Read full complaint
THE FUSE FOR MY DIMMER SWITCH KEPT BLOWING. AND I KEPT REPLACING. BECAUSE WITH OUT IT IN I CAN NOT SEE GAUGES. AND MY OUTSIDE MARKER LIGHT FUSE KEPT DOING SAME. I REPLACED FUSES AGAIN TODAY THEY IMMEDIATELY BLEW. I ROTATED THE DIMMER SWITCH TO THE LOWEST POSITION. AGAIN I REPLACED FUSES. THEN I TURNED ON LIGHTS AND SLOWLY ROTATED DIMMER SWITCH UP AND I SAW SMOKE COMING FROM CORNER OF INSTRUMENT PANEL NEAR WHERE SWITCH SETS IN DASH. *TR
NHTSA ODI #10214478
63,000 miles · Oct 25, 2007
EquipmentExterior Lighting
I HAVE A 2001 DODGE DAKOTA. ONE HEADLIGHT BULB FAILED. THE VEHICLE MANUAL INSTRUCTS ONE TO REMOVE TWO BOLTS TO ACCESS THE BULB. THIS BULB IS SUBJECT TO THE WEATHER AND HAS RUSTED. I NEED TO REPLACE THE BOLTS. DODGE INDICATES THAT THE BOLT IS NOT SOLD SEPARATELY AND IS PART OF THE HEADLIGHT UNIT. THIS UNIT IS $250.00. I B…
Read full complaint
I HAVE A 2001 DODGE DAKOTA. ONE HEADLIGHT BULB FAILED. THE VEHICLE MANUAL INSTRUCTS ONE TO REMOVE TWO BOLTS TO ACCESS THE BULB. THIS BULB IS SUBJECT TO THE WEATHER AND HAS RUSTED. I NEED TO REPLACE THE BOLTS. DODGE INDICATES THAT THE BOLT IS NOT SOLD SEPARATELY AND IS PART OF THE HEADLIGHT UNIT. THIS UNIT IS $250.00. I BELIEVE THIS IS AN ABSURD AMOUNT TO PAY FOR A BOLT WHICH IS REQUIRED TO OPERATE THE VEHICLE WITH FUNCTIONAL HEADLIGHTS. *JB
NHTSA ODI #10206866
132,000 miles · Dec 8, 2006
Exterior Lighting
MOVEMENT OF TILT STEERING WHEEL IN LOWER HALF OF RANGE WILL CAUSE SHORT-CIRCUIT OF TURN SIGNAL OPERATION. LEFT AND RIGHT TURN SIGNAL WILL BE INOPERATIVE. RADIO CIRCUIT ALSO AFFECTED. MOVEMENT BACK INTO UPPER HALF OF RANGE WILL CORRECT PROBLEM. AS OF DATE NO REPAIR HAS BEEN ATTEMPTED. *NM
NHTSA ODI #10175632
5,000 miles · May 13, 2006
Electrical SystemEquipmentExterior Lighting
FOR THE 2ND TIME THE FAN MOTOR FOR THE A/C,HEATER HAS STOPPED WORKING ALL TOGETHER. THE DEALER HAD THE TRUCK FOR OVER A WEEK THE FIRST AND IT REALLY NEVER SEEM TO WORK RIGHT. THE FRONT HEAD LIGHTS WORK WHEN THEY WANT TO. *JB
NHTSA ODI #10157499
37,500 miles · Jun 8, 2005
Electrical SystemExterior LightingLatches/locks/linkages
DT: THE DASHLIGHTS AND HEADLIGHTS STARTED FLASHING AND HEADLIGHTS WILL NOT COME ON AT ALL. ALSO, THE REMOTE WOULD NOT OPEN DOORS, TOOK VEHICLE TO DEALER, AND HAVD TO REPLACE CENTRAL TIMER MODULE (CTM). DEALER UNHOOKED THE MODULE AND CONECTED IT BACK, AND ITWORKED FOR ABOUT 30 MINUTES. *AK
NHTSA ODI #10124563
56,982 miles · May 2, 2005
Engine And Engine CoolingExterior LightingPower Train
CONSUMER STATES: THAT ABS LIGHT, ENGINE LIGHT, AND BRAKE LIGHTS CAME ON AT THE SAME TIME. THE CLUTCH PACKED IN THE REAR DIFFERENTIAL IS HALF INCH LONG , AND ITS JOB IS TO HOLD THE CLUTCHES AND LEMON SLIPPED DIFFERENTIAL, AND IT FAILED. IT CAME OUT AND SHREDDED SPEED SENSOR IN REAR DIFFERENTIAL. *AK
NHTSA ODI #10118864
59,840 miles · Dec 2, 2004
Exterior LightingInterior LightingLatches/locks/linkages
HEADLIGHTS TURNING OFF AND ON AND FLASHING WHILE DRIVING, POWER DOOR LOCKS NOT WORKING DURING THIS TIME. IF INTERIOR LIGHTS ARE ON AT THIS TIME THEY WOULD FLASH ON AND OFF ALSO. FOUND PREVIOUS YEAR MODELS OF DODGE RAM'S AND DAKOTA'S HAVE SAME PROBLEM WHICH WAS RECALLED. CENTRAL TIMER MODULE HAD TO BE REPLACED AND REPROGRAMMED. …
Read full complaint
HEADLIGHTS TURNING OFF AND ON AND FLASHING WHILE DRIVING, POWER DOOR LOCKS NOT WORKING DURING THIS TIME. IF INTERIOR LIGHTS ARE ON AT THIS TIME THEY WOULD FLASH ON AND OFF ALSO. FOUND PREVIOUS YEAR MODELS OF DODGE RAM'S AND DAKOTA'S HAVE SAME PROBLEM WHICH WAS RECALLED. CENTRAL TIMER MODULE HAD TO BE REPLACED AND REPROGRAMMED. A VEHICLE WITH 60,000 MILES SHOULD NOT HAVE THIS PROBLEM. COULD ONLY DRIVE IN DAYLIGHT HOURS UNTIL PROBLEM WAS RESOLVED AT MY EXPENSE.*AK
NHTSA ODI #10100945
73,350 miles · May 19, 2004
Exterior Lighting
WHILE DRIVING MY 2001 DODGE DAKOTA QUAD CAB AT NIGHT, ALL OF THE LIGHTS (EXTERIOR AND INTERIOR) STARTED FLASHING INTERMITTENTLY. THIS COULD EASILY STARTLE THE DRIVER OR THE DRIVERS OF OTHER VEHICLES, AND COULD LEAVE THE VEHICLE WITH NO LIGHTS. DEALER DIAGNOSIS REVEALED A BAD CENTRAL TIMER MODULE (CTM) WHICH CONTROLS THE LIGHTIN…
Read full complaint
WHILE DRIVING MY 2001 DODGE DAKOTA QUAD CAB AT NIGHT, ALL OF THE LIGHTS (EXTERIOR AND INTERIOR) STARTED FLASHING INTERMITTENTLY. THIS COULD EASILY STARTLE THE DRIVER OR THE DRIVERS OF OTHER VEHICLES, AND COULD LEAVE THE VEHICLE WITH NO LIGHTS. DEALER DIAGNOSIS REVEALED A BAD CENTRAL TIMER MODULE (CTM) WHICH CONTROLS THE LIGHTING SYSTEM OF THE VEHICLE. ANECDOTAL EVIDENCE GATHERED ON VARIOUS DODGE FORUMS REVEALED SEVERAL INSTANCES OF THIS SAME PROBLEM. DAIMLER CHRYSLER SHOULD BE QUERIED ON HOW MANY OF THESE MODULES THEY ARE REPLACING ON 1998-2004 DODGE DAKOTAS.
NHTSA ODI #10072859
Mileage unknown · Nov 13, 2003
Electrical SystemExterior LightingInterior Lighting
VEHICLE WAS TAKEN TO THE DEALER FOR RECALL 03V389000 REPAIRS CONCERNING DASHBOARD WIRING HARNESS. THE REPAIRS WERE DONE, BUT VEHICLE WAS STILL HAVING PROBLEMS WITH WINDSHIELD WIPERS/ HORN/ INTERIOR AND EXTERIOR LIGHTING SYSTEMS. THE DEALER WAS ASKING CONSUMER TO PAY $500 TO DIAGNOSES AND RESOLUTION OF THE PROBLEM. CONSUMER …
Read full complaint
VEHICLE WAS TAKEN TO THE DEALER FOR RECALL 03V389000 REPAIRS CONCERNING DASHBOARD WIRING HARNESS. THE REPAIRS WERE DONE, BUT VEHICLE WAS STILL HAVING PROBLEMS WITH WINDSHIELD WIPERS/ HORN/ INTERIOR AND EXTERIOR LIGHTING SYSTEMS. THE DEALER WAS ASKING CONSUMER TO PAY $500 TO DIAGNOSES AND RESOLUTION OF THE PROBLEM. CONSUMER WAS REQUESTING A CALL BACK.*AK
NHTSA ODI #10047913
Mileage unknown · Jun 27, 2002
Exterior Lighting
REAR BRAKE LIGHTS FAIL TO OPERATE. DEALER CONTACTED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8012799
Official recalls
7Dec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Oct 10, 2003
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Jul 5, 2001
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS. THE FRONT OUTBOARD LOWER SEAT BELT ANCHOR BOLTS MAY NOT BE TIGHTENED CORRECTLY.
Consequence & remedy
Consequence: AN IMPROPERLY TIGHTENED SEAT BELT ANCHOR MAY NOT PROVIDE THE ANTICIPATED LEVEL OF OCCUPANT RESTRAINT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE DRIVER AND PASSENGER SIDE LOWER SEAT BELT ANCHOR BOLTS AND TIGHTEN TO SPECIFICATION. OWNER NOTIFICATION BEGAN JULY 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 7, 2001
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE ELECTRIC SHIFT TRANSFER CASE MAY NOT FULLY ENGAGE INTO GEAR WHEN THE OPERATOR MOVES THE TRANSFER CASE SELECTOR SWITCH.
Consequence & remedy
Consequence: THIS COULD CAUSE THE TRANSFER CASE TO END UP IN THE NEUTRAL POSITION UNEXPECTEDLY AND ALLOW THE VEHICLE TO ROLL AWAY IF THE PARKING BRAKE IS NOT APPLIED.
Remedy: DEALERS WILL REPROGRAM THE TRANSFER CASE CONTROL MODULE. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
Illustration