NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
53 reportsClear category filter61,300 miles · Jan 3, 2006
Engine And Engine Cooling
ON THURSDAY, DECEMBER 29, 2005, I WAS RETURNING HOME FROM FINDLAY, OH, I WAS ABOUT 37 MILES FROM HOME WHEN THE CHECK GAUGES LIGHT CAME ON AND THE OIL PRESSURE GAGE DROPPED TO 0. I WAS ABLE TO GET OFF THE HIGHWAY INTO A PARKING LOT AT WHICH TIME THE TRUCK WOULDN'T START. I HAD THE TRUCK TOWED TO THE DEALERSHIP WHERE I BOUGHT IT…
Read full complaint
ON THURSDAY, DECEMBER 29, 2005, I WAS RETURNING HOME FROM FINDLAY, OH, I WAS ABOUT 37 MILES FROM HOME WHEN THE CHECK GAUGES LIGHT CAME ON AND THE OIL PRESSURE GAGE DROPPED TO 0. I WAS ABLE TO GET OFF THE HIGHWAY INTO A PARKING LOT AT WHICH TIME THE TRUCK WOULDN'T START. I HAD THE TRUCK TOWED TO THE DEALERSHIP WHERE I BOUGHT IT. THE SERVICE DEPARTMENT CHECKED IT OUT AND SAID I NEEDED A NEW ENGINE DUE TO SLUDGE BUILD UP CAUSED BY IMPROPER MAINTENANCE. I CHANGE MY OIL ON A REGULAR BASIS. I HAVE A DODGE NEON WITH OVER 120,000 MILES AND MY PREVIOUS CAR WAS A 1987 CHEVY NOVA WITH OVER 199,000 MILES. *NM
NHTSA ODI #10146829
56,982 miles · May 2, 2005
Engine And Engine CoolingExterior LightingPower Train
CONSUMER STATES: THAT ABS LIGHT, ENGINE LIGHT, AND BRAKE LIGHTS CAME ON AT THE SAME TIME. THE CLUTCH PACKED IN THE REAR DIFFERENTIAL IS HALF INCH LONG , AND ITS JOB IS TO HOLD THE CLUTCHES AND LEMON SLIPPED DIFFERENTIAL, AND IT FAILED. IT CAME OUT AND SHREDDED SPEED SENSOR IN REAR DIFFERENTIAL. *AK
NHTSA ODI #10118864
62,910 miles · Jan 26, 2005
Engine And Engine Cooling
WHILE DRIVING 55 MPH THE ENGINE STALLED WITHOUT WARNING. VEHICLE WAS TOWED TO THE NEAREST DEALER. *AK
NHTSA ODI #10108970
Mileage unknown · Dec 3, 2004
Engine And Engine Cooling
WHEN COLD MY 2001 DAKOTA STUTTERS FROM 2300 TO 2500 RPM. WHEN I TALK TO OTHER DAKOTA OWNERS THEY ALL HAVE THE SAME PROBLEM. THIS COULD BE DANGEROUS FOR SOMEONE NOT INFORMED OF THE PROBLEM.*AK
NHTSA ODI #10102109
Mileage unknown · Aug 12, 2004
Engine And Engine Cooling
WHEN THE GAS PEDAL WAS RELEASED, THE ENGINE IDLED HIGH. PLEASE PROVIDE FURTHER DETAILS. *JB WHEN MOVING SLOWLY OR ACCELERATING FROM A STOP THE VEHICLE CONTINUED TO IDLE HIGH A WHILE BEFORE IT WOULD IDLE DOWN. THE VEHICLE'S THROTTLE SENSOR AND AIR SENSOR WERE REPLACED. *NM
NHTSA ODI #10083332
46,025 miles · Apr 18, 2004
Engine And Engine Cooling
2001 DODGE DAKOTA EQUIPPED WITH A 4.7 LITER EIGHT CYLINDER ENGINE WITH 46024 MILES BEGAN TO HAVE A LIGHT KNOCK. I HAD THE VEHICLE TOWED TO METROLINA DODGE WHERE I WAS INFORMED THAT THE VEHICLE HAD SPUN A ROD, DUE TO EXCESSIVE OIL SLUDGE BUILD UP. THE VEHICLE WAS PURCHASED WITH A EXTENDED WARRANTY, BUT I WAS INFORMED THAT THE …
Read full complaint
2001 DODGE DAKOTA EQUIPPED WITH A 4.7 LITER EIGHT CYLINDER ENGINE WITH 46024 MILES BEGAN TO HAVE A LIGHT KNOCK. I HAD THE VEHICLE TOWED TO METROLINA DODGE WHERE I WAS INFORMED THAT THE VEHICLE HAD SPUN A ROD, DUE TO EXCESSIVE OIL SLUDGE BUILD UP. THE VEHICLE WAS PURCHASED WITH A EXTENDED WARRANTY, BUT I WAS INFORMED THAT THE DAMAGE WOULD NOT BE COVERED UNDER THE WARRANTY BECAUSE THE OIL HAD NOT BEEN CHANGED BY DODGE CERTIFIED MECHANICS. MY HUSBAND AND FATHER HAVE CHANGED THE OIL EVERY 3500 MILES, BUT ACCORDING TO THE PEOPLE AT METROLINA IF DODGE DID NOT PERFORM ALL THE MAINTENANCE ON THE VEHICLE THEN THE WARRANTY IS VOIDED. MY HUSBAND WENT TO METROLINA DODGE TO HAVE THE SERVICE WRITER SHOW HIM THE SLUDGE BUILD UP THAT THEY WERE TELLING ME ABOUT. WHILE HE WAS THERE THE SERVICE WRITER KEVIN ST.CLAIR TOLD MY HUSBAND THAT THEY HAVE HAD SEVERAL 4.7 AND 2.7-LITER ENGINES WITH THE SAME PROBLEM. KEVIN SAID THAT IT WOULD COST $6500.00 TO REPLACE THE CRANKSHAFT, ONE ROD, AND THE BEARINGS. *JB
NHTSA ODI #10066415
Mileage unknown · Apr 14, 2004
Engine And Engine Cooling
WHILE DRIVING 65 MPH VEHICLE STALLED. CONSUMER TRIED TO RESTART VEHICLE, BUT WAS UNABLE TO DO SO. CONSUMER HAD VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT ENGINE NEEDED TO BE REPLACED DUE TO SLUDGE BUILT UP. *AK
NHTSA ODI #10067162
85,000 miles · Apr 1, 2004
Engine And Engine Cooling
WHILE DRIVING AT 45 MPH AN ALARM SOUNDED WARNING THE CONSUMER TO CHECK THE INSTRUMENT PANEL. OIL PRESSURE GAUGE REGISTERED VERY LOW OIL PRESSURE. CONSUMER CHECKED THE OIL LEVEL WITH THE DIP STICK AND FOUND IT TO BE UP TO PAR. DEALER EXAMINED THE VEHICLE, AND FOUND A SLUDGE BUILD UP IN THE ENGINE. A NEW ENGINE WAS NEEDED. *…
Read full complaint
WHILE DRIVING AT 45 MPH AN ALARM SOUNDED WARNING THE CONSUMER TO CHECK THE INSTRUMENT PANEL. OIL PRESSURE GAUGE REGISTERED VERY LOW OIL PRESSURE. CONSUMER CHECKED THE OIL LEVEL WITH THE DIP STICK AND FOUND IT TO BE UP TO PAR. DEALER EXAMINED THE VEHICLE, AND FOUND A SLUDGE BUILD UP IN THE ENGINE. A NEW ENGINE WAS NEEDED. *AK
NHTSA ODI #10065414
Mileage unknown · Jan 15, 2004
Engine And Engine Cooling
BLOWER MOTOR FIRST INOPERABLE AT 7566 MILES. CURRENTLY IN FOR SERVICE FOR THE 12TH TIME FOR THIS PROBLEM. I LIVE IN MINNESOTA - WHEN MOTOR GOES OUT I CANNOT DEFOG OR DEFROST WINDOWS. ADDITIONAL PROBLEMS POSSIBLY RELATED INCLUDE: HEADLIGHT ACCESSORY PANEL GOING OUT, HVAC CONTROL LIGHTS GOING OUT, DOOR ALARM MALFUNCTIONING, AND…
Read full complaint
BLOWER MOTOR FIRST INOPERABLE AT 7566 MILES. CURRENTLY IN FOR SERVICE FOR THE 12TH TIME FOR THIS PROBLEM. I LIVE IN MINNESOTA - WHEN MOTOR GOES OUT I CANNOT DEFOG OR DEFROST WINDOWS. ADDITIONAL PROBLEMS POSSIBLY RELATED INCLUDE: HEADLIGHT ACCESSORY PANEL GOING OUT, HVAC CONTROL LIGHTS GOING OUT, DOOR ALARM MALFUNCTIONING, AND CIGARETTE LIGHTER INOPERABLE. CURRENT MILEAGE IS 44,XXX MILES. BLOWER MOTOR PROBLEM IS AT TIMES INTERMITTENT WITH LONGEST TIME BETWEEN COMPLETE FAILURES BEING TEN MONTHS. DEALER HAS TRIED REPLACING BLOWER MOTOR, RELAY, FUSES, WIRING HARNESS, DUCT WORK, ETC.
NHTSA ODI #10070294
12,450 miles · Jan 15, 2004
Engine And Engine CoolingUnknown Or Other
I PUCHASED THIS TRUCK USED WITH 12,500 MILES.IT HAS A REAR WINDOW LEAK,I HAVE YET TO SOLVE THIS PROBLEM.IT ALSO HAS SOME PAINT FLAWS.I HAD A PROBLEM WITH THE GAS CAP WHICH CAUSED A ENGINE CODE LIGHT.WHEN I WENT TO LOCAL DEALER TO SOLVE CODE PROBLEM,I WAS TOLD THAT I HAD NO WARRANTEE.DODGE ADVERTISES OTHERWISE.
NHTSA ODI #10069361
Official recalls
7Dec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Oct 10, 2003
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Jul 5, 2001
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS. THE FRONT OUTBOARD LOWER SEAT BELT ANCHOR BOLTS MAY NOT BE TIGHTENED CORRECTLY.
Consequence & remedy
Consequence: AN IMPROPERLY TIGHTENED SEAT BELT ANCHOR MAY NOT PROVIDE THE ANTICIPATED LEVEL OF OCCUPANT RESTRAINT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE DRIVER AND PASSENGER SIDE LOWER SEAT BELT ANCHOR BOLTS AND TIGHTEN TO SPECIFICATION. OWNER NOTIFICATION BEGAN JULY 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 7, 2001
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE ELECTRIC SHIFT TRANSFER CASE MAY NOT FULLY ENGAGE INTO GEAR WHEN THE OPERATOR MOVES THE TRANSFER CASE SELECTOR SWITCH.
Consequence & remedy
Consequence: THIS COULD CAUSE THE TRANSFER CASE TO END UP IN THE NEUTRAL POSITION UNEXPECTEDLY AND ALLOW THE VEHICLE TO ROLL AWAY IF THE PARKING BRAKE IS NOT APPLIED.
Remedy: DEALERS WILL REPROGRAM THE TRANSFER CASE CONTROL MODULE. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
Illustration