NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
282 reportsClear category filter235,177 miles · Mar 23, 2021
Suspension
TL* THE CONTACT OWNS 2000 DODGE DAKOTA EQUIPPED WITH COOPER TIRES, TIRE LINE: FUTURA, TIRE SIZE: 275/75/R15. THE CONTACT STATED THAT THE TIRES WERE VERY LOUD WHILE DRIVING. THE CONTACT STATED HE TOOK THE TIRES TO PEPBOYS (7725 W NEWBERRY RD, GAINESVILLE, FL 32606, (352)332-6003) TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE…
Read full complaint
TL* THE CONTACT OWNS 2000 DODGE DAKOTA EQUIPPED WITH COOPER TIRES, TIRE LINE: FUTURA, TIRE SIZE: 275/75/R15. THE CONTACT STATED THAT THE TIRES WERE VERY LOUD WHILE DRIVING. THE CONTACT STATED HE TOOK THE TIRES TO PEPBOYS (7725 W NEWBERRY RD, GAINESVILLE, FL 32606, (352)332-6003) TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE WHEEL BEARINGS WERE FAULTY AND NEEDED TO BE REPLACED. THE TIRES WERE NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 235,100.
NHTSA ODI #11404428
130,000 miles · Sep 16, 2018
Power TrainStructureSuspension
BAD RUST ISSUE TO AREAS INCLUDING FRONT AND REAR BUMBER, THE ENTIRE BED INCLUDING MOUNTING POINTS, FENDERS, CAB CORNERS AND FRAME. LOST FENDER FLARE TWICE DUE TO RUST AND ALMOST CAUSED AN ACCIDENT THE ENTIRE BED SLID BACK AND ALMOST FELL OFF AND FENDERS AND BUMBERS ARE BASICALLY RUST AND NEED REPLACED, WHEEL WELLS ON BED ARE FAL…
Read full complaint
BAD RUST ISSUE TO AREAS INCLUDING FRONT AND REAR BUMBER, THE ENTIRE BED INCLUDING MOUNTING POINTS, FENDERS, CAB CORNERS AND FRAME. LOST FENDER FLARE TWICE DUE TO RUST AND ALMOST CAUSED AN ACCIDENT THE ENTIRE BED SLID BACK AND ALMOST FELL OFF AND FENDERS AND BUMBERS ARE BASICALLY RUST AND NEED REPLACED, WHEEL WELLS ON BED ARE FALLING APART CAUSING A SAFETY ISSUE IF I HAUL ANYTHING
NHTSA ODI #11129717
98,000 miles · May 9, 2011
Suspension
TL*THE CONTACT OWNS A 2000 DODGE DAKOTA QUAD CAB. WHILE DRIVING APPROXIMATELY 30 MPH THE CONTACT BEGAN TO HEAR A SQUEAKING NOISE AND THE STEERING WHEEL SUDDENLY BECAME LOOSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THEY INFORMED THAT THE THE STEERING WHEEL FAILURE WAS RELATED TO THE DEFECTIVE UPPER BALL JOIN…
Read full complaint
TL*THE CONTACT OWNS A 2000 DODGE DAKOTA QUAD CAB. WHILE DRIVING APPROXIMATELY 30 MPH THE CONTACT BEGAN TO HEAR A SQUEAKING NOISE AND THE STEERING WHEEL SUDDENLY BECAME LOOSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THEY INFORMED THAT THE THE STEERING WHEEL FAILURE WAS RELATED TO THE DEFECTIVE UPPER BALL JOINTS. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS ADVISED THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V596000 (SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,000 AND THE CURRENT MILEAGE WAS 134,000.
NHTSA ODI #10399531
99,100 miles · Apr 24, 2009
Suspension
THE BALL JOINTS IN 2000 DAKOTAS WERE RECALLED ON ONLY THE 4X4 MODELS. I HAVE A 2000 WITH 2 WHEELS DRIVE. THE MANUFACTURER SENT OUT A LETTER SAYING IT WAS RECALLED, INSPECTED IT AND SAID THEY WERE FINE. THAT WAS AT 50,000 MILES. NOW AT 99,000 THE BALL JOINT DISCONNECTED FROM ITS UNIT, CAUSING ME TO ALMOST CRASH INTO A TELEPHONE P…
Read full complaint
THE BALL JOINTS IN 2000 DAKOTAS WERE RECALLED ON ONLY THE 4X4 MODELS. I HAVE A 2000 WITH 2 WHEELS DRIVE. THE MANUFACTURER SENT OUT A LETTER SAYING IT WAS RECALLED, INSPECTED IT AND SAID THEY WERE FINE. THAT WAS AT 50,000 MILES. NOW AT 99,000 THE BALL JOINT DISCONNECTED FROM ITS UNIT, CAUSING ME TO ALMOST CRASH INTO A TELEPHONE POLE. MANUFACTURER WILL NOT PAY FOR TOWING TO GET SEEN, AND WILL ONLY REPLACE THE BALL JOINT. MOST OF THE SUSPENSION PARTS ON THE SIDE OF THE DEFECTIVE BALL JOINT WERE DAMAGED. *TR
NHTSA ODI #10266583
8,000 miles · Sep 4, 2008
Suspension
TL*THE CONTACT OWNS A 2000 DODGE DAKOTA. WHENEVER THE CONTACT TURNS THE STEERING WHEEL WHILE DRIVING AT ANY SPEED, THE FRONT END OF THE VEHICLE POPS. SHE ALSO HEARS A CLANKING NOISE IN THE FRONT SUSPENSION. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP AND WAS INFORMED OF NHTSA CAMPAIGN ID NUMBER 04V596000 (SUSPENSION:FRONT:C…
Read full complaint
TL*THE CONTACT OWNS A 2000 DODGE DAKOTA. WHENEVER THE CONTACT TURNS THE STEERING WHEEL WHILE DRIVING AT ANY SPEED, THE FRONT END OF THE VEHICLE POPS. SHE ALSO HEARS A CLANKING NOISE IN THE FRONT SUSPENSION. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP AND WAS INFORMED OF NHTSA CAMPAIGN ID NUMBER 04V596000 (SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT). THE FAILURE MILEAGE WAS 8,000.
NHTSA ODI #10240941
Mileage unknown · Feb 25, 2008
Suspension
PREMATURE FRONT WHEEL BEARING FAILURE: REPLACED LEFT FRONT WHEEL BEARING AT 72,026 MILES; NEEDS REPLACEMENT AGAIN AT 79,505 MILES; 15 MONTHS LATER. (2000 DODGE DAKOTA: P/N: 52009528AE. *TR
NHTSA ODI #10219104
95,000 miles · Jul 16, 2007
Suspension
TL*THE CONTACT OWNS A 2000 DODGE DAKOTA. THE CONTACT HEARD A CLUNKING NOISE WHEN HE DROVE OVER A BUMP IN THE ROAD. HE NOTICED THAT THE STEERING WHEEL WAS LOOSE WHEN HE ATTEMPTED TO TURN THE VEHICLE. THE DEALER REPLACED THE UPPER BALL JOINT. THE FAILURE OCCURRED IMMEDIATELY AFTER THE UPPER BALL JOINT WAS REPLACED. THE DEALER…
Read full complaint
TL*THE CONTACT OWNS A 2000 DODGE DAKOTA. THE CONTACT HEARD A CLUNKING NOISE WHEN HE DROVE OVER A BUMP IN THE ROAD. HE NOTICED THAT THE STEERING WHEEL WAS LOOSE WHEN HE ATTEMPTED TO TURN THE VEHICLE. THE DEALER REPLACED THE UPPER BALL JOINT. THE FAILURE OCCURRED IMMEDIATELY AFTER THE UPPER BALL JOINT WAS REPLACED. THE DEALER PERFORMED A WHEEL ALIGNMENT AND STATED THAT THE FRONT END WAS OUT OF SYMMETRY. THE DEALER STATED THAT THE LOWER BALL JOINTS NEEDED TO BE REPLACED. THE DEALER REPLACED THE LOWER BALL JOINTS, ROTORS, CALIPERS, AND TIRES. HOWEVER, THE FAILURE PERSISTS. THE CURRENT MILEAGE IS 101,000 AND FAILURE MILEAGE WAS 95,000.
NHTSA ODI #10196496
71,528 miles · Mar 2, 2007
SteeringSuspension
NOISE FROM ENGINE COMPARTMENT AND VIBRATION FROM STEERING WHEEL. SOUNDS AS IF POWER STEERING PUMP WAS LOW ON FLUID. MAKES A LOAD NOISE WHEN STEERING BECAME DIFFICULT TO STEER. DROVE SHORT DISTANCE TO REPAIR FACILITY AND WAS SHOCKED THAT THE HIGH PRESSURE HOSES HAD SPLIT. ALSO THE RACK AND PINION STEERING WILL HAVE TO BE REBUILT …
Read full complaint
NOISE FROM ENGINE COMPARTMENT AND VIBRATION FROM STEERING WHEEL. SOUNDS AS IF POWER STEERING PUMP WAS LOW ON FLUID. MAKES A LOAD NOISE WHEN STEERING BECAME DIFFICULT TO STEER. DROVE SHORT DISTANCE TO REPAIR FACILITY AND WAS SHOCKED THAT THE HIGH PRESSURE HOSES HAD SPLIT. ALSO THE RACK AND PINION STEERING WILL HAVE TO BE REBUILT IF POSSIBLE IF NOT REPLACED. ALSO A BOOT WAS TORN AND HAS TO BE REPLACED. WORK HAS NOT BEEN STARTED AS I FIND IT IS NECESSARY TO GET MORE THAN ONE ESTIMATE. THE LOCAL GARAGE WANTS IN EXCESS OF $1200 FOR THE REPAIRS WHILE THE DEALER WANTS OVER $2000. APPROXIMATELY 12 MONTHS AGO I HAD THE UPPER BALL JOINTS REPLACED UNDER WARRANTY AND HAD TO GET A FRONT END ALIGNMENT AT AN EXTRA CHARGE. NO VISUAL SIGNS OF WEAR WAS NOTICED. *JB
NHTSA ODI #10184056
43,000 miles · Oct 6, 2006
Suspension
I BOUGHT A 00 DAKOTA R/T USED NOT FROM A DEALER IN 2004. I HAD SOME ALIGNMENT PROBLEMS AND TOOK IT TO THE DEALER WHERE THE TRUCK WAS ORIGINALLY PURCHASED FROM. THEY SAID THEY NEEDED TO CHANGE SOME PARTS TO ALIGN IT WHICH COST OVER $1000. ABOUT 1 1/2 YEARS LATER IT NEEDED ALIGNMENT AGAIN AND NOW THE ALIGNMENT IS STILL OFF. THE WH…
Read full complaint
I BOUGHT A 00 DAKOTA R/T USED NOT FROM A DEALER IN 2004. I HAD SOME ALIGNMENT PROBLEMS AND TOOK IT TO THE DEALER WHERE THE TRUCK WAS ORIGINALLY PURCHASED FROM. THEY SAID THEY NEEDED TO CHANGE SOME PARTS TO ALIGN IT WHICH COST OVER $1000. ABOUT 1 1/2 YEARS LATER IT NEEDED ALIGNMENT AGAIN AND NOW THE ALIGNMENT IS STILL OFF. THE WHEELS ARE FIGHTING EACH OTHER AND THERE IS A CREAKING SOUND WHEN GOING OVER BUMPS AND IT ALSO FEELS LIKE THERE IS NO SUSPENSION AT ALL. I HAVE CHANGED THE SHOCKS RECENTLY AND IT MADE NO DIFFERENCE WHATSOEVER. *JB
NHTSA ODI #10170121
57,122 miles · Sep 21, 2006
Suspension
FELT 'CLUNKING' NOISES THROUGH STEERING WHEEL. DURING ANNUAL MASSACHUSETTS VEHICLE INSPECTION IN AUGUST 2006 TRUCK FAILED ON FRONT SUSPENSION TEST. TOOK TO WCS AUTOMOTIVE IN ROCKLAND, MA. MECHANIC DETERMINED BOTH UPPER AND LOWER BALL JOINTS ON BOTH RIGHT AND LEFT SIDE REQUIRED REPLACEMENT. TOTAL REPAIR BILL WAS $809.56. OLD (ORI…
Read full complaint
FELT 'CLUNKING' NOISES THROUGH STEERING WHEEL. DURING ANNUAL MASSACHUSETTS VEHICLE INSPECTION IN AUGUST 2006 TRUCK FAILED ON FRONT SUSPENSION TEST. TOOK TO WCS AUTOMOTIVE IN ROCKLAND, MA. MECHANIC DETERMINED BOTH UPPER AND LOWER BALL JOINTS ON BOTH RIGHT AND LEFT SIDE REQUIRED REPLACEMENT. TOTAL REPAIR BILL WAS $809.56. OLD (ORIGINAL) PARTS NO LONGER AVAILABLE. *JB
NHTSA ODI #10168818
Official recalls
5Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH 2.5L ENGINES. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE POWER STEERING HOSE.
Consequence & remedy
Consequence: A PUNCTURE OF THE LEFT FRONT BRAKE TUBE CAN RESULT IN A LOSS OF BRAKING FORCE AT THE FRONT WHEELS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBE AND POWER STEERING HOSE FOR WEAR. IF WEAR IS EVIDENT, THE BRAKE TUBE AND/OR POWER STEERING HOSE WILL BE REPLACED. A POWER STEERING STANDOFF BRACKET WILL BE INSTALLED ON ALL VEHICLES TO ENSURE THAT ADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND POWER STEERING HOSE IS MAINTAINED.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 4.7L ENGINE AND AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION MAY EXPEL FLUID FROM THE FILL TUBE DURING NORMAL TEMPERATURE OPERATION.
Consequence & remedy
Consequence: THE TRANSMISSION FLUID COULD COME INTO CONTACT WITH THE HOT EXHAUST SYSTEM AND IGNITION OF THE TRANSMISSION FLUID COULD RESULT.
Remedy: DEALERS WILL SHORTEN THE VENT HOSE AND ASSURE ADEQUATE CLEARANCE.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE REAR AXLE VENT HOSE AND THE BRAKE HOSE.
Consequence & remedy
Consequence: A PUNCTURE IN THE REAR BRAKE HOSE WILL RESULT IN A LOSS OF BRAKING FORCE AT THE REAR WHEELS.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE HOSE FOR EVIDENCE OF WEAR. WORN BRAKE HOSES WILL BE REPLACED. THE REAR VENT HOSE WILL BE SHORTENED BY 3 INCHES AND A CLIP WILL BE INSTALLED TO ASSURE CLEARANCE BETWEEN THE AXLE VENT LINE AND BRAKE HOSE IS MAINTAINED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
PE00035 · Stop Lamp Switch
Opened Sep 7, 2000 · Closed Mar 9, 2001
Status: closed (inferred from source dates) · Electrical System
ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE
PE00030 · Front Safety Belt Anchorage Disengagemen
Opened Jul 21, 2000 · Closed Mar 8, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS
Illustration