IllustrationFRONT ROTORS WARPED CAUSING VIOLENT PULSATIONS UNDER NORMAL BRAKING CONDITIONS. ROTORS WERE TURNED AND THEN FINALLY REPLACED AT 30K MILES. NEW ROTORS LASTED 5000 MILES BEFORE SHIMMY RETURNED. CHRYSLER NEEDS TO STEP UP AND TAKE RESPONSIBILITY FOR THIS ONGOING PROBLEM.*AK
2000 Dodge Dakota
Owner reports · Recalls · Investigations
More warning signs than most Dakota years
Owner complaints for the 2000 Dodge Dakota are substantially higher than the model-year median of 166.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dakota years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
520–25K
11025–50K
11950–75K
4475–100K
24100–150K
10150K+
359 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 282 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 248 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
60 crash reports14 fire reports35 injury reports
Service Brakes, Hydraulic complaints
248 reportsBRAKE ROTOR ON MY 2000 DODGE DAKOTA HAVE BEEN TURNED DOWN TWICE AND REPLACE ONCE IN 30,000 MILES. THE WAS DUE TO EXCESSIVE PULSATING AND DEGRADATION OF STOPPING ABILITY. I AM CONCERNED THAT THIS PROBLEM IS A SAFETY ISSUE DUE TO THE OCCURRENCE OF REDUCED BRAKING POWER. THIS PROBLEM IS OCCURING ONCE AGAIN AND NEEDS TO BE REMEDI…
Read full complaint
BRAKE ROTOR ON MY 2000 DODGE DAKOTA HAVE BEEN TURNED DOWN TWICE AND REPLACE ONCE IN 30,000 MILES. THE WAS DUE TO EXCESSIVE PULSATING AND DEGRADATION OF STOPPING ABILITY. I AM CONCERNED THAT THIS PROBLEM IS A SAFETY ISSUE DUE TO THE OCCURRENCE OF REDUCED BRAKING POWER. THIS PROBLEM IS OCCURING ONCE AGAIN AND NEEDS TO BE REMEDIED. I HAVE BEEN TOLD BY DODGE THAT IS IS NORMAL WEAR AND WILL HAPPEN. A WARPED BRAKE ROTOR IS NOT CONSIDERED NORMAL WEAR. THE PULSATION OF THE BRAKES CAN EASILY CAUSE SOMEONE TO LOSE CONTROL ON A SLIPPERY SURFACE. IT IS ALSO CONCIEVABLE THAT THE ABS SYSTEM MAY NOT WORK PROPERLY WHEN THE ROTOR IS WARPED. PLEASE LOOK FURTHER INTO THIS, THANK YOU. *AK
FRONT BRAKE ROTORS ON THE 2000 DODGE DAKOTA TRUCK ARE OF INADEQUATE DESIGNED, THEY WARP TOO OFTEN..NO SUPPORT FROM THE DEALER OR MANUFACTURER.*AK
CONSUMER STATED THAT WHILE DRIVING THE VEHICLE WOULD ONLY SHIFT TO NEUTRAL. DEALER NOTIFIED. *PH WHEN THE VEHICLE WAS IN 3RD GEAR IT WENT TO NEUTRAL AND THE ENGINE RPM'S INCREASED FOR A SHORT PERIOD OF TIME WHEN THE TRANSMISSION SHOULD HAVE CHANGED TO 4TH GEAR. THE VEHICLE HAD BEEN TO THE SERVICE DEALER 6 TIMES FOR REPA…
Read full complaint
CONSUMER STATED THAT WHILE DRIVING THE VEHICLE WOULD ONLY SHIFT TO NEUTRAL. DEALER NOTIFIED. *PH WHEN THE VEHICLE WAS IN 3RD GEAR IT WENT TO NEUTRAL AND THE ENGINE RPM'S INCREASED FOR A SHORT PERIOD OF TIME WHEN THE TRANSMISSION SHOULD HAVE CHANGED TO 4TH GEAR. THE VEHICLE HAD BEEN TO THE SERVICE DEALER 6 TIMES FOR REPAIRS. THERE WAS A VIBRATION IN THE FRONT OF THE VEHICLE DUE TO WARPED ROTORS. FAULTY WHEEL BEARINGS CAUSED A POPPING NOISE IN THE STEERING WHEN THE CONSUMER MADE LEFT TURNS. *SCC *NLM
REPEATED REPLACEMENT OF FRONT BRAKE ROTORS DUE TO WARPING. DEALERS KEPT SAYING NEVER HEARD OF ANY PROBLEMS WITH DODGE DAKOTA BRAKE PROBLEMS.*AK
I HAVE A 2000 DODGE DAKOTA R/T. IT ONLY HAS 25K ON IT. I FIRST NOTICED THE PROBLEM AT PROBABLY 20000. THE PROBLEM IS THE ROTORS. WHENEVER I SLOWING DOWN TO STOP AT A LIGHT/INTERSECTION THE WHOLE TRUCK SHAKES.*AK
MY 2000 DODGE DAKOTA HAS HAS FRONT ROTOR PROBLEMS CONTINUALLY. DEALER TEMPORARLY CURED THE PROBLEM BY CHANGING FRONT PADS, TURNING DOWN FRONT ROTORS AND REAR DRUMS. WARRANTY RAN OUT AND I HAD SAME PROBLEM. WARPED FRONT ROTORS. I HAD HEAVY DUTY ROTORS INSTALLED AND CERAMIC PADS INSTALLED AT DIFFERENT TIMES. NOTHING HAS HELPE…
Read full complaint
MY 2000 DODGE DAKOTA HAS HAS FRONT ROTOR PROBLEMS CONTINUALLY. DEALER TEMPORARLY CURED THE PROBLEM BY CHANGING FRONT PADS, TURNING DOWN FRONT ROTORS AND REAR DRUMS. WARRANTY RAN OUT AND I HAD SAME PROBLEM. WARPED FRONT ROTORS. I HAD HEAVY DUTY ROTORS INSTALLED AND CERAMIC PADS INSTALLED AT DIFFERENT TIMES. NOTHING HAS HELPED THE PROBLEM. WHEN I STEP ON THE BREAKS THE FRONT END SHIMMYS UNTIL I TAKE IT TO A REPAIR FACILITY TO HAVE MORE WORK DONE. OKAY FOR ABOUT 5,000 OR LESS MILES. WHAT ARE MY OPTIONS BESIDES SETTING THE THING ON FIRE AND GETTING A NEW ONE?*AK
I CURRENTLY HAVE A HEAVY SURGING SENSATION WHILE BRAKING. I WAS TOLD MY ROTORS WERE WARPED. MY DODGE DAKOTA 4X2 QUAD CAB HAS 40000 MILES. I FEEL THAT I SHOULD BE ABLE TO RELY ON MY VEHICLE TO STOP WITHOUT SHAKING ME OR MY FAMILY LIKE A RAG DOLL. THE HEAVY SHAKING MAY LEAD TO MY ABILITY TO CONTROL MY TRUCK WHILE STOPPING, WH…
Read full complaint
I CURRENTLY HAVE A HEAVY SURGING SENSATION WHILE BRAKING. I WAS TOLD MY ROTORS WERE WARPED. MY DODGE DAKOTA 4X2 QUAD CAB HAS 40000 MILES. I FEEL THAT I SHOULD BE ABLE TO RELY ON MY VEHICLE TO STOP WITHOUT SHAKING ME OR MY FAMILY LIKE A RAG DOLL. THE HEAVY SHAKING MAY LEAD TO MY ABILITY TO CONTROL MY TRUCK WHILE STOPPING, WHICH CONSTITUTES A SERIOUS SAFEY ISSUE.*AK
BRAKE ROTORS WARP PREMATURELY AND THERE IS SHAKING AND VIBRATION INSIDE OF THE VEHICLE. *AK
MULTIPLE ISSUES WITH THE DISC BRAKES IN MY DAKOTA. ORIGINAL ROTORS WARPED ONCE, I HAD THEM TURNED (PAID FOR BY ME), THEY WARPED A SECOND TIME. I PAID THE DEALERSHIP TO REPLACE WITH NEW ROTORS. THESE ROTORS WARPED. THE DEALERSHIP PAID TO REPLACE THIS SET OF ROTORS. I WAS ON MY 3RD SET OF ROTORS BY 75000 MILES.*AK
Official recalls
504V596000 · Suspension:front:control Arm:upper Ball Joint
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V153000 · Air Bags
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V193000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH 2.5L ENGINES. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE POWER STEERING HOSE.
Consequence & remedy
Consequence: A PUNCTURE OF THE LEFT FRONT BRAKE TUBE CAN RESULT IN A LOSS OF BRAKING FORCE AT THE FRONT WHEELS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBE AND POWER STEERING HOSE FOR WEAR. IF WEAR IS EVIDENT, THE BRAKE TUBE AND/OR POWER STEERING HOSE WILL BE REPLACED. A POWER STEERING STANDOFF BRACKET WILL BE INSTALLED ON ALL VEHICLES TO ENSURE THAT ADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND POWER STEERING HOSE IS MAINTAINED.
00V197000 · Power Train:automatic Transmission
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 4.7L ENGINE AND AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION MAY EXPEL FLUID FROM THE FILL TUBE DURING NORMAL TEMPERATURE OPERATION.
Consequence & remedy
Consequence: THE TRANSMISSION FLUID COULD COME INTO CONTACT WITH THE HOT EXHAUST SYSTEM AND IGNITION OF THE TRANSMISSION FLUID COULD RESULT.
Remedy: DEALERS WILL SHORTEN THE VENT HOSE AND ASSURE ADEQUATE CLEARANCE.
00V198000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE REAR AXLE VENT HOSE AND THE BRAKE HOSE.
Consequence & remedy
Consequence: A PUNCTURE IN THE REAR BRAKE HOSE WILL RESULT IN A LOSS OF BRAKING FORCE AT THE REAR WHEELS.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE HOSE FOR EVIDENCE OF WEAR. WORN BRAKE HOSES WILL BE REPLACED. THE REAR VENT HOSE WILL BE SHORTENED BY 3 INCHES AND A CLIP WILL BE INSTALLED TO ASSURE CLEARANCE BETWEEN THE AXLE VENT LINE AND BRAKE HOSE IS MAINTAINED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
PE00035 · Stop Lamp Switch
Opened Sep 7, 2000 · Closed Mar 9, 2001
Status: closed (inferred from source dates) · Electrical System
ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE
PE00030 · Front Safety Belt Anchorage Disengagemen
Opened Jul 21, 2000 · Closed Mar 8, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS