NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
248 reportsClear category filterMileage unknown · Feb 23, 2002
Engine And Engine CoolingFuel System, GasolineService Brakes, Hydraulic
BAD ROTORS AFTER 12,000K,DEALER WILL NOT COVER. LOW IDLE AND ENGINE STUDDERING AT 400 RPM AFTER 2 PCM RECALLS FOR REPROGRAMING, DEALER CAN'T FIND PROBLEM WITH IDLE. PROBLEM WITH THE BAFFLES IN THE GAS TANK, YOU CAN FEEL THE FUEL MOVING AROUND WHEN YOU COME TO A STOP AT ABOUT 3/4 FULL TANK. CONDENSATION IN OIL FILLER CAP. SOUNDS …
Read full complaint
BAD ROTORS AFTER 12,000K,DEALER WILL NOT COVER. LOW IDLE AND ENGINE STUDDERING AT 400 RPM AFTER 2 PCM RECALLS FOR REPROGRAMING, DEALER CAN'T FIND PROBLEM WITH IDLE. PROBLEM WITH THE BAFFLES IN THE GAS TANK, YOU CAN FEEL THE FUEL MOVING AROUND WHEN YOU COME TO A STOP AT ABOUT 3/4 FULL TANK. CONDENSATION IN OIL FILLER CAP. SOUNDS LIKE I BOUGHT A 2000 DAKOTA. I'VE FOUND COUNTLESS ENTRIES OF THE SAME COMPLAINTS ON THE INTERNET. NHTS NEED TO GET ON CHRYSLER ABOUT THESE PROBLEMS BEFOR SOMEONE REALLY GETS HURT. SPECIALY THE PROBLEM WITH THE BRAKES.*AK
NHTSA ODI #758538
Mileage unknown · Jan 30, 2002
Service Brakes, Hydraulic
I PURCHASED THE 2000 DODGE DAKOTA CLB. NEW. I NOTICED THE SHIMMY IN THE BRAKES WITH LESS THAN 5000 MILES.IT WAS NOT SO BAD AS TO AFFECT THE SAFETY OF THE VEHICLE AND IT WAS COVERED UNDER WARRANTY. AT 11,430 MILES THE DEALER TURNED THE FRONT ROTERS UPON MY INSISTANCE THAT THE SHIMMY WAS A SAFETY PROBLEM.THEY DID NOT REPLACE THE R…
Read full complaint
I PURCHASED THE 2000 DODGE DAKOTA CLB. NEW. I NOTICED THE SHIMMY IN THE BRAKES WITH LESS THAN 5000 MILES.IT WAS NOT SO BAD AS TO AFFECT THE SAFETY OF THE VEHICLE AND IT WAS COVERED UNDER WARRANTY. AT 11,430 MILES THE DEALER TURNED THE FRONT ROTERS UPON MY INSISTANCE THAT THE SHIMMY WAS A SAFETY PROBLEM.THEY DID NOT REPLACE THE ROTERS. AT 22,994 MILES I RETURNED THE TRUCK TO THE DEALER WITH THE SAME PROBLEM AS BEFORE. I WAS TOLD THAT THE FRONT ROTERS AS WELL AS THE REAR DRUMS NEEDED TO BE REPLACED, AND THESE ITEMS WERE NOT COVERED UNDER WARRENTY AFTER 12MONTHS OR 12000 MILES. THAT THEY WERE WEAR ITEMS THAT WERE OMITED FROM THE 36MONTH OR 36,000 MILE BUMPER TO BUMPER WARRENTY AS ADVERTISED WHEN I PURCHASED THE TRUCK. I WAS TOLD THAT EVEN THOUGH THE PROBLEM WAS A REOCURRENCE OF A PREVIOUS PROBLEM. THE DEALERSHIP COULD NOT TREAT IT AS A WARRENTY PROBLEM AGAIN. I HAVE SPOKEN TO 3 OTHER ASE CERTIFYED MECHANICS THAT SAY THAT ROTERS AND DRUMS SHOULD NOT WARP IN SUCH A SHORT TIME AND THAT ROTERS AND DRUMS ARE NOT WEAR ITEMS, PADS AND SHOES, HOWEVER, ARE. I HAVE BEEN IN COMUNICATION WITH SEVERAL OTHER 2000/2001 DODGE DAKOTA OWNERS AND 90% OF THEM HAVE HAD BRAKE PROBLEMS JUST LIKE ME. I AM SURE CHRYSLER/DODGE IS FULLY AWARE OF THE UNSAFE/ FAULTY BRAKE COMPONENTS THAT HAVE BEEN PLACED ON THEIR VEHICLES, BUT ARE NOT WILLING TO COME FORWARD AND RECALL THE INFERIOR PARTS WITHOUT BEING FORCED TO BY SOMEONE OTHER THAN THE CONSUMER. CHRYSLER HAS MODIFIED THE 2002 MODELS SO AS TO NOT HAVE THIS PROBLEM NOW. THE COST TO REPLACE THE FRONT ROTERS AND THE REAR DRUMS WAS $544.00 QUOTED TO ME. I DO NOT BELIEVE THAT CONSUMERS SHOULD HAVE TO PAY FOR A MANUFACTURERS WILLFULL USE OF INFERIOR PARTS. THANK YOU FOR LOOKING INTO THIS UNETHICAL ACTION. LES MAXWELL. *AK
NHTSA ODI #757571
Mileage unknown · Jan 28, 2002
Service Brakes, Hydraulic
CONSUMER STATED THE VEHICLE SHAKES VIOLENTLY WHEN COMING TO A GRADUAL OR A SUDDEN STOP, DEALER HAS NOT TO BE CONTACTED.*AK CONSUMER STATED HE DID CONTACT THE DEALER AND WAS INFORMED THAT THEY WOULD NO LONGER CORRECT THE PROBLEM UNDER WARRANTY, SINCE THE FRONT ROTORS HAD BEEN REPLACED 3 TIMES PRIOR.*SLC
NHTSA ODI #8002991
Mileage unknown · Jan 28, 2002
Service Brakes, Hydraulic
WHILE DRIVING AT NORMAL SPEED AND WHEN DEPRESSING BRAKE PEDAL TO MAKE A GRADUAL STOP BRAKES FAILED TO RESPOND, CAUSING EXTENDED STOPPING DISTANCE. ALSO, VEHICLE VIBRATED UPON BRAKING. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
NHTSA ODI #8002910
Mileage unknown · Jan 28, 2002
Service Brakes, Hydraulic
WHILE DRIVING AND WHEN ATTEMPTING TO MAKE A SUDDEN STOP BY DEPRESSING BRAKE PEDAL, BRAKES LOCKED UP AND FAILED TO RESPOND ,CAUSING EXTENDED STOPPING DISTANCE . ALSO, THERE WAS SUDDEN VIBRATION. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
NHTSA ODI #8002909
Mileage unknown · Jan 28, 2002
Service Brakes, Hydraulic
ROTORS REFACED BY DEALER AT 11848 MILES, WARPED AGAIN AND REPLACED AT 22946, WARPED AGAIN AT 33000 AND I'M NOW OUT OF WARRANTY. CONTINUOUS PROBLEM FROM DODGE DAKOTA'S. PLEASE PUSH FOR A RECALL SO ALL OF US CAN BE COMPENSATED. *AKI
NHTSA ODI #757424
Mileage unknown · Jan 27, 2002
Service Brakes, Hydraulic
THE FACTORY BRAKES WARP AND CAUSE EXCESSIVE SHAKING WHEN BRAKES ARE APPLIED. DEFECTIVE ROTORS. I'VE HEARD A LOT OF OTHER DODGE OWNERS ARE HAVING SIMILAR PROBLEMS, AND IT SEEMS PRETTY UNREASONABLE TO HAVE TO REPLACE MY ROTORS AND HUBS EVERY 5K-10K MILES. THE TRUCK IS GREAT, BUT THE BRAKES ARE POORLY ENGINEERED OR DESIGNED.*AK
NHTSA ODI #757400
Mileage unknown · Jan 26, 2002
Service Brakes, Hydraulic
FRONT BRAKE ROTORS WARPING EVERY 2000 MILES. *AK
NHTSA ODI #757364
Mileage unknown · Jan 22, 2002
Service Brakes, Hydraulic
THIS VEHICLE IS PART OF RECALL FOR REAR BRAKE HOSE .CONSUMER STATES THERE WERE TWO RECALLS FOR SAME MALFUNCTION. *AK
NHTSA ODI #8002584
Mileage unknown · Jan 2, 2002
Service Brakes, Hydraulic
ABOUT EVERY 12-15K MILES, THE ROTORS ON THE FRONT OF THE VEHICLE WARPED AND EITHER HAVE TO BE REPLACED OR TURNED. I HAVE NEVER HAD A VECHICLE THAT WARPED ROTERS...LET ALONE ONE THAT WARPS THEM SO OFTEN. THE MANUFACTURE SAYS IT'S NORMAL WEAR AND TEAR AND WILL NOT COVER IT. I HAVE SEEN SEVERAL PEOPLE COMPLAINING ABOUT THE SAME …
Read full complaint
ABOUT EVERY 12-15K MILES, THE ROTORS ON THE FRONT OF THE VEHICLE WARPED AND EITHER HAVE TO BE REPLACED OR TURNED. I HAVE NEVER HAD A VECHICLE THAT WARPED ROTERS...LET ALONE ONE THAT WARPS THEM SO OFTEN. THE MANUFACTURE SAYS IT'S NORMAL WEAR AND TEAR AND WILL NOT COVER IT. I HAVE SEEN SEVERAL PEOPLE COMPLAINING ABOUT THE SAME PROBLEM WITH THEIR TRUCK.*AK
NHTSA ODI #756303
Official recalls
5Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH 2.5L ENGINES. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE POWER STEERING HOSE.
Consequence & remedy
Consequence: A PUNCTURE OF THE LEFT FRONT BRAKE TUBE CAN RESULT IN A LOSS OF BRAKING FORCE AT THE FRONT WHEELS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBE AND POWER STEERING HOSE FOR WEAR. IF WEAR IS EVIDENT, THE BRAKE TUBE AND/OR POWER STEERING HOSE WILL BE REPLACED. A POWER STEERING STANDOFF BRACKET WILL BE INSTALLED ON ALL VEHICLES TO ENSURE THAT ADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND POWER STEERING HOSE IS MAINTAINED.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 4.7L ENGINE AND AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION MAY EXPEL FLUID FROM THE FILL TUBE DURING NORMAL TEMPERATURE OPERATION.
Consequence & remedy
Consequence: THE TRANSMISSION FLUID COULD COME INTO CONTACT WITH THE HOT EXHAUST SYSTEM AND IGNITION OF THE TRANSMISSION FLUID COULD RESULT.
Remedy: DEALERS WILL SHORTEN THE VENT HOSE AND ASSURE ADEQUATE CLEARANCE.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE REAR AXLE VENT HOSE AND THE BRAKE HOSE.
Consequence & remedy
Consequence: A PUNCTURE IN THE REAR BRAKE HOSE WILL RESULT IN A LOSS OF BRAKING FORCE AT THE REAR WHEELS.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE HOSE FOR EVIDENCE OF WEAR. WORN BRAKE HOSES WILL BE REPLACED. THE REAR VENT HOSE WILL BE SHORTENED BY 3 INCHES AND A CLIP WILL BE INSTALLED TO ASSURE CLEARANCE BETWEEN THE AXLE VENT LINE AND BRAKE HOSE IS MAINTAINED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
PE00035 · Stop Lamp Switch
Opened Sep 7, 2000 · Closed Mar 9, 2001
Status: closed (inferred from source dates) · Electrical System
ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE
PE00030 · Front Safety Belt Anchorage Disengagemen
Opened Jul 21, 2000 · Closed Mar 8, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS
Illustration