NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
248 reportsClear category filterMileage unknown · Apr 30, 2002
Service Brakes, Hydraulic
ROTORS NEED TO BE REPLACED DUE TO CORROSION AND CHIPPING ON BRAKES. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK CONSUMERS VEHICLE IS EXPERIENCING PREMATURE FAILURE OF FRONT ROTORS. METAL ON ROTORS IS FLAKING OFF AND PEELING AWAY, BECAUSE OF THIS THE FRONT DISC BRAKE PADS HAVE TO BE REPLACED, EVEN THOUGH…
Read full complaint
ROTORS NEED TO BE REPLACED DUE TO CORROSION AND CHIPPING ON BRAKES. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK CONSUMERS VEHICLE IS EXPERIENCING PREMATURE FAILURE OF FRONT ROTORS. METAL ON ROTORS IS FLAKING OFF AND PEELING AWAY, BECAUSE OF THIS THE FRONT DISC BRAKE PADS HAVE TO BE REPLACED, EVEN THOUGH THEY ARE ABOUT HALF WORN. DEALER NOTIFIED. OWNER FEELS THIS IS A DEFECTIVE PART PROBLEM AND SHOULD BE REPLACED BY MANUFACTURER NOT AT OWNERS EXPENSE. *TT
NHTSA ODI #8008827
Mileage unknown · Apr 23, 2002
Service Brakes, Hydraulic
ROTORS HAVE WARPPED UNTIMELY CHECK WEBSITE DODGEDAKOTA.COM NOTE ALL THE FRONT ROTOR WARPPING. DODGE MECHANIC ADVISED HE SEE A LOT OF THESE IN THE V-8 DAKOTAS, HIS OPINION IS THE ROTORS ARE NOT SUITABLE FOR THE ENGINE WEIGHT WHILE BRAKEING. COULD LEAD TO LOSS OF CONTROL AND POSSIBLE ACCIDENTS.*AK
NHTSA ODI #761110
Mileage unknown · Apr 22, 2002
Service Brakes, Hydraulic
VEHICLE IS EXPERIENCING PROBLEMS WITH PULSATION WHEN APPLYING BRAKES. THIS OCCURRED 3 TIMES. DEALER FOUND FRONT ROTORS WARPED AND REPLACED BOTH FRONT BRAKE ROTORS. HOWEVER CONSUMER WAS APPALLED WHEN ADVISED THAT 3 WARPED BRAKE ROTORS PROBLEMS WITHIN 30,000 MILES WERE DUE TO HIS DRIVING HABITS. MANUFACTURER NOTIFIED. *TT …
Read full complaint
VEHICLE IS EXPERIENCING PROBLEMS WITH PULSATION WHEN APPLYING BRAKES. THIS OCCURRED 3 TIMES. DEALER FOUND FRONT ROTORS WARPED AND REPLACED BOTH FRONT BRAKE ROTORS. HOWEVER CONSUMER WAS APPALLED WHEN ADVISED THAT 3 WARPED BRAKE ROTORS PROBLEMS WITHIN 30,000 MILES WERE DUE TO HIS DRIVING HABITS. MANUFACTURER NOTIFIED. *TT
NHTSA ODI #565300
Mileage unknown · Apr 17, 2002
Service Brakes, HydraulicVisibility
IS ANYONE READING THESE COMPLAINTS ON DAKOTA BRAKE ROTORS?!? I AM ON MY 4TH SET OF FRONT ROTORS, WHICH ARE ALREADY WARPED. EACH SET GOES ABOUT 10-11K UNTILL NEEDING RESURFACING/ REPLACEMENT.. MY LOCAL DEALERSHIP ACTUALLY BILLED SOME OF MY VISITS FOR ROTORS IN A MANNER THAT THE DEALERSHIP I BOUGHT IT FROM CAN'T EVEN UNDERST…
Read full complaint
IS ANYONE READING THESE COMPLAINTS ON DAKOTA BRAKE ROTORS?!? I AM ON MY 4TH SET OF FRONT ROTORS, WHICH ARE ALREADY WARPED. EACH SET GOES ABOUT 10-11K UNTILL NEEDING RESURFACING/ REPLACEMENT.. MY LOCAL DEALERSHIP ACTUALLY BILLED SOME OF MY VISITS FOR ROTORS IN A MANNER THAT THE DEALERSHIP I BOUGHT IT FROM CAN'T EVEN UNDERSTAND WHAT WAS DONE. I NO LONGER TOW ANYTHING, TRYING TO MAKE THE ROTORS LAST LONGER- WHY DID I WASTE MONEY ORDERING THE HEAVYDUTY TOW PACKAGE? I AM SICK OF THESE BRAKES, LIKE SO MANY OTHER DAKOTA OWNERS. HOW MANY COMPLAINTS DOES IT TAKE? NLM
NHTSA ODI #760802
Mileage unknown · Mar 20, 2002
Service Brakes, Hydraulic
CONSUMER HAS HAD NUMEROUS PROBLEMS WITH BRAKES, CONSUMER IS APPROACHING THE END OF THE 36,000 MILE WARRANTY AND IS STILL EXPERIENCING PROBLEMS WITH BRAKES, CONSUMER STATES THAT BRAKES NEED TO BE REPLACED EVERY 3 TO 5,000 MILES, AND DEALER IS STARTING TO DENY CLAIM FOR REPAIRS. *TT
NHTSA ODI #564792
Mileage unknown · Mar 9, 2002
Service Brakes, Hydraulic
REAR BRAKES HAVE BEEN INOPERABLE SINCE THE DAY WE BOUGHT THIS VEHICLE, RETURNED TO DEALER WITH COMPLAINT. THEY SAID IT WAS "NORMAL". RETURNED LATER WITH FURTHER EVIDENCE TO SHOW THEM AND THEY TESTED IT , ADJUSTED THE BRAKES AND SAID IT WAS OK. LATER I JACKED THE VEHICLE UP WITH THE WHEELS POWERED UP AND COULD NOT STOP THE WHEEL…
Read full complaint
REAR BRAKES HAVE BEEN INOPERABLE SINCE THE DAY WE BOUGHT THIS VEHICLE, RETURNED TO DEALER WITH COMPLAINT. THEY SAID IT WAS "NORMAL". RETURNED LATER WITH FURTHER EVIDENCE TO SHOW THEM AND THEY TESTED IT , ADJUSTED THE BRAKES AND SAID IT WAS OK. LATER I JACKED THE VEHICLE UP WITH THE WHEELS POWERED UP AND COULD NOT STOP THE WHEELS FROM TURNING. TOOK IT BACK TO DEALER, SHOWED THEM MY TEST AND THEY NOW PROCLAIMED A PROBLEM. THEY REPLACED EVERY COMPONENT AND STILL NO BRAKES. THEY TOOK IT TO A BRAKE SHOP FOR SECOND OPINION, THE OWNER CLAIMED I WAS RIGHT. CHRYSLER SENT A REP TO LOOK AT IT, CLAIMED IT WAS "NORMAL" SO CHRYSLER SAID THEY WERE DONE WITH IT. SO DODGE WON'T DO ANY MORE EITHER. IN SLICK CONDITIONS LIKE SNOW, THE REAR WHEELS KEEP TURNING AFTER THE VEHICLE STOPS. I HAVE TO SHIFT TO NEUTRAL TO KEEP FROM BEING PUSHED INTO AN INTERSECTION.*AK
NHTSA ODI #759145
Mileage unknown · Mar 8, 2002
Service Brakes, Hydraulic
FRONT BRAKES ROTOR PROBLEM, REPLACED SEVER TIMES, ROTORS ARE WARPED OR HAVE EXCESSIVE RUN OUT, CAN NOT FIND THE CAUSE. RESULTING IN VEHICLE VIBRATION WHEN THE BRAKES ARE APPLIED. REPLACED FRONT DISC ROTORS SEVERAL TIMES.
NHTSA ODI #9005657
Mileage unknown · Mar 8, 2002
Service Brakes, Hydraulic
CONSUMER STATED THERE IS NO BRAKING ACTION COMING FROM THE REAR BRAKES, VEHICLE WAS TAKEN INTO DEALERSHIP WHERE PARTS WERE REPLACED, HOWEVER THE PROBLEM STILL EXISTS.*AK. CONSUMER STATED WHEN STOPPING ON SNOW AND ICE THE REAR WHEELS CONTINUE TO SPIN AFTER THE FRONT WHEELS HAVE STOPPED, NO MATTER HOW HARD THE BRAKES ARE BEING AP…
Read full complaint
CONSUMER STATED THERE IS NO BRAKING ACTION COMING FROM THE REAR BRAKES, VEHICLE WAS TAKEN INTO DEALERSHIP WHERE PARTS WERE REPLACED, HOWEVER THE PROBLEM STILL EXISTS.*AK. CONSUMER STATED WHEN STOPPING ON SNOW AND ICE THE REAR WHEELS CONTINUE TO SPIN AFTER THE FRONT WHEELS HAVE STOPPED, NO MATTER HOW HARD THE BRAKES ARE BEING APPLIED, THE DEALER HAS REPLACED THE BOOSTER, MASTER CYLINDER, PROPORTIONING VALVE, ABS VALVE, REAR BRAKE HOSE WHEEL CYLINDER AND BRAKE SHOES, CONSUMER STATED HE STILL HAS NO REAR BRAKES.*JB
NHTSA ODI #8005235
Mileage unknown · Mar 6, 2002
Service Brakes, Hydraulic
#1 BRAKES FRONT AND REAR WHEN APPLIED VIBRATE THE WHOLE TRUCK # 2WHEN TRUCK SHIFTS FROM 2 TO 3 IT BANGS HARD INTO GEAR. *AK
NHTSA ODI #759012
Mileage unknown · Feb 25, 2002
Service Brakes, Hydraulic
REAR BRAKES FAILED TO WORK FROM THE FACTORY, (NEVER WORKED) AND DODGE CANNOT FIX IT, SO THEY RECOMMEND I TAKE IT HOME!*AK
NHTSA ODI #758582
Official recalls
5Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH 2.5L ENGINES. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE POWER STEERING HOSE.
Consequence & remedy
Consequence: A PUNCTURE OF THE LEFT FRONT BRAKE TUBE CAN RESULT IN A LOSS OF BRAKING FORCE AT THE FRONT WHEELS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBE AND POWER STEERING HOSE FOR WEAR. IF WEAR IS EVIDENT, THE BRAKE TUBE AND/OR POWER STEERING HOSE WILL BE REPLACED. A POWER STEERING STANDOFF BRACKET WILL BE INSTALLED ON ALL VEHICLES TO ENSURE THAT ADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND POWER STEERING HOSE IS MAINTAINED.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 4.7L ENGINE AND AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION MAY EXPEL FLUID FROM THE FILL TUBE DURING NORMAL TEMPERATURE OPERATION.
Consequence & remedy
Consequence: THE TRANSMISSION FLUID COULD COME INTO CONTACT WITH THE HOT EXHAUST SYSTEM AND IGNITION OF THE TRANSMISSION FLUID COULD RESULT.
Remedy: DEALERS WILL SHORTEN THE VENT HOSE AND ASSURE ADEQUATE CLEARANCE.
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE REAR AXLE VENT HOSE AND THE BRAKE HOSE.
Consequence & remedy
Consequence: A PUNCTURE IN THE REAR BRAKE HOSE WILL RESULT IN A LOSS OF BRAKING FORCE AT THE REAR WHEELS.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE HOSE FOR EVIDENCE OF WEAR. WORN BRAKE HOSES WILL BE REPLACED. THE REAR VENT HOSE WILL BE SHORTENED BY 3 INCHES AND A CLIP WILL BE INSTALLED TO ASSURE CLEARANCE BETWEEN THE AXLE VENT LINE AND BRAKE HOSE IS MAINTAINED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
PE00035 · Stop Lamp Switch
Opened Sep 7, 2000 · Closed Mar 9, 2001
Status: closed (inferred from source dates) · Electrical System
ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE
PE00030 · Front Safety Belt Anchorage Disengagemen
Opened Jul 21, 2000 · Closed Mar 8, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS
Illustration