← New search

2018 Dodge Charger

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

60 reports with mileage · 62 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports1 fire reports3 injury reports

Structure complaints

19 reports
Clear category filter
Mileage unknown · Jun 7, 2021
Structure

Inside door panels started to separate from the door, this is causing my power locks malfunction on the driver side (the separation is causing a lock button to misalign with the hole in the door panel). This started approximately 2 weeks ago. This problem started with the driver side door and has now affected 3 of the for doo…

Read full complaint

Inside door panels started to separate from the door, this is causing my power locks malfunction on the driver side (the separation is causing a lock button to misalign with the hole in the door panel). This started approximately 2 weeks ago. This problem started with the driver side door and has now affected 3 of the for doors in the car. Of course it happened about 4 months past the 3 year Dodge warranty period.

NHTSA ODI #11420040

Mileage unknown · Apr 28, 2021
Structure

THIS AT ABOUT 5:30 AM WHEN I WAS GETTING IN MY CAR TO GO TO WORK I NOTICED THE PANEL ON MY DRIVER SIDE DOOR WAS BEGINNING TO LIFT UP.MY CAR IS RARELY PARKED IN THE SUN LIGHT BECAUSE I PARK IT IN MY GARAGE AT HOME AND A SHADED AREA AT WORK.

NHTSA ODI #11414362

Mileage unknown · Sep 5, 2020
Structure

INTERIOR, I BELIEVE THE SUN OR HEAT WARPS THE DOOR TRIM INSIDE AND IT POPS OUT REVEALING THE INSIDE OF THE DOOR, NEAR THE WINDOWS. IT'S HAPPENED TO MY PASSENGER DOOR AND RECENTLY TO MY DRIVER DOOR.

NHTSA ODI #11353306

60,000 miles · Jul 9, 2020
Structure

TL* THE CONTACT OWNS A 2018 DODGE CHARGER. THE CONTACT STATED THAT THE INNER DOOR PANEL DETACHED FROM THE DOOR FRAME. THE CONTACT WAS CONCERNED THAT A CHILD MAY STICK THEIR FINGERS IN BETWEEN THE DOOR PANEL AND THE DOOR FRAME AND HURT THEMSELVES. THE DEALER WAS NOT CALLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE …

Read full complaint

TL* THE CONTACT OWNS A 2018 DODGE CHARGER. THE CONTACT STATED THAT THE INNER DOOR PANEL DETACHED FROM THE DOOR FRAME. THE CONTACT WAS CONCERNED THAT A CHILD MAY STICK THEIR FINGERS IN BETWEEN THE DOOR PANEL AND THE DOOR FRAME AND HURT THEMSELVES. THE DEALER WAS NOT CALLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

NHTSA ODI #11338386

58,843 miles · Jun 30, 2020
Structure

WENT TO GET IN THE VEHICLE ONE MORNING AND THE DOOR HANDLE ON THE DRIVER SIDE WILL NOT OPEN FROM THE OUTSIDE BUT WILL OPEN FROM THE INSIDE, I BELIEVE THE SCREW HAD COME OUT, AND WENT TO GET IN THE VEHICLE THIS MORNING AND NOTICE THE PANEL ON THE PASSENGER SIDE DOOR PANEL PEEL UP FROM THE TOP OF THE DOOR WHERE THE LOCK IS. *TR

NHTSA ODI #11331717

30,000 miles · Jan 22, 2020
Structure

TL* THE CONTACT OWNS A 2018 DODGE CHARGER. THE CONTACT STATED THAT UPON INSPECTION IT WAS DISCOVERED THAT THE FRONT DRIVER SIDE INTERIOR DOOR PANEL WAS NOT SECURED AND CAME OFF THE FRAME OF THE DOOR. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER MCKINNEY DODGE (4574 CALHOUN MEMORIAL HWY, EASLY SC.) AND THE MANUFA…

Read full complaint

TL* THE CONTACT OWNS A 2018 DODGE CHARGER. THE CONTACT STATED THAT UPON INSPECTION IT WAS DISCOVERED THAT THE FRONT DRIVER SIDE INTERIOR DOOR PANEL WAS NOT SECURED AND CAME OFF THE FRAME OF THE DOOR. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER MCKINNEY DODGE (4574 CALHOUN MEMORIAL HWY, EASLY SC.) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 30,000.

NHTSA ODI #11301165

32,000 miles · Dec 11, 2019
Air BagsStructureVehicle Speed ControlCrashInjury

MY DAUGHTER COULD NOT GET THE CAR TO STOP, AS SHE WAS ENGAGING THE BREAK TO THE FLOOR. SHE IS UNSURE IF WHEN SHE TURNED CRUISE CONTROL WAS SET, BUT EITHER WAY THE BRAKE SHOULD HAVE TURNED IT OFF. THEN WHEN THE POLE WAS HIT, ALL THE AIRBAGS WENT OFF EXCEPT THE PASSENGER LOWER AIRBAG. I WAS THE PASSENGER AND I HAVE A HURT ANKLE…

Read full complaint

MY DAUGHTER COULD NOT GET THE CAR TO STOP, AS SHE WAS ENGAGING THE BREAK TO THE FLOOR. SHE IS UNSURE IF WHEN SHE TURNED CRUISE CONTROL WAS SET, BUT EITHER WAY THE BRAKE SHOULD HAVE TURNED IT OFF. THEN WHEN THE POLE WAS HIT, ALL THE AIRBAGS WENT OFF EXCEPT THE PASSENGER LOWER AIRBAG. I WAS THE PASSENGER AND I HAVE A HURT ANKLE, KNEE, AND HIP. WHY WOULD ALL AIRBAGS GO OFF EXCEPT ONE IF THE IMPACT WAS DIRECTLY IN THE FRONT OF THE CAR? THE VEHICLE WAS TURNING WHEN SHE NOTICED IT WOULD NOT SLOW DOWN.

NHTSA ODI #11288524

6,600 miles · Jan 14, 2019
Structure

WHILE DRIVING ON A FREEWAY DOING ABOUT 65 MPH, THE SUNROOF SPONTANEOUSLY SHATTERED UPWARD, AS IF IT WAS HIT FROM THE INSIDE, SENDING GLASS FLYING DOWN THE BACK OF THE CAR HITTING OTHER VEHICLES BEHIND ME. THANKFULLY THE INTERNAL SUNROOF COVER WAS CLOSED SO GLASS DIDN'T RAIN DOWN ON US WHEN THIS HAPPENED. I HAD TO PULL OVER ON TH…

Read full complaint

WHILE DRIVING ON A FREEWAY DOING ABOUT 65 MPH, THE SUNROOF SPONTANEOUSLY SHATTERED UPWARD, AS IF IT WAS HIT FROM THE INSIDE, SENDING GLASS FLYING DOWN THE BACK OF THE CAR HITTING OTHER VEHICLES BEHIND ME. THANKFULLY THE INTERNAL SUNROOF COVER WAS CLOSED SO GLASS DIDN'T RAIN DOWN ON US WHEN THIS HAPPENED. I HAD TO PULL OVER ON THE SIDE OF THE FREEWAY AND CLEAN UP AS MUCH OF THE GLASS AS POSSIBLE SO IT WOULDN'T CONTINUE FLYING OFF AND HITTING VEHICLES BEHIND ME. DEFINITELY A SAFETY CONCERN, EVEN THOUGH IT'S TEMPERED GLASS, IT'S STILL SHARP. IF THE INTERNAL SUNROOF COVER WAS SLID OPEN IT WOULD HAVE BEEN MUCH WORSE THAN THE FEW CUTS I GOT ON MY HANDS FROM CLEANING UP THE GLASS.

NHTSA ODI #11166791

16,500 miles · May 15, 2018
Structure

THIS IS A RENTAL AND I HAVE BEEN DRIVING THIS CAR FOR ABOUT 6. IN THE AFTERNOON OF DAY 6, I WENT TO GET INTO THE CAR AND THE DOOR HANDLE MADE A FUNNY CLICKING SOUND AND WOULD NOT OPEN THE DOOR. IT IS ATTACHED BUT FEELS LIKE SOMEONE IS UNHOOKED INSIDE THE DOOR BECAUSE IT SEEMS TO LIFT UP HIGHER THAN IT SHOULD. DOOR OPENS FROM …

Read full complaint

THIS IS A RENTAL AND I HAVE BEEN DRIVING THIS CAR FOR ABOUT 6. IN THE AFTERNOON OF DAY 6, I WENT TO GET INTO THE CAR AND THE DOOR HANDLE MADE A FUNNY CLICKING SOUND AND WOULD NOT OPEN THE DOOR. IT IS ATTACHED BUT FEELS LIKE SOMEONE IS UNHOOKED INSIDE THE DOOR BECAUSE IT SEEMS TO LIFT UP HIGHER THAN IT SHOULD. DOOR OPENS FROM THE INSIDE WITH NO PROBLEM.

NHTSA ODI #11093864

Official recalls

6

24V198000 · Air Bags:side/window:curtain:inflator

Mar 14, 2024

Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2018-2021 Dodge Charger and Chrysler 300 vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.

Consequence & remedy

Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury or death.

Remedy: Dealers will replace both side curtain air bags, free of charge. Owner notification letters were mailed beginning February 20, 2025. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 19B.

20V512000 · Back Over Prevention: Sensing System: Camera

Aug 27, 2020

Chrysler (FCA US LLC) is recalling certain 2018-2020 Dodge Charger Pursuit vehicles equipped with a "stealth mode." When stealth mode is selected, the backup camera rearview image will not display when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rearview Mirrors."

Consequence & remedy

Consequence: The lack of a back-up camera display increases the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will update body control module software to disable stealth mode when the vehicle is shifted into "Reverse", free of charge. The recall began October 22, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W62.

18V524000 · Electrical System:wiring:front Underhood

Aug 9, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Consequence & remedy

Consequence: A vehicle stall can increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Electrical System:wiring

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

18V280000 · Power Train:automatic Transmission

May 1, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Dodge Charger, Durango and Challenger, Jeep Grand Cherokee and Wrangler, Chrysler 300, and RAM 1500 vehicles. An incorrect transmission park lock rod may have been installed in the transmission.

Consequence & remedy

Consequence: If the incorrect park lock rod is installed, the transmission may not shift into 'PARK' and keep the vehicle from moving, increasing the risk of unintended vehicle movement and the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will install the correct park lock rod, free of charge. The recall began June 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U43.

18V281000 · Power Train:driveline:driveshaft

May 1, 2018

Chrysler (FCA US LLC) is recalling certain 2015-2018 Dodge Charger pursuit police vehicles equipped with all-wheel drive and V8 engines. The front driveshaft universal joint may seize or fracture causing the shaft to detach from the vehicle.

Consequence & remedy

Consequence: If the front driveshaft detaches from the vehicle it may become a road hazard, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began June 27, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U37.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.