← New search

2013 Dodge Charger

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

266 reports with mileage · 94 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 167 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports20 fire reports14 injury reports

Electrical System complaints

167 reports
Clear category filter
Mileage unknown · Dec 22, 2015
Electrical System

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V634000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO DO THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE…

Read full complaint

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V634000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO DO THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED ANY FAILURES WITH THE VEHICLE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ODI #10811778

69,292 miles · Nov 19, 2015
Electrical System

I RECENTLY TOOK MY CAR TO THE DEALER TO GET CHECK OUT BECAUSE THE WIPERS ARE CONSTANTLY GOING WHILE I AM DRIVING ON HIGH. THE TECH STATED I NEED A ( MULTI FUNCTION SWITCH INTERNAL PART #1JH93DX9AL. ) WHICH IS LOCATED IN THE STEERING WHEEL. HE STATED THE PART IS ON A NATIONAL BACK ORDER AND IF I WAS TO COME PAY FOR IT. HE DONT H…

Read full complaint

I RECENTLY TOOK MY CAR TO THE DEALER TO GET CHECK OUT BECAUSE THE WIPERS ARE CONSTANTLY GOING WHILE I AM DRIVING ON HIGH. THE TECH STATED I NEED A ( MULTI FUNCTION SWITCH INTERNAL PART #1JH93DX9AL. ) WHICH IS LOCATED IN THE STEERING WHEEL. HE STATED THE PART IS ON A NATIONAL BACK ORDER AND IF I WAS TO COME PAY FOR IT. HE DONT HAVE A ETA WHEN IT WILL COME. IT COULD TAKE MONTHS AND MONTHS HE STATED. I CALL CRYSTLER RECALL HOTLINE TO GET MORE IN DEPT WITH HELP ON GETTING THIS PART, THEY TOLD ME THE SAME THING, AND TO CALL BACK NEXT TUESDAY , FIVE DAYS FROM NOW TO SEE IF THEM AND THE DEALER HAVE A ETA IF THE PART IS AVAILABLE. THE WIPERS ARE WEARING DOWN, AND MY WINDSHIELD IS VIBRATING DUE TO THE FAST MOTION OF THE WIPERS ARE GOING. I DRIVE A 2HR ROUND TRIP TO WORK 5 TO 6 DAYS A WEEK AND THE WEAR AND TEAR IS GETTING WORSE ON MY WINDSHIELD. I ASK THE TECH IF THERE ANYWAY HE COULD BY PAST IT OR PULL THE FUSE, HE STATED NO BECAUSE THE FUSE CONTROLS THE STARTER AND OTHER MAJOR COMPONENTS IN THE CAR. I DONT KNOW WHAT TO DO, I NEED THIS PART, I DONT UNDERSTAND WHY IS THERE NOT A RECALL ON THESE CARS IF THERE IS A NATIONAL BACK ORDER, THIS IS MY ONLY TRANSPORTATION TO GET BACK TO WORK.. I BOUGHT THIS CAR BRAND NEW WITH 10 MILES ON IT IN 2013. I TAKE GOOD ARE ON THE CAR.THIS PART CONTROL JUST ABOUT EVERYTHING IN MY STEERING WHEEL ( THE TECH STATED).. IF I DONT NEVER GET THIS PART, WHAT CAN I DO. I NEED MY TRANSPORTATION. PLEASE HELP ME RESOLVE THIS ISSUE IF YOU GUYS CAN

NHTSA ODI #10794810

46,000 miles · Nov 11, 2015
Electrical System

ALTERNATOR FAILED / TURNED OFF 4 LANE HWY (55 SPEED LIMIT) ON TO (35) SIDE STREET THEN ON TO (25) TO HOME . CAR FAILED TURNING INTO DRIVEWAY.

NHTSA ODI #10789847

51,000 miles · Nov 6, 2015
Electrical System

2013 DODGE CHARGER 50000 MILES JUST DRIVING DOWN THE ROAD AND I START HEARING A WHINING SOUND I NEVER HEARD BEFORE THEN 10 MINUTES LATER A MESSAGE POPS UP AND SAYS MY CAR IS IN BATTERY SAVER MODE. ALTERNATOR WENT OUT SUDDENLY WITH NO WARNING THE SAME THAT HAPPENS WITH THE V6 MODELS BUT CRYSLER ONLY RECALLED V6 MODELS NOT V8. TH…

Read full complaint

2013 DODGE CHARGER 50000 MILES JUST DRIVING DOWN THE ROAD AND I START HEARING A WHINING SOUND I NEVER HEARD BEFORE THEN 10 MINUTES LATER A MESSAGE POPS UP AND SAYS MY CAR IS IN BATTERY SAVER MODE. ALTERNATOR WENT OUT SUDDENLY WITH NO WARNING THE SAME THAT HAPPENS WITH THE V6 MODELS BUT CRYSLER ONLY RECALLED V6 MODELS NOT V8. THANKFULLY MY DAD WHO HAD THE EXACT SAME PROBLEM WITH HIS 2013 V8 CRYSLER 300 WARNED ME TO PARK BEFORE I DAMAGED MY BATTERY OR MY CAR STALL ON THE SIDE OF THE ROAD LIKE HIS DID 4 MONTHS AGO. IT IS IRRESPONSIBLE FOR CRYSLER TO ONLY DO A RECALL THAT COVERS HALF THE CARS THAT IS AFFECTED WITH THESE BAD ALTERNATORS

NHTSA ODI #10788810

Mileage unknown · Oct 2, 2015
Electrical SystemLatches/locks/linkages

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. THE CONTACT STATED THAT THE DOORS UNLOCKED WITHOUT WARNING WHEN THE VEHICLE WAS PARKED. THE VEHICLE COULD NOT BE DIAGNOSED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED TWO WEEKS PRIOR, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE…

Read full complaint

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. THE CONTACT STATED THAT THE DOORS UNLOCKED WITHOUT WARNING WHEN THE VEHICLE WAS PARKED. THE VEHICLE COULD NOT BE DIAGNOSED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED TWO WEEKS PRIOR, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ODI #10779412

73,000 miles · Oct 1, 2015
Electrical SystemFire

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. THE CONTACT STATED THAT THE VEHICLE STALED TWICE. DURING THE SECOND FAILURE, THE BATTERY SAVER WARNING INDICATOR ILLUMINATED, AN ABNORMAL NOISE WAS HEARD, AND SMOKE APPEARED. THE CONTACT WAS ABLE TO PARK THE VEHICLE AND PURCHASED AN ALTERNATOR ASSEMBLY. THE CONTACT REPLACED THE ALTERNAT…

Read full complaint

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. THE CONTACT STATED THAT THE VEHICLE STALED TWICE. DURING THE SECOND FAILURE, THE BATTERY SAVER WARNING INDICATOR ILLUMINATED, AN ABNORMAL NOISE WAS HEARD, AND SMOKE APPEARED. THE CONTACT WAS ABLE TO PARK THE VEHICLE AND PURCHASED AN ALTERNATOR ASSEMBLY. THE CONTACT REPLACED THE ALTERNATOR ASSEMBLY AND THE VEHICLE WAS REPAIRED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V467000 (AIR BAGS), BUT THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

NHTSA ODI #10779141

58,000 miles · Sep 21, 2015
Electrical SystemEnginePower Train

THE COOLING SYSTEM RADIATOR WATER PUMP HEATER CORE IS GIVING PROBLEMS IN A LOT OF THESES CARS THE MECHANIC AT THE DEALERSHIP SAYS HE SEES IT ALL THE TIME THE RADIATOR IN MINE IS COMING APART AT THE SEEMS AND A POLICE FRIEND OF MINE SAYS THEY HAVE LOST 3 DUE TO THE SAME PROBLEM THEN RUNNING HOT AND BLOWING UP

NHTSA ODI #10766700

Mileage unknown · Sep 11, 2015
Electrical SystemVisibility/wiper

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. WHILE DRIVING AT VARIOUS SPEEDS, THE WINDSHIELD WIPERS WOULD REMAIN ON AND COULD NOT BE SHUT OFF. AS A RESULT, THE FUSE REQUIRED TO BE DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILA…

Read full complaint

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. WHILE DRIVING AT VARIOUS SPEEDS, THE WINDSHIELD WIPERS WOULD REMAIN ON AND COULD NOT BE SHUT OFF. AS A RESULT, THE FUSE REQUIRED TO BE DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ODI #10763092

44,000 miles · Sep 10, 2015
Electrical SystemEngine

COMPLETED THE RECALL ON CAMPAIGN 14V634000 , FOR THE ALTERNATOR. LESS THAN 2 WEEKS LATER, DRIVING ON A TWO LANE ROAD, GOING 35MPH, THE VEHICLE LOOSES ALL POWER. AFTER GETTING IT TO A DEALERSHIP, NOW INFORMED THAT IT IS A BAD STARTER. THE ISSUES WITH THE CAR HAVE BEEN ALL ELECTRICAL: DOOR WINDOW BUTTON STOPPED WORKING, AIR CON…

Read full complaint

COMPLETED THE RECALL ON CAMPAIGN 14V634000 , FOR THE ALTERNATOR. LESS THAN 2 WEEKS LATER, DRIVING ON A TWO LANE ROAD, GOING 35MPH, THE VEHICLE LOOSES ALL POWER. AFTER GETTING IT TO A DEALERSHIP, NOW INFORMED THAT IT IS A BAD STARTER. THE ISSUES WITH THE CAR HAVE BEEN ALL ELECTRICAL: DOOR WINDOW BUTTON STOPPED WORKING, AIR CONDITIONING DOES NOT WORK (DEALER IS UNABLE TO FIGURE OUT PROBLEM). THESE ARE SIGNIFICANT ELECTRICAL ISSUES WITH A 2 YEAR OLD VEHICLE.

NHTSA ODI #10762873

Mileage unknown · Sep 10, 2015
Air BagsElectrical SystemSeat Belts

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. THE CONTACT RECEIVED NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 15V467000 (AIR BAGS, SEAT BELTS) AND 14V634000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS NEEDED WERE NOT AVAILABLE. THE DEALER WAS UNABLE TO PROVIDE A TIMEFRAME FOR WHEN THE PARTS WOULD BECOME AVAILABLE. THE CONTACT STATED THA…

Read full complaint

TL* THE CONTACT OWNS A 2013 DODGE CHARGER. THE CONTACT RECEIVED NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 15V467000 (AIR BAGS, SEAT BELTS) AND 14V634000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS NEEDED WERE NOT AVAILABLE. THE DEALER WAS UNABLE TO PROVIDE A TIMEFRAME FOR WHEN THE PARTS WOULD BECOME AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO PROVIDE THE REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI #10762786

Official recalls

8

19V018000 · Air Bags:frontal:passenger Side:inflator Module

Jan 15, 2019

Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.

18V021000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

17V435000 · Electrical System:alternator/generator/regulator

Jul 10, 2017

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.

16V240000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Apr 25, 2016

Chrysler (FCA US LLC) is recalling certain model year 2012-2014 Dodge Charger and Chrysler 300 vehicles manufactured February 15, 2011, to November 27, 2014, and 2014-2015 Jeep Grand Cherokee vehicles manufactured July 16, 2012, to December 22, 2015. The affected vehicles, equipped with an eight-speed automatic transmission and a monostable gear selector, may not adequately warn the driver when driver's door is opened and the vehicle is not in PARK, allowing them to exit the vehicle while the vehicle is still in gear.

Consequence & remedy

Consequence: Drivers thinking that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.

Remedy: Chrysler will notify owners, and dealers will update the vehicle software to mitigate the risk of vehicle rollaway, free of charge. The recall began on June 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S27. Note: On October 19, 2016 Chrysler identified some previously repaired vehicles did not receive the complete software updates. Chrysler will renotify the affected owners, and dealers will update the software again.

16V043000 · Structure

Jan 28, 2016

FCA US LLC (Chrysler) is recalling certain model year 2011-2016 Dodge Charger vehicles manufactured August 23, 2010, to January 7, 2016. When an affected vehicle is lifted using the supplied tire jack without chocking the wheels, the vehicle's body-side sill may give causing the tire jack to fail and the car to fall.

Consequence & remedy

Consequence: A car that falls unexpectedly increases the risk of injury.

Remedy: Chrysler will notify owners, and dealers will provide owners with wheel chocks and instructions for their use, free of charge. The recall began on March 21, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S03.

15V467000 · Air Bags:side/window; Seat Belts

Jul 27, 2015

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence & remedy

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

Additional source detail variants (2)

Seat Belts

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

Air Bags:side/window

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

14V634000 · Electrical System:alternator/generator/regulator

Oct 8, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

13V610000 · Power Train:automatic Transmission

Dec 6, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2013 Chrysler 300 AWD, Dodge Charger AWD, and Dodge Ram 1500 4x4 vehicles equipped with ZF all wheel drive ("AWD") 8HP45 transmissions. In the affected vehicles, the transmission output shaft may fracture.

Consequence & remedy

Consequence: The transmission output shaft fracture could result in a loss of power, increasing the risk of a crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park'.

Remedy: Chrysler will notify owners, and dealers will inspect and replace the transmissions, as necessary, free of charge. The recall began on March 31, 2014. Customers may contact Chrysler at 1-800-853-1403. Chrysler's recall number is N65.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

EA16002 · Vehicle Rollaway, Engine On

Opened Feb 3, 2016 · Closed Jun 24, 2016

Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)

On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.

Additional source detail variants (2)

Power Train:automatic Transmission:gear Position Indication (prndl)

On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.

Power Train:automatic Transmission:gear Position Indication (prndl)

On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.