NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
53 reportsClear category filter74,000 miles · Jul 14, 2017
Electrical SystemFuel/propulsion SystemSteering
I WAS DRIVING MY 2012 CHARGER SXT, AND THE CAR SUDDENLY WENT INTO BATTERY SAVER MODE. I HAD PULLED OVER TO GOOGLE IT ON MY PHONE, AND MY CAR WAS STARTING TO DISPLAY THE SYMPTOMS IN THE P60 RECALL. THE BATTERY LIGHT CAME ON, THE TRACTION CONTROL, ABS, CHECK ENGINE LIGHTS, THEY ALL CAME ON. THEN AS I WAS PULLING INTO A PARKING SPA…
Read full complaint
I WAS DRIVING MY 2012 CHARGER SXT, AND THE CAR SUDDENLY WENT INTO BATTERY SAVER MODE. I HAD PULLED OVER TO GOOGLE IT ON MY PHONE, AND MY CAR WAS STARTING TO DISPLAY THE SYMPTOMS IN THE P60 RECALL. THE BATTERY LIGHT CAME ON, THE TRACTION CONTROL, ABS, CHECK ENGINE LIGHTS, THEY ALL CAME ON. THEN AS I WAS PULLING INTO A PARKING SPACE AT DODGE THE CENTER SCREEN SHUT OFF, I LOST POWER STEERING, THE CAR SHUT ITSELF OFF. SOMEHOW THE WINDSHIELD WIPERS RAN A FEW CYCLES. THE DEALERSHIP INFORMED ME THAT MY CAR HAD A 180 AMPS ALTERNATOR, THAT IT WAS NOT PART OF THE P60. MY CAR HAD JUST REACHED 119000KM (74000MI), AND THE AVERAGE MILEAGE OF CHARGERS WITH 180 AMPS ALTERNATORS APPEARS TO BE AROUND 106000KM (66000MI). THE ROAD THAT I WAS ON, IT FOLLOWED THE A WINDING CLIFF. IF THE PROBLEM HAD BEEN MORE SEVERE I WOULD CERTAINLY HAVE DIED, EITHER GONE INTO THE ROCK FACE, OFF THE CLIFF, OR INTO ONCOMING TRAFFIC. THE REPLACEMENT ALTERNATOR WAS OVER $800 CND, THAT'S BEFORE THE INSPECTION, BEFORE LABOR, AND IF THE BATTERY FRIED IN THIS ORDEAL, IT DOESN'T INCLUDE THAT EITHER. IT DOESN'T COVER THE RENTAL CAR I HAD TO GET. OBVIOUSLY, CHRYSLER-DODGE-FIAT HAD TO DO A MASSIVE RECALL WITH ONE ALTERNATOR, IS IT REALLY A STRETCH TO THINK THAT THE OTHER ALTERNATOR THAT THEY INSTALLED IN OTHER VEHICLES WERE DEFECTIVE AS WELL? I LOOKED UP THE COST OF A REPLACEMENT ONLINE ACCORDING TO OFFICIAL DODGE SPECIFICATIONS FOR THE CHRYSLER 300 / CHARGER - THEY'RE LISTED AT ABOUT $200-250 CND, WHY IS THE ONE DODGE SELLING ME OVER $800? IS IT BECAUSE THEY REALIZED THEY HAVE TO PUT IN SOMETHING OF MUCH HIGHER QUALITY AND OUTPUT SO THAT THIS DOESN'T HAPPEN AGAIN? THERE HAD BETTER BE A RECALL ABOUT THIS - PEOPLE WILL GET SEVERELY HURT BECAUSE OF THIS.
NHTSA ODI #11005222
110,000 miles · Jun 2, 2017
Air BagsElectrical SystemPower Train
TL* THE CONTACT OWNS A 2012 DODGE CHARGER. WHILE DRIVING APPROXIMATELY 30 MPH, ALL THE LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED AND DIMMED. IN ADDITION, THE ABS WARNING INDICATOR ILLUMINATED, THE STEERING WHEEL SEIZED, THE GEAR SHIFTER FAILED TO SHIFT GEARS, AND THE VEHICLE STALLED AND LOST POWER. THE VEHICLE WAS TOWED TO ED V…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE CHARGER. WHILE DRIVING APPROXIMATELY 30 MPH, ALL THE LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED AND DIMMED. IN ADDITION, THE ABS WARNING INDICATOR ILLUMINATED, THE STEERING WHEEL SEIZED, THE GEAR SHIFTER FAILED TO SHIFT GEARS, AND THE VEHICLE STALLED AND LOST POWER. THE VEHICLE WAS TOWED TO ED VOYLES CHRYSLER DEALER (LOCATED ON 789 COBB PARKWAY SE, MARIETTA GA, 30060, (770)429-1100), BUT THE PARTS FOR THE REPAIR WERE NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBERS: 14V634000 (ELECTRICAL SYSTEM), 15V467000 (AIR BAGS, SEAT BELTS), 16V043000 (STRUCTURE), AND 16V352000 (AIR BAGS). THE PARTS NEEDED FOR THE REPAIRS WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10992851
70,000 miles · Dec 20, 2016
Electrical SystemSteering
MY DODGE CHARGER WENT DEAD WHILE I WAS DRIVING ONE DAY. THE BATTERY INDICATOR CAME ON AND CHARGING SYSTEM ON MY MONITOR, I WAS DRIVING WITH MY WIFE IN THE CAR AND I WAS LUCKY TO BE ABLE TO TURN ON A SIDE STREET AS THE WIPERS CAME ON AND SUDDENLY I HAD NO MORE POWER TO STEER THE CAR. I HAD MY HAZARDOUS LIGHTS ON TOO AND EVERYTHI…
Read full complaint
MY DODGE CHARGER WENT DEAD WHILE I WAS DRIVING ONE DAY. THE BATTERY INDICATOR CAME ON AND CHARGING SYSTEM ON MY MONITOR, I WAS DRIVING WITH MY WIFE IN THE CAR AND I WAS LUCKY TO BE ABLE TO TURN ON A SIDE STREET AS THE WIPERS CAME ON AND SUDDENLY I HAD NO MORE POWER TO STEER THE CAR. I HAD MY HAZARDOUS LIGHTS ON TOO AND EVERYTHING THEN WENT DEAD. I WAS LUCKY THAT DAY AND GOD WATCHED OVER ME AND MY WIFE. WHEN MY ROADSIDE SERVICE GOT THERE AND HE TRIED TO GIVE ME A JUMP IT WOULD NOT START AND HE TESTED THE BATTERY AND IT HAD A FULL CHARGE ON IT. I HAD THE CAR TOWED TO THE DODGE DEALER THAT NIGHT. THE NEXT DAY I WENT TO FIND OUT THAT THE ALTERNATOR WAS FRIED. I LOOKED UP AT THE TIME MY VEHICLE WAS DOWN BEFORE MY ROADSIDE SERVICE GOT THERE THAT NIGHT. I FOUNDED OUT THERE WAS A P60 RECALL ALTERNATOR (AMP 160) FOR DODGE CHARGER YEAR 2011-2014. I CALLED CHRYSLER CORPORATION THE NIGHT I WENT DOWN, AND THEY LOOKED UP AND SAID IT WAS NOT ON MY VEHICLE. THEY SAID I HAD A AMP 180, BUT AFTER GETTING A NEW ALTERNATOR IN MY DODGE CHARGER I'M STILL HAVING PROBLEMS WITH A BATTERY SAVE MODE THAT KEEPS POPPING UP ON MY MONITOR SCREEN. I PLEADED WITH THE CHRYSLER CORPORATION THAT SOMETHING IS WRONG WITH THE ALTERNATOR AND THAT NIGHT I COULD HAVE DIED. IF I WAS ON THE HIGHWAY. I DON'T FEEL SAFE EVERYDAY DRIVING, BECAUSE I HAVE TO GET ON THE HIGHWAY TO GO TO WORK. I'M GOING BACK TO THE DODGE SERVICE DEPARTMENT TO GET THIS BATTERY SAVE MODE CHECKED OUT, BECAUSE THEY USED ONE OF THE P60 RECALL ALTERNATOR TO FIX MY VEHICLE. I THINK THEY DON'T HAVE A STABLE ALTERNATOR, BECAUSE IT IS PROBABLY DRAINING THE BATTERY. *TR
NHTSA ODI #10936627
71,000 miles · Oct 7, 2016
Electrical SystemService BrakesSteering
THE RADIO TURNED OFF, EVERY LIGHT ON THE INSTRUMENT CLUSTER LIT UP, WIPERS TURNED ON AUTOMATICALLY, LOST BOTH POWER BREAK AND POWER STEERING. ALL THIS AT OVER 50 MPH WITH OUR YOUNG SON IN THE BACK SEAT....EVENTUALLY MY WIFE WAS ABLE TO GET THE VEHICLE STOPPED, BUT EVEN AFTER MANY ATTEMPTS WAS UNABLE TO PUT THE CAR IN PARK. EVENT…
Read full complaint
THE RADIO TURNED OFF, EVERY LIGHT ON THE INSTRUMENT CLUSTER LIT UP, WIPERS TURNED ON AUTOMATICALLY, LOST BOTH POWER BREAK AND POWER STEERING. ALL THIS AT OVER 50 MPH WITH OUR YOUNG SON IN THE BACK SEAT....EVENTUALLY MY WIFE WAS ABLE TO GET THE VEHICLE STOPPED, BUT EVEN AFTER MANY ATTEMPTS WAS UNABLE TO PUT THE CAR IN PARK. EVENTUALLY THE CAR JUST COMPLETELY DIED. SHE WAS STUCK IN THE MIDDLE OF A TURNING LANE AND WASN'T EVEN ABLE TO TURN ON THE EMERGENCY FLASHERS. THE CAR ENDED UP BEING TOWED TO THE NEAREST CHRYSLER DEALERSHIP AND DIAGNOSED WITH A FAULTY ALTERNATOR TO THE TUNE OF ALMOST $900. FINANCIAL BURDEN ASIDE, THIS WAS A VERY FRIGHTENING EXPERIENCE FOR MY WIFE AND SON, AND ALTHOUGH THE CAR HAS BEEN REPAIRED NEITHER MY WIFE NOR I FEEL ENTIRELY COMFORTABLE DRIVING THE CAR BY OURSELVES MUCH LESS HAVING OUR YOUNG SON IN THE BACK SEAT.
NHTSA ODI #10914505
100,000 miles · Jul 11, 2016
Steering
TAKATA RECALL I WAS LEAVING CHURCH AND WAS ABOUT TO STOP AT A GAS STATION TO GET COFFEE AND A DOUGHNUT LIKE I USUALLY DO EVERY SUNDAY. I WAS ABOUT TO MAKE A RIGHT TURN INTO THE GAS STATION, MY STEERING ALL OF A SUDDEN GOT STIFF AND THE POWER STEERING WARNING LIGHT CAME ON AND MY WINDSHIELD WIPERS CAME ON AND IT SCARED THE DAY …
Read full complaint
TAKATA RECALL I WAS LEAVING CHURCH AND WAS ABOUT TO STOP AT A GAS STATION TO GET COFFEE AND A DOUGHNUT LIKE I USUALLY DO EVERY SUNDAY. I WAS ABOUT TO MAKE A RIGHT TURN INTO THE GAS STATION, MY STEERING ALL OF A SUDDEN GOT STIFF AND THE POWER STEERING WARNING LIGHT CAME ON AND MY WINDSHIELD WIPERS CAME ON AND IT SCARED THE DAY LIGHTS OUT OF ME. I HAD TO GO ON THE CURB A LITTLE JUST TO MAKE THE TURN.
NHTSA ODI #10883883
82,100 miles · Dec 7, 2015
Electrical SystemPower TrainSteeringFire
I STARTED MY VEHICLE AND PULLED OUT OF MY GARAGE AS I DO EACH MORNING. AS I WENT DOWN THE DRIVEWAY AT ALMOST IDLE SPEED, I COULD FEEL A STRONG RESISTANCE (AS IF THE EMERGENCY BRAKE WAS ON) AND THE POWER STEERING TIGHTENED UP. SUDDENLY A STRONG BURNING SMELL FILLED THE CAR, ALL OF THE LIGHTS ON THE DASH CAME ON AND THE AC FAN BL…
Read full complaint
I STARTED MY VEHICLE AND PULLED OUT OF MY GARAGE AS I DO EACH MORNING. AS I WENT DOWN THE DRIVEWAY AT ALMOST IDLE SPEED, I COULD FEEL A STRONG RESISTANCE (AS IF THE EMERGENCY BRAKE WAS ON) AND THE POWER STEERING TIGHTENED UP. SUDDENLY A STRONG BURNING SMELL FILLED THE CAR, ALL OF THE LIGHTS ON THE DASH CAME ON AND THE AC FAN BLEW ON HIGH SPEED. I IMMEDIATELY REVERSED BACK TO THE GARAGE (100 FEET OR LESS) AND WAS BARELY ABLE TO PARK. THERE WAS OBVIOUSLY SOMETHING BURNING UNDER THE HOOD AS THE SMELL FILLED THE GARAGE. I TURNED OFF THE CAR. WHEN AAA ARRIVED TO TOW IT, THE CAR WAS COMPLETELY DEAD. THE DRIVER CHOSE NOT TO JUMP IT FOR FEAR OF DOING MORE DAMAGE. MY LOCAL TRUSTED MECHANIC ADVISED ME THAT THERE WAS A RECALL ON 2012 DODGE CHARGER ALTERNATORS AND HE BELIEVED THAT IT WAS MY ALTERNATOR THAT HAD FAILED. I HAD THE CAR TOWED TO ARRIGO SAWGRASS DODGE WHERE THEY CONFIRMED THAT THE ALTERNATOR HAD IN FACT FAILED AND WAS BURNING. HE SAID THE RECALL DID NOT INCLUDE MY VIN AND THAT CHRYSLER WOULD NOT COVER MY EXPENSES. MY 16 YEAR OLD SON AND I WERE LUCKY WE WERE IN THE DRIVEWAY, LUCKY THE FIRE DIDN'T IGNITE WHILE WE WERE SLEEPING AND LUCKY MY SON (A NEW DRIVER) WAS NOT FACED WITH A TOTALLY DISABLED VEHICLE ON THE ROAD. ACCORDING TO THE RECALL, THIS FAILURE CREATED A HIGH RISK OF CRASH. HAD WE BEEN ON ANY ROAD INSTEAD OF MY DRIVEWAY, WE COULD HAVE BEEN KILLED.
NHTSA ODI #10808805
82,000 miles · Dec 1, 2015
SteeringFire
TL* THE CONTACT OWNS A 2012 DODGE CHARGER. WHILE DRIVING 5 MPH, THE STEERING BECAME DIFFICULT TO CONTROL. THE VEHICLE WAS ABLE TO BE PARKED AND ALL THE WARNING LIGHTS ILLUMINATED. WHILE PARKED, SMOKE APPEARED FROM THE VEHICLE AND THEN DISAPPEARED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 82,000.
NHTSA ODI #10807782
37,000 miles · Sep 22, 2015
Air BagsSteeringCrashInjury
TL* THE CONTACT OWNS A 2012 DODGE CHARGER. WHILE DRIVING APPROXIMATELY 10 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL SEIZED. AS A RESULT, THE CONTACT CRASHED INTO A DITCH AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE CHARGER. WHILE DRIVING APPROXIMATELY 10 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL SEIZED. AS A RESULT, THE CONTACT CRASHED INTO A DITCH AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.
NHTSA ODI #10767490
52,300 miles · Apr 20, 2015
SteeringSuspensionWheels
NIGHT TIME @ 8:30PM, I WAS TRAVELING 20W/59S TOWARDS THE FOSTER EXIT. BEFORE I CAME UPON THE BLACK WARRIOR RIVER BRIDGE, I HIT AN UNEXPECTED POTHOLE IN THE LEFT LANE AND IT BEND AND CRACKED THE FRONT DRIVER'S SIDE RIM AND THREW OFF THE FRONT ALIGNMENT OF MY VEHICLE. *TR
NHTSA ODI #10711801
49,800 miles · Jan 22, 2015
Electrical SystemSteeringVisibility/wiper
TL*THE CONTACT OWNS A 2012 DODGE CHARGER. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY EXCESSIVE FORCE TO THE STEERING WHEEL IN ORDER TO TURN THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE JERKED AND VIBRATED. THE CONTACT ALSO STATED THAT TH…
Read full complaint
TL*THE CONTACT OWNS A 2012 DODGE CHARGER. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY EXCESSIVE FORCE TO THE STEERING WHEEL IN ORDER TO TURN THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE JERKED AND VIBRATED. THE CONTACT ALSO STATED THAT THE WIND SHIELD WIPER ACTIVATED INDEPENDENTLY AND ALL WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V634000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 49,800.
NHTSA ODI #10678310
Official recalls
14Jan 15, 2019
Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.
Jan 9, 2018
Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.
Jul 10, 2017
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.
May 24, 2016
Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.
Consequence & remedy
Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.
Apr 25, 2016
Chrysler (FCA US LLC) is recalling certain model year 2012-2014 Dodge Charger and Chrysler 300 vehicles manufactured February 15, 2011, to November 27, 2014, and 2014-2015 Jeep Grand Cherokee vehicles manufactured July 16, 2012, to December 22, 2015. The affected vehicles, equipped with an eight-speed automatic transmission and a monostable gear selector, may not adequately warn the driver when driver's door is opened and the vehicle is not in PARK, allowing them to exit the vehicle while the vehicle is still in gear.
Consequence & remedy
Consequence: Drivers thinking that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.
Remedy: Chrysler will notify owners, and dealers will update the vehicle software to mitigate the risk of vehicle rollaway, free of charge. The recall began on June 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S27. Note: On October 19, 2016 Chrysler identified some previously repaired vehicles did not receive the complete software updates. Chrysler will renotify the affected owners, and dealers will update the software again.
Jan 28, 2016
FCA US LLC (Chrysler) is recalling certain model year 2011-2016 Dodge Charger vehicles manufactured August 23, 2010, to January 7, 2016. When an affected vehicle is lifted using the supplied tire jack without chocking the wheels, the vehicle's body-side sill may give causing the tire jack to fail and the car to fall.
Consequence & remedy
Consequence: A car that falls unexpectedly increases the risk of injury.
Remedy: Chrysler will notify owners, and dealers will provide owners with wheel chocks and instructions for their use, free of charge. The recall began on March 21, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S03.
Jul 27, 2015
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence & remedy
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Additional source detail variants (2)
Seat Belts
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Air Bags:side/window
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Oct 8, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.
Mar 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Dodge Charger vehicles manufactured May 20, 2010, through November 8, 2011, and equipped with halogen headlamps. In the affected vehicles, a sub-harness for the headlights may overheat and cause the low beam headlights to go out.
Consequence & remedy
Consequence: Loss of headlights reduces the driver's visibility, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the headlamp jumper harnesses and bulbs, or the headlamp assemblies, as necessary, free of charge. The recall began on May 2, 2014. Owners may contract Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P08. This recall concerns non-police vehicles. A separate campaign was launched in 2012 to address police vehicles. See NHTSA recall 12V-042.
Apr 3, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Chrysler 300, Dodge Challenger, and Dodge Charger vehicles manufactured April 11, 2011, through December 14, 2011. The affected vehicles may have improperly sized terminal crimps on the seat side-airbag wiring harness which may cause the seat side-airbags to malfunction and illuminate the airbag warning light.
Consequence & remedy
Consequence: In the event of a crash necessitating airbag deployment the airbags may not operate as designed, increasing the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace both driver and passenger seat airbag wiring harnesses, free of charge. The recall began on April 22, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N07.
May 2, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence & remedy
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (2)
Electrical System:wiring:fuses And Circuit Breakers
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Service Brakes, Air:antilock:control Unit/module
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Feb 7, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence & remedy
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (4)
Exterior Lighting:headlights
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring:fuses And Circuit Breakers
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jan 6, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 DODGE CHARGER SRT8 AND THE CHRYSLER 300 SRT8 VEHICLES MANUFACTURED FROM MAY 2, 2011, THROUGH NOVEMBER 17, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 138, "TIRE PRESSURE MONITORING SYSTEM" (TPMS). AS BUILT, THE TPMS DOES NOT WARN THE DRIVER WHEN A TIRE IS 25 PERCENT BELOW THE RECOMMENDED PRESSURE. THE RECALLED VEHICLES NOTIFY THE CUSTOMERS WHEN THE TIRE PRESSURE REACHES 22 PSI RATHER THAN THE REQUIRED 24 PSI.
Consequence & remedy
Consequence: UNDERINFLATED TIRES CAN RESULT IN TIRE OVERLOADING AND OVERHEATING, WHICH COULD LEAD TO A BLOWOUT AND POSSIBLE CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPROGRAM THE VEHICLES TPMS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Sep 29, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.
Consequence & remedy
Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
EA16002 · Vehicle Rollaway, Engine On
Opened Feb 3, 2016 · Closed Jun 24, 2016
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.
Additional source detail variants (2)
Power Train:automatic Transmission:gear Position Indication (prndl)
On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.
Power Train:automatic Transmission:gear Position Indication (prndl)
On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.
PE14022 · Alternator Failure
Opened Jul 22, 2014 · Closed Nov 6, 2014
Status: closed (inferred from source dates) · Electrical System:alternator/generator/regulator
On July 22, 2014, the Office of Defects Investigation (ODI) opened PE14-022 to investigate 14 complaints (VOQs) alleging incidents of alternator failure resulting in engine stall while driving in model year (MY) 2011 through 2012 Dodge Charger vehicles.The MY 2011 through 2012 Dodge Charger vehicles were sold with three different engine options:1) 3.6L V6 (VIN8 = G), 88,766 vehicles; 2) 5.7L V8 (VIN8 = T), 38,615 vehicles; and 3) 6.4L V8 (VIN8 = J), 2,406 MY 2012 vehicles.The 14 VOQs identified in the PE14-022 opening resume involve 13 vehicles with 3.6L V6 engines and 1 vehicle with unknown engine (no VIN provided).In an October 7, 2014 letter to NHTSA, Chrysler described a safety defect condition that could result in rapid alternator failure having limited or no detection in approximately 434,581 MY 2011 through 2014 Chrysler 300, Dodge Charger, Dodge Challenger, Dodge Durango and Jeep Grand Cherokee vehicles equipped with 3.6L engines and 160 amp alternators (NHTSA Recall No. 14V-634, Chrysler P60).The subject alternators are used in vehicles equipped with 3.6L V6 engines and without towing packages.According to Chrysler, the silicone diodes in the alternator rectifier bridge may experience thermal fatigue due to cyclic loading from the Electric Hydraulic Power Steering (EHPS) system, eventually resulting in no output, reduced output, or a fully shorted to ground condition.These failure modes vary in their time to failure and warning to the driver.Depending on the failure mode and timing, system voltage may drop to critically low levels, disabling systems such as the Anti-lock Brake System/Electronic Stability Control, Engine Control Module/Central Body Controller, or a total vehicle electrical system shut down (in the event of a short to ground failure mode).Analysis of complaints to ODI and Chrysler identified a total of 146 incidents of alternator failure resulting in engine stall while driving in MY 2011 through 2012 Dodge Charger vehicles, including 142 involving vehicles equipped with the 3.6L V6 engines (1.6 IPTV) that were included in 14V-634 and 4 involving vehicles with 5.7L V8 engines (0.1 IPTV), which are equipped with different alternators.Analysis of all alternator failure complaints found that approximately 48 percent of VOQs and 21 percent of Chrysler complaints involved allegations of engine stall.Many (98) complaints reported fire and/or smoke, but analysis of these determined that they involved thermal damage to the alternator diode and did not identify any incidents involving damage beyond the alternator assembly.One VOQ identified in the opening resume for PE14-022 alleged a crash, but further evaluation determined that this involved a minor rear-end impact with slight bumper damage.This investigation is closed based on Chrysler's decision to conduct a safety recall.The VOQs associated with this investigation are:10641479,10641366,10641349,10642017,10640770,10640687,10640553,10639692,10638810,10638356,10638175,10638143,10637460,10633806,10633304,10632943,10632006,10631704,10631613,10631420,10631088,10630991,10630854,10630844,10630108,10629623,10629603,10628228,10628150,10627941,10627342,10626452,10626254,10625962,10622385,10622340,10621603,10620961,10619481,10618950,10618948,10618539,10618476,10618334,10618081,10618107,10616834,10616461,10616456,10615754,10615719,10606580,10605090,10604958,10597295,10592085,10588675,10587141,10562463,10559730,10511407
Illustration