← New search

2011 Dodge Charger

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

576 reports with mileage · 119 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 395 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Exterior Lighting. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports64 fire reports14 injury reports

Engine complaints

77 reports
Clear category filter
38,600 miles · Sep 8, 2014
Electrical SystemEngine

I GOT THE "BATTERY SAVER MODE" WARNING ON MY CAR. I LOOKED IT UP ON THE INTERNET AND A LOT OF PEOPLE WERE COMPLAINING ABOUT DODGE CHARGERS AND THERE ALTERNATORS. THE NEXT MORNING I CALLED THE DEALER SHIP TO SEE WHAT THEY THINK IT IS AND IF I CAN GET IN SO THEY CAN LOOK AT THE CAR, THEY ALSO SAID IT COULD BE THE ALTERNATOR BUT CO…

Read full complaint

I GOT THE "BATTERY SAVER MODE" WARNING ON MY CAR. I LOOKED IT UP ON THE INTERNET AND A LOT OF PEOPLE WERE COMPLAINING ABOUT DODGE CHARGERS AND THERE ALTERNATORS. THE NEXT MORNING I CALLED THE DEALER SHIP TO SEE WHAT THEY THINK IT IS AND IF I CAN GET IN SO THEY CAN LOOK AT THE CAR, THEY ALSO SAID IT COULD BE THE ALTERNATOR BUT COULD NOT GET ME IN UNTIL THE NEXT MORNING BUT SAID IT SHOULD BE SAFE TO DRIVE. THEY LOOK UP MY WARRANTY AND IT WAS OUT OF WARRANTY FOR THE ALTERNATOR...I ONLY HAVE 38,600 MILES ON MY CAR!! I SHOULD NOT BE DEALING WITH THING LIKE THIS ON A 3 YEAR OLD CAR! LUCKILY I BOUGHT A PORTFOLIO WARRANTY THAT COVERS IT BUT WITH $100 DEDUCTIBLE BUT THE CATCH IS I HAVE TO GO TO THE DEALER WHERE I BOUGHT IT FROM! WHEN THERE IS A DEALER 2 MILES FROM WHERE I AM AND THE ONE I BOUGHT IT FROM IS ABOUT 25 MINUTES AWAY. SO I MAKE THE APPOINTMENT AND GO TO WORK, BY THE TIME I GET TO WORK MY RADIO STOPPED WORKING AND ABS LIGHT TURNED ON. I PARKED AND SMOKE WAS COMING FROM THE ALTERNATOR! I CALLED THE DEALER BACK AND TOLD THEM WHAT HAPPEN, THEY SAID I CAN BRING IT IN NOW AND LEAVE IT THERE AND THEY WILL LOOK AT IT THE NEXT DAY. SO I HAVE TO LEAVE WORK TO TAKE THE CAR THERE AND THE CAR COMPLETELY DIES ON THE WAY THERE! I HAD TO CALL A TOW TRUCK AND GET IT TOWED ALL THE WAY TO THE DEALER. THEY WERE ABLE TO REPLACE THE ALTERNATOR BY THE MIDDLE OF THE NEXT DAY. BUT I HAVE NOW HAD THE CAR FOR 2 WHOLE DAYS AND THE BATTERY SAVER MODE JUST TURNED ON AGAIN!!!!! SO NOW IN THE MORNING I'M GOING TO HAVE TO CALL THE DEALER AGAIN AND SEE WHAT TO DO NOW! REPLACE ANOTHER ALTERNATOR!?!?!?!? THIS HAS TO BE A RECALL!! THERE SHOULD NOT BE ANY OF THESE PROBLEMS ON A CAR THAT IS 3 YEARS OLD AND HAS LESS THEN 40,000 MILES!!! THIS IS RIDICULOUS AND I'M SERIOUSLY LOOKING AT OTHER CARS TO TRADE IN FOR NOW! I AM NEVER BUYING DODGE AGAIN!! OH AND THE DEALER WOULDN'T GIVE ME A LOANER CAR FOR FREE! *TR

NHTSA ODI #10631420

48,000 miles · Sep 5, 2014
Engine

TL* THE CONTACT OWNS A 2011 DODGE CHARGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.

NHTSA ODI #10630991

89,999 miles · Aug 30, 2014
EngineSteeringVehicle Speed Control

ON 8/24 I WAS DRIVING ABOUT 30 MPH WHEN MY CAR STARTED CUTTING OUT. THE RADIO WENT OFF, MY ENGINE DIED AND MY STEERING LOCKED. I ALMOST HIT A PEDESTRIAN AND WHAT COULD HAVE BEEN A FEW CARS BUT I WAS ABLE TO AVOID IT. I STOPPED AND WAS ABLE TO START MY CAR TO GET IT TO THE SIDE OF THE ROAD. I HAD IT TOWED HOME, NEXT DAY I HAD IT …

Read full complaint

ON 8/24 I WAS DRIVING ABOUT 30 MPH WHEN MY CAR STARTED CUTTING OUT. THE RADIO WENT OFF, MY ENGINE DIED AND MY STEERING LOCKED. I ALMOST HIT A PEDESTRIAN AND WHAT COULD HAVE BEEN A FEW CARS BUT I WAS ABLE TO AVOID IT. I STOPPED AND WAS ABLE TO START MY CAR TO GET IT TO THE SIDE OF THE ROAD. I HAD IT TOWED HOME, NEXT DAY I HAD IT TOWED TO MOMENTUM DODGE BECAUSE I LOOKED ONLINE AND HAD 3 RECALLS, DOOR HANDLES, HEADLIGHTS AND I DON'T KNOW THE 3RD ONE. I WAS HOPING IT WAS THE PROBLEM. IT WAS NOT. I THEN HAD MY CAR TOWED TO ANOTHER SHOP WHO VERIFIED MY ALTERNATOR IS OUT. AS OF NOW THE ONLY PLACE I CAN THE FIND THE ALTERNATOR IS, OF COURSE, THE DODGE DEALER WHICH I CANNOT AFFORD. *TR

NHTSA ODI #10629603

59,500 miles · Aug 27, 2014
Electrical SystemEngine

WHILE DRIVING ON HIGHWAY AT APPROX. 50 MPH, THE "BATTER SAVER" MESSAGE APPEARED ON THE DASH DISPLAY FOLLOWED BY MULTIPLE SYSTEMS SHUTTING DOWN ALONG WITH MULTIPLE FAULT LIGHTS INCLUDING BRAKES, ABS, BAT. THE ENGINE STOPPED RUNNING AND THERE WAS MINIMAL CONTROL OF THE VEHICLE. STEERING & BRAKING WERE ALMOST NON EXISTENT. AFTER…

Read full complaint

WHILE DRIVING ON HIGHWAY AT APPROX. 50 MPH, THE "BATTER SAVER" MESSAGE APPEARED ON THE DASH DISPLAY FOLLOWED BY MULTIPLE SYSTEMS SHUTTING DOWN ALONG WITH MULTIPLE FAULT LIGHTS INCLUDING BRAKES, ABS, BAT. THE ENGINE STOPPED RUNNING AND THERE WAS MINIMAL CONTROL OF THE VEHICLE. STEERING & BRAKING WERE ALMOST NON EXISTENT. AFTER PULLING TO THE SIDE OF THE HIGHWAY, THERE WAS A STRONG ELECTRICAL SMELL COMING FROM THE ENGINE COMPARTMENT. UPON FURTHER INVESTIGATION, THE SMELL WAS COMING FROM THE ALTERNATOR. NO ELECTRICAL POWER WAS AVAILABLE TO LOCK/UNLOCK DOORS, TURN ON HAZARD LIGHTS, OR PLACE THE CAR IN NEUTRAL IN ORDER TO PULL THE VEHICLE ON TO A TOW TRUCK. *TR

NHTSA ODI #10628985

43,000 miles · Aug 9, 2014
Electrical SystemEngine

MORNING OF THE INCIDENT, HEARD A "WHINING" NOISE WHEN CAR STARTED. DRIVE SHORT DISTANCE TO WORK AND HOME. WHILE DRIVING ON HIGHWAY IN TRAFFIC GOING 25MPH AT 6PM, LOST POWER TO RADIO, POWER STEERING, ABS LIGHT FLASHED, BRAKE LIGHT FLASHED, AND STRONG ELECTRICAL SMELL. WHEN I FINALLY GOT THE CAR TO THE SHOULDER, ITWAS IN BATTERY…

Read full complaint

MORNING OF THE INCIDENT, HEARD A "WHINING" NOISE WHEN CAR STARTED. DRIVE SHORT DISTANCE TO WORK AND HOME. WHILE DRIVING ON HIGHWAY IN TRAFFIC GOING 25MPH AT 6PM, LOST POWER TO RADIO, POWER STEERING, ABS LIGHT FLASHED, BRAKE LIGHT FLASHED, AND STRONG ELECTRICAL SMELL. WHEN I FINALLY GOT THE CAR TO THE SHOULDER, ITWAS IN BATTERY SAVER MODE AND COULD NOT DETECT KEY FOR KEYLESS ENTRY. NO ELECTRICAL POWER. WHEN I CALLED DODGE DEALER WHERE IT WAS TOWED, THEY SAID IT WOULD BE $700 FOR PARTS AND LABOR. *TR

NHTSA ODI #10621073

58,000 miles · Aug 4, 2014
Electrical SystemEngine

MY CAR STARTED MAKING A SQUEAKY NOISE FROM THE ENGINE ONE MORNING, THEN AS I DROVE IT THE RADIO WENT OFF AND MY BATTERY SAID IT WAS GOING INTO BATTERY SAVING MODE. MY AC STARTED TO TURN ON AND OFF, SO I LOWERED MY WINDOWS THEN MY WINDOWS WOULDN'T GO BACK UP. I HAD NUMEROUS ENGINE LIGHTS COME. MY WINDSHIELD WIPERS WHERE TURNING O…

Read full complaint

MY CAR STARTED MAKING A SQUEAKY NOISE FROM THE ENGINE ONE MORNING, THEN AS I DROVE IT THE RADIO WENT OFF AND MY BATTERY SAID IT WAS GOING INTO BATTERY SAVING MODE. MY AC STARTED TO TURN ON AND OFF, SO I LOWERED MY WINDOWS THEN MY WINDOWS WOULDN'T GO BACK UP. I HAD NUMEROUS ENGINE LIGHTS COME. MY WINDSHIELD WIPERS WHERE TURNING ON AND OFF. MY POWER STEERING STOPPED WORKING, SO I PULLED OVER. I TURNED MY CAR OFF AND IT WOULDN'T TURN ON. I CHECKED MY BATTERY THE NEXT MORNING TO SEE IF I NEEDED A NEW ONE BUT IT WAS FINE. I JUMPED MY CAR AND DROVE IT AROUND A LITTLE AND STILL HAD ALL THE PROBLEMS STATED ABOVE WITH MY HEADLIGHTS FLASHING ON AND OFF THIS TIME. I TURNED THE CAR OFF AND THE LIGHTS INSIDE WHERE STILL FLASHING, SO I UNPLUGGED THE BATTERY. MY CAR IS NOW AT THE DODGE DEALER AND THEY ARE TELLING ME IT MIGHT BE ALTERNATOR. I DON'T UNDERSTAND HOW THIS HAPPENS TO A 2011 VEHICLE. *TR

NHTSA ODI #10618708

65,000 miles · Aug 2, 2014
Electrical SystemEngineFire

I WAS DRIVING AND ALL OF A SUDDEN THE CAR STARTED SMOKING AND THEN STARTED TO DECELERATE.I PULLED OVER TO THE SIDE TO TAKE A LOOK UNDER THE HOOD AND HEARD A BUZZING/RINGING NOISE FROM THE ENGINE.I SLOWLY DROVE TO AUTO ZONE TO GET A DIAGNOSTIC AND IT READ ALTERNATOR. *TR

NHTSA ODI #10618399

Mileage unknown · Aug 1, 2014
Electrical SystemEngineFire

DRIVING AND THE CAR STARTED TO MAKE A HUMMING SOUND FROM THE ENGINE. THEN OUT OF NOWHERE CAR STARTED TO BLOW HOT AIR, THE RADIO WENT OFF, "BATTERY SAFE MODE" WAS ON THE SCREEN AND I COULD START TO SMELL SMOKE. I PULLED OVER AND TRIED TO FIGURE OUT WHAT WAS GOING ON. I WAS DIRECTED TO GO TO EITHER AN AUTO STORE OR THE DEALERSH…

Read full complaint

DRIVING AND THE CAR STARTED TO MAKE A HUMMING SOUND FROM THE ENGINE. THEN OUT OF NOWHERE CAR STARTED TO BLOW HOT AIR, THE RADIO WENT OFF, "BATTERY SAFE MODE" WAS ON THE SCREEN AND I COULD START TO SMELL SMOKE. I PULLED OVER AND TRIED TO FIGURE OUT WHAT WAS GOING ON. I WAS DIRECTED TO GO TO EITHER AN AUTO STORE OR THE DEALERSHIP TO GET A DIAGNOSTIC RAN. I CAUTIOUSLY DROVE THE CAR (ONLY GOING ABOUT 20 MPH TOPS) TO AN AUTO STORE. THEY RAN A DIAGNOSTIC AND I WAS TOLD THE ALTERNATOR WAS SHOT AND THAT I WAS THE 3RD PERSON THIS WEEK THAT HAD THE SAME ISSUE. I DROVE MY CAR LESS THAN A MILE HOME AND THE MOMENT THAT I TURNED INTO MY APARTMENT COMPLEX THE CAR JUST SHUT OFF AND SMOKE WAS BILLOWING FROM UNDER THE HOOD. THE NEXT DAY WHEN I TRIED TO TURN THE CAR ON TO GET IT ON THE TOW TRUCK, THE AUTOMATIC DOORS WOULDN'T UNLOCK- THE WHOLE CAR WAS COMPLETELY DEAD! FROM READING MULTIPLE POST I'M NOT SURE WHY DODGE HASN'T ISSUED A RECALL FOR THIS. I CLEARLY AM NOT THE ONLY ONE EXPERIENCING THIS PRICEY ISSUE FOR SUCH A NEWER CAR. I'M JUST GLAD ALL THIS HAPPENED WHEN I WAS ON SIDE STREETS AND NOT GOING AT A HIGH RATE OF SPEED AND MY CHILD WAS NOT IN THE CAR WITH ME OR ELSE THIS COULD BE A DIFFERENT STORY! *TR

NHTSA ODI #10618107

47,040 miles · Aug 1, 2014
Electrical SystemEngineSteering

I WAS TRAVELING NORTHBOUND ON A HIGHWAY AT APPROXIMATELY 1730 AND MY RADIO SCREEN COMPLETELY WENT OUT, FOLLOWED BY EVERYTHING ELSE THAT USES POWER IN THE VEHICLE I STARTED GETTING SEVERAL WARNING LIGHTS FOR BREAKS, TIRE PRESSURE, PRETTY MUCH EVERY WARNING, VEHICLE ENTERED BATTERY SAVER MODE WHILE DRIVING. STEERING WHEEL WAS ALMO…

Read full complaint

I WAS TRAVELING NORTHBOUND ON A HIGHWAY AT APPROXIMATELY 1730 AND MY RADIO SCREEN COMPLETELY WENT OUT, FOLLOWED BY EVERYTHING ELSE THAT USES POWER IN THE VEHICLE I STARTED GETTING SEVERAL WARNING LIGHTS FOR BREAKS, TIRE PRESSURE, PRETTY MUCH EVERY WARNING, VEHICLE ENTERED BATTERY SAVER MODE WHILE DRIVING. STEERING WHEEL WAS ALMOST IMPOSSIBLE TO MANIPULATE MAYBE AFTER A COUPLE MINUTES MY VEHICLE COMPLETELY SHUT OFF IN THE MIDDLE OF TRAFFIC WITHOUT WARNING. I WAS UNABLE TO TURN ON HAZARDS, OR ROLL WINDOWS DOWN OR DO ANYTHING WITH MY VEHICLE, THIS WAS VERY UNSAFE AND COULD HAVE CAUSED A MAJOR ACCIDENT. THE ISSUE SEEMS TO STEM FROM THE ALTERNATOR COMPLETELY FAILING WHILE DRIVING. THIS WAS VERY STRESSFUL FOR ME AND EVERYONE INVOLVED. *TR

NHTSA ODI #10618081

34,596 miles · Jul 26, 2014
Electrical SystemEngineSteering

3/9/13 - VEHICLE IN FOR OIL CHANGE. BATTERY SAVER MODE MESSAGE DISPLAYED ON DASH 2 MILES DOWN THE ROAD. PULLED OVER TO CHECK OWNER'S MANUAL WHICH STATES IMMEDIATE VEHICLE SERVICE REQUIRED. TO AIRPARK DODGE DEALERSHIP APPROX 7 MILES DOWN THE ROAD AND POWER STEERING FAILURE AND THEN ENGINE STALLS WHILE MAKING LEFT TURN THROUGH …

Read full complaint

3/9/13 - VEHICLE IN FOR OIL CHANGE. BATTERY SAVER MODE MESSAGE DISPLAYED ON DASH 2 MILES DOWN THE ROAD. PULLED OVER TO CHECK OWNER'S MANUAL WHICH STATES IMMEDIATE VEHICLE SERVICE REQUIRED. TO AIRPARK DODGE DEALERSHIP APPROX 7 MILES DOWN THE ROAD AND POWER STEERING FAILURE AND THEN ENGINE STALLS WHILE MAKING LEFT TURN THROUGH INTERSECTION. HAD BOTH MY CHILDREN AGES 2 AND 5 IN THE VEHICLE AT THE TIME AND THANKFULLY NO ON COMING TRAFFIC DURING THE TURN. 3/12/13 - ALTERNATOR AND BATTERY REPLACED AT AIRPARK DODGE. 4/23/13 (35,690 MILES) - VEHICLE BACK TO AIRPARK DODGE FOR ANOTHER BATTERY SAVER MODE MESSAGE. SOURCE COULD NOT BE FOUND, NO REPAIRS MADE. 7/25/14 (47,900 MILES) - BATTERY SAVER MODE MESSAGE, NO DASH LIGHTS, NO A/C, NO POWER STEERING, NO HEADLIGHTS WHILE DOING 30 MPH. VEHICLE TO AIRPARK DODGE AGAIN ON 7/29/14. *TR

NHTSA ODI #10616461

Official recalls

11

19V018000 · Air Bags:frontal:passenger Side:inflator Module

Jan 15, 2019

Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.

18V021000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

17V435000 · Electrical System:alternator/generator/regulator

Jul 10, 2017

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.

16V352000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence & remedy

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

16V043000 · Structure

Jan 28, 2016

FCA US LLC (Chrysler) is recalling certain model year 2011-2016 Dodge Charger vehicles manufactured August 23, 2010, to January 7, 2016. When an affected vehicle is lifted using the supplied tire jack without chocking the wheels, the vehicle's body-side sill may give causing the tire jack to fail and the car to fall.

Consequence & remedy

Consequence: A car that falls unexpectedly increases the risk of injury.

Remedy: Chrysler will notify owners, and dealers will provide owners with wheel chocks and instructions for their use, free of charge. The recall began on March 21, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S03.

15V467000 · Air Bags:side/window; Seat Belts

Jul 27, 2015

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence & remedy

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

Additional source detail variants (2)

Seat Belts

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

Air Bags:side/window

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

14V634000 · Electrical System:alternator/generator/regulator

Oct 8, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

14V101000 · Exterior Lighting:headlights

Mar 4, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Dodge Charger vehicles manufactured May 20, 2010, through November 8, 2011, and equipped with halogen headlamps. In the affected vehicles, a sub-harness for the headlights may overheat and cause the low beam headlights to go out.

Consequence & remedy

Consequence: Loss of headlights reduces the driver's visibility, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the headlamp jumper harnesses and bulbs, or the headlamp assemblies, as necessary, free of charge. The recall began on May 2, 2014. Owners may contract Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P08. This recall concerns non-police vehicles. A separate campaign was launched in 2012 to address police vehicles. See NHTSA recall 12V-042.

13V118000 · Air Bags

Apr 3, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Chrysler 300, Dodge Challenger, and Dodge Charger vehicles manufactured April 11, 2011, through December 14, 2011. The affected vehicles may have improperly sized terminal crimps on the seat side-airbag wiring harness which may cause the seat side-airbags to malfunction and illuminate the airbag warning light.

Consequence & remedy

Consequence: In the event of a crash necessitating airbag deployment the airbags may not operate as designed, increasing the risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace both driver and passenger seat airbag wiring harnesses, free of charge. The recall began on April 22, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N07.

12V197000 · Electrical System:wiring:fuses And Circuit Breakers; Service Brakes, Air:antilock:control Unit/module

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence & remedy

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Additional source detail variants (2)

Electrical System:wiring:fuses And Circuit Breakers

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Service Brakes, Air:antilock:control Unit/module

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V042000 · Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting:headlights; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 7, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence & remedy

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Additional source detail variants (4)

Electrical System:wiring:fuses And Circuit Breakers

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Exterior Lighting:headlights

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Electrical System:wiring

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

PE14022 · Alternator Failure

Opened Jul 22, 2014 · Closed Nov 6, 2014

Status: closed (inferred from source dates) · Electrical System:alternator/generator/regulator

On July 22, 2014, the Office of Defects Investigation (ODI) opened PE14-022 to investigate 14 complaints (VOQs) alleging incidents of alternator failure resulting in engine stall while driving in model year (MY) 2011 through 2012 Dodge Charger vehicles.The MY 2011 through 2012 Dodge Charger vehicles were sold with three different engine options:1) 3.6L V6 (VIN8 = G), 88,766 vehicles; 2) 5.7L V8 (VIN8 = T), 38,615 vehicles; and 3) 6.4L V8 (VIN8 = J), 2,406 MY 2012 vehicles.The 14 VOQs identified in the PE14-022 opening resume involve 13 vehicles with 3.6L V6 engines and 1 vehicle with unknown engine (no VIN provided).In an October 7, 2014 letter to NHTSA, Chrysler described a safety defect condition that could result in rapid alternator failure having limited or no detection in approximately 434,581 MY 2011 through 2014 Chrysler 300, Dodge Charger, Dodge Challenger, Dodge Durango and Jeep Grand Cherokee vehicles equipped with 3.6L engines and 160 amp alternators (NHTSA Recall No. 14V-634, Chrysler P60).The subject alternators are used in vehicles equipped with 3.6L V6 engines and without towing packages.According to Chrysler, the silicone diodes in the alternator rectifier bridge may experience thermal fatigue due to cyclic loading from the Electric Hydraulic Power Steering (EHPS) system, eventually resulting in no output, reduced output, or a fully shorted to ground condition.These failure modes vary in their time to failure and warning to the driver.Depending on the failure mode and timing, system voltage may drop to critically low levels, disabling systems such as the Anti-lock Brake System/Electronic Stability Control, Engine Control Module/Central Body Controller, or a total vehicle electrical system shut down (in the event of a short to ground failure mode).Analysis of complaints to ODI and Chrysler identified a total of 146 incidents of alternator failure resulting in engine stall while driving in MY 2011 through 2012 Dodge Charger vehicles, including 142 involving vehicles equipped with the 3.6L V6 engines (1.6 IPTV) that were included in 14V-634 and 4 involving vehicles with 5.7L V8 engines (0.1 IPTV), which are equipped with different alternators.Analysis of all alternator failure complaints found that approximately 48 percent of VOQs and 21 percent of Chrysler complaints involved allegations of engine stall.Many (98) complaints reported fire and/or smoke, but analysis of these determined that they involved thermal damage to the alternator diode and did not identify any incidents involving damage beyond the alternator assembly.One VOQ identified in the opening resume for PE14-022 alleged a crash, but further evaluation determined that this involved a minor rear-end impact with slight bumper damage.This investigation is closed based on Chrysler's decision to conduct a safety recall.The VOQs associated with this investigation are:10641479,10641366,10641349,10642017,10640770,10640687,10640553,10639692,10638810,10638356,10638175,10638143,10637460,10633806,10633304,10632943,10632006,10631704,10631613,10631420,10631088,10630991,10630854,10630844,10630108,10629623,10629603,10628228,10628150,10627941,10627342,10626452,10626254,10625962,10622385,10622340,10621603,10620961,10619481,10618950,10618948,10618539,10618476,10618334,10618081,10618107,10616834,10616461,10616456,10615754,10615719,10606580,10605090,10604958,10597295,10592085,10588675,10587141,10562463,10559730,10511407