Electrical System. Review the 395 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports64 fire reports14 injury reports

Engine complaints

77 reports

Clear category filter

45,000 miles · Oct 13, 2014

Engine

DRIVING CAR AND IT STARTED SMOKING. HAD TO PULL OFF THE SIDE OF THE ROAD IT STARTED LOSING POWER. HAD TO CALL A TOLL TRUCK TO TAKE IT TO THE DEALERSHIP AND THEY SAID I NEEDED A NEW ALTERNATOR. THE CAR IS A 2011 AND ONLY HAS 45,000 MILES ON IT. THIS SHOULD NOT HAPPEN. *TR

NHTSA ODI #10644228

54,000 miles · Oct 8, 2014

Electrical SystemElectronic Stability Control (esc)Engine

Read full complaint

WHILE DRIVING, "BATTERY SAVER MODE" MESSAGE CAME UP. FROM HERE, I COULD SMELL SOMETHING COMING FROM UNDER THE HOOD. THEN THE ABS LIGHT AND TRACTION CONTROL LIGHT CAME ON. WAS ABLE TO GET IT HOME, BEFORE TRYING TO DRIVE IT AGAIN LATER AFTER JUMPING IT AND IT WAS COMPLETELY DEAD. WAS ABLE TO FINALLY JUMP IT LONG ENOUGH TO GET OUT OF MY DRIVEWAY AND INTO THE STREET SO IT COULD BE TOWED. BROUGHT IT TO MY DEALERSHIP AND THEY SAID IT WAS A BAD ALTERNATOR. IT IS ONLY A 2011 AND HAS OVER 50K MILES. *TR

NHTSA ODI #10643260

62,000 miles · Oct 6, 2014

Electrical SystemEngineSteering

Read full complaint

DRIVING WITH MY DAUGHTER IN THE CAR IN HEAVY MORNING TRAFFIC AND IVIC MESSAGE CAME ON STATING CAR WAS IN BATTERY SAVER MODE. SECOND TIME IN 4 MONTHS THIS HAS HAPPENED (GOT ALTERNATOR AND BATTERY TESTED AND REPLACED THE FIRST TIME) SO I IMMEDIATELY TURNED AROUND TO HEAD BACK HOME. BY THE TIME I GOT NEAR MY NEIGHBORHOOD ABOUT 5 MINUTES LATER EVERYTHING WAS SHUTTING OFF AND I COULD ONLY GO 25 MPH WITH NO POWER STEERING. ABOUT A MINUTE OR SO BEFORE THE IVIC MESSAGE I NOTICED A SLIGHT WHINING COMING FROM MY ENGINE COMPARTMENT. IF I JUMP THE BATTERY, CAR STARTS BUT STILL IN BATTERY SAVER MODE. *TR

NHTSA ODI #10641605

70,049 miles · Oct 4, 2014

Electrical SystemEngineSteering

Read full complaint

DRIVING HOME AT APPROXIMATELY 45MPH, THE MESSAGE SCREEN INDICATED "BATTERY SAVER MODE". AT THIS TIME, THE RADIO SHUT ITSELF OFF, THE AIR CONDITIONING SWITCHED TO FULL-BLAST HEAT, THE SPEEDOMETER STOPPED WORKING, ALL LIGHTS SHUT OFF, THE WINDSHIELD WIPERS CAME ON FOR A FEW SWIPES AND THEN STOPPED, AND THE THROTTLE RESPONSE TO THE ACCELERATOR PEDAL WOULD ONLY ALLOW ME TO REACH AROUND 30MPH (ON A 50MPH HIGHWAY). I MANAGED TO GET THE CAR INTO MY NEIGHBORHOOD, BUT IT DIED BEFORE I COULD PARK IT. I HAD TO PUT IT IN NEUTRAL AND PUSH IT INTO A PARKING SPACE. *TR

NHTSA ODI #10641366

26,000 miles · Sep 30, 2014

Electrical SystemEngine

Read full complaint

DRIVING ON THE ROAD AT ABOUT 75 MPH (THE SPEED LIMIT AT THE TIME) IN THE MIDDLE OF NOWHERE TEXAS, MY ELECTRICAL SYSTEMS STARTED TO SHUT DOWN. THE FIRST THING WE NOTICED TURN OFF WAS THE AUDIO SYSTEM AND IT WOULDN'T TURN BACK ON, THEN THE CLIMATE CONTROL SYSTEM. I CHECKED THE MESSAGES ON MY DASHES MESSAGE CENTER AND IT TOLD ME THE VEHICLE WAS IN BATTERY SAVER MODE. SHORTLY THEREAFTER (MAYBE ANOTHER MINUTE OR TWO) THE ABS AND TRACTION CONTROL INDICATORS CAME ON AND ALL MY GAUGES (SPEEDOMETER AND WHATNOT) ALL DROPPED TO ZERO. THE CAR WAS STILL IN MOTION AND WE WERE LUCKY ENOUGH TO FIND A ROAD TO PULL OFF AT (THOUGH WE WERE NO WHERE NEAR ANYTHING AT THE TIME). AT THAT POINT I NOTICED THE POWER STEERING, LOCKS, WINDOWS, AND ANYTHING ELECTRIC WENT ON THE CAR TOO. AFTER WE TURNED OFF THE CAR, IT WOULD NOT RESTART. AFTER DEALING WITH CHRYSLER AND GETTING MYSELF, MY FAMILY, AND MY CAR BACK FROM MIDLAND TO AUSTIN, IT TURNS OUT THE ALTERNATOR WENT ON IT. THIS SHOULD NOT BE AN ISSUE THIS EARLY (APPROXIMATELY 26,000 MILES) IN THE LIFE OF MY CAR. HOPEFULLY THIS GETS ADDED TO THE ONGOING INVESTIGATION (NHTSA ACTION NUMBER: PE14022) FOR THIS ISSUE. *TR

NHTSA ODI #10640221

62,000 miles · Sep 22, 2014

Electrical SystemEngine

Read full complaint

WAS DRIVING AND THE POWER SAVER MODE CAME ON THE CAR. SAW SMOKE, CHECKED THE ENGINE AND THE ALTERNATOR WAS SMOKING. SOMETHING NEEDS TO BE DONE. THIS CAR IS 3 YEARS OLD WITH 60,000 MILES ON IT. THAT IS RIDICULOUS. THE CAR HAS NOT WENT THROUGH ANYTHING STENOS. WE ARE AT A LOST FOR WORDS AND THEN WHEN CALLED AND ASKED ABOUT IT THERE IS NOTHING THAT CAN BE DONE WITHOUT FURTHER INVESTIGATION. PLEASE INVESTIGATE, THERE ARE TOO MANY COMPLAINTS ABOUT THIS. THIS IS COSTING OVER 800 DOLLARS, THIS IS RIDICULOUS ON A LOW MILE LOW YEAR CAR, RIGHT AFTER THE WARRANTY GOES OUT. PLEASE INVESTIGATE AND DO SOMETHING, THANKS. *TR

NHTSA ODI #10638090

15,000 miles · Sep 16, 2014

Electrical SystemEngine

WAS DRIVING CAR WHEN RADIO SHUT OFF, ABS BRAKE WARNING CAME ON AND CAR LOST STEERING AND BRAKE POWER. GOT CAR HOME AND IT STOPPED RUNNING. TRIED TO JUMP AND DRIVE TO DEALER BUT COULD NOT KEEP ENGINE RUNNING, POWER WORKED OFF AND ON. TOO DANGEROUS TO DRIVE ON HIGHWAY WITH POSSIBLE LOSS OF CONTROL. $800 TO REPLACE ALTERNATOR. *TR…

Read full complaint

NHTSA ODI #10633806

37,000 miles · Sep 16, 2014

Electrical SystemEngine

Read full complaint

DRIVING AT 25 MPH, WARNING LIGHTS CAME ON FOR DIFFERENT FUNCTIONS. ODD SOUND COMING FROM MOTOR. THE INFORMATION MESSAGE ALERT LIT UP. CHECKED IT, AND THE MESSAGE ALERT WAS "BATTERY SAVER MODE". ODD SMELL (ELECTRICAL) COMING FROM THE ENGINE. PARKED, CLOSED WINDOWS, SHUT THE CAR OFF. WENT TO RESTART CAR AND IT WOULDN'T START. HAD A FRIEND TRY TO JUMP WITH CABLES, AND IT DIDN'T WORK. CALLED FOR TOW TRUCK TO COME AND TAKE TO DEALER. I HAVE A BUMPER TO BUMPER LIFETIME WARRANTY. DEALER CAN'T "LOOK" AT IT UNTIL TOMORROW. IT HAS BEEN ALMOST 2 HOURS WAIT FOR TOW TRUCK,(PROMISED TO BE HERE AN HOUR AGO.) *TR

NHTSA ODI #10633694

72,475 miles · Sep 16, 2014

Electrical SystemEngine

Read full complaint

I WAS DRIVING NOTICED MY CAR HAD A SLIGHT LOUDER SOUND COMING FROM THE ENGINE LIKE IT WAS RIVED UP. AS I WAS DRIVING I NOTICED THE ABS LIGHTS CAME ON; TRACTION LIGHT; AND ENGINE LIGHT ALL FLASHED ACROSS THE SCREEN AND WENT OFF. THEN I STARTED SMELLING A STRONG BURNING SMELL I HAD MAD IT TO MY DESTINATION CUT THE CAR OFF. I WENT TO CRANK THE CAR BACK UP ;NOTHING HAPPENED CAR HAD LOST ALL PRIOR MY WINDOWS, DOORS ALL LOCKED UP WOULD NOT ROLL UP OR DOWN OR DOORS UNLOCK HAD TO CALL A TOW TRUCK. CAR HAD NO POWER COMPLETELY BLACK SCREENS EVERYTHING SHUTDOWN. *TR

NHTSA ODI #10633647

45,670 miles · Sep 8, 2014

EngineService BrakesSteering

Read full complaint

I HAVE A 2011 DODGE CHARGER THAT I SAVED UP A LONG TIME TO BUY. LAST WEEK ON 9/3/14 ON MY TO TAKE MY KIDS TO SCHOOL THE AUDIO IN THE CAR WENT OUT. THE TOUCH SCREEN STILL HAD FUNCTIONALITY JUST NO AUDIO, FIGURED A FUSE MAY HAVE BLOWN. CHECK THE FUSES AND EVERYTHING SEEMED OK. LATER ON THE SAME DAY, ON THE WAY TO PICK THE KIDS UP FROM SCHOOL THE RADIO WAS WORKING FINE. I APPROACHED A INTERSECTION AND STARTED TO SLOW DOWN WHEN THE RADIO CUT OFF. THE CAR STARTED PUTTERING AND THE INSIDE GAUGES BEGAN FLASHING AND THE WIPERS JUST TURNED ON BY THEMSELVES. NEXT THING I KNOW EVERYTHING IN THE CAR SHUT OFF. THE RADIO,THE ENGINE, THE LIGHTS, EVERYTHING. I COULD NOT GET IT TO GO INTO NEUTRAL TO PUSH THE CAR OUT OF THE ROAD BECAUSE NOTHING IN THE CAR WOULD COME ON. *TR

NHTSA ODI #10631428

Official recalls

19V018000 · Air Bags:frontal:passenger Side:inflator Module

Jan 15, 2019

Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.

18V021000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

17V435000 · Electrical System:alternator/generator/regulator

Jul 10, 2017

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.

16V352000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence & remedy

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

16V043000 · Structure

Jan 28, 2016

FCA US LLC (Chrysler) is recalling certain model year 2011-2016 Dodge Charger vehicles manufactured August 23, 2010, to January 7, 2016. When an affected vehicle is lifted using the supplied tire jack without chocking the wheels, the vehicle's body-side sill may give causing the tire jack to fail and the car to fall.

Consequence & remedy

Consequence: A car that falls unexpectedly increases the risk of injury.

Remedy: Chrysler will notify owners, and dealers will provide owners with wheel chocks and instructions for their use, free of charge. The recall began on March 21, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S03.

15V467000 · Air Bags:side/window; Seat Belts

Jul 27, 2015

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence & remedy

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

Additional source detail variants (2)

Seat Belts

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

Air Bags:side/window

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

14V634000 · Electrical System:alternator/generator/regulator

Oct 8, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

14V101000 · Exterior Lighting:headlights

Mar 4, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Dodge Charger vehicles manufactured May 20, 2010, through November 8, 2011, and equipped with halogen headlamps. In the affected vehicles, a sub-harness for the headlights may overheat and cause the low beam headlights to go out.

Consequence & remedy

Consequence: Loss of headlights reduces the driver's visibility, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the headlamp jumper harnesses and bulbs, or the headlamp assemblies, as necessary, free of charge. The recall began on May 2, 2014. Owners may contract Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P08. This recall concerns non-police vehicles. A separate campaign was launched in 2012 to address police vehicles. See NHTSA recall 12V-042.

13V118000 · Air Bags

Apr 3, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Chrysler 300, Dodge Challenger, and Dodge Charger vehicles manufactured April 11, 2011, through December 14, 2011. The affected vehicles may have improperly sized terminal crimps on the seat side-airbag wiring harness which may cause the seat side-airbags to malfunction and illuminate the airbag warning light.

Consequence & remedy

Consequence: In the event of a crash necessitating airbag deployment the airbags may not operate as designed, increasing the risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace both driver and passenger seat airbag wiring harnesses, free of charge. The recall began on April 22, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N07.

12V197000 · Electrical System:wiring:fuses And Circuit Breakers; Service Brakes, Air:antilock:control Unit/module

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence & remedy

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Additional source detail variants (2)

Electrical System:wiring:fuses And Circuit Breakers

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Service Brakes, Air:antilock:control Unit/module

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V042000 · Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting:headlights; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 7, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence & remedy

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Additional source detail variants (4)

Electrical System:wiring:fuses And Circuit Breakers

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Exterior Lighting:headlights

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Electrical System:wiring

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

Air Bags:frontal:passenger Side:inflator Module

PE14022 · Alternator Failure

Opened Jul 22, 2014 · Closed Nov 6, 2014

Status: closed (inferred from source dates) · Electrical System:alternator/generator/regulator

On July 22, 2014, the Office of Defects Investigation (ODI) opened PE14-022 to investigate 14 complaints (VOQs) alleging incidents of alternator failure resulting in engine stall while driving in model year (MY) 2011 through 2012 Dodge Charger vehicles.The MY 2011 through 2012 Dodge Charger vehicles were sold with three different engine options:1) 3.6L V6 (VIN8 = G), 88,766 vehicles; 2) 5.7L V8 (VIN8 = T), 38,615 vehicles; and 3) 6.4L V8 (VIN8 = J), 2,406 MY 2012 vehicles.The 14 VOQs identified in the PE14-022 opening resume involve 13 vehicles with 3.6L V6 engines and 1 vehicle with unknown engine (no VIN provided).In an October 7, 2014 letter to NHTSA, Chrysler described a safety defect condition that could result in rapid alternator failure having limited or no detection in approximately 434,581 MY 2011 through 2014 Chrysler 300, Dodge Charger, Dodge Challenger, Dodge Durango and Jeep Grand Cherokee vehicles equipped with 3.6L engines and 160 amp alternators (NHTSA Recall No. 14V-634, Chrysler P60).The subject alternators are used in vehicles equipped with 3.6L V6 engines and without towing packages.According to Chrysler, the silicone diodes in the alternator rectifier bridge may experience thermal fatigue due to cyclic loading from the Electric Hydraulic Power Steering (EHPS) system, eventually resulting in no output, reduced output, or a fully shorted to ground condition.These failure modes vary in their time to failure and warning to the driver.Depending on the failure mode and timing, system voltage may drop to critically low levels, disabling systems such as the Anti-lock Brake System/Electronic Stability Control, Engine Control Module/Central Body Controller, or a total vehicle electrical system shut down (in the event of a short to ground failure mode).Analysis of complaints to ODI and Chrysler identified a total of 146 incidents of alternator failure resulting in engine stall while driving in MY 2011 through 2012 Dodge Charger vehicles, including 142 involving vehicles equipped with the 3.6L V6 engines (1.6 IPTV) that were included in 14V-634 and 4 involving vehicles with 5.7L V8 engines (0.1 IPTV), which are equipped with different alternators.Analysis of all alternator failure complaints found that approximately 48 percent of VOQs and 21 percent of Chrysler complaints involved allegations of engine stall.Many (98) complaints reported fire and/or smoke, but analysis of these determined that they involved thermal damage to the alternator diode and did not identify any incidents involving damage beyond the alternator assembly.One VOQ identified in the opening resume for PE14-022 alleged a crash, but further evaluation determined that this involved a minor rear-end impact with slight bumper damage.This investigation is closed based on Chrysler's decision to conduct a safety recall.The VOQs associated with this investigation are:10641479,10641366,10641349,10642017,10640770,10640687,10640553,10639692,10638810,10638356,10638175,10638143,10637460,10633806,10633304,10632943,10632006,10631704,10631613,10631420,10631088,10630991,10630854,10630844,10630108,10629623,10629603,10628228,10628150,10627941,10627342,10626452,10626254,10625962,10622385,10622340,10621603,10620961,10619481,10618950,10618948,10618539,10618476,10618334,10618081,10618107,10616834,10616461,10616456,10615754,10615719,10606580,10605090,10604958,10597295,10592085,10588675,10587141,10562463,10559730,10511407