← New search

2011 Dodge Charger

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

576 reports with mileage · 119 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 395 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Exterior Lighting. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports64 fire reports14 injury reports

Electrical System complaints

395 reports
Clear category filter
46,000 miles · Sep 15, 2014
Electrical System

I BOUGHT A 2011 CHARGER IN 2012. DEC 11 2013 MY SON WAS STRANDED IN THE COLD WITH A DEAD ALTERNATOR. IT COST A FORTUNE FOR TOW, NEW ALTERNATOR, LABOR ($865.00) . THAT IS UNACCEPTABLE FOR A 2 YEAR OLD CAR AND OWNERS SHOULD BE COMPENSATED. *TR

NHTSA ODI #10633396

48,000 miles · Sep 14, 2014
Electrical System

AT FIRST MY CAR STARTED MAKING A WHINING TYPE OF SOUND IT SEEMED TO BE DRIVING A LITTLE BIT OFF. THEN AFTER DRIVING DOWN THE STREET I NOTICED THAT THE ABS LIGHT AND THE TRACTION LIGHT WAS ON, AND A BURNT ELECTRICAL WIRE SMELL WAS COMING THROUGH THE VENTS. SO I PULLED OVER AND PARKED AND TURNED THE VEHICLE OFF. I OPENED THE HOOD…

Read full complaint

AT FIRST MY CAR STARTED MAKING A WHINING TYPE OF SOUND IT SEEMED TO BE DRIVING A LITTLE BIT OFF. THEN AFTER DRIVING DOWN THE STREET I NOTICED THAT THE ABS LIGHT AND THE TRACTION LIGHT WAS ON, AND A BURNT ELECTRICAL WIRE SMELL WAS COMING THROUGH THE VENTS. SO I PULLED OVER AND PARKED AND TURNED THE VEHICLE OFF. I OPENED THE HOOD AND THE SMELL OF BURNT WIRE WAS REALLY BAD. I DECIDED TO LEAVE THE VEHICLE WHERE I HAD PARKED IT, BUT WANTED TO ROLL UP THE WINDOWS. WHEN I WENT TO TURN THE CAR BACK ON THE CAR WAS COMPLETELY DEAD. SO LONG STORY SHORT MY RELATIVELY NEW CAR BROKE DOWN ON ME. AND THIS IS NOT THE FIRST TIME THIS HAS HAPPENED TO ME. I PREVIOUSLY OWNED A 2008 DODGE CHARGER THAT HAD THE SAME ISSUES. ITS REALLY A DISAPPOINTMENT BECAUSE THE WHOLE REASON I TRADED IN MY OLD CHARGER FOR A NEW ONE WAS BECAUSE I NEEDED A RELIABLE VEHICLE THAT I COULD DEPEND ON. AND THAT IS OBVIOUSLY NOT A DODGE. *TR

NHTSA ODI #10633080

47,250 miles · Sep 13, 2014
Electrical SystemElectronic Stability Control (esc)Service Brakes

CAR WENT INTO BATTERY SAVER MODE WHILE DRIVING. TOOK TO DEALERSHIP SAID NOTHING WRONG. DROVE NEXT DAY WHERE ALL LIGHTS AND WIPERS GOING OFF. RADIO CUT OFF AND ABS, TRACTION CONTROL AND E-BRAKE LIGHTS CAME ON. THEN CAR BEGAN HAVING SMOKY SMELL. COMPLETELY SHUT OFF IN INTERSECTION WITH NO RECHARGE OR ABILITY TO START UP. COULD NOT…

Read full complaint

CAR WENT INTO BATTERY SAVER MODE WHILE DRIVING. TOOK TO DEALERSHIP SAID NOTHING WRONG. DROVE NEXT DAY WHERE ALL LIGHTS AND WIPERS GOING OFF. RADIO CUT OFF AND ABS, TRACTION CONTROL AND E-BRAKE LIGHTS CAME ON. THEN CAR BEGAN HAVING SMOKY SMELL. COMPLETELY SHUT OFF IN INTERSECTION WITH NO RECHARGE OR ABILITY TO START UP. COULD NOT EVEN LOCK DOORS OR OPEN TRUNK. *TR

NHTSA ODI #10632943

44,000 miles · Sep 12, 2014
Electrical SystemElectronic Stability Control (esc)Service Brakes

I HAVE REPLACED MY CAR'S ALTERNATOR TWICE WITHIN 16 MONTHS DUE TO TOTAL FAILURE (CAR WON'T TURN ON) AND IMPENDING FAILURE (LOW CHARGING WHILE ON). THIS RESULTED IN MY BATTERY NEEDING TO BE REPLACED. ADDITIONALLY, I HAVE REPLACED ALL 4 WHEEL SPEED SENSORS TWICE WITHIN THE LAST 24 MONTHS BECAUSE THEY ARE FAILING AND THE ABS / ES…

Read full complaint

I HAVE REPLACED MY CAR'S ALTERNATOR TWICE WITHIN 16 MONTHS DUE TO TOTAL FAILURE (CAR WON'T TURN ON) AND IMPENDING FAILURE (LOW CHARGING WHILE ON). THIS RESULTED IN MY BATTERY NEEDING TO BE REPLACED. ADDITIONALLY, I HAVE REPLACED ALL 4 WHEEL SPEED SENSORS TWICE WITHIN THE LAST 24 MONTHS BECAUSE THEY ARE FAILING AND THE ABS / ESC LIGHT COMES ON. VERY DISAPPOINTING IN A CAR THAT'S ONLY 3 YEARS OLD. DEALERSHIP TELLS ME BOTH REPAIRS ARE TYPICAL OF THESE CARS, EVEN THE NEW ONES. LASTLY, BOTH OF MY HEADLIGHTS HAVE BLOWN OUT DUE TO A KNOWN RECALL. *TR

NHTSA ODI #10632769

35,000 miles · Sep 11, 2014
Electrical System

I WAS DRIVING TOWARDS WORK IN THE MORNING, WHEN ALL OF A SUDDEN, THE BATTERY LIGHT GOES ON. A FEW MINUTES LATER, THE ABS LIGHT GOES ON AND THEN THE TRACTION LIGHT GOES ON. THEN, THERE WAS THE SMELL OF BURNT WIRE AND A WHINING TYPE OF SOUND, SO I PARKED THE CAR AND SMOKE CAME OUT FROM UNDER THE HOOD. LATER IN THE AFTERNOON, I…

Read full complaint

I WAS DRIVING TOWARDS WORK IN THE MORNING, WHEN ALL OF A SUDDEN, THE BATTERY LIGHT GOES ON. A FEW MINUTES LATER, THE ABS LIGHT GOES ON AND THEN THE TRACTION LIGHT GOES ON. THEN, THERE WAS THE SMELL OF BURNT WIRE AND A WHINING TYPE OF SOUND, SO I PARKED THE CAR AND SMOKE CAME OUT FROM UNDER THE HOOD. LATER IN THE AFTERNOON, I HAD MY HUSBAND TAKE A LOOK UNDER THE HOOD AND HE STATED THAT THERE SEEMED TO BE SPARKS COMING OUT FROM THE ALTERNATOR, SO WE ATTEMPTED TO DRIVE IT TO THE DEALERSHIP. AFTER 3 MILES OF DRIVING IN TRAFFIC ON A 40 MPH ROAD, THE RADIO SHUTS OFF, THE LIGHTS GO OFF, THE AIR CONDITIONING TURNS OFF, THE DASHBOARD SCREEN/NAVIGATION SYSTEM TURNED OFF, THE WINDSHIELD WIPERS WENT OUT, AND THE ENGINE STOPS RUNNING. NOTHING IN THE VEHICLE WORKED OR WAS RUNNING, EVEN THE WINDOWS DIDN'T WORK. A BURNT ELECTRICAL WIRE SMELL CAME THROUGH THE VENTS. I COULDN'T EVEN TURN ON THE HAZARD LIGHTS OR UNLOCK THE TRUNK. SO MY HUSBAND PUSHED THE CAR OVER TO A PARKING LOT WHILE I STRUGGLED TO MANEUVER THE VEHICLE BECAUSE THE POWER STEERING AND THE POWER BRAKES ALSO WENT OUT. WE TRIED TO JUMP START THE CAR; HOWEVER, WE STOPPED BECAUSE THERE WAS MORE SMOKE COMING FROM THE ENGINE, SO WE CALLED FOR A TOW TRUCK DRIVER. THE NEXT DAY, WE WENT BACK TO THE SERVICE DEPARTMENT AT THE DODGE DEALERSHIP AND THEY TOLD US THAT IT WAS THE ALTERNATOR; HOWEVER, WE PROBABLY NEED A BATTERY AS WELL. WE ALSO WILL HAVE TO PAY FOR TOWING. THIS VEHICLE IS ONLY 3 YEARS OLD AND SHOULDN'T BE HAVING THESE TYPES OF ENGINE PROBLEMS. IT'S A SAFETY HAZARD WHEN YOUR CAR TOTALLY SHUTS DOWN IN THE MIDDLE OF TRAFFIC, LEAVING YOU WITHOUT A WAY TO TURN ON THE HAZARD LIGHTS OR PROVIDE YOU WITH A SAFE WAY TO STEER AND BRAKE. *TR

NHTSA ODI #10632618

48,000 miles · Sep 11, 2014
Electrical SystemService BrakesSuspension

I WAS DRIVING MY VEHICLE WHEN ALL OF A SUDDEN MY RADIO TURNS OFF, THEN MY ABS AND TREAD LIGHT COME ON ALONG WITH A LIGHT THAT SAYS "BRAKE NOW." I COME TO A STOP AND THEN EVERYTHING SHUTS OFF. I CAN NOT PUSH THE BRAKE TO START THE CAR BACK UP AND A BURNING ELECTRICAL SMELL IS COMING FROM THE HOOD. I HAVE TO MANUALLY LOCK MY DOORS…

Read full complaint

I WAS DRIVING MY VEHICLE WHEN ALL OF A SUDDEN MY RADIO TURNS OFF, THEN MY ABS AND TREAD LIGHT COME ON ALONG WITH A LIGHT THAT SAYS "BRAKE NOW." I COME TO A STOP AND THEN EVERYTHING SHUTS OFF. I CAN NOT PUSH THE BRAKE TO START THE CAR BACK UP AND A BURNING ELECTRICAL SMELL IS COMING FROM THE HOOD. I HAVE TO MANUALLY LOCK MY DOORS AS THE ALARM DOES NOT WORK, THEN MY WINDSHIELD WIPERS START GOING OFF. BASED OFF OF RESEARCH A LOT OF PEOPLE ARE HAVING THESE ISSUES AND SAYING IT IS THE ALTERNATOR. THAT IS UNACCEPTABLE FOR A 2011. *TR

NHTSA ODI #10632611

39,000 miles · Sep 11, 2014
Electrical SystemFire

DRIVING TO GET ON HIGHWAY AND GOT A MESSAGE ON MY CAR DASHBOARD SAYING IM IN BATTERY SAVE MODE. SO GOT MY SPEED UP TO ABOUT 70 AND MY CAR LIGHT AND POWER STEERING AND WINDSHIELD WIPER CAME ON. MY POWER STEERING LOCKED UP ON THE HIGHWAY THINK GOD I WAS ON THE HIGHWAY SIMI BY MYSELF. BUT I JUST BROUGHT THE CAR AND THE DODGE COMPAN…

Read full complaint

DRIVING TO GET ON HIGHWAY AND GOT A MESSAGE ON MY CAR DASHBOARD SAYING IM IN BATTERY SAVE MODE. SO GOT MY SPEED UP TO ABOUT 70 AND MY CAR LIGHT AND POWER STEERING AND WINDSHIELD WIPER CAME ON. MY POWER STEERING LOCKED UP ON THE HIGHWAY THINK GOD I WAS ON THE HIGHWAY SIMI BY MYSELF. BUT I JUST BROUGHT THE CAR AND THE DODGE COMPANY IS CHARGE EVERYONE WHO HAS THIS PROBLEM WITH THIS PARTICULAR CAR 800 DOLLARS TO FIX EVEN THROUGH THESE ARE HORRIBLE ALTERNATORS AND THEY KNOW IT. READING ONLINE WHERE CARS ARE BURNING UP BECAUSE OF THIS PROBLEM AND THE DODGE COMPANY TELLS YOU EVERYTHING IS FINE AND ITS NOT BUT THIS CAR REALLY NEED TO BE INVESTIGATED ABOUT THEIR HORRIBLE ALTERNATORS AND THE CONSEQUENCES WHEN THIS PROBLEM OCCURS. FOR SOME IS IT NOT PRETTY AND ITS UNSAFE WHEN YOU SEE BATTERY SAVE MODE BECAUSE YOU DON'T KNOW HOLE LONG BEFORE YOUR CAR BURN UP AND NOT TRYING TO GET TO THAT POINT. THIS IS REALLY MAKE ME REGRET A DODGE PRODUCT AFTER THIS THANKS. *TR

NHTSA ODI #10632353

43,000 miles · Sep 9, 2014
Electrical System

MY SON WAS DRIVING HIS 2011 DODGE CHARGER BACK TO CAMPUS WHEN THE BATTERY SAVER MODE CAME ON AND THERE WAS AN ELECTRICAL FIRE SMELL. HE PARKED IT AND THE NEXT MORNING WHEN THE TOW TRUCK CAME TO TOW IT, HE HAD TO MANUALLY UNLOCK THE DOORS AS THE WHOLE SYSTEM SHUT DOWN, THE DEALERSHIP CONFIRMED IT WAS AN ALTERNATOR PROBLEM AND I…

Read full complaint

MY SON WAS DRIVING HIS 2011 DODGE CHARGER BACK TO CAMPUS WHEN THE BATTERY SAVER MODE CAME ON AND THERE WAS AN ELECTRICAL FIRE SMELL. HE PARKED IT AND THE NEXT MORNING WHEN THE TOW TRUCK CAME TO TOW IT, HE HAD TO MANUALLY UNLOCK THE DOORS AS THE WHOLE SYSTEM SHUT DOWN, THE DEALERSHIP CONFIRMED IT WAS AN ALTERNATOR PROBLEM AND IT WOULD BE $800.00 TO REPLACE IT. *TR

NHTSA ODI #10632009

38,600 miles · Sep 8, 2014
Electrical SystemEngine

I GOT THE "BATTERY SAVER MODE" WARNING ON MY CAR. I LOOKED IT UP ON THE INTERNET AND A LOT OF PEOPLE WERE COMPLAINING ABOUT DODGE CHARGERS AND THERE ALTERNATORS. THE NEXT MORNING I CALLED THE DEALER SHIP TO SEE WHAT THEY THINK IT IS AND IF I CAN GET IN SO THEY CAN LOOK AT THE CAR, THEY ALSO SAID IT COULD BE THE ALTERNATOR BUT CO…

Read full complaint

I GOT THE "BATTERY SAVER MODE" WARNING ON MY CAR. I LOOKED IT UP ON THE INTERNET AND A LOT OF PEOPLE WERE COMPLAINING ABOUT DODGE CHARGERS AND THERE ALTERNATORS. THE NEXT MORNING I CALLED THE DEALER SHIP TO SEE WHAT THEY THINK IT IS AND IF I CAN GET IN SO THEY CAN LOOK AT THE CAR, THEY ALSO SAID IT COULD BE THE ALTERNATOR BUT COULD NOT GET ME IN UNTIL THE NEXT MORNING BUT SAID IT SHOULD BE SAFE TO DRIVE. THEY LOOK UP MY WARRANTY AND IT WAS OUT OF WARRANTY FOR THE ALTERNATOR...I ONLY HAVE 38,600 MILES ON MY CAR!! I SHOULD NOT BE DEALING WITH THING LIKE THIS ON A 3 YEAR OLD CAR! LUCKILY I BOUGHT A PORTFOLIO WARRANTY THAT COVERS IT BUT WITH $100 DEDUCTIBLE BUT THE CATCH IS I HAVE TO GO TO THE DEALER WHERE I BOUGHT IT FROM! WHEN THERE IS A DEALER 2 MILES FROM WHERE I AM AND THE ONE I BOUGHT IT FROM IS ABOUT 25 MINUTES AWAY. SO I MAKE THE APPOINTMENT AND GO TO WORK, BY THE TIME I GET TO WORK MY RADIO STOPPED WORKING AND ABS LIGHT TURNED ON. I PARKED AND SMOKE WAS COMING FROM THE ALTERNATOR! I CALLED THE DEALER BACK AND TOLD THEM WHAT HAPPEN, THEY SAID I CAN BRING IT IN NOW AND LEAVE IT THERE AND THEY WILL LOOK AT IT THE NEXT DAY. SO I HAVE TO LEAVE WORK TO TAKE THE CAR THERE AND THE CAR COMPLETELY DIES ON THE WAY THERE! I HAD TO CALL A TOW TRUCK AND GET IT TOWED ALL THE WAY TO THE DEALER. THEY WERE ABLE TO REPLACE THE ALTERNATOR BY THE MIDDLE OF THE NEXT DAY. BUT I HAVE NOW HAD THE CAR FOR 2 WHOLE DAYS AND THE BATTERY SAVER MODE JUST TURNED ON AGAIN!!!!! SO NOW IN THE MORNING I'M GOING TO HAVE TO CALL THE DEALER AGAIN AND SEE WHAT TO DO NOW! REPLACE ANOTHER ALTERNATOR!?!?!?!? THIS HAS TO BE A RECALL!! THERE SHOULD NOT BE ANY OF THESE PROBLEMS ON A CAR THAT IS 3 YEARS OLD AND HAS LESS THEN 40,000 MILES!!! THIS IS RIDICULOUS AND I'M SERIOUSLY LOOKING AT OTHER CARS TO TRADE IN FOR NOW! I AM NEVER BUYING DODGE AGAIN!! OH AND THE DEALER WOULDN'T GIVE ME A LOANER CAR FOR FREE! *TR

NHTSA ODI #10631420

67,000 miles · Sep 7, 2014
Electrical System

DROVE UP TO A TRANSMOUNTAIN REST STOP TO ENJOY THE VIEW, START SMELLING AN ELECTRICAL BURNING SMELL OTHER CARS WERE THERE SO I DIDN'T THINK IT WOULD BE A CAR I HAVE ONLY HAD FOR A YEAR (3 YEAR OLD CAR)..HOUR LATER I GO BACK TO MY CAR TO LEAVE AND WHEN I PRESS THE BUTTON TO START, ALL I HEAR IS A CLICK THEN SILENCE, NOTHING IS ON…

Read full complaint

DROVE UP TO A TRANSMOUNTAIN REST STOP TO ENJOY THE VIEW, START SMELLING AN ELECTRICAL BURNING SMELL OTHER CARS WERE THERE SO I DIDN'T THINK IT WOULD BE A CAR I HAVE ONLY HAD FOR A YEAR (3 YEAR OLD CAR)..HOUR LATER I GO BACK TO MY CAR TO LEAVE AND WHEN I PRESS THE BUTTON TO START, ALL I HEAR IS A CLICK THEN SILENCE, NOTHING IS ON SO I TRY AGAIN AND ONCE AGAIN NOTHING..GOT OUT AND POPPED MY HOOD OPEN AND THERE I SAW MY ALTERNATOR ALL FRIED UP AND SMOKING, NO LONGER COVERED IN WARRANTY SO IT COST ME $700 TO REPLACE THE ALTERNATOR AND THE BATTERY IT KILLED WHEN IT FRIED. *TR

NHTSA ODI #10631365

Official recalls

11

19V018000 · Air Bags:frontal:passenger Side:inflator Module

Jan 15, 2019

Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.

18V021000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

17V435000 · Electrical System:alternator/generator/regulator

Jul 10, 2017

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.

16V352000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence & remedy

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

16V043000 · Structure

Jan 28, 2016

FCA US LLC (Chrysler) is recalling certain model year 2011-2016 Dodge Charger vehicles manufactured August 23, 2010, to January 7, 2016. When an affected vehicle is lifted using the supplied tire jack without chocking the wheels, the vehicle's body-side sill may give causing the tire jack to fail and the car to fall.

Consequence & remedy

Consequence: A car that falls unexpectedly increases the risk of injury.

Remedy: Chrysler will notify owners, and dealers will provide owners with wheel chocks and instructions for their use, free of charge. The recall began on March 21, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S03.

15V467000 · Air Bags:side/window; Seat Belts

Jul 27, 2015

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence & remedy

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

Additional source detail variants (2)

Seat Belts

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

Air Bags:side/window

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.

14V634000 · Electrical System:alternator/generator/regulator

Oct 8, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

14V101000 · Exterior Lighting:headlights

Mar 4, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Dodge Charger vehicles manufactured May 20, 2010, through November 8, 2011, and equipped with halogen headlamps. In the affected vehicles, a sub-harness for the headlights may overheat and cause the low beam headlights to go out.

Consequence & remedy

Consequence: Loss of headlights reduces the driver's visibility, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the headlamp jumper harnesses and bulbs, or the headlamp assemblies, as necessary, free of charge. The recall began on May 2, 2014. Owners may contract Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P08. This recall concerns non-police vehicles. A separate campaign was launched in 2012 to address police vehicles. See NHTSA recall 12V-042.

13V118000 · Air Bags

Apr 3, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Chrysler 300, Dodge Challenger, and Dodge Charger vehicles manufactured April 11, 2011, through December 14, 2011. The affected vehicles may have improperly sized terminal crimps on the seat side-airbag wiring harness which may cause the seat side-airbags to malfunction and illuminate the airbag warning light.

Consequence & remedy

Consequence: In the event of a crash necessitating airbag deployment the airbags may not operate as designed, increasing the risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace both driver and passenger seat airbag wiring harnesses, free of charge. The recall began on April 22, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N07.

12V197000 · Electrical System:wiring:fuses And Circuit Breakers; Service Brakes, Air:antilock:control Unit/module

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence & remedy

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Additional source detail variants (2)

Electrical System:wiring:fuses And Circuit Breakers

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Service Brakes, Air:antilock:control Unit/module

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V042000 · Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting:headlights; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 7, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence & remedy

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Additional source detail variants (4)

Electrical System:wiring:fuses And Circuit Breakers

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Exterior Lighting:headlights

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Electrical System:wiring

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

PE14022 · Alternator Failure

Opened Jul 22, 2014 · Closed Nov 6, 2014

Status: closed (inferred from source dates) · Electrical System:alternator/generator/regulator

On July 22, 2014, the Office of Defects Investigation (ODI) opened PE14-022 to investigate 14 complaints (VOQs) alleging incidents of alternator failure resulting in engine stall while driving in model year (MY) 2011 through 2012 Dodge Charger vehicles.The MY 2011 through 2012 Dodge Charger vehicles were sold with three different engine options:1) 3.6L V6 (VIN8 = G), 88,766 vehicles; 2) 5.7L V8 (VIN8 = T), 38,615 vehicles; and 3) 6.4L V8 (VIN8 = J), 2,406 MY 2012 vehicles.The 14 VOQs identified in the PE14-022 opening resume involve 13 vehicles with 3.6L V6 engines and 1 vehicle with unknown engine (no VIN provided).In an October 7, 2014 letter to NHTSA, Chrysler described a safety defect condition that could result in rapid alternator failure having limited or no detection in approximately 434,581 MY 2011 through 2014 Chrysler 300, Dodge Charger, Dodge Challenger, Dodge Durango and Jeep Grand Cherokee vehicles equipped with 3.6L engines and 160 amp alternators (NHTSA Recall No. 14V-634, Chrysler P60).The subject alternators are used in vehicles equipped with 3.6L V6 engines and without towing packages.According to Chrysler, the silicone diodes in the alternator rectifier bridge may experience thermal fatigue due to cyclic loading from the Electric Hydraulic Power Steering (EHPS) system, eventually resulting in no output, reduced output, or a fully shorted to ground condition.These failure modes vary in their time to failure and warning to the driver.Depending on the failure mode and timing, system voltage may drop to critically low levels, disabling systems such as the Anti-lock Brake System/Electronic Stability Control, Engine Control Module/Central Body Controller, or a total vehicle electrical system shut down (in the event of a short to ground failure mode).Analysis of complaints to ODI and Chrysler identified a total of 146 incidents of alternator failure resulting in engine stall while driving in MY 2011 through 2012 Dodge Charger vehicles, including 142 involving vehicles equipped with the 3.6L V6 engines (1.6 IPTV) that were included in 14V-634 and 4 involving vehicles with 5.7L V8 engines (0.1 IPTV), which are equipped with different alternators.Analysis of all alternator failure complaints found that approximately 48 percent of VOQs and 21 percent of Chrysler complaints involved allegations of engine stall.Many (98) complaints reported fire and/or smoke, but analysis of these determined that they involved thermal damage to the alternator diode and did not identify any incidents involving damage beyond the alternator assembly.One VOQ identified in the opening resume for PE14-022 alleged a crash, but further evaluation determined that this involved a minor rear-end impact with slight bumper damage.This investigation is closed based on Chrysler's decision to conduct a safety recall.The VOQs associated with this investigation are:10641479,10641366,10641349,10642017,10640770,10640687,10640553,10639692,10638810,10638356,10638175,10638143,10637460,10633806,10633304,10632943,10632006,10631704,10631613,10631420,10631088,10630991,10630854,10630844,10630108,10629623,10629603,10628228,10628150,10627941,10627342,10626452,10626254,10625962,10622385,10622340,10621603,10620961,10619481,10618950,10618948,10618539,10618476,10618334,10618081,10618107,10616834,10616461,10616456,10615754,10615719,10606580,10605090,10604958,10597295,10592085,10588675,10587141,10562463,10559730,10511407