← New search

2018 Dodge Challenger

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2018 Dodge Challenger do not stand out strongly from the model-year median of 45.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Challenger years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

35 reports with mileage · 40 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Steering. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports2 fire reports5 injury reports

What owners actually said

75 reports
25,000 miles · Jan 22, 2021
Power TrainUnknown Or Other

MANUAL TRANSMISSION GEAR SHIFTER GETS STUCK IN GEAR AND WILL NOT SHIFT OUT OF GEAR WHILE MAKING GEAR SHIFT CHANGE STARTED HAPPENING AT 19000 MILES THEN AT 25000 MILES THE CLUTCH SHATTERED INTO A 100 PIECES MAKEING A LOUD BANG AND NONE STOP CHATTERING WHILE DRIVING IN 3RD GEAR AT 40MPH ON CITY STREET CAUSING COMPLETE CLUTCH FAILU…

Read full complaint

MANUAL TRANSMISSION GEAR SHIFTER GETS STUCK IN GEAR AND WILL NOT SHIFT OUT OF GEAR WHILE MAKING GEAR SHIFT CHANGE STARTED HAPPENING AT 19000 MILES THEN AT 25000 MILES THE CLUTCH SHATTERED INTO A 100 PIECES MAKEING A LOUD BANG AND NONE STOP CHATTERING WHILE DRIVING IN 3RD GEAR AT 40MPH ON CITY STREET CAUSING COMPLETE CLUTCH FAILURE AN UNABLE TO SHIFT INTO ANY GEAR AFTER THE CLUTCH FAILURE ONLY LEAVING NEUTRAL AVAILABLE. CAUSING ME TO HAVE TO QUICKLY COAST AND PULL OVER 3 LANES AND PARK BEFORE GETTING STUCK IN A MOVING LANE. DEALER WON'T COVER THE FAULTY SHATTERED CLUTCH UNDER ITS 36000 3 YEAR BUMPER TO BUMPER WARRANTY. SAYING IT'S NORMAL WEAR AND TEAR IF IT WAS NORMAL WEAR AND TEAR THE CLUTCH WOULD BE WORN AND INTACT AND SLIPPING NOT SHATTERED IN PIECES DUE TO THE SEVER FAILURE OF THE CLUTCH THE FLYWHEEL AND RELEASE THROW OUT BEARINGS WERE ALSO SEVERELY DAMAGED AND NEEDED REPLACING AS WELL

NHTSA ODI #11389347

40,000 miles · Dec 21, 2020
Electrical System

UNCONNECT SYSTEM CONSTANTLY SHUTS OFF DURING NORMAL OPERATION WHICH CAUSES ISSUES WITH NAVIGATION. THERE IS ALSO A SHORT OF SOME TYPE WITH THE ELECTRICAL SYSTEM WHICH CAUSES GLITCHES IN THE SPEEDOMETER/MAIN DISPLAY SYSTEM - IT FLICKERS AND THEN RESUMES TO NORMAL ON OCCASION DURING NORMAL OPERATIONS.

NHTSA ODI #11384380

50,000 miles · Dec 20, 2020
Unknown Or Other

THIS PERTAINS TO THE VEHICLES RADIO WERE THIS IS COMMON IN THE 8.4 TOUCH SCREEN WERE IT DEVELOPS BUBBLES IN THE SCREEN AND THE RADIO WILL INADVERTENTLY SELECT RANDOM TOUCH SCREEN SELECTIONS CAUSEING UNPREDICTABLE BEHAVIOR. THIS IS A DRIVER DISTRACTION AND SAFETY HAZARD.

NHTSA ODI #11384242

48,000 miles · Dec 9, 2020
Service BrakesVehicle Speed Control

TL* THE CONTACT OWNS A 2018 DODGE CHALLENGER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED UP TO 46 MPH WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE BRAKE PEDAL WAS DEPRESSED AND SLOWED THE VEHICLE AS DESIGNED. THE VEHICLE WAS TAKEN TO STAR DODGE CHRYSLER JEEP RAM (5101 S 1ST ST, ABILENE,…

Read full complaint

TL* THE CONTACT OWNS A 2018 DODGE CHALLENGER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED UP TO 46 MPH WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE BRAKE PEDAL WAS DEPRESSED AND SLOWED THE VEHICLE AS DESIGNED. THE VEHICLE WAS TAKEN TO STAR DODGE CHRYSLER JEEP RAM (5101 S 1ST ST, ABILENE, TX 79605 (325)-698-2222) WHERE IT REMAINED UNREPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 48,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #11382763

Mileage unknown · Oct 30, 2020
Electrical System

RADIO WILL NOT TURN ON. BLACK SCREEN.

NHTSA ODI #11372455

96 miles · Jul 17, 2020
Electronic Stability Control (esc)Service BrakesSteeringCrashInjury

I WAS IN THE CITY OF OLD SAN JUAN, IN MOTION DRIVING DOWN A TWO LANE STREET. I WAS IN A STRAIGHT WAY I HAD BEEN PRESSING THE BRAKE DOWN TO 55 MILES APPROACHING A A SLIGHT CURVE ( NOT EVEN HARD, THE CURVE ONLY DEVIATED FEW FEET TO A RIGHT AND THEN A COUPLE FEET TO LEFT, IN PR TRAVELING TO THE IN THE HISTORICAL AREA THERE IS A CEM…

Read full complaint

I WAS IN THE CITY OF OLD SAN JUAN, IN MOTION DRIVING DOWN A TWO LANE STREET. I WAS IN A STRAIGHT WAY I HAD BEEN PRESSING THE BRAKE DOWN TO 55 MILES APPROACHING A A SLIGHT CURVE ( NOT EVEN HARD, THE CURVE ONLY DEVIATED FEW FEET TO A RIGHT AND THEN A COUPLE FEET TO LEFT, IN PR TRAVELING TO THE IN THE HISTORICAL AREA THERE IS A CEMENT LIKE STRUCTURE NO MORE THAN 10 INCHES SERVING AS A BARRIER BETWEEN THE TWO CAR LANES AND THE BICYCLE PATH). AT THAT MOMENT I LOST CONTROL OF THE VEHICLE, BRAKES FELT WEIRD COMPLETELY PRESSING THEM DOWN, IN MOTION. WHEN I SLIGHTLY PUMP THE BRAKE AGAIN GOING TOWARD A FULL PRESS THE BRAKE AND WHEELS DIDN'T RESPOND. I TRIED GETTING CONTROL AND AS I LEFT THE LAST CORNER AND STEER I LOST CONTROL HITTING THE BARRIER. MY FRONT TIRE WENT OFF!! ROLLED DOWN HILL. AFTER THAT MY CAR GOT SCRATCH AT THE BOTTOM DRIVING ON MY BRAKE PAD. I BOUGHT THE CAR THE SAME DAY!!!!! I CAN'T STRESS ENOUGH THE SITUATION. I USED TO DRIVE OLDER MODELS AND I'VE NEVER HAD THIS ENCOUNTER. THE STREET THAT IT HAPPEN WAS ASPHALT. THE DEALER AND BANK I GOT MY LOAN, DENIED MY CIVIL CODE RIGHTS, HAD TO GO THROUGH THE INSURANCE. I DIDN'T SIGN THE DOCUMENT STATING I GAVE THE RIGHTS TO THE CAR. THE DEALER INDEPENDENT DODGE DEALER TOOK BACK THE CAR AND NEVER COMPENSATED ME NOR DEALT WITH ME AGAIN. THEY NEVER GAVE ME AN ALTERNATE VEHICLE FOR MY TROUBLE WHILE I FIXED THE PROBLEM. THEY NEVER CALLED BACK! I TRIED GETTING A GOOD LAWYER BUT AFTER THEY TESTED WHAT HAPPEN IN THE BLACK BOX THEY GOT TO THE CONCLUSION I WAS 40 MPH, 5 SECONDS, PRIOR TO THE MOMENT THE INCIDENT TOOK PLACE, SO I WASN'T GOING THAT FAST PUSHING MY BRAKES LOSING CONTROL FROM THE LEFT LANE TOWARDS THE CONCRETE I COULDN'T GET A LAWYER IN PUERTO RICO. I FELT THEY STOLE MY HARD EARNED MONEY, $5,000 I PAID UPFRONT, PLUS THE LOAN AND PLUS THE INSURANCE MONEY AND THE LAWYER I HAD TO PAY FOR THE AGGRAVATION.

NHTSA ODI #11339855

99,559 miles · May 26, 2020
Unknown Or Other

TL* THE CONTACT OWNS A 2018 DODGE CHALLENGER. THE CONTACT STATED THAT THE GEAR SHIFTER WAS PLACED IN THE PARK POSITION HOWEVER, THE VEHICLE STARTED TO ROLLAWAY AFTER THE BRAKE PEDAL WAS RELEASED. THE CONTACT ACTIVATED THE PARKING BRAKE TO STOP THE VEHICLE FROM ROLLING. ADDITIONALLY, WHILE DRIVING AT VARIOUS SPEEDS, THE TRANSMISS…

Read full complaint

TL* THE CONTACT OWNS A 2018 DODGE CHALLENGER. THE CONTACT STATED THAT THE GEAR SHIFTER WAS PLACED IN THE PARK POSITION HOWEVER, THE VEHICLE STARTED TO ROLLAWAY AFTER THE BRAKE PEDAL WAS RELEASED. THE CONTACT ACTIVATED THE PARKING BRAKE TO STOP THE VEHICLE FROM ROLLING. ADDITIONALLY, WHILE DRIVING AT VARIOUS SPEEDS, THE TRANSMISSION EXPERIENCED HARD SHIFTS BETWEEN GEARS. STARR MOTORS, INC. (2584 PRUDEN BLVD, SUFFOLK, VA 23434, (757)539-0214) WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 99,559.

NHTSA ODI #11325948

27,071 miles · Apr 6, 2020
Wheels

TL* THE CONTACT'S SON OWNS A 2018 DODGE CHALLENGER. THE CONTACT STATED WHILE DRIVING AT AN UNKNOWN SPEED, THE DRIVER'S SIDE WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE…

Read full complaint

TL* THE CONTACT'S SON OWNS A 2018 DODGE CHALLENGER. THE CONTACT STATED WHILE DRIVING AT AN UNKNOWN SPEED, THE DRIVER'S SIDE WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 27,071.*DT*JB*DT*JB*DT*TP

NHTSA ODI #11320319

1,000 miles · Nov 21, 2019
Electrical System

THIS HAS BEEN GOING ON FOR A YEAR NOW AND STARTED THE 2ND MONTH I BOUGHT THE CAR. WHAT WILL HAPPEN IS 1 TO 2 TIMES A WEEK THE UCONNECT 8.4C NAVIGATION SCREEN WILL FREEZE ON THE SCREEN IT STARTED UP ON AND CAN NOT BE CHANGE. YOU CAN MAKE SELECTIONS ON THE SCREEN ITS STUCK ON, BUT WHEN YOU NEED TO WITH GO TO ANOTHER PAGE YOU CANT.…

Read full complaint

THIS HAS BEEN GOING ON FOR A YEAR NOW AND STARTED THE 2ND MONTH I BOUGHT THE CAR. WHAT WILL HAPPEN IS 1 TO 2 TIMES A WEEK THE UCONNECT 8.4C NAVIGATION SCREEN WILL FREEZE ON THE SCREEN IT STARTED UP ON AND CAN NOT BE CHANGE. YOU CAN MAKE SELECTIONS ON THE SCREEN ITS STUCK ON, BUT WHEN YOU NEED TO WITH GO TO ANOTHER PAGE YOU CANT. YOU MUST PUT THE CAR IN NEUTRAL AND TURN IT OFF THEN BACK ON TO GET THE SYSTEM TO WORK PROPERLY. I LET THE DEALER KNOW DURING AN OIL CHANGE AND THEY SAID THEY WHERE NOT ABLE TO DUPLICATE THE ISSUES. I THEN TOOK THE CAR IN 3 MONTHS LATER AND AGAIN THEY COULD NOT DUPLICATE THE ISSUE. WHEN I ASKED FOR RECORDS OF MY COMPLAINT AND THE CAR IN THE SHOP THEY SAID THEY COULD NOT FIND THEM. I WILL BE TAKING THE CAR TO ANOTHER DEALER AS THE ONE I WAS GOING TO IS HORRIBLE. ALSO THE ISSUE HAPPENS AT ANYTIME I COULD BE STATIONARY, OR DRIVING, WHEN DRIVING IT BECOMES A SAFETY ISSUE AS I TURN OFF AND BACK ON THE CAR WHILE IN MOTION

NHTSA ODI #11281483

27,000 miles · Nov 18, 2019
SeatsWheels

MY FRONT DRIVER SIDE TIRE KEEPS LOSING AIR SO I TRY TO GET MY TIRE FIXED, COME TO FIND OUT THAT MY RIM HAS A SMALL CRACK. I'VE NEVER EXPERIENCED A CRACKED RIM ON A LESS THAN 2 YEAR OLD CAR. IT PICKS AND CHOOSES WHEN IT WANTS TO KEEP AIR WHICH IS NOT SAFE AND THESE RIMS COST WAY TOO MUCH. ALSO MY DRIVER SEAT HAS A SQUEAKING NOIS…

Read full complaint

MY FRONT DRIVER SIDE TIRE KEEPS LOSING AIR SO I TRY TO GET MY TIRE FIXED, COME TO FIND OUT THAT MY RIM HAS A SMALL CRACK. I'VE NEVER EXPERIENCED A CRACKED RIM ON A LESS THAN 2 YEAR OLD CAR. IT PICKS AND CHOOSES WHEN IT WANTS TO KEEP AIR WHICH IS NOT SAFE AND THESE RIMS COST WAY TOO MUCH. ALSO MY DRIVER SEAT HAS A SQUEAKING NOISE WHICH IS IRRITATING, IT HAPPENED WHEN I WAS DRIVING ON THE HIGHWAY AROUND 60 WHEN I CAME ACROSS A DIP IN THE ROAD WHICH CAUSED ME TO BOUNCE UP SLIGHTLY. IT PERIODICALLY SQUEAKS.

NHTSA ODI #11280853

Official recalls

3

18V524000 · Electrical System:wiring:front Underhood

Aug 9, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Consequence & remedy

Consequence: A vehicle stall can increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Electrical System:wiring

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

18V280000 · Power Train:automatic Transmission

May 1, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Dodge Charger, Durango and Challenger, Jeep Grand Cherokee and Wrangler, Chrysler 300, and RAM 1500 vehicles. An incorrect transmission park lock rod may have been installed in the transmission.

Consequence & remedy

Consequence: If the incorrect park lock rod is installed, the transmission may not shift into 'PARK' and keep the vehicle from moving, increasing the risk of unintended vehicle movement and the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will install the correct park lock rod, free of charge. The recall began June 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U43.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.