← New search

2012 Dodge Challenger

Owner reports · Recalls · Investigations

More warning signs than most Challenger years

Owner complaints for the 2012 Dodge Challenger are substantially higher than the model-year median of 45.

About this comparison →

When problems were reported

Mileage at the reported incident

189 reports with mileage · 64 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 138 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports8 fire reports7 injury reports

Unknown Or Other complaints

20 reports
Clear category filter
48,699 miles · Mar 30, 2018
Latches/locks/linkagesUnknown Or Other

TL* THE CONTACT OWNS A 2012 DODGE CHALLENGER. THE CONTACT STATED THAT THE DOOR LATCH ASSEMBLIES FOR BOTH DOORS BEGAN TO FAIL. THE VEHICLE WAS TAKEN TO I-5 CHRYSLER JEEP DODGE RAM FIAT (1560 NW STATE AVE, CHEHALIS, WA 98532) WHERE IT WAS DIAGNOSED THAT THE DOOR LATCH ASSEMBLY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE CHALLENGER. THE CONTACT STATED THAT THE DOOR LATCH ASSEMBLIES FOR BOTH DOORS BEGAN TO FAIL. THE VEHICLE WAS TAKEN TO I-5 CHRYSLER JEEP DODGE RAM FIAT (1560 NW STATE AVE, CHEHALIS, WA 98532) WHERE IT WAS DIAGNOSED THAT THE DOOR LATCH ASSEMBLY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 48,699.

NHTSA ODI #11082183

104,000 miles · Jul 7, 2017
Electrical SystemUnknown Or Other

SMART WINDOWS GO UP AND DOWN ON THEIR OWN RUNNING THE BATTERY DOWN.

NHTSA ODI #11003745

60,200 miles · Jun 13, 2017
Electrical SystemUnknown Or Other

DRIVER SIDE WINDOW GOES UP AND DOWN ABOUT EVERY 10-12 SECONDS WHEN I PARKED IN DRIVEWAY. CAR POWER IS OFF AND NO ONE IN CAR. STARTED WHERE DRIVER WINDOW WOULD NOT CLOSE ALL THE WAY WHEN DOOR SHUTS. LASTED ABOUT 10 DAYS. I DID NOT DRIVE IT AS I AM A DISABLED VET AND COULD NOT CLIMB OVER PASSENGER SEAT TO GET OUT, OR TO LET WINDOW…

Read full complaint

DRIVER SIDE WINDOW GOES UP AND DOWN ABOUT EVERY 10-12 SECONDS WHEN I PARKED IN DRIVEWAY. CAR POWER IS OFF AND NO ONE IN CAR. STARTED WHERE DRIVER WINDOW WOULD NOT CLOSE ALL THE WAY WHEN DOOR SHUTS. LASTED ABOUT 10 DAYS. I DID NOT DRIVE IT AS I AM A DISABLED VET AND COULD NOT CLIMB OVER PASSENGER SEAT TO GET OUT, OR TO LET WINDOW UP AFTER DOOR IS CLOSED. MOBILITY/FLEXIBILITY NOT GOOD. RAINY SEASON IN FLA. FINALLY DROVE IT, WINDOW BEGAN MAKING CLICKING SOUND. GOT HOME, GOT OUT OF CAR, CLOSED DOOR AND WINDOW BEGAN GOING UP AND DOWN. CAR PARKED WITH PLASTIC BAG OVER IT. HAD TO LEAVE WINDOW PARTIALLY DOWN TO PREVENT FURTHER ISSUES OR BATTERY TO DRAIN. NOW CAR NOT SECURE FROM THEFT AND INTERIOR DAMAGE. IN SEARCH ONLINE, THIS IS COMMON PROBLEM FOR 2012 CHALLENGER AND RECALL ISSUED FOR 2011 CHALLENGER FOR SAME/SIMILAR PROBLEM. PROBLEM IS WIDESPREAD AND DODGE ANSWER IS TAKE TO SERVICE CENTER. SERVICE CENTER CHARGES MIN. $140.00 JUST TO DIAGNOSE THEN I'M SURE REPAIR COST IS HIGH ALSO. ITS OBVIOUSLY A MANUFACTURER PROBLEM AND DODGE NEEDS TO OWN IT. I JUST HOPE MY CAR IS NOT RUINED FROM THE DAILY RAIN/CONSTANT BAD WEATHER OR STOLEN OR INSIDE DAMAGED. I DON'T UNDERSTAND WHY RECALL IS NOT FOR ALL VEHICLES EFFECTED BY THIS ISSUE. ITS OBVIOUS IT IS RELATED AND VERY COMMON. CAR HAS 60200 MILES. OF COURSE HAPPENED JUST AFTER WARRANTY EXPIRED. THIS IS AN ISSUE THAT NEEDS TO BE ADDRESSED AND FIXED ASAP. USE TO LOVE MY CAR, BUT NOW IT IS USELESS TO ME. BEEN INFORMED ALSO CAUSES BATTERY FAILURE. THAT'S NOT A GOOD THING TO HAPPEN WHILE DRIVING. PLEASE HELP. PLEASE LOOK INTO THE MANY COMPLAINTS AND ISSUE A RECALL. MAKE DODGE OWN THEIR FAULTS. SO NOW I'M PAYING FOR A $30,000 CAR I CANT DRIVE AND IS SITTING OUTSIDE WITH PLASTIC OVER IT.

NHTSA ODI #10995025

Mileage unknown · Mar 16, 2017
Unknown Or Other

"TAKATA RECALL" THE DRIVER WINDOW MOVES UP AND DOWN LIKE WHEN YOU OPEN THE DOOR BUT IT HAPPENED WHEN IGNITION IS OFF AND KEY IS OFF AND DRAIN BATTERY.

NHTSA ODI #10966318

129,500 miles · Feb 8, 2017
Unknown Or OtherCrash

I TIRED TO PUT THE CAR IN PARK AND GET OUT WHILE IT WAS RUNNING. BECAUSE OF THE SHIFTIER DESIGN IT WENT TO 'R' AND NOT PARK CAUSING THE CAR TO START REVERSING AS I WAS GETTING OUT. I WAS ABLE TO JUMP BACK IN AND HIT THE BREAKS BUT THE CAR DOOR HIT THE GARAGE WALL AND MESSED UP NOT ONLY MY CAR DOOR BUT THE WALL.

NHTSA ODI #10950381

50,000 miles · Apr 21, 2016
Electrical SystemElectronic Stability Control (esc)Unknown Or Other

DRIVING AND THE POWER SURGED, ALL LIGHTS CAME ON, NONE OF MY GAUGES WORKED AND STEERING FELT EXTREMELY LOOSE. HAVE BEEN WAITING SINCE LAST SUMMER TO GET THIS FIXED L. AND NOW TWO MONTHS SINCE IT FINALLY WENT SOUTH AND HAVE STILL BEEN WAITING. WONDERFUL JOB BY THE COMPANY.

NHTSA ODI #10860733

58,000 miles · Aug 17, 2015
Unknown Or Other

I WAS BACKING MY CAR OUT OF THE DRIVEWAY WHEN IT SUDDENLY SHUT DOWN. THE DODGE COMPANY SAID THERE WAS A RECALL ON THE ALTERNATOR AND IT NEEDS TO REPLACE. AFTER DOING THE REPLACEMENT THEY SAID MY BATTERY WAS ALSO NEEDED TO REPLACED BUT BECAUSE THERE IS A CHANCE THAT THE BATTERY DAMAGE WAS EITHER DONE BY USAGE OR BY THE ALTERNATOR…

Read full complaint

I WAS BACKING MY CAR OUT OF THE DRIVEWAY WHEN IT SUDDENLY SHUT DOWN. THE DODGE COMPANY SAID THERE WAS A RECALL ON THE ALTERNATOR AND IT NEEDS TO REPLACE. AFTER DOING THE REPLACEMENT THEY SAID MY BATTERY WAS ALSO NEEDED TO REPLACED BUT BECAUSE THERE IS A CHANCE THAT THE BATTERY DAMAGE WAS EITHER DONE BY USAGE OR BY THE ALTERNATOR THEY WILL NOT REPLACE THE BATTERY. THE MECHANIC AT DODGE DEALER SAID " THROUGH HIS EXPERIENCE THAT WHEN A ALTERNATOR CAN DAMAGE A BATTERY , THEY WILL NOT REPLACE THE BATTERY. THROUGH HIS 14 YEARS EXPERIENCE DODGE WILL NOT REPLACE THE BATTERY. "

NHTSA ODI #10749207

30,000 miles · Jun 15, 2015
Unknown Or Other

A 35 DOLLAR PART HAS MALFUNCTIONED OR BROKEN (AC/HVAC BLEND DOOR ACTUATOR). IT RESULTS IN AN 800 DOLLAR REPAIR. THE VEHICLE HAD JUST PASSED THE 36 MONTH WARRANTY AND STILL HAS LESS THAN 36000 MILES TO DATE. IF YOU INVESTIGATE THIS PROBLEM IS WIDESPREAD AMONG MANY DODGE OWNERS. IT IS RIDICULOUS THAT THE QUALITY OF SAID PRODUCT IS…

Read full complaint

A 35 DOLLAR PART HAS MALFUNCTIONED OR BROKEN (AC/HVAC BLEND DOOR ACTUATOR). IT RESULTS IN AN 800 DOLLAR REPAIR. THE VEHICLE HAD JUST PASSED THE 36 MONTH WARRANTY AND STILL HAS LESS THAN 36000 MILES TO DATE. IF YOU INVESTIGATE THIS PROBLEM IS WIDESPREAD AMONG MANY DODGE OWNERS. IT IS RIDICULOUS THAT THE QUALITY OF SAID PRODUCT IS SO POOR CONSIDERING THE COST REQUIRED TO REPLACE IT.

NHTSA ODI #10725299

Mileage unknown · Jun 8, 2015
Unknown Or Other

2012 DODGE CHALLENGER. CONSUMER WRITES IN REGARDS TO PARTS NOT AVAILABLE TO COMPLETE RECALL NOTICE. *SMD

NHTSA ODI #10722976

Mileage unknown · Jan 14, 2015
Unknown Or Other

LETTER FROM SENATOR NELSON ON BEHALF OF CONSTITUENT REGARDING HIS 2012 DODGE CHALLENGER THAT STATES BAY DODGE DOESN'T KNOW ANYTHING ABOUT A RECALL AND WOULD LIKE FOR SOMEONE TO NOTIFY THEM; REF: (ATTN: JOSIAH MANZO) *TGW

NHTSA ODI #10671061

Official recalls

6

19V018000 · Air Bags:frontal:passenger Side:inflator Module

Jan 15, 2019

Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.

18V021000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

17V435000 · Electrical System:alternator/generator/regulator

Jul 10, 2017

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.

16V352000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence & remedy

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

14V634000 · Electrical System:alternator/generator/regulator

Oct 8, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

13V118000 · Air Bags

Apr 3, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Chrysler 300, Dodge Challenger, and Dodge Charger vehicles manufactured April 11, 2011, through December 14, 2011. The affected vehicles may have improperly sized terminal crimps on the seat side-airbag wiring harness which may cause the seat side-airbags to malfunction and illuminate the airbag warning light.

Consequence & remedy

Consequence: In the event of a crash necessitating airbag deployment the airbags may not operate as designed, increasing the risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace both driver and passenger seat airbag wiring harnesses, free of charge. The recall began on April 22, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N07.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.