Air Bags. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports4 fire reports6 injury reports

Engine And Engine Cooling complaints

13 reports

Clear category filter

15,481 miles · Feb 25, 2012

Engine And Engine CoolingPower Train

Read full complaint

OVERVIEW: MY 2009 DODGE CHALLENGER R/T, WITH THE 5.7L HEMI ENGINE AND MANUAL 6-SPEED TRANSMISSION, HAS AN EXCESSIVE DELAY BETWEEN PRESSING THE THROTTLE AND ACHIEVING ENGINE RESPONSE. THIS OCCURS ONLY IN GEARS 4-6, AND IS THE RESULT OF A POWERTRAIN CONTROL MODULE (PCM) UPDATE. BACKGROUND: THIS VEHICLE HAS AN ELECTRONIC THROTTLE ("DRIVE BY WIRE") SYSTEM, WHERE THROTTLE RESPONSE IS CONTROLLED BY THE PCM AND NOT VIA A THROTTLE CABLE. HISTORY: ON OCTOBER 14, 2011, I BROUGHT MY VEHICLE TO MY LOCAL DODGE/CHRYSLER DEALERSHIP DUE TO A ROUGH ENGINE IDLE. THEY INFORMED ME THAT A PCM UPDATE WAS AVAILABLE, BASED ON TECHNICAL SERVICE BULLETIN (TSB) 18-014-10. THIS UPDATE CHANGED THE ENGINE CALIBRATION ID FROM 05187899AE TO 05187899AG. EVER SINCE THIS UPDATE WAS PERFORMED, THE VEHICLE HAS A SIGNIFICANT (AND UNSAFE) THROTTLE DELAY WHILE IN GEARS 4-6. BASICALLY, WHEN THE THROTTLE IS DEPRESSED, IT TAKES ABOUT 2 SECONDS FOR THE ENGINE TO RESPOND. THIS HAS RESULTED IN SEVERAL NEAR-COLLISIONS, DURING TIMES WHERE ACCELERATION IS EXPECTED TO AVOID AN UNSAFE ROAD CONDITION BUT THE VEHICLE FAILS TO RESPOND IN A TIMELY MANNER. TO DEMONSTRATE THE PROBLEM, YOU COULD ACTUALLY RAPIDLY PULSE THE THROTTLE REPEATEDLY WITHOUT HAVING ANY ENGINE RESPONSE AT ALL. THIS ISSUE AFFECTS ALL OWNERS OF 2009-2010 DODGE CHALLENGER R/TS WITH THE 05187899AG CALIBRATION ID. AS OF THIS DATE, NO PCM UPDATE HAS BEEN RELEASED TO CORRECT THIS UNSAFE CONDITION. *TR

NHTSA ODI #10449347

28,000 miles · Sep 18, 2011

Electrical SystemEngine And Engine Cooling

Read full complaint

TOOK MY CAR INTO DEALERSHIP FOR WARRANTY WORK ON TRIM AND WINDOW SWITCH. CAR WAS FINE. HAD OWNED IT FOR 2.5 YEARS. DEALER PERFORMED FLASH ON PCM PER CHRYLSERS INFORMATION. WHEN I LEFT THE DEALER, I NOTECED A 1.5 SECOND DELAY WHEN GAS PEDEL IS DEPRESSED. FOUND OUT WHEN TRYING TO PASS SLOWER TRAFFIC. HUMAN NATURE CAUSES YOU TO PRESS IF MORE. THEN ALL OF THE SUDDEN, THE POWER COMES ON HARD. TOOK IT BACK, AND HAD CHRYLER TECH TEST DRIVE WITH SERVICE MGR. THEY SAW THE PROBLEM WITH THE SCAN TOOL HOOKED UP. WAS TOLD THAT THERE WAS A 1.4 SECOND DELAY. TECH SAID HE MADE CHANGES IN PROGRAM AND TOOK IT TO .7 SECONDS. I DO NOT SEE A DIFFERANCE IN PERFORMANCE. CALLED CONTACT AT CHRYSLER. AND WAS TOLD THAT IT FALLS WITHIN FACTORY STANDARDS. THERE IS NO WAY THIS IS RIGHT. CAR WAS FINE UNTILL THEY FLASHED IT. I AM UNABLE TO GET ANY PAPERWORK FROM CHRYSLER STATING THE PROBLEM IS NORMAL. THIS IS VERY DANGEROUS. AT 55 OR 70MPH 1.4 SECONDS CAN BE A LIFETIME. IF A TIME DELAY IS NORMAL FOR THE FLY BY WIRE SYSTEMS, THEN I AM GLAD I AM NOT A PILOT OF A FIGHTER AIRCRAFT OR NEW COMERCAL AIR LINER. *TT

NHTSA ODI #10425960

12,000 miles · Sep 18, 2011

Engine And Engine CoolingUnknown Or Other

VEHICLE HAS A SEVERE THROTTLE LAD WHEN IN 4 TO 6 GEAR WHEN LETTING OFF PEDAL THEN RETURNING BACK INTO THROTTLE. *TT

NHTSA ODI #10425957

5,605 miles · Aug 12, 2011

Engine And Engine Cooling

CAR PERIODICALLY STALLS WHEN COMING TO A STOP. DEALER DOES NOT KNOW THE CAUSE- MAY BE COMPUTER-RELATED. FRIENDS HAVING THE SAME DODGE VEHICLE HAVE HAD THEIR CAR STALL IN HEAVY HIGH SPEED TRAFFIC. THIS COULD CAUSE A SERIOUS OR FATAL CRASH.

NHTSA ODI #10420237

23,114 miles · Jul 23, 2011

Engine And Engine Cooling

WHILE DRIVING HOME FROM WORK COMING TO THE TURN AND SLOWING DOWN THE CAR LITERALLY JUST DIED WHILE ONCOMING TRAFFIC WAS COMING DOWN THE ROAD. ALL LIGHTS CAME ON AND CAR WAS DEAD. PUT IN PARK AND RESTARTED WITH NO CEL. DEALERSHIP HAS NO IDEA WHY ITS DOING THIS. *TR

NHTSA ODI #10414799

23,012 miles · Jul 23, 2011

Engine And Engine Cooling

2009 DODGE CHALLENGER RT AUTO, WHILE DRIVING ALONG AT HIGHWAY SPEED THE CAR LITERALLY JUST DIED, NO RIME OR REASON. PULLED OFF THE HIGHWAY AND RESTARTED THE CAR, CHECK ENGINE LIGHT CAME ON, WENT TO BOERNE DODGE AND THEY COULDN'T FIGURE OUT THE PROBLEM. SAID THE LIGHT JUST WENT AWAY. AND IF IT HAPPENS AGAIN TO BRING IT BACK. …

Read full complaint

NHTSA ODI #10414798

15,539 miles · Apr 1, 2011

Engine And Engine CoolingVehicle Speed Control

Read full complaint

THE DEALERSHIP FLASHED THE PCM AS DETAILED IN SERVICE BULLETIN 18-021-09 REV. A. IMMEDIATELY AFTER THAT I NOTICED AN INTERMITTENT THROTTLE LAG. WHEN PRESSING THE GAS PEDAL, THE CAR WILL WAIT 1/2 TO 3/4 SECOND, THEN THE ENGINE WILL RESPOND AND THE CAR WILL GO. MERGING INTO HIGHWAY TRAFFIC IS NOW DANGEROUS AS THE CAR WILL NOT ALWAYS RESPOND TO THE PEDAL INPUT. WHEN IT FINALLY DOES RESPOND THE CAR WILL SURGE FORWARD (SINCE I'M PUSHING DOWN MORE ON THE PEDAL TRYING TO GET THE CAR TO MOVE). THIS IS DANGEROUS AS THE REAR TIRES CAN LOSE TRACTION ON WET ROADS. THE DEALERSHIP HOOKED UP A PORTABLE DATA LOGGER AND ROAD TESTED THE VEHICLE. THEY WERE ABLE TO VERIFY THE COMPLAINT. THEY SENT THE RESULTS TO CHRYSLER'S ENGINEERS. THOSE ENGINEERS REVIEWED THE DATA AND SAID, "THE VEHICLE IS OPERATING AS DESIGNED, DELAY IS NORMAL, WE SEE NOTHING WRONG." I HAD THE CAR FOR 22 MONTHS PRIOR TO THIS UPDATE AND NEVER HAD THE PROBLEM BEFORE.

NHTSA ODI #10394926

7,000 miles · Nov 5, 2010

Engine And Engine Cooling

TL*THE CONTACT OWNS A 2009 DODGE CHALLENGER. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE VEHICLE STALLED. THE CONTACT PULLED OVER, RESTARTED THE VEHICLE AND DROVE TO THE LOCAL DEALER WHERE HE WAS TOLD THAT THE FAILURE COULD NOT BE DUPLICATED. THE FAILURE OCCURRED AGAIN. THE VEHICLEHAD NOT BEEN REPAIRED. THE FAILURE MILEAGE…

Read full complaint

NHTSA ODI #10364170

31,706 miles · Sep 28, 2010

Engine And Engine Cooling

Read full complaint

TL*THE CONTACT OWNS A 2009 DODGE CHALLENGER. THE CONTACT STATED THAT WHILE APPROACHING A STOP SIGN AT 25 MPH, THE VEHICLE SUDDENLY STALLED AND ALL THE LIGHTS ON THE INSTRUMENT PANEL FLASHED. THE CONTACT SHIFTED INTO PARK AND RESTARTED THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER BUT THE DEALER COULD NOT DUPLICATE THE FAILURE. THE FAILURE CONTINUED AND THE VEHICLE WAS TAKEN TO ANOTHER AUTHORIZED DEALER. THE DEALER WAS UNABLE TO LOCATE THE FAILURE BUT NOTICED THAT THERE WAS A KILL SWITCH. THE VEHICLE WAS TAKEN TO A THIRD DEALER WHO REMOVED THE ANTI THEFT DEVICE INSTALLED BY ANOTHER DEALER. THE FAILURE CONTINUED AND THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 31,706 AND THE CURRENT MILEAGE WAS APPROXIMATELY 33,000.

NHTSA ODI #10358048

1,200 miles · Sep 8, 2010

Engine And Engine Cooling

2009 DODGE CHALLENGER, COMPLETE ENGINE SHUTOFF AFTER DECELERATING. VERY DANGEROUS. BREAKS AND STEERING SHUT OFF. HAS HAPPENED 4 TIMES TO ME. THERE ARE DOZENS OF REPORTS OF THIS LOCATED HERE: HTTP://WWW.CHALLENGERTALK.COM/FORUMS/F36/ENGINE-STALLING-35997/. *TR

NHTSA ODI #10354485

Official recalls

18V021000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

17V824000 · Equipment

Dec 21, 2017

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence & remedy

Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

16V352000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence & remedy

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

15V444000 · Air Bags:frontal:driver Side:inflator Module

Jul 10, 2015

Chrysler (FCA US LLC) is recalling certain model year 2008-2010 Dodge Challenger vehicles manufactured September 19, 2007, to October 29, 2010. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began on November 17, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R37.

09V420000 · Wheels:lugs/nuts/bolts/studs

Oct 29, 2009

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2010 PASSENGER VEHICLES EQUIPPED WITH REAR WHEEL DRIVE. THESE VEHICLES MAY HAVE BEEN BUILT WITHOUT A FRONT WHEEL SPINDLE NUT.

Consequence & remedy

Consequence: WHILE DRIVING, A TIRE AND WHEEL SEPARATION COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE TIRE AND WHEEL ASSEMBLY AND IF FOUND WITHOUT A SPINDLE NUT IT WILL BE REPAIRED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 2, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-835-1403.

08V642000 · Tires:pressure Monitoring And Regulating Systems

Dec 5, 2008

CHRYSLER IS RECALLING 175 MY 2009 DODGE CHARGER, CHALLENGER, AND CHRYSLER 300 VEHICLES. THE TIRE PRESSURE MONITOR (TPM) SENSORS MAY NOT TRANSMIT THE ACTUAL TIRE PRESSURE. THIS COULD RESULT IN THE DRIVER NOT BEING AWARE OF LOW TIRE PRESSURE.

Consequence & remedy

Consequence: OPERATION OF THE VEHICLE WITH LOW TIRE PRESSURE COULD RESULT IN TIRE DAMAGE AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPLACE THE TPM SENSORS. THE RECALL IS EXPECTED TO BEGIN ON FEBRUARY 9, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

08V458000 · Power Train:automatic Transmission:park/neutral Start Interlock Switch

Sep 10, 2008

CHRYSLER IS RECALLING 6,636 MY 2008-2009 DODGE CHALLENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND "KEYLESS GO" OPTION. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PREVENTION." IF THE STOP/START BUTTON IS PRESSED AND HELD AND THE ENGINE TURNS OFF, THE ELECTRONIC KEY CODE IS REMOVED FROM THE VEHICLE. SINCE THIS CAN OCCUR IN A TRANSMISSION OR GEAR SELECTOR POSITION OTHER THAN "PARK," AND THE TRANSMISSION OR GEAR SELECTOR DOES NOT BECOME LOCKED IN "PARK" AS A DIRECT RESULT OF KEY REMOVAL, IT WAS DETERMINED THAT A NONCOMPLIANCE MAY EXIST.

Consequence & remedy

Consequence: THIS STANDARD SPECIFIES VEHICLE PERFORMANCE REQUIREMENTS INTENDED TO REDUCE THE INCIDENCE OF CRASHES RESULTING FROM THEFT AND ACCIDENTAL ROLLAWAY OF MOTOR VEHICLES.

Remedy: DEALERS WILL REPROGRAM THE WIRELESS IGNITION NODE MODULE SO THE ENGINE CAN ONLY BE TURNED OFF WHEN THE TRANSMISSION AND GEAR SELECTOR IS IN THE "PARK" POSITION. THE RECALL BEGAN ON SEPTEMBER 15, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

Air Bags:frontal:passenger Side:inflator Module