NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
41 reportsClear category filterMileage unknown · Mar 27, 2014
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
1991 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO ANTI LOCK BRAKE SYSTEM RECALL AND SEEKS REIMBURSEMENT FOR REPAIRS. *SMD THE CONSUMER STATED HE PAID FOR THE REPAIRS ON APRIL 20, 2006 AND WAS CHARGED $376.73, EVEN THOUGH A RECALL HAD BEEN ISSUED. THE CONSUMER EXPERIENCED ABS PROBLEMS AGAIN IN DECEMBER 2013. THE CONSUMER STAT…
Read full complaint
1991 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO ANTI LOCK BRAKE SYSTEM RECALL AND SEEKS REIMBURSEMENT FOR REPAIRS. *SMD THE CONSUMER STATED HE PAID FOR THE REPAIRS ON APRIL 20, 2006 AND WAS CHARGED $376.73, EVEN THOUGH A RECALL HAD BEEN ISSUED. THE CONSUMER EXPERIENCED ABS PROBLEMS AGAIN IN DECEMBER 2013. THE CONSUMER STATED THE RECALL LETTER STATED IF THE PROBLEM OCCURRED AGAIN, CHRYSLER WOULD COVER ANY REPAIRS. THE DEALER INFORMED THE CONSUMER, HE HAD TO PAY $112 FOR A DIAGNOSTIC TEST, TO SEE IF THE PROBLEM WOULD BE COVERED, UNDER THE RECALL. THE DEALER THEN INFORMED THE CONSUMER, THEY DIDN'T HAVE THE EQUIPMENT TO TEST HIS VEHICLE, DUE TO THE AGE. HOWEVER, A FEW DAYS LATER, THE DEALER INFORMED THE CONSUMER, THEY HAD THE EQUIPMENT, BUT IT WOULD COST $336. THE CONSUMER DECLINED THE TEST. ALSO, THE TRANSMISSION, STARTER, FUEL PUMP, IGNITION COIL BLOCKS , SERPENTINE BELT, PULLEYS, POWER STEERING PUMP, AND RADIATOR WERE ALL REPLACED. *JB UPDATED 04/16/14
NHTSA ODI #10574533
216,500 miles · Mar 10, 2004
Electrical SystemEngine And Engine Cooling
1991 DODGE CARAVAN 3.3 LITER ENGINE. PROBLEMS CAUSED BY OIL PAN CLEARANCE TO THE GROUND CAUSE POSSIBLE DAMAGE TO THE OIL PAN IN A BOTTOM OUT SITUATION IF THE DAMAGE GOES UNNOTICED IT COULD LEAD TO A POSSIBLE FIRE SITUATION DUE TO OIL DEPOSITS ON THE LOWER SIDE OF THE VAN . POSSIBLE SOLUTION TO THIS PROBLEM WOULD BE A MORE COMPAC…
Read full complaint
1991 DODGE CARAVAN 3.3 LITER ENGINE. PROBLEMS CAUSED BY OIL PAN CLEARANCE TO THE GROUND CAUSE POSSIBLE DAMAGE TO THE OIL PAN IN A BOTTOM OUT SITUATION IF THE DAMAGE GOES UNNOTICED IT COULD LEAD TO A POSSIBLE FIRE SITUATION DUE TO OIL DEPOSITS ON THE LOWER SIDE OF THE VAN . POSSIBLE SOLUTION TO THIS PROBLEM WOULD BE A MORE COMPACT OIL PAN THAT IS FARTHER FROM THE GROUND .THERE NOTED PROBLEMS WITH THIS MODEL CARAVAN INSUFFICIENT BACK UP LIGHTS CAUSE PROBLEMS BACKING UP THE VEHICLE IN THE EVENING HOURS IN LOW LIGHT SITUATIONS . BLINKER SWITCH FAILED DUE TO PORIS PLASTIC CAUSE THE BLINKER SWITCH TO BREAK OFF AT THE STEARING COLUM . OTHER COMPLAINTS : BOTH PASSANGER AND DRIVER SIDE DOORS WEAK HINGES CAUSE HAZARDUS SEPARATION OF THE HINDGE FROM THE DOOR ITSELF COULD CAUSE THE DOOR TO SIMPLY FALL OFF THE CAR .*AK
NHTSA ODI #10061875
216,500 miles · Mar 10, 2004
Electrical SystemEngine And Engine CoolingEquipment
1991 DODGE CARAVAN 3.3 LITER ENGINE PROBLEMS CAUSED BY OIL PAN CLEARANCE TO THE GROUND CAUSE POSSIBLE DAMAGE TO THE OIL PAN IN A BOTTOM OUT SITUATION IF THE DAMAGE GOES UNNOTICED IT COULD LEAD TO A POSSABLE FIRE SITUATION DUE TO OIL DEPOSITS ON THE LOWER SIDE OF THE VAN . POSSIBLE SOLUTION TO THIS PROBLEM WOULD BE A MORE COMPACT…
Read full complaint
1991 DODGE CARAVAN 3.3 LITER ENGINE PROBLEMS CAUSED BY OIL PAN CLEARANCE TO THE GROUND CAUSE POSSIBLE DAMAGE TO THE OIL PAN IN A BOTTOM OUT SITUATION IF THE DAMAGE GOES UNNOTICED IT COULD LEAD TO A POSSABLE FIRE SITUATION DUE TO OIL DEPOSITS ON THE LOWER SIDE OF THE VAN . POSSIBLE SOLUTION TO THIS PROBLEM WOULD BE A MORE COMPACT OIL PAN THAT IS FARTHER FROM THE GROUND . *AK OTHER NOTED PROBLEMS WITH THIS MODEL CARAVAN INSOFENT BACK UP LIGHTS CAUSE PROBLEMS BACKING UP THE VEICLE IN THE EVENING HOURS IN LOW LIGHT SITUATIONS . BLINKER SWITCH FAILER DUE TO PORIS PLASTIC CAUSE THE BLINKER SWITCH TO BREAK OFF AT THE STEARING COLUM . OTHER COMPLAINTS : BOTH PASSANGER AND DRIVER SIDE DOORS WEAK HINGES CAUSE HAZARDUS SEPARATION OF THE HINDGE FROM THE DOOR ITSELF COULD CAUSE THE DOOR TO SIMPLY FALL OFF THE CAR .
NHTSA ODI #10061874
Mileage unknown · May 27, 2003
Engine And Engine Cooling
WHILE DRIVING THROUGH WATER THE COLD AIR INTAKE TOOK IN WATER THAT WENT STRAIGHT TO THE ENGINE. AS A RESULT THE ENGINE CUT OUT SUDDENLY AND FAILED TO RESTART. *NLM. *AK
NHTSA ODI #10021643
Mileage unknown · Jan 18, 2002
Engine And Engine CoolingStructureVisibility
WHILE DRIVING, VENTILATION SYSTEM BLOWS OUT COLD AIR, AND HEAT GETS LUKE WARM. HEATER CORE AND THERMOSTAT HAVE BEEN REPLACED. *AK CONSUMER STATES THAT THE PINS ON THE DRIVER DOOR HINGES KEEP FALLING OFF. *JB
NHTSA ODI #8002504
Mileage unknown · Apr 16, 2001
Engine And Engine CoolingSteering
BOLT THAT HOLDS TENSIONER BROKE, CAUSING IT TO SEPARATE FROM VEHICLE, AND RESULTING IN LOSS OF POWER STEERING AND VEHICLE TO OVERHEAT. OWNER REPLACED THE PART THREE TIMES. *AK CONSUMER STATES THAT WEBSITE SHOWS THIS FAILURE HAPPENING FREQUENTLY. *SLC
NHTSA ODI #885942
Mileage unknown · Jan 19, 2001
Engine And Engine CoolingFire
WHILE TRAVELING DRIVER NOTICED SMOKE COMING FROM ENGINE. UPON VISUAL INSPECTION ENGINE WAS ENGULFED IN FLAMES. INSURENCE COMPANY TOTALED VEHICLE.*AK
NHTSA ODI #878589
Mileage unknown · Jul 17, 2000
Engine And Engine Cooling
INTERMITTENT STALLING AFTER WHICH IT SOMETIMES STARTS, SOMETIMES NOT. STALLS GOING DOWN THE ROAD, STALLS WAITING IN TRAFFIC, WON'T START AFTER SITTING FOR 1 HOUR BUT STARTS SOMETIMES AFTER SITTING FOR 2 MINUTES! RUNS ROUGH (IS NOT MISSING). REPLACED 4 O2 SENSORS, CAT, MUFFLER, OIL, ALL BELTS, BRAKES, DISTRIBUTOR CAP, SPART PL…
Read full complaint
INTERMITTENT STALLING AFTER WHICH IT SOMETIMES STARTS, SOMETIMES NOT. STALLS GOING DOWN THE ROAD, STALLS WAITING IN TRAFFIC, WON'T START AFTER SITTING FOR 1 HOUR BUT STARTS SOMETIMES AFTER SITTING FOR 2 MINUTES! RUNS ROUGH (IS NOT MISSING). REPLACED 4 O2 SENSORS, CAT, MUFFLER, OIL, ALL BELTS, BRAKES, DISTRIBUTOR CAP, SPART PLUGS. I HAVE HAD IT WITH THIS VAN MADE IN CANADA! THIS WAS A REPLACEMENT FOR THE 86 CARAVAN I HAD BUT LOST TO A DRUNK DRIVER! HELP!!!!!! *AK
NHTSA ODI #725575
Mileage unknown · Mar 29, 2000
Engine And Engine CoolingUnknown Or Other
DIGITAL SENSOR FAILURE FOR CRUISE CONTROL AND SPEEDOMETER, REPLACED AND WORKS FOR ONLY 8-9 MONTHS, BECOMES ERRATIC AND FINALLY STOPS WORKING. *MJS
NHTSA ODI #551595
Mileage unknown · Oct 26, 1999
Engine And Engine Cooling
VEHICLE WAS SMOKING WHITE SMOKE. WHEN CONSUMERTOOK VEHICLE FOR EMISSION TEST, IT DIDN'T PASS. MECHANIC TOLD CONSUMER THAT ENGINE HAS TO BE REBUILT, AND THE SEALS TO THE GASKET VALVE COVER HAVE TO BE REPLACED. *AK
NHTSA ODI #851849
NHTSA investigations
16RQ99004 · Rear Liftgate Support
Opened Apr 19, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991-1993 CHRYSLER MINIVANS IN PE 96-035 AND EA96-027.AT THE TIME OF CLOSING EA96-027 ON MAY 16, 1997, A SAFETY RELATED DEFECT TREND HAD NOT BEEN IDENTIFIED ON THE 1991 AND 1993 MODELS.SINCE THE CLOSING OF EA96-027, ODI HAS RECEIVED 34 COMPLAINTS OF REAR LIFTGATE SUPPORT ATTACHING BOLT FAILURES, INCLUDING TEN INJURIES, ON THE SUBJECET VEHICLES.IT IS RECOMMENDED THAT A RECALL QUERY BE OPENED TO DETERMINE THE SCOPE OF LIFTGATE SUPPORT FAILURES ON THE SUBJECT VEHICLES.CLOSING NOTE: ON JULY 19, 1999, DAMILERCHRYSLER AGREED TO RECALL 1991, 1993, AND 1994 MODEL YEAR VEHICLES TO REMEDY REAR LIFTGATE SUPPORTS; SAFETY RECALL 99V-213.IT IS RECOMMENDED THAT RQ99-004 BE CLOSED.
Additional source detail variants (2)
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991-1993 CHRYSLER MINIVANS IN PE 96-035 AND EA96-027.AT THE TIME OF CLOSING EA96-027 ON MAY 16, 1997, A SAFETY RELATED DEFECT TREND HAD NOT BEEN IDENTIFIED ON THE 1991 AND 1993 MODELS.SINCE THE CLOSING OF EA96-027, ODI HAS RECEIVED 34 COMPLAINTS OF REAR LIFTGATE SUPPORT ATTACHING BOLT FAILURES, INCLUDING TEN INJURIES, ON THE SUBJECET VEHICLES.IT IS RECOMMENDED THAT A RECALL QUERY BE OPENED TO DETERMINE THE SCOPE OF LIFTGATE SUPPORT FAILURES ON THE SUBJECT VEHICLES.CLOSING NOTE: ON JULY 19, 1999, DAMILERCHRYSLER AGREED TO RECALL 1991, 1993, AND 1994 MODEL YEAR VEHICLES TO REMEDY REAR LIFTGATE SUPPORTS; SAFETY RECALL 99V-213.IT IS RECOMMENDED THAT RQ99-004 BE CLOSED.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991-1993 CHRYSLER MINIVANS IN PE 96-035 AND EA96-027.AT THE TIME OF CLOSING EA96-027 ON MAY 16, 1997, A SAFETY RELATED DEFECT TREND HAD NOT BEEN IDENTIFIED ON THE 1991 AND 1993 MODELS.SINCE THE CLOSING OF EA96-027, ODI HAS RECEIVED 34 COMPLAINTS OF REAR LIFTGATE SUPPORT ATTACHING BOLT FAILURES, INCLUDING TEN INJURIES, ON THE SUBJECET VEHICLES.IT IS RECOMMENDED THAT A RECALL QUERY BE OPENED TO DETERMINE THE SCOPE OF LIFTGATE SUPPORT FAILURES ON THE SUBJECT VEHICLES.CLOSING NOTE: ON JULY 19, 1999, DAMILERCHRYSLER AGREED TO RECALL 1991, 1993, AND 1994 MODEL YEAR VEHICLES TO REMEDY REAR LIFTGATE SUPPORTS; SAFETY RECALL 99V-213.IT IS RECOMMENDED THAT RQ99-004 BE CLOSED.
EA97005 · Safety Belt Anchorage Failures
Opened Apr 10, 1997 · Closed Dec 23, 1997
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
There is no summary currently available
EA96027 · Alleged Rear Liftgate Support Failure
Opened Oct 31, 1996 · Closed May 16, 1997
Status: closed (inferred from source dates) · Structure
THE RETAINER BOLT OF THE REAR LIFTGATE SUPPORT CYLINDERS MAY SHEAR RESULTING IN SUDDEN COLLAPSE OF THE REAR HATCH DOOR.
EA96016 · Inconsistent Safety Belt Buckle
Opened Jun 28, 1996 · Closed Dec 17, 1997
Status: closed (inferred from source dates) · Seat Belts
safety belt buckle hosing slips down, pinching the red release button.owners report having trouble opening and closing them many allege belt unlatches while driving because of the release buttom
PE96036 · Throttle Will Not Return To The Position
Opened May 14, 1996 · Closed Oct 31, 1996
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
UNCONTROLLED ENGINE SPEED CONDITION RESULTS FRO THROTTLE SHAFT BINDING
PE96035 · Alleged Rear Liftgate Support Failure
Opened May 6, 1996 · Closed Oct 31, 1996
Status: closed (inferred from source dates) · Structure
THE RETAINER BOLT OF THE REAR LIFT GATE SUPPORT CYLINDERS MAY SHEER RESULTING IN THE SUDDEN COLLAPSE OF THE REAR HATCH DOOR.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA95029 · Steering Wheel Separation
Opened Sep 26, 1995 · Closed Nov 13, 1996
Status: closed (inferred from source dates) · Steering
AFTER AN EXTENSIVE INVESTIGATION AND ANALYSIS, CHRYSLER HAS IDENTIFIED THE DEFECT AS A FATIGUE FAILURE, ORIGINATION IN THE HEAT AFFECTED REGION OF THE PROJECTION WELDS OF THE STEERING WHEEL HUB TO STEERING WHEEL ARMATURE ATTACHMENT.THE HUB IS THE PORTION OF THE STEERING WHEEL ASSEMBLY THAT CONNECTS IT TO THE STEERING COLUMN SHAFT AND IS ATTACHED TO THE UNDERSIDE OF THE STEERING WHEEL ASSEMBLY BY 4 WELDS.IF CRACKS DEVELOP IN THE HEAT AFFECTED REGION OF THE WELDS AND PROPAGATE THROUGH THE STEERING WHEEL ARMATURE TO EACH OF THE WELDS, THE STEERING WHEEL CAN SEPARATE FROM THE HUB.THIS IS A SLOW PROGRESSIVE FAILURE WHICH NORMALLY OCCURS AT HIGH MILEAGE.IN SOME CASES COMPLAINANTS HAVE REPORTED A LOOSENESS OR WOBBLING OF THE STEERING WHEEL PRIOR TO SEPARATION.TO REMEDY THIS DEFECT, CHRYSLER WILL INSPECT THE STEERING WHEELS OF THE AFFECTED VEHICLES FOR CRACKS IN THE HUB AREA.IF ANY CRACKS ARE FOUND, THE STEERING WHEEL WILL BE REPLACED.ALL OTHER VEHICLES WILL HAVE REINFORCING PLATES INSTALLED WHICH WOULD PREVENT A STEERING WHEEL SEPARATION SHOULD CRACKING OCCUR.
EA94028 · Abs Braking System Fails
Opened Jul 29, 1994 · Closed Jun 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94024 · Abs Braking System Fails
Opened Mar 7, 1994 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.
PE93056 · Melted Throttle Cables
Opened Jun 9, 1993 · Closed Sep 14, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92053 · Window Shattering
Opened Jun 8, 1992 · Closed Oct 9, 1992
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE92028 · Safety Blt Anchorage Brks
Opened Mar 11, 1992 · Closed Jul 20, 1992
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
There is no summary currently available
PE91094 · Braking Performance Loss
Opened Jul 5, 1991 · Closed Nov 26, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ABS SYSTEM LEAKS ARE ALLEGED BY CONSUMERS WHICH RESULT IN COMPLETE BRAKEFAILURE. SEVERRE LEAKING OCCURS WHILE THE VEHICLE SITS FOR SEVERAL HOURSRESULTING IN COMPLETE LOSS OF FLUID. LEAKS ARE APPEARING IN BOTH THE HIGHAND LOW PRESSURE LINES POSSIBLY DUE TO A FAULTY SEAL OR COUPLING. ONECOMPLAINT ALLEGES FLUID BEING FORCED OUT OF BRAKE RESERVOIR WHEN ENGINE ISSTARTED, POSSIBLE POINTING TO A FAULTY CHECK VALVE IN THE ACCUMULATOR.
Additional source detail variants (2)
Service Brakes, Hydraulic
ABS SYSTEM LEAKS ARE ALLEGED BY CONSUMERS WHICH RESULT IN COMPLETE BRAKEFAILURE. SEVERRE LEAKING OCCURS WHILE THE VEHICLE SITS FOR SEVERAL HOURSRESULTING IN COMPLETE LOSS OF FLUID. LEAKS ARE APPEARING IN BOTH THE HIGHAND LOW PRESSURE LINES POSSIBLY DUE TO A FAULTY SEAL OR COUPLING. ONECOMPLAINT ALLEGES FLUID BEING FORCED OUT OF BRAKE RESERVOIR WHEN ENGINE ISSTARTED, POSSIBLE POINTING TO A FAULTY CHECK VALVE IN THE ACCUMULATOR.
Service Brakes, Hydraulic
ABS SYSTEM LEAKS ARE ALLEGED BY CONSUMERS WHICH RESULT IN COMPLETE BRAKEFAILURE. SEVERRE LEAKING OCCURS WHILE THE VEHICLE SITS FOR SEVERAL HOURSRESULTING IN COMPLETE LOSS OF FLUID. LEAKS ARE APPEARING IN BOTH THE HIGHAND LOW PRESSURE LINES POSSIBLY DUE TO A FAULTY SEAL OR COUPLING. ONECOMPLAINT ALLEGES FLUID BEING FORCED OUT OF BRAKE RESERVOIR WHEN ENGINE ISSTARTED, POSSIBLE POINTING TO A FAULTY CHECK VALVE IN THE ACCUMULATOR.
PE91093 · Abs Control Failure
Opened Jun 28, 1991 · Closed Oct 23, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration