IllustrationHEATER CORE IS BLOCKED WITH CASTING SAND FROM ENGINE MANUFACTURING PROCESS MAKING IT UNSAFE TO DRIVE DUE TO INOPERABLE DEFROST OR HEAT. WINDSHIELD ICED OVER WHILE DRIVING VEHICLE.
2012 Dodge Avenger
Owner reports · Recalls · Investigations
More warning signs than most Avenger years
Owner complaints for the 2012 Dodge Avenger are substantially higher than the model-year median of 157.
About this comparison →How this year compares
Owner complaints by model year
Compare all Avenger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
370–25K
7225–50K
10650–75K
8775–100K
74100–150K
15150K+
391 reports with mileage · 162 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports7 fire reports30 injury reports
What owners actually said
553 reportsI WAS ON A HILL ABOUT TO TURN ONTO THE FREEWAY WHEN MY VEHICLE TURNED OFF/STALLED. I WAS MOVING ABOUT 10 MILES PER HOUR AND WHEN I WENT TO TURN RIGHT I FOUND IT DIFFICULT TO MOVE THE STEERING WHEEL, AT WHICH POINT I REALIZED MY VEHICLE HAD STALLED. THIS IS THE THIRD TIME I HAVE HAD THIS ISSUE WITH MY VEHICLE WITHIN THE LAST YEAR…
Read full complaint
I WAS ON A HILL ABOUT TO TURN ONTO THE FREEWAY WHEN MY VEHICLE TURNED OFF/STALLED. I WAS MOVING ABOUT 10 MILES PER HOUR AND WHEN I WENT TO TURN RIGHT I FOUND IT DIFFICULT TO MOVE THE STEERING WHEEL, AT WHICH POINT I REALIZED MY VEHICLE HAD STALLED. THIS IS THE THIRD TIME I HAVE HAD THIS ISSUE WITH MY VEHICLE WITHIN THE LAST YEAR.
MY COOLING SYSTEM IS CONTAMINATED BY INFERIOR PRODUCTS MANUFACTURED WITHIN MY DODGE AVENGER. MATERIAL/S WITHIN THE COOLING SYSTEM FAIL AND CAUSE DEBRIS TO BUILD UP WITHIN THE ENTIRE COOLING SYSTEM. THIS MATERIAL/S IS A SANDY LIKE SUBSTANCE THAT BLOCKS CRITICAL COOLING AND HEATING COMPONENTS THAT HAS LEAD TO MAJOR FAILURES OF MY …
Read full complaint
MY COOLING SYSTEM IS CONTAMINATED BY INFERIOR PRODUCTS MANUFACTURED WITHIN MY DODGE AVENGER. MATERIAL/S WITHIN THE COOLING SYSTEM FAIL AND CAUSE DEBRIS TO BUILD UP WITHIN THE ENTIRE COOLING SYSTEM. THIS MATERIAL/S IS A SANDY LIKE SUBSTANCE THAT BLOCKS CRITICAL COOLING AND HEATING COMPONENTS THAT HAS LEAD TO MAJOR FAILURES OF MY HEATING SYSTEM VIA THE DEBRIS BLOCKING THE HEATER CORE FROM FUNCTIONING. I CERTAIN THAT THIS DEBRIS IS ALSO AFFECTING MY ENGINE'S COOLING FUNCTION.
TAKATA RECALL I HAVE A 2012 DODGE AVENGER R/T. LIKE MANY OTHER AVENGERS, THE HEAT ON THE PASSENGER SIDE OF MY VEHICLE STOPPED WORKING. I GET NOTHING BUT COLD AIR ON THE PASSENGER SIDE. I'VE DONE MY RESEARCH, AND THIS IS A MANAFACTURER DEFECT THAT RESULTS FROM BAD CASTING THAT CAUSES METAL FLAKES TO BREAK OFF AND FILL UP TH…
Read full complaint
TAKATA RECALL I HAVE A 2012 DODGE AVENGER R/T. LIKE MANY OTHER AVENGERS, THE HEAT ON THE PASSENGER SIDE OF MY VEHICLE STOPPED WORKING. I GET NOTHING BUT COLD AIR ON THE PASSENGER SIDE. I'VE DONE MY RESEARCH, AND THIS IS A MANAFACTURER DEFECT THAT RESULTS FROM BAD CASTING THAT CAUSES METAL FLAKES TO BREAK OFF AND FILL UP THE HEATER CORE UNTIL IT BECOMES SO CLOGGED THAT IT STOPS WORKING PROPERLY. A SIMPLE FLUSH WILL NOT DO THE JOB, AND THE HEATER CORE MUST BE REPLACED. THIS IS AN EXPENSIVE REPAIR. I HIGHLY BELIEVE THAT THIS SHOULD BE A RECALL, DUE TO THE FACT THAT VISIBILITY IS SEVERELY DECREASED IN WINTER ON THE RIGHT SIDE OF THE CAR. THIS NOT ONLY PUTS THE DRIVER AND PASSENGERS IN DANGER, BUT OTHER VEHICES AND PEDESTRIANS AS WELL.
TL* THE CONTACT OWNS A 2012 DODGE AVENGER. WHILE OPERATING THE VEHICLE, THE HEATER WOULD NOT OPERATE AND THE WINDOWS COULD NOT BE DEFROSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO FLUSHED THE HEATER CORE, BUT THE FAILURE CONTINUED. IN ADDITION, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHUT OFF. DURING THE FAILURE,…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE AVENGER. WHILE OPERATING THE VEHICLE, THE HEATER WOULD NOT OPERATE AND THE WINDOWS COULD NOT BE DEFROSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO FLUSHED THE HEATER CORE, BUT THE FAILURE CONTINUED. IN ADDITION, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHUT OFF. DURING THE FAILURE, THE ELECTRONIC THROTTLE AND ESP ACTIVATION MALFUNCTION INDICATORS ILLUMINATED. THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 107,000. *BF. CONSUMER STATED MANUFACTURER WAS NOTIFIED ON THE SAME DAY. *JB
HEATER CORE FAILURE. NOTICED THE 2012 DODGE AVENGER PASSENGER SIDE WAS NOT BLOWING HOT AIR. INSTEAD THE AIR WAS COMING OUT COLD NO MATTER HOW MUCH THE TEMPERATURE WAS ADJUSTED. EVEN AFTER DRIVING TO DESTINATIONS THE HEAT NEVER WORKED FO THE PASSENGER SIDE. ONLY THE DRIVER'S SIDE HOT AIR WORKS. TOOK IT TO A REPAIR SHOP AND THEY D…
Read full complaint
HEATER CORE FAILURE. NOTICED THE 2012 DODGE AVENGER PASSENGER SIDE WAS NOT BLOWING HOT AIR. INSTEAD THE AIR WAS COMING OUT COLD NO MATTER HOW MUCH THE TEMPERATURE WAS ADJUSTED. EVEN AFTER DRIVING TO DESTINATIONS THE HEAT NEVER WORKED FO THE PASSENGER SIDE. ONLY THE DRIVER'S SIDE HOT AIR WORKS. TOOK IT TO A REPAIR SHOP AND THEY DID A FLUSH 3 TIMES BECAUSE THEY SAID GUNK CAN SOMETIMES BUILD UP ON THOSE CARS IN PARTICULAR, HOWEVER IT DID NOT FIX THE PROBLEM. THEY INFORMED ME THAT IT WAS THE HEATER CORE THAT NEEDED TO BE REPAIRED. THE CAR ONLY HAS 63K MILES SO THIS IS NOT SOMETHING THAT A CAR WITH LOW MILEAGE SHOULD EXPERIENCE.
TAKATA RECALL THE DODGE AVENGER 2012 HAS MESSED UP HEATING SYSTEMS. THE LEFT DRIVERS SIDE IS HOT, THEN AS YOU GO TO THE PASSENGER SIDE IT IS ICE COLD. WHEN ON THE HIGHWAYS THE COLD DOESNT GO AWAY. IT STAYS COLD ON THE PASSENGER SIDE THE WHOLE TIME. THE HOTTEST ONE IS LEFT OF THE WHEEL. THEN RIGHT OF THE WHEEL IS LUKEWARM. THEN…
Read full complaint
TAKATA RECALL THE DODGE AVENGER 2012 HAS MESSED UP HEATING SYSTEMS. THE LEFT DRIVERS SIDE IS HOT, THEN AS YOU GO TO THE PASSENGER SIDE IT IS ICE COLD. WHEN ON THE HIGHWAYS THE COLD DOESNT GO AWAY. IT STAYS COLD ON THE PASSENGER SIDE THE WHOLE TIME. THE HOTTEST ONE IS LEFT OF THE WHEEL. THEN RIGHT OF THE WHEEL IS LUKEWARM. THEN PASSENGERS LEFT HEATER IS COLD AND PASSENGERS RIGHT HEATER IS FREEZING. DURING THE WINTER IT GETS TO BE -20 OUTSIDE. THERE IS NO WAY I AM ABLE TO DRIVE IN THAT SINCE MY CAR WONT HEAT UP CORRECTLY. NO AUTO SHOP IS ABLE TO FIX THE ISSUE. PLEASE ISSUE A RECALL SO WE ARE ABLE TO DRIVE IN COLD WEATHER AND HAVE OUR HEAT ON. PLEASE STABILIZE THE HEATING AND COOLING SYSTEM TO WHERE IT IS ALL EVEN FOR EVERY HEATER.
MY 2012 DODGE AVENGER CAUGHT FIRE UNDER THE HOOD WHILE I WAS DRIVING ON THE FWY. I COULD NOT STOP THE CAR BECAUSE THE BRAKE BECAME LOCKED IN PLACE AND I COULDNT PRESS IT DOWN WITH MY FOOT. THE EMERGENCY BRAKE DID NOT WORK. IT WAS UNSAFE TO GET OUT OF THE MOVING CAR, SO I WAS TRAPPED IN THE CAR AS THE FIRE UNDER THE HOOD GREW RAP…
Read full complaint
MY 2012 DODGE AVENGER CAUGHT FIRE UNDER THE HOOD WHILE I WAS DRIVING ON THE FWY. I COULD NOT STOP THE CAR BECAUSE THE BRAKE BECAME LOCKED IN PLACE AND I COULDNT PRESS IT DOWN WITH MY FOOT. THE EMERGENCY BRAKE DID NOT WORK. IT WAS UNSAFE TO GET OUT OF THE MOVING CAR, SO I WAS TRAPPED IN THE CAR AS THE FIRE UNDER THE HOOD GREW RAPIDLY. I WAS ABLE TO GET OFF AT THE NEXT EXIT AND WITH QUICK THINKING, I USED THE CURB AT THE END OF THE FWY OFF RAMP TO HELP ME STOP THE CAR. WHEN FIREFIGHTERS ARRIVED, THE ENTIRE FRONT END OF MY CAR WAS FULLY ENGULFED. FROM MY UNDERSTANDING, CHRYSLER/DODGE HAS HAD REAPEATED COMPLAINTS REGARDING SIMILAR INCIDENTS.
HEAT DOES NOT WORK ON THE PASSENGER SIDE OF THE CAR HAVE READ SEVERAL COMPLAINTS FROM NUMEROUS CUSTOMERS COMPLAINING OF THE SAME EXACT PROBLEM HE WORKS FINE ON THE DRIVER SIDE
COLD AIR BLOWING OUT OF PASSENGER SIDE VENTS, WHEN HEAT IS COMING OUT OF DRIVERS SIDE. I HAD THE THERMOSTAT REPLACED, THE RADIATOR FLUSHED, THE HEATER CORE CHECKED. I REPLACED THE HEATER BLEND DOOR ACTUATOR AND THE BLOWER MOTOR CONTROL MODULE AND RESISTER AND STILL HAVE COLD AIR COMING OUT OF THE VENTS.
Official recalls
317V640000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats:front Assembly:head Restraint
Oct 10, 2017
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence & remedy
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Additional source detail variants (2)
Seats:front Assembly:head Restraint
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
16V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
13V282000 · Air Bags; Electrical System
Jul 2, 2013
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence & remedy
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Additional source detail variants (2)
Air Bags
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Electrical System
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.