IllustrationWHEN I TURN ON HEAT OR AIR IT MAKE A ON GOING NOISE WHILE ON. WHEN AIR IS ON IT MAKES ONGOING NOISE AND LEAKS WATER UNDERNEATH GLOVE COMPARTMENT. *TR
2012 Dodge Avenger
Owner reports · Recalls · Investigations
More warning signs than most Avenger years
Owner complaints for the 2012 Dodge Avenger are substantially higher than the model-year median of 157.
About this comparison →How this year compares
Owner complaints by model year
Compare all Avenger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
370–25K
7225–50K
10650–75K
8775–100K
74100–150K
15150K+
391 reports with mileage · 162 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports7 fire reports30 injury reports
Structure complaints
20 reportsTL* THE CONTACT OWNS A 2012 DODGE AVENGER. UPON USING THE VENT CONTROLS FOR THE HEATER OR AIR CONDITIONER, A KNOCKING NOISE PROGRESSED NEAR THE AREA OF THE GLOVE COMPARTMENT. THE CONTACT ALSO INDICATED THAT WATER POURED IN EXCESS WHEN THE TRUNK WAS OPENED AND THAT THERE MAY BE A POTENTIAL LEAK WITHIN A SEAL. ALSO, THE FRONT PASS…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE AVENGER. UPON USING THE VENT CONTROLS FOR THE HEATER OR AIR CONDITIONER, A KNOCKING NOISE PROGRESSED NEAR THE AREA OF THE GLOVE COMPARTMENT. THE CONTACT ALSO INDICATED THAT WATER POURED IN EXCESS WHEN THE TRUNK WAS OPENED AND THAT THERE MAY BE A POTENTIAL LEAK WITHIN A SEAL. ALSO, THE FRONT PASSENGER SIDE DOOR HANDLE WAS DETERIORATING WITHOUT WARNING. THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V282000 (AIR BAGS, ELECTRICAL SYSTEM). THE DEALER WAS UNABLE TO DETERMINE WHEN THE PART WOULD BECOME AVAILABLE TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.
DRIVING HOME FROM WORK AT 5:40 PM, 3 DEER RAN OUT AND AFTER SLAMMING ON BRAKES THE LAST ONE WAS STRUCK, HEAD ON. THE HOOD BUCKLED AND THE ENTIRE ENGINE OF THE CAR IMPLODED IN FLAMES. NO AIRBAGS WENT OFF AND THE CAR IMMEDIATELY DIED. I WAS ABLE TO PULL CAR OVER TO THE SIDE OF THE ROAD AND GET OUT OF CAR HOWEVER, THE CAR BURNE…
Read full complaint
DRIVING HOME FROM WORK AT 5:40 PM, 3 DEER RAN OUT AND AFTER SLAMMING ON BRAKES THE LAST ONE WAS STRUCK, HEAD ON. THE HOOD BUCKLED AND THE ENTIRE ENGINE OF THE CAR IMPLODED IN FLAMES. NO AIRBAGS WENT OFF AND THE CAR IMMEDIATELY DIED. I WAS ABLE TO PULL CAR OVER TO THE SIDE OF THE ROAD AND GET OUT OF CAR HOWEVER, THE CAR BURNED COMPLETELY. THE CAR ENGULFED IN FLAMES AND THE ENGINE, WINDOWS, ENTIRE INSIDE, EVERYTHING BURNED. THERE IS NO DASH, NO STEERING WHEEL, SEATS, FRONT TIRES, ETC ARE GONE. THERE IS VERY LITTLE LEFT AND THE MANUFACTURER HAD AN INVESTIGATION DONE AND WILL NOT TELL ME WHY THIS HAPPENED. MY HUSBAND HAS A 2014 AVENGER AND WE WANT TO KNOW IF IT IS SAFE. BUT WERE TOLD MY MANUFACTURER REPRESENTATIVE THEY WOULD NOT TELL ME BECAUSE THEY WOULD NOT WANT IT OUT IN THE PUBLIC. *TR
HIT A DEER AT 60 MPH THE CAR STARTED ON FIRE AND COMPLETELY BURNED UP NO AIR BAGS WENT OFF DODGE INVESTIGATED BUT WILL NOT TELL US WHY THE CAR BURNED UP. *TR
TL* THE CONTACT RENTED A 2013 DODGE AVENGER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ON THE FIRST ATTEMPT. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS TO START THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE UNDER CARRIAGE BECAME SEPARATED FROM THE VEHICLE. THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT RENTED A 2013 DODGE AVENGER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ON THE FIRST ATTEMPT. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS TO START THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE UNDER CARRIAGE BECAME SEPARATED FROM THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 01/20/15*LJ UPDATED 9/7/2017*CN
I NOTICED SEVERAL TIMES BEFORE THIS DATE GOING DOWN THE HWY AND THE CAR ACCELERATING ON ITS OWN. I WAS AT A DEAD STOP AND GO ON THE HWY RUSH OUR I LET OFF THE BRAKE TO EASE ON UP AND MY CAR WENT UNDER INTO A TRUCK DOING OVER $7800.00 IN DAMAGES NO AIRBAGS NONE DEPLOYED I JUST GOT MY CAR FROM THE SHOP ON 8/30. I GOT IN THE CAR ST…
Read full complaint
I NOTICED SEVERAL TIMES BEFORE THIS DATE GOING DOWN THE HWY AND THE CAR ACCELERATING ON ITS OWN. I WAS AT A DEAD STOP AND GO ON THE HWY RUSH OUR I LET OFF THE BRAKE TO EASE ON UP AND MY CAR WENT UNDER INTO A TRUCK DOING OVER $7800.00 IN DAMAGES NO AIRBAGS NONE DEPLOYED I JUST GOT MY CAR FROM THE SHOP ON 8/30. I GOT IN THE CAR STARTED IT AND BACKED UP PUT THE CAR IN DRIVE AND IT JOLTED INTO DRIVE NO FOOT ON THE GAS PEDDLE I HAD TO HIT MY BRAKES AGAIN THEN I PROCEEDED HOME. STILL NOTICED THIS A COUPLE MORE TIMES. I DIDN'T THINK ABOUT IT AT THE TIME OF THE ACCIDENT I WAS TAKEN STRAIGHT OUT BY EMS WITH A NECKBRACE. I'VE SIT HERE CONFUSED FOR 2 MONTHS KNOWING HOW DID THIS HAPPEN KNOWING IT WAS A BRAKE EASE OFF AND BRAKE AGAIN TRAFFIC AND THE AMOUNT OF DAMAGE DONE TO THE CAR. MY 14 YR OLD DAUGHTER HAD TO CONVINCE MY MOM I WAS NOT SPEEDING BECAUSE OF THE AMOUNT OF DAMAGE. I WILL CALL THE SHOP AGAIN ON MON AM BUT ALSO DODGE OR CHRYSLER RE: THIS. I HAD TO PAY OUT OVER $4K IN CAR RENTAL (NO I DIDN'T KNOW I DID NOT HAVE THAT COVERAGE.) I'M NOW PISSED OFF AND CONFUSED AT DID THIS CAUSE THE COLLISION? I'VE ONLY HAD THIS CAR A YEAR AND UNTIL THAT POINT HAD NEVER HAD AN ACCIDENT MY FAULT IN M LIFE I DID HAVE ONE THIS LAST WEEK IN A RENTAL IT WAS MY FAULT I OWN UP TO THAT BUT NOT THE FIRST IN THE AVENGER AFTER STARTING IT AGAIN YESTERDAY AT PICKUP AND THIS IMMEDIATELY HAPPENING AND I MEAN IMMEDIATELY HAPPENING AGAIN HAD THE SHOP NOT ALREADY BEING CLOSED FOR THE WEEKEND AND MY RIDE LEFT I WOULD HAVE LEFT THE CAR AT THE SHOP. I KNOW OF THE OVERHEAD AIRBAG PROBLEMS I HAVE TRIED TO CALL ONCE BEFORE. I WILL CALL MONDAY UNTIL MY CALLS ARE RETURNED PLEASE REPLY TO THIS. I AM ALSO CONTACTING MY INSURANCE AGENCY RE: THIS PROBLEM AND THE ACCIDENT. PLEASE CONTACT ME. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
WE HIT A DEER AND THE FRONT OF THE CAR WAS DEMOLISHED. UPON INSPECTION THE NEXT MORNING, I NOTICED THAT AN AIRBAG SENSOR WAS SHATTERED AND JUST HANGING BY THE WIRE HARNESS. AIRBAGS DID NOT DEPLOY, I WAS CONCERNED ABOUT THIS AND NEVER GOT A STRAIGHT ANSWER FROM ANYONE. NOW I GET A RECALL NOTICE SAYING FAULTY RESTRAINT SYSTEM, I'M…
Read full complaint
WE HIT A DEER AND THE FRONT OF THE CAR WAS DEMOLISHED. UPON INSPECTION THE NEXT MORNING, I NOTICED THAT AN AIRBAG SENSOR WAS SHATTERED AND JUST HANGING BY THE WIRE HARNESS. AIRBAGS DID NOT DEPLOY, I WAS CONCERNED ABOUT THIS AND NEVER GOT A STRAIGHT ANSWER FROM ANYONE. NOW I GET A RECALL NOTICE SAYING FAULTY RESTRAINT SYSTEM, I'M NOT TOO HAPPY... *TR
TL* THE CONTACT OWNS A 2012 DODGE AVENGER. THE CONTACT STATED THAT THE VEHICLE WOULD VIBRATE EXCESSIVELY WHEN TRAVELING OVER ROAD BUMPS. THE CONTACT ALSO MENTIONED THAT THE UNDER CARRIAGE WAS LOOSE AND PARTIALLY DETACHING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER, WHO STATED THAT THE FAILURE WAS UNKNOWN. THE MANUFACTUR…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE AVENGER. THE CONTACT STATED THAT THE VEHICLE WOULD VIBRATE EXCESSIVELY WHEN TRAVELING OVER ROAD BUMPS. THE CONTACT ALSO MENTIONED THAT THE UNDER CARRIAGE WAS LOOSE AND PARTIALLY DETACHING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER, WHO STATED THAT THE FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 25,000. THE VIN WAS NOT AVAILABLE. THE CONSUMER STATED THERE WAS A CONSTANT VIBRATION COMING FROM THE VEHICLE. THE DEALER DID NOT KNOW, HOW TO FIX THE PROBLEM. UPDATED 09/15/14
TL* THE CONTACT OWNS A 2012 DODGE AVENGER. THE CONTACT STATED THAT WHEN DRIVING IN INCLEMENT WEATHER, WATER WOULD DRAIN INTO THE VEHICLE, CAUSING THE TRUNK LIGHTS TO FAIL. THE CONTACT ALSO STATED THAT THE THIRD BRAKE LIGHT FAILED. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACT…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE AVENGER. THE CONTACT STATED THAT WHEN DRIVING IN INCLEMENT WEATHER, WATER WOULD DRAIN INTO THE VEHICLE, CAUSING THE TRUNK LIGHTS TO FAIL. THE CONTACT ALSO STATED THAT THE THIRD BRAKE LIGHT FAILED. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 41,000. THE CURRENT MILEAGE WAS APPROXIMATELY 43,000. THE VIN WAS UNAVAILABLE. *TR
I WAS ON MY WAY TO WORK AND CAUTIOUSLY PRECEDED AROUND THE CURVY ROAD WITH MY STEERING WHEEL HELD TO THE RIGHT. WHEN I ENDED THE CURVE AND TRIED TO TURN MY STEERING WHEEL BACK TOO THE RIGHT IT WOULDN'T TURN BACK TO THE LEFT. THIS CAUSED ME TO CRASH HEAD ON INTO A TREE. THE AIR BAGS WERE DEPLOYED. *TR
Official recalls
317V640000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats:front Assembly:head Restraint
Oct 10, 2017
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence & remedy
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Additional source detail variants (2)
Seats:front Assembly:head Restraint
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
16V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
13V282000 · Air Bags; Electrical System
Jul 2, 2013
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence & remedy
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Additional source detail variants (2)
Air Bags
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Electrical System
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.