THE SEALED BALL JOINTS ON THE RIGHT, FRONT WERE COMPLETELY VOID OF GREASE. THE BALL JOINTS POPPED OUT DURING A LANE CHANGE AND CAUSED THE VEHICLE TO SKID OUT OF CONTROL TO THE RIGHT, ACROSS TWO LANES OF HEAVY TRAFFIC. FORTUNATELY THE VEHICLES TO THE RIGHT SAW THE INCIDENT AND TOOK THE APPROPRIATE ACTIONS TO AVOID COLLISION. T…
Read full complaint
THE SEALED BALL JOINTS ON THE RIGHT, FRONT WERE COMPLETELY VOID OF GREASE. THE BALL JOINTS POPPED OUT DURING A LANE CHANGE AND CAUSED THE VEHICLE TO SKID OUT OF CONTROL TO THE RIGHT, ACROSS TWO LANES OF HEAVY TRAFFIC. FORTUNATELY THE VEHICLES TO THE RIGHT SAW THE INCIDENT AND TOOK THE APPROPRIATE ACTIONS TO AVOID COLLISION. THE FRONT OF THE VEHICLE DROPPED TO THE GROUND, BREAKING APART THE FRONT GRILL. THE RIGHT FRONT TIRE WAS TURNED AT A 90 DEGREE ANGLE TO THE CAR AND CAUSED THE FENDER TO BEND OUTWARD. I NOTICED A POPPING SOUND TWO DAYS PRIOR TO INCIDENT AND IN THE MORNING OF 12/26/1998 I HAD SCHEDULED A MECHANIC TO SERVICE THE POPPING NOISE FOR THE MORNING OF 12/27/1998. THE INCIDENT OCCURRED TWO HOURS AFTER I HAD SCHEDULED THE MECHANIC TO EXAMINE AND REPAIR THE VEHICLE.
NHTSA ODI #701638
Mileage unknown · Dec 8, 1998
Engine And Engine CoolingSteeringSuspension
ALARM CONTINUALLY GOES OFF, DEFROSTER WILL NOT WORK UNLESS THE A/C IS ACTIVATED IN THE FRONT AND REAR INADEQUATE DEFROSTING, SUSPENSION SHAKED DUE TO BAD BUSHINGS. OTHER THINGS HAVE OCCURRED AS WELL - TOO MUCH TO KEEP TRACK OF. *MJS
NHTSA ODI #701204
Mileage unknown · Jun 22, 1998
Suspension
WHILE DRIVING VEHICLE ABOUT 50 MPH LOWER BALL JOINT FELL OUT OF VEHICLE WITHOUT A WARNING, AND CAUSING LOSS OF CONTROL. CONSUMER HAD NO IDEA ABOUT THE SAFETY DEFFECT. *AK
NHTSA ODI #824549
Mileage unknown · May 27, 1998
Suspension
NO UNUSUAL CONDITIONS OR WEIGHT EXIST. DEALER SUSPECTS THAT ALL 3 SETS OF REAR STRUTS THAT HAVE BEEN INSTALLED SO FAR ARE DEFECTIVE, INCLUDING THE ORIGINAL SET. NO OTHER EXPLANATION PROVIDED. FOURTH SET TO BE INSTALLED WHEN RECEIVED BY DEALER.
NHTSA ODI #536065
Mileage unknown · Apr 14, 1998
SteeringSuspension
FRONT END RATTLES. ALSO REPLACED TIED ROD END.
NHTSA ODI #534239
Mileage unknown · Feb 2, 1998
Suspension
FRONT SUSPENSION FAILURE.
NHTSA ODI #529488
Mileage unknown · Jan 2, 1998
SuspensionVisibility
BALL JOINT BROKE AND FELL OFF.
NHTSA ODI #527297
Mileage unknown · Jun 12, 1995
StructureSuspension
REAR OF VEHICLE IS DESIGNED TOO HIGH, IMPAIRING VISIBILITY.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00015 · Lower Contrtol Arm Ball Joint
Opened Aug 2, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Additional source detail variants (3)
Suspension
There is no summary currently available
Suspension
There is no summary currently available
Suspension
There is no summary currently available
PE99008 · Ball Joint
Opened Feb 1, 1999 · Closed Apr 13, 1999
Status: closed (inferred from source dates) · Suspension
allege failure of front ball joints may cause the driver to loose control of the vehicle as the front suspension collapses on one side.this loss of control increases the risk of a vehicle crash.
Additional source detail variants (4)
Suspension
allege failure of front ball joints may cause the driver to loose control of the vehicle as the front suspension collapses on one side.this loss of control increases the risk of a vehicle crash.
Suspension
allege failure of front ball joints may cause the driver to loose control of the vehicle as the front suspension collapses on one side.this loss of control increases the risk of a vehicle crash.
Suspension
allege failure of front ball joints may cause the driver to loose control of the vehicle as the front suspension collapses on one side.this loss of control increases the risk of a vehicle crash.
Suspension
allege failure of front ball joints may cause the driver to loose control of the vehicle as the front suspension collapses on one side.this loss of control increases the risk of a vehicle crash.
1995 Dodge Avenger Problems, Complaints & Recalls | Skip That Year
Illustration