I PURCHASED THIS RV IN DEC 2016 I HAVE BEEN ON A COUPLE SMALL TRIPS THEN WENT ON A 1000 MILE TRIP AND FOUND THAT A SWAY BAR BOLT WAS MISSING AND THE PROPANE TANK WAS RUBBING ON THE REAR LEAF SPRINGS. THE SPACE BETWEEN THE PROPANE TANK AND LEAF SPRINGS IS TO CLOSE. I HAVE TAKEN A PHOTO OF THE ISSUE. I HAVE LOOKED FOR A RECALL B…
Read full complaint
I PURCHASED THIS RV IN DEC 2016 I HAVE BEEN ON A COUPLE SMALL TRIPS THEN WENT ON A 1000 MILE TRIP AND FOUND THAT A SWAY BAR BOLT WAS MISSING AND THE PROPANE TANK WAS RUBBING ON THE REAR LEAF SPRINGS. THE SPACE BETWEEN THE PROPANE TANK AND LEAF SPRINGS IS TO CLOSE. I HAVE TAKEN A PHOTO OF THE ISSUE. I HAVE LOOKED FOR A RECALL BUT I THINK BECAUSE OF THE AGE IT HAS DROPPED OFF. THERE ARE MORE VEHICLES OUT THERE THAT ARE LIKE MINE AND I WOULD BE AFRAID IF SOMETHING WOULD HAPPEN TO SOMEONE ELSE.I AM A RETIRED FIREFIGHTER AND HAVE BEEN ON A PROPANE TANK EXPLOSION ENVOLVING AN RV. AND IT'S NOT A GOOD FEELING TO SEE THIS. I HAVE CONTACTED THOR MOTOR COACH AND FORD BOTH ARE UNAWARE OF ANY RECALL INVOLVING THIS ISSUE. MY DAMON INTRUDER IS AT THE SHOP NOW I AM JUST TRYING TO TRACK DOWN OLD INFORMATION THERE HAS TO BE SOME KIND OF RECALL ON THIS ISSUE.
DAMON IS RECALLING 2,415 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG.
Consequence & remedy
Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY AND OWNER NOTIFICATION FOR THIS CAMPAIGN PLEASE SEE 09V-110. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT 1-800-860-3812.
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence & remedy
Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION IS BEGAN MAY 12, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAMON AT 1-219-272-9212.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Damon Intruder Problems, Complaints & Recalls | Skip That Year
Illustration