IllustrationTHE AIR BAG LIGHT BLINKED ON AND OFF INTERMITTENTLY. *NM THE CONSUMER WAS TOLD THE VEHICLE HAD A DEFECTIVE CLOCK SPRING. *JB
2001 Chrysler Voyager
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1425–50K
950–75K
775–100K
6100–150K
1150K+
41 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports1 injury reports
What owners actually said
80 reports2001 CHRYSLER VOYAGER DEFECTIVE FUEL TANK SENDER. *BF THE VEHICLE WAS IN THE SHOP 4 TIMES FOR THE SAME PROBLEM. *JB
WHILE DRIVING AT NIGHT HEADLIGHTS INTERMITTENTLY FAILED. THIS CAUSED POOR VISIBILITY TO THE DRIVER. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE CONTROL MODULE NEEDED TO BE REPLACED. *AK DASH LIGHTS TAIL LIGHTS PARKING LIGHT ALL STAY ON WHEN…
Read full complaint
WHILE DRIVING AT NIGHT HEADLIGHTS INTERMITTENTLY FAILED. THIS CAUSED POOR VISIBILITY TO THE DRIVER. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE CONTROL MODULE NEEDED TO BE REPLACED. *AK DASH LIGHTS TAIL LIGHTS PARKING LIGHT ALL STAY ON WHEN HEADLIGHTS GO OUT. *TC
WHILE DRIVING 2001 CHRYSLER VOYAGER RPMS DROPPED TO ZERO, VAN SUDDENLY STALLS OUT.NO BRAKES OR STEERING. WILL NOT START UP. ALREADY HAD THIS HAPPEN ONCE, AND MECHANIC REPLACED FUEL FILTER AND FUEL PUMP. RAN FOR ONE MONTH, AND IT HAPPENED AGAIN. TOWED IT TO SAME MECHANIC, STARTED UP AFTER COUPLE TRIES. STALLED OUT AGAIN. VERY SCA…
Read full complaint
WHILE DRIVING 2001 CHRYSLER VOYAGER RPMS DROPPED TO ZERO, VAN SUDDENLY STALLS OUT.NO BRAKES OR STEERING. WILL NOT START UP. ALREADY HAD THIS HAPPEN ONCE, AND MECHANIC REPLACED FUEL FILTER AND FUEL PUMP. RAN FOR ONE MONTH, AND IT HAPPENED AGAIN. TOWED IT TO SAME MECHANIC, STARTED UP AFTER COUPLE TRIES. STALLED OUT AGAIN. VERY SCARY SINCE I HAVE 3 CHILDREN, 2 UNDER TWO YEARS OLD. CANNOT AFFORD NEW VEHICLE, BUT ALSO CANNOT AFFORD MONTHLY VISIT TO MECHANIC. SEARCHED SEVERAL WEBSITES AND FOUND THIS A COMMON PROBLEM, I CANNOT BELIEVE THIS HAS NOT BEEN INVESTIGATED YET! FROM WHAT I'M FINDING, NO MECHANIC HAS BEEN ABLE TO THOROUGHLY FIX THIS RECURRENT PROBLEM.*AK
DAUGHTER, FRIEND AND HER 22 MO. OLD DAUGHTER WERE ABOUT TO LEAVE THE MALL PARKING LOT WHEN THE PASSENGER SIDE AIR BAG DEPLOYED. ALTHOUGH THERE WERE NO PHYSICAL INJURIES, THEY WERE OBVIOUSLY SHAKEN BY THE EXPERIENCE. HEARD ON ABC NEWS ABOUT CHRYSLER RECALL ON OTHER MODELS FOR SIMILAR PROBLEM. THEN WENT TO INTERNET TO GET MORE IN…
Read full complaint
DAUGHTER, FRIEND AND HER 22 MO. OLD DAUGHTER WERE ABOUT TO LEAVE THE MALL PARKING LOT WHEN THE PASSENGER SIDE AIR BAG DEPLOYED. ALTHOUGH THERE WERE NO PHYSICAL INJURIES, THEY WERE OBVIOUSLY SHAKEN BY THE EXPERIENCE. HEARD ON ABC NEWS ABOUT CHRYSLER RECALL ON OTHER MODELS FOR SIMILAR PROBLEM. THEN WENT TO INTERNET TO GET MORE INFORMATION.*AK
THE AIR BAG LIGHT ILLUMINATED INTERMITTENTLY WHEN MAKING TURNS WHILE DRIVING. DEALER WAS NOTIFIED. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB
MY VAN WAS OPERATING AND SERVICED AS NORMAL. SUDDENLY ONE DAY THERE WAS A SQUEALING NOISE NAD THE AIR CONDITIONING WOULD NOT WORK. I TOOK IT TO PARK JEEP/CHRYSLER IN BURNSVILLE, MN (952-808-2442) AND WAS INFORMED BY KEVIN THE SERVICE TECH THAT THE COMPRESSER HAD FAILED AND THAT THE REPAIR WOULD BE OVER $700.00. I HAVE NOT AUT…
Read full complaint
MY VAN WAS OPERATING AND SERVICED AS NORMAL. SUDDENLY ONE DAY THERE WAS A SQUEALING NOISE NAD THE AIR CONDITIONING WOULD NOT WORK. I TOOK IT TO PARK JEEP/CHRYSLER IN BURNSVILLE, MN (952-808-2442) AND WAS INFORMED BY KEVIN THE SERVICE TECH THAT THE COMPRESSER HAD FAILED AND THAT THE REPAIR WOULD BE OVER $700.00. I HAVE NOT AUTHORIZED THE REPAIR YET, BUT I SEEM TO HAVE NO CHOICE. HE TOLD ME THAT EVEN THOUGH THERE WAS A SERVICE BULLETIN, IT WOULD NOT BE COVERED.*AK
THE CLOCK SPRING SENSOR FAILED WITHOUT WARNING. AS A RESULT THE AIRBAG LIGHT STAYED ON. *JB THE CONSUMER WAS CONCERNED THAT THE AIR BAG MAY NOT DEPLOY IN THE EVENT OF AN ACCIDENT. *SC THE CONSUMER STATED THIS WAS THE SECOND REPAIR ON THE CLOCK SPRING. *JB
THE PLUG TO THE AIR CONDITIONER FAN PROCEED TO SMOKE AND BURN WHERE IT WAS PLUGGED INTO THE FAN/BLOWER. NOW THE AIR CONDITIONER WORKS BUT IT DOES NOT BLOW. IT FILLED THE VAN UP WITH SMOKE TO WHERE I THOUGHT THE ENGINE WAS ON FIRE. *LA
ALTHOUGH THERE HAS NOT BEEN AN ACCIDENT, THERE IS A CERTAIN AMOUNT OF ACCEPTABLE REPLACEMENT TIME BEFORE PADS SHOULD BE CHANGED. I HAVE HAD TO REPLACE THESE JUST ABOUT EVERY THREE MONTHS. THE ROTORS HAVE BEEN DONE AT THE SAME TIME. NORMALLY I WOULD SAY THAT THE REPAIR SHOP WAS TAKING ADVANTAGE OF ME, BUT THIS HAS BEEN DONE WI…
Read full complaint
ALTHOUGH THERE HAS NOT BEEN AN ACCIDENT, THERE IS A CERTAIN AMOUNT OF ACCEPTABLE REPLACEMENT TIME BEFORE PADS SHOULD BE CHANGED. I HAVE HAD TO REPLACE THESE JUST ABOUT EVERY THREE MONTHS. THE ROTORS HAVE BEEN DONE AT THE SAME TIME. NORMALLY I WOULD SAY THAT THE REPAIR SHOP WAS TAKING ADVANTAGE OF ME, BUT THIS HAS BEEN DONE WITH MORE THAN JUST A SECOND OPINION AND A MECHANIC FOR A FATHER IN LAW. THIS IS UNACCEPTABLE AND I KNOW IM NOT THE ONLY CONSUMER THAT IS IN THIS SITUATION. PADS SHOULD NOT BE REPLACED THAT OFTEN ESPECIALLY WITH MOST OF THE MILEAGE COMING FROM HIGHWAY USE RATHER THAN CITY USE. *AK
Official recalls
204V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V152000 · Suspension:front:control Arm:lower Arm
May 8, 2001
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.