← New search

2011 Chrysler Town And Country

Owner reports · Recalls · Investigations

More warning signs than most Town And Country years

Owner complaints for the 2011 Chrysler Town And Country are substantially higher than the model-year median of 216.5.

About this comparison →

When problems were reported

Mileage at the reported incident

554 reports with mileage · 219 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 523 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

10 crash reports12 fire reports12 injury reports

Power Train complaints

39 reports
Clear category filter
Mileage unknown · May 18, 2022
Electrical SystemEnginePower Train

"P0740" OBD2 code, causing vehicle to Fail state Safety Inspection. issue is due to a defect within the transmission, very common with the 2011 Chrysler Town & Country. "Dealer Only Repair" , very costly. Serious Safety Issue. Vehicle cannot be diagnosed by most Certified Mechanics. this faulty reading could mask very serious i…

Read full complaint

"P0740" OBD2 code, causing vehicle to Fail state Safety Inspection. issue is due to a defect within the transmission, very common with the 2011 Chrysler Town & Country. "Dealer Only Repair" , very costly. Serious Safety Issue. Vehicle cannot be diagnosed by most Certified Mechanics. this faulty reading could mask very serious issues with the Transmission. This issue needs to be expedited to review ASAP. Thank You.

NHTSA ODI #11465141

149,990 miles · Apr 21, 2022
Power Train

The contact owns a 2011 Chrysler Town and Country. The contact stated while driving approximately 45 MPH, the check engine warning light illuminated. The contact parked on the side of the road to check the engine oil, but no failure was found. The contact continued driving to his residence. The contact took the vehicle to an ind…

Read full complaint

The contact owns a 2011 Chrysler Town and Country. The contact stated while driving approximately 45 MPH, the check engine warning light illuminated. The contact parked on the side of the road to check the engine oil, but no failure was found. The contact continued driving to his residence. The contact took the vehicle to an independent mechanic, where it was diagnosed with needing the converter clutch solenoid circuit to be replaced. The vehicle was not repaired but was pending repairs. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was 149,990.

NHTSA ODI #11461609

97,983 miles · Feb 23, 2021
Power Train

2011 CHRYSLER TOWN AND COUNTRY WITH 97,983 MILES. WHILE STOPPED AT A TRAFFIC LIGHT, THE TRANSMISSION STOPPED WORKING AND THE VAN WOULD NOT MOVE. WAITED INTO THE NIGHT FOR A TOW TRUCK TO TOW US TO A REPAIR SHOP. THE TRANSMISSION FAILURE IS A KNOWN ISSUE BUT NO RECALL ISSUED FROM CHRYSLER. STUCK WITH A $3,338.92 BILL FOR A NEW…

Read full complaint

2011 CHRYSLER TOWN AND COUNTRY WITH 97,983 MILES. WHILE STOPPED AT A TRAFFIC LIGHT, THE TRANSMISSION STOPPED WORKING AND THE VAN WOULD NOT MOVE. WAITED INTO THE NIGHT FOR A TOW TRUCK TO TOW US TO A REPAIR SHOP. THE TRANSMISSION FAILURE IS A KNOWN ISSUE BUT NO RECALL ISSUED FROM CHRYSLER. STUCK WITH A $3,338.92 BILL FOR A NEW TRANSMISSION.

NHTSA ODI #11397532

95,000 miles · Jan 16, 2020
Electrical SystemFuel/propulsion SystemPower Train

FUEL PUMP RELAY PREMATURELY FAILS INSIDE THE TOTAL INTEGRATED POWER MODULE (TIPM) CAUSING LOSS OF CONTROL WHILE DRIVING. THE FUEL RELAY FUSE IS NOT REPLACEABLE AS IT IS HARD WIRED INSIDE THE TIPM. THE ENTIRE TIPM UNNECESSARILY NEEDS REPLACED AT GREAT EXPENSE AND LABOR OF NEARLY $1,800 FOR WHAT SHOULD BE AN INEXPENSIVE FUSE. OTHE…

Read full complaint

FUEL PUMP RELAY PREMATURELY FAILS INSIDE THE TOTAL INTEGRATED POWER MODULE (TIPM) CAUSING LOSS OF CONTROL WHILE DRIVING. THE FUEL RELAY FUSE IS NOT REPLACEABLE AS IT IS HARD WIRED INSIDE THE TIPM. THE ENTIRE TIPM UNNECESSARILY NEEDS REPLACED AT GREAT EXPENSE AND LABOR OF NEARLY $1,800 FOR WHAT SHOULD BE AN INEXPENSIVE FUSE. OTHER CHRYSLER/ DODGE/ JEEP VEHICLES HAVE BEEN RECALLED AND REPAIRED FOR THE SAME ISSUE, BUT NOT THE CHRYSLER TOWN & COUNTRY MINIVANS. THE MANUFACTURER AND ITS DEALERSHIPS IS AVOIDING A RECALL SO THAT THIS MODEL 'AGES OUT' AND PERMANENTLY DISPOSED SO THAT IT DOESN'T HAVE TO DO A RECALL.

NHTSA ODI #11299730

Mileage unknown · Nov 27, 2019
Power Train

MY TODDLER CHILDREN AND I WERE STRANDED BECAUSE MY VAN COMPLETELY SHUT DOWN. I LEFT THE VEHICLE RUNNING TO RUN IN AND GET MY CHILDREN FROM DAYCARE, ONLY TO RETURN TO A VEHICLE THAT HAD NO ELECTRICITY. MY CHILDREN AND I WERE STUCK ALL EVENING, AWAY FROM HOME, WHILE THE VEHICLE WAS CHECK OUT AND EVENTUALLY TOWED. AFTER BEING TO…

Read full complaint

MY TODDLER CHILDREN AND I WERE STRANDED BECAUSE MY VAN COMPLETELY SHUT DOWN. I LEFT THE VEHICLE RUNNING TO RUN IN AND GET MY CHILDREN FROM DAYCARE, ONLY TO RETURN TO A VEHICLE THAT HAD NO ELECTRICITY. MY CHILDREN AND I WERE STUCK ALL EVENING, AWAY FROM HOME, WHILE THE VEHICLE WAS CHECK OUT AND EVENTUALLY TOWED. AFTER BEING TOWED, NOT ONLY ONCE BUT TWICE, AND BEING WITHOUT A VEHICLE SINCE 11/8/2019 WE FINALLY FIND OUT THE PROBLEM IS THE PCM, WHICH HAS BEEN AN ISSUE WITH THESE VANS. THIS IS MAJOR INCONVENIENCE FOR MY FAMILY. WITH THIS BEING A RE-OCCURRING ISSUE WITH THIS VEHICLE, CHRYSLER SHOULD BE TAKING CARE OF THIS ISSUE.

NHTSA ODI #11282638

83,000 miles · Jun 25, 2019
Power Train

WHEN DECELERATING FROM OVER 45 MPH ENGINE LIGHT COMES ON SHIFTS SUDDENLY TO 3RD OR 2ND GEAR. CODES P0733 P0734 P0792. CLEAR ENGINE CODES, DRIVES NORMAL UNTIL DECELERATION AT ELEVATED SPEEDS. TRANSMISSION SHIFTS NORMALLY OTHERWISE. THIS IS THE 62TE 6-SPEED TRANSMISSION.

NHTSA ODI #11222571

124,000 miles · Mar 30, 2019
Electrical SystemPower Train

TAKATA RECALL- HAD TO REPLACE THE BATTERY AND ALTERNATOR TWICE IN LESS THAN TWO YEARS BECAUSE OF BEING STRANDED OR JUST NOT STARTING MULTIPLE TIMES. THE TORK CLUTCH HAD TO BE REPLACED AND STILL RUNS ROUGH

NHTSA ODI #11192616

94,000 miles · Oct 10, 2018
EnginePower Train

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE ENGINE SEIZED UPON ACCELERATING FROM A COMPLETE STOP. IN ADDITION, THE VEHICLE UPSHIFTED OUT OF GEAR AND THE POWER TRAIN WAS FAULTY. THE VEHICL…

Read full complaint

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE ENGINE SEIZED UPON ACCELERATING FROM A COMPLETE STOP. IN ADDITION, THE VEHICLE UPSHIFTED OUT OF GEAR AND THE POWER TRAIN WAS FAULTY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000.

NHTSA ODI #11139413

130,000 miles · Sep 11, 2018
Power Train

IT SLAMS INTO GEARS BECAUSE HYDROLOGIC PUMP THAT WAS RECALLED IN THE S44 RECALL.

NHTSA ODI #11128818

95,000 miles · Mar 14, 2018
Power Train

THE TRANSMISSION HAS KNOW ISSUES OF SLIPPAGE. THIS SLIPPAGE CAUSED ME TO ROLL BACKWARDS AT AN MAJOR INTERSECTION AND ALMOST CAUSE A ACCIDENT. THIS CHRYSLER TOWN AND COUNTRY HAS HAD HUNDREDS OF COMPLAINTS IN THE LAST FEW YEARS BUT THIS TYPE OF MALFUNCTION DUE TO THE SLIPPAGE ON THE TRANSMISSION COULD RESULT IN FATALITIES. THI…

Read full complaint

THE TRANSMISSION HAS KNOW ISSUES OF SLIPPAGE. THIS SLIPPAGE CAUSED ME TO ROLL BACKWARDS AT AN MAJOR INTERSECTION AND ALMOST CAUSE A ACCIDENT. THIS CHRYSLER TOWN AND COUNTRY HAS HAD HUNDREDS OF COMPLAINTS IN THE LAST FEW YEARS BUT THIS TYPE OF MALFUNCTION DUE TO THE SLIPPAGE ON THE TRANSMISSION COULD RESULT IN FATALITIES. THIS NEEDS TO BE ADDRESSED THIS HAS WENT ON THE ENTIRE TIME WE HAVE OWNED THE CHRYSLER TOWN AND COUNTRY NOW IT JUST GETS WORSE AND WORSE BY THE DAY.

NHTSA ODI #11079070

Official recalls

3

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den