IllustrationWHEN DRIVING AT 30 MPH ESP/ BAS/ABS & BRAKE LIGHTS APPEAR ON THE DASH,THEN STEERING BECAME DIFFICULT .WE ARE SO GRATEFUL IT'S NOT ON THE HIGHWAY.
2008 Chrysler Town And Country
Owner reports · Recalls · Investigations
More warning signs than most Town And Country years
Owner complaints for the 2008 Chrysler Town And Country are substantially higher than the model-year median of 216.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Town And Country years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2210–25K
19425–50K
24350–75K
25275–100K
277100–150K
65150K+
1,252 reports with mileage · 687 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 1,242 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 375 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 204 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports17 fire reports29 injury reports
Steering complaints
95 reportsTL* THE CONTACT OWNS A 2008 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING 45 MPH, THE VEHICLE INADVERTENTLY VEERED TO THE LEFT AND THE EPS AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A FAULTY TIRE. THE TIRE WAS ROTATED TO THE REAR OF THE VEHICLE. THE FAILURE RE…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING 45 MPH, THE VEHICLE INADVERTENTLY VEERED TO THE LEFT AND THE EPS AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A FAULTY TIRE. THE TIRE WAS ROTATED TO THE REAR OF THE VEHICLE. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A STEERING ANGLE MODULE AND CLOCK SPRING MALFUNCTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.
THERE SEEMS TO BE AN ISSUE WITH THE CLOCKSPRING MECHANISM IN THE STEERING COLUMN OF THE 2008 T&C VANS. MINE WENT OUT AND WHEN THE MECHANIC TRIED TO GET ONE FROM THE LOCAL DEALER HE WAS TOLD THAT IT IS BACKORDERED ALONG WITH SEVERAL HUNDRED BACKORDERED. OBVIOUSLY THIS IS AN ISSUE THAT NEEDS TO BE ADDRESSED AS IT AFFECTS MANY IT…
Read full complaint
THERE SEEMS TO BE AN ISSUE WITH THE CLOCKSPRING MECHANISM IN THE STEERING COLUMN OF THE 2008 T&C VANS. MINE WENT OUT AND WHEN THE MECHANIC TRIED TO GET ONE FROM THE LOCAL DEALER HE WAS TOLD THAT IT IS BACKORDERED ALONG WITH SEVERAL HUNDRED BACKORDERED. OBVIOUSLY THIS IS AN ISSUE THAT NEEDS TO BE ADDRESSED AS IT AFFECTS MANY ITEMS.
I WAS DRIVING DOWN A CITY STREET WHEN THE VAN SUDDENLY DIED IN THE MIDDLE OF THE ROAD. IT LOST POWER STEERING AND BRAKES AND WOULDN'T RELEASE THE KEY. AFTER A FEW MINUTES THE VAN STARTED AGAIN. I BEGAN TO DRIVE HOME THROUGH CITY STREETS WHEN ABOUT 10 MINUTES LATER THE VAN ONCE AGAIN DIED AND LOST POWER TO THE BRAKES AND STEERING…
Read full complaint
I WAS DRIVING DOWN A CITY STREET WHEN THE VAN SUDDENLY DIED IN THE MIDDLE OF THE ROAD. IT LOST POWER STEERING AND BRAKES AND WOULDN'T RELEASE THE KEY. AFTER A FEW MINUTES THE VAN STARTED AGAIN. I BEGAN TO DRIVE HOME THROUGH CITY STREETS WHEN ABOUT 10 MINUTES LATER THE VAN ONCE AGAIN DIED AND LOST POWER TO THE BRAKES AND STEERING AND WOULDN'T RELEASE KEY EVENTUALLY THE CAR MAYBE A CLICKING SOUND AND ALLOWED ME TO START CAR. I TOOK IT TO THE DEALERSHIP AND THEY COULD NOT DUPLICATE THE PROBLEM AND FOUND NO ERROR CODES.
ENGINE SHUTS DOWN COMPLETELY CAUSING LOSS OF POWER STEERING AND BRAKES. NO WARNINGS, JUST DIES. DIAGNOSTICS REVEAL A BAD TOTALLY INTEGRATED POWER MODULE. RECALLS ISSUED FOR MULTIPLE MODELS BUT NOT MINE. I WAS TOLD, I HAVE ALL THE SYMPTOMS BUT I DON'T HAVE THE FLU ! NOW THEY WANT ALMOST $ 1000 TO FIX IT ! IT'S AN ESTABLISHED, DEF…
Read full complaint
ENGINE SHUTS DOWN COMPLETELY CAUSING LOSS OF POWER STEERING AND BRAKES. NO WARNINGS, JUST DIES. DIAGNOSTICS REVEAL A BAD TOTALLY INTEGRATED POWER MODULE. RECALLS ISSUED FOR MULTIPLE MODELS BUT NOT MINE. I WAS TOLD, I HAVE ALL THE SYMPTOMS BUT I DON'T HAVE THE FLU ! NOW THEY WANT ALMOST $ 1000 TO FIX IT ! IT'S AN ESTABLISHED, DEFECTIVE PART BUT THEY'LL LET ME DRIVE AWAY IN IT UNLESS I CAN COME UP WITH THE MONEY. CHRYSLER SAID IT'S THE SAME PART AS THE RECALLED ONES BUT I DON'T HAVE A RECALL ON MY MODEL. ANT TIME ANY WHERE AT ANY SPEED, IT SHUTS DOWN.
WHILE DRIVING MY CAR SHUTS OFF IN THE MIDDLE OF DRIVING WIPERS STARTS FLASHING DASH BOARD GOES HEY WIRE CHECK ENGINE LIGHT COMES ON AND ITS VERY HARD TO STEER AND WONT START. THEN AFTER A FEW HOURS IT MIGHT STAR BACK UP OR DAYS LATER.
I HAVE A 2008 CHRYSLER TOWN AND COUNTRY. MY VIN NUMBER IS [XXX]. I HAD THE RECALL (R03 / NHTSA 14V-373) DONE TO MY VEHICLE THAT WHEN DRIVING THE VEHICLE JUST TURNS OFF AND STEERING LOCKS. SO I TOOK MY VEHICLE IN FOR REPAIR OF THIS RECALL HOWEVER, IT STILL DOES THE SAME THING. WHENEVER DRIVING IT TURNS OFF AND LOCKS WHEEL WHICH I…
Read full complaint
I HAVE A 2008 CHRYSLER TOWN AND COUNTRY. MY VIN NUMBER IS [XXX]. I HAD THE RECALL (R03 / NHTSA 14V-373) DONE TO MY VEHICLE THAT WHEN DRIVING THE VEHICLE JUST TURNS OFF AND STEERING LOCKS. SO I TOOK MY VEHICLE IN FOR REPAIR OF THIS RECALL HOWEVER, IT STILL DOES THE SAME THING. WHENEVER DRIVING IT TURNS OFF AND LOCKS WHEEL WHICH IN SEVERAL INSTANCES ME AND MY FAMILY COULD HAVE BEEN INVOLVED IN AN ACCIDENT. I ALSO LET A FRIEND BORROW THE VEHICLE AND IT DID THE SAME THING TO HIM. NOW I TOOK IT BACK TO THE DEALERSHIP WHICH IS JEEP CHRYSLER LOCATED AT 55 W I 240 SERVICE RD, OKLAHOMA CITY, OK 73139. THEY STATED THE CODES DID NOT SHOW A MODULE REPAIR AND THEY COULD NOT REPLICATE THE PROBLEM. HOWEVER, THIS IS THE SAME ISSUE AS BEFORE. THEY SUPPOSEDLY REPLACED THE MODULE AND THE KEY FOBS BEFORE DURING THE RECALL REPAIR. THEY WANTED ME TO PAY AND AUTHORIZE A TWO HOUR DIAGNOSTIC FOR A PROBLEM THAT SHOULD HAVE ALREADY BEEN REPAIRED. THIS HAS BEEN AN ONGOING PROBLEM WITH THIS VEHICLE SINCE I PURCHASED IT. HOWEVER, WHEN I FIRST WENT IN 2011 AND ADDRESSED THE ISSUE WITH JEEP CHRYSLER ORGANIZATION. THEY STATED THEY COULD NOT DUPLICATE THE PROBLEM. HOWEVER, YEARS LATER NOW THAT A RECALL FOR THE SAME ISSUE THAT WAS REPORTED BY ME PREVIOUSLY , THEY TRIED FIXING IT. ATTACHED IS THE RECALL FOR THIS PROBLEM. EVEN AFTER THEY ALLEGEDLY REPAIRED THIS PROBLEM, IT STILL DOES THE SAME THING AS BEFORE TURNS OFF, SO THE PROBLEM WAS NOT FIXED CORRECTLY. NOW THEY ARE WANTING ME TO PAY FOR FURTHER TESTING OF MY VEHICLE BEFORE THEY WILL REPAIR THE ISSUE. IT IS A TRUE SAFETY HAZARD AND COULD LEAD TO SERIOUS INJURY. I ALSO HAVE WITNESSES WHO HAVE NOTICED THIS PROBLEM THAT THEY CLAIM THEY CAN'T DUPLICATE AT THE SHOP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
AFTER THE IGNITION SWITCH RECALL WAS PERFORMED ON MY VEHICLE WE EXPERIENCED A STALL CONDITION THAT RENDERED THE STEERING AND BRAKES UNUSABLE FOR SEVERAL SECONDS. THE SITUATION NEARLY RESULTED IN AN ACCIDENT. THE CONDITION HAPPEN ON A DRY, SUNNY DAY WHILE THE CAR WAS IN MOTION BUT NOT ACCELERATING PRIOR TO GOING INTO A TURN.
WHILE I WAS DRIVING ON THE ON-RAMP TO A HIGHWAY MY CAR HIT A BUMP AND LOST CONTROL AND I STARTED SLIDING. THANKFULLY THERE HAPPENED TO BE NO ONE COMING. I NOTICED THAT WHEN MY VAN STOPPED HALFWAY IN A DITCH AND HALFWAY ON THE LEFT LANE I WENT TO MOVE MY VEHICLE IT WOULDN'T MOVE SO I THEN NOTICED IT WAS OFF BUT STILL IN DRIVE AND…
Read full complaint
WHILE I WAS DRIVING ON THE ON-RAMP TO A HIGHWAY MY CAR HIT A BUMP AND LOST CONTROL AND I STARTED SLIDING. THANKFULLY THERE HAPPENED TO BE NO ONE COMING. I NOTICED THAT WHEN MY VAN STOPPED HALFWAY IN A DITCH AND HALFWAY ON THE LEFT LANE I WENT TO MOVE MY VEHICLE IT WOULDN'T MOVE SO I THEN NOTICED IT WAS OFF BUT STILL IN DRIVE AND THE KEY WAS STILL ON. SO I PUT IT IN PARK AND SHUT IT OFF THEN TURNED IT BACK ON THEN WAS ABLE TO PROCEED DRIVING BUT SINCE THEN MY ESP/BAS, AND TRACTION CONTROL LIGHT HAVE BEEN ON. AFTER HAVING THAT HAPPENED I HAD THE RECALL ON MY VAN FIXED. WELL THE LIGHTS ARE STILL THERE AND NOW THE DRIVING IS WORSE. I CANT CONTROL MY STEERING AND THEY SAY IT IS MY STEERING ANGLE SENSOR. THEY ALSO SAY MY CATALYTIC CONVERTER NEEDS FIXED AND A PCM FLASH. WHICH I DON'T UNDERSTAND HOW ALL THESE PROBLEMS STARTED SINCE MY IGNITION UNWILLINGLY SHUT OFF. I AM THINKING THAT CAUSED A POWER SURGE, AND NOW ITS GOING TO COST ME $2000 TO FIX IT IF NOT MORE. MY PROBLEMS NOW ARE: 1) MISFIRE IN CYLINDER 4 2) ROUGH IDLE 3) ACCELERATING SLOWLY WHILE RPM'S ARE ABOVE 3000 4) STUMBLING WHILE DRIVING (SHAKES OR VIBRATES REALLY BAD WHILE IN DRIVE/ OR PUTTERS) 5) ESP/BAS, TRACTION CONTROL, AND CHECK ENGINE LIGHT ILLUMINATED ON DASH 6) STEERING WHEEL SHAKES FROM LEFT TO RIGHT ON ITS OWN 7) LOUD ENGINE NOISE 8) MOTOR SHAKES 9) ABS READER SAYS TO REPLACE STEERING ANGLE SENSOR (CLOCKSPRING) 10) THERE IS MORE I JUST CANNOT THINK OF IT RIGHT NOW. THIS IS CURRENTLY WHAT I HAVE FIXED IN THE LAST TWO WEEKS TO SEE IF IT HELPS THE PROBLEM. 1) OIL CHANGE (ALWAYS UP TO DATE) 2) SPARK PLUGS 3) SPARK PLUG WIRES 4) BATTERY 5) IGNITION COIL PACK 6) UPSTREAM O2 SENSOR 7) RECALL DONE ON WIN MODULE IGNITION SWITCH FOBIK KEY I HAVE CONTACTED CHRYSLER TO INFORM THEM OF THIS AND THEY TELL ME THERE IS NOTHING THEY CAN DO ABOUT IT AND ITS NOT A MANUFACTURE DEFECT.
VEHICLE SHUTS OFF RANDOMLY WHILE IN MOTION ON CITY STREETS GOING BETWEEN 10 - 30 MPH. THE RECALL (R03) FOR THIS PROBLEM HAS BEEN DONE AND THE SHUT-OFFS STILL HAPPEN. UNKNOWN FAULT OR PROBLEM. SEVERAL DIAGNOSTICS DONE OVER THE PAST 2 YEARS, ALL TO NO AVAIL. ENGINE TUNE UP WITH PLUGS PERFORMED. MAP SENSOR REPLACED. NO ERROR CODES…
Read full complaint
VEHICLE SHUTS OFF RANDOMLY WHILE IN MOTION ON CITY STREETS GOING BETWEEN 10 - 30 MPH. THE RECALL (R03) FOR THIS PROBLEM HAS BEEN DONE AND THE SHUT-OFFS STILL HAPPEN. UNKNOWN FAULT OR PROBLEM. SEVERAL DIAGNOSTICS DONE OVER THE PAST 2 YEARS, ALL TO NO AVAIL. ENGINE TUNE UP WITH PLUGS PERFORMED. MAP SENSOR REPLACED. NO ERROR CODES. HELP US!!!
Official recalls
720V396000 · Air Bags:frontal:driver Side:inflator Module; Steering: Steering Wheel/handle Bar
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
16V047000 · Air Bags:frontal
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
14V373000 · Air Bags; Electrical System:ignition:switch
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
14V055000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
11V394000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Equipment:appliance:air Conditioner
Aug 3, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Equipment:appliance:air Conditioner
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V611000 · Equipment:appliance:air Conditioner
Dec 8, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK At THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
09V351000 · Service Brakes, Hydraulic
Sep 11, 2009
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
Remedy: ELDORADO NATIONAL AMERIVAN DEALERS WILL INSPECT THE VEHICLES AND IF THE BRAKE LINES WERE IMPROPERLY ROUTED THEY WILL BE CORRECTLY REINSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 13, 2009. OWNERS MAY CONTACT ELDORADO NATIONAL AT 1-800-955-9086. THESE MINIVANS HAVE BEEN ALTERED INTO WHEELCHAIR ACCESSIBLE VEHICLES BY ELDORADO. THIS RECALL IS NOT BEING CONDUCTED BY CHRYSLER GROUP LLC AND WILL NOT BE PERFORMED AT NO COST BY DODGE OR CHRYSLER DEALERS UNLESS THEY ARE ALSO AN ELDORADO NATIONAL DEALER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972